2019 Lincoln Mkc Owner Complaints

1. What component or system failed or malfunctioned, and is it available for inspection upon request? Answer: Engine / Powertrain (Engine Block & Cooling System). The vehicle suffered an internal engine failure caused by coolant intrusion into Cylinder #4, requiring a full engine long block replacement per Ford Technical Service Bulletin (TSB) 22-2229. The vehicle and component are available for inspection upon request. ​2. How was your safety or the safety of others put at risk? Answer: The engine suffered a sudden and complete loss of power without warning in the middle of active, moving traffic, leaving the vehicle dead in a live travel lane. Because the engine stalled abruptly due to coolant flooding the cylinder, the vehicle became an immediate, stationary obstacle in harm's way, creating an extreme risk of a high-speed rear-end collision or chain-reaction pileup that easily could have resulted in severe injury or a fatality for myself and other motorists. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Answer: Yes. The problem was confirmed by a certified technician who pulled active diagnostic trouble codes P0304 and P0316. The technician performed a borescope inspection through spark plug #4 and visually verified coolant intrusion inside Cylinder 4. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Answer: Inspected and diagnosed by a servicing dealer/technician who generated an official repair estimate (#9,496.97) confirming the defect and recommending engine replacement per Ford TSB 22-2229. (Note: Mention if inspected by insurance/police, otherwise leave as dealership/facility only). 5. Were there any warning lamps, messages? Answer: The Check Engine Light (CEL) illuminated immediately before or during the engine shutdown. The diagnostic codes (P0316 and P0304) indicate startup misfires caused by coolant accumulating in the cylinder while parked.

NHTSA ID

11756258

Incident

Aug 9, 2026

Car started shaking roughly when started, check engine light came on for cylinder misfire. Known engine problem where coolant leaks in to the engine block due to a known defect from Ford for these 2.0L engines. There is a TSB 22-2229 ([XXX]) already issued for this. Dealer inspected and confirmed the problem. Now the entire engine long block needs to be replaced resulting in $10,000 repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755475

Incident

Aug 1, 2026

Component: Engine (2.0L EcoBoost) — coolant intrusion into cylinders What failed: The engine in my 2019 Lincoln MKC (2.0L EcoBoost, approximately 83,000 miles) failed due to internal coolant intrusion into the cylinders. This is a known defect in this engine, documented by the manufacturer in TSB 22-2229 (superseding TSB 19-2346), which acknowledges coolant leaking into the cylinders on 2.0L EcoBoost vehicles and specifies complete long block engine replacement as the only repair. My vehicle and the failed engine are available for inspection upon request. The car/engine is currently at the [XXX] Ford in Draper, UT. Safety risk: Coolant intrusion causes engine misfires and can cause sudden loss of engine power while driving, hydro-locking of the engine, and — per the manufacturer's own bulletins and pending litigation — overheating, cracked cylinder heads, and engine fires. The check engine light began flashing while I was on the highway. I am also a dialysis patient awaiting a kidney transplant, and a sudden engine failure or stall while driving to medical treatment poses a serious safety risk. Confirmed by a service center: Yes. On or about XXX, [XXX], a franchised Lincoln dealership, performed a borescope inspection of the engine and confirmed the failure, stating the engine must be replaced at a quoted cost of $7,897.45. I have the written diagnosis and repair estimate. Inspected by the manufacturer or others: No police or insurance inspection was involved, as this was a mechanical failure rather than a collision. Warning signs before failure: Unexplained low coolant level requiring repeated top-offs; white smoke from the exhaust, especially at cold start; check engine light, steady or flashing; rough running or misfire, often with codes P0300–P0304 or P0316; sweet coolant smell. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11751568

Incident

Jun 5, 2026

There is coolant intrusion into the cyl. It is a known concern and many complaints on line. Lincoln refuses to assist in the engine repair or replacement. Going down the road the engine misses and looses power causing difficulty controlling vehicle causing unsafe conditions for all traffic.

NHTSA ID

11750623

Incident

Jul 1, 2026

The engine on my 2019 Lincoln MKC has failed due to coolant intrusion. A known issue with this model car between 2017-2019. There are two cracked cylinders on the engine block. The dealership says that the engine must be replaced.

NHTSA ID

11745253

Incident

Jun 15, 2026

The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention). The contact had not experienced a failure associated with the recall. However, the contact was concerned that the dealer intended to inspect the vehicle to determine whether there was an issue with the rearview camera instead of replacing the back over prevention camera. The contact believed that replacing the part regardless if a failure had occurred or not would be a more appropriate preventative measure due to the failure associated with the rearview camera. The manufacturer was not notified of the issue.

NHTSA ID

11744737

Incident

Sep 30, 2025

Engine has coolant intrusion at 57,000 miles. Mechanic recommends full engine replacement.

NHTSA ID

11742458

Incident

Jun 2, 2026

The contact owns a 2019 Lincoln MKC. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the following day, while attempting to start the vehicle, the contact noticed white smoke coming from the exhaust. The contact stated that while driving at an undisclosed speed, the vehicle idled and drove unusually rough. In addition, the contact stated that the vehicle misfired. The vehicle was taken to the dealer where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact referenced two Technical Bulletins, TSB 19-2346 and TSB 22-2133, which had similar failure descriptions. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 96,000.

NHTSA ID

11742022

Incident

May 4, 2026

Mileage

96,000 mi

The contact owns a 2019 Lincoln MKC. The contact stated that the engine experienced rough idling after starting with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who replaced the spark plugs and coil pack; however, the failure recurred with the vehicle shuddering while driving. The vehicle was taken to the dealer, who determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 58,000.

NHTSA ID

11741772

Incident

Mar 1, 2026

Mileage

58,000 mi

The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while in reverse(R), the vehicle failed to display an image of the rear of the vehicle. Additional safety information were also not available on the screen. The dealer was contacted and confirmed that the part to do the recall repair was not yet available. The manufacturer was not made aware of the issue. The failure mileage was approximately 96,000.

NHTSA ID

11731792

Incident

Sep 8, 2025

Mileage

96,000 mi

Engine failure TSB 19-2346, A known/common issue with this engine. The car only has 73,790 miles on it. The car started shaking when started, engine light on, empty coolant reservoir and off then parking brake came on randomly several times , and the brakes locked up twice, which resulted in going over a curb. Discontinued driving the vehicle after that incident obviously due to safety. Ford service center gave a $13,000 repair estimate. The vehicle is still at Ford and available for inspection.

NHTSA ID

11731447

Incident

Apr 7, 2026

The contact owns a 2019 Lincoln MKC. The contact stated that while in reverse(R), the back over prevention system displayed a black or blue distorted image, with the message "Camera Not Available" displayed. The contact stated that the failure created a visibility hazard for the driver. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V572000 (BACK OVER PREVENTION). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 62,000.

NHTSA ID

11730825

Incident

Dec 1, 2025

Mileage

62,000 mi

The back up camera works intermittently. Sometimes it just has a blurry or blue screen. It has been ongoing for the last month.

NHTSA ID

11729070

Incident

Mar 1, 2026

The engine on my 2019 Lincoln MKC (2.0L EcoBoost) suffered a sudden internal failure without warning shortly after the factory powertrain warranty expired. The vehicle had no prior drivability issues, no warning lights, and had been maintained on schedule. While driving, the engine began running roughly and quickly lost power. The vehicle became unsafe to operate and had to be towed. The dealership diagnosed the engine as having internal mechanical failure requiring complete engine replacement. I was told the failure was not due to maintenance and that the engine could not be repaired. The failure occurred only weeks after the 6-year/70,000-mile powertrain warranty period ended. This appears consistent with other reported EcoBoost engine failures involving internal defects such as coolant intrusion, low-tension piston rings, or block-related issues. A sudden loss of power while driving presents a safety hazard, especially in traffic or at highway speeds. I am submitting this complaint so NHTSA is aware of this engine failure pattern and the safety risk associated with unexpected engine shutdowns on these vehicles.

NHTSA ID

11728019

Incident

Jun 24, 2025

The rear camera recall is many many months overdue for a fix. My rear camera hasn’t worked probably in almost a year. Neither The dealership nor Ford have provided updates.

NHTSA ID

11727638

Incident

Mar 27, 2026

The head gasket has failed, leading to coolant intrusion into the number 2 cylinder. Several misfires occurred due to this. This is a known issue due to the design of the lower block, which uses a channel, thus causing a very small surface area for the head gasket between the channel and the cylinder, which accelerates wear. Spent $3,000 to fix this well-known design issue. Car at ~100k miles.

NHTSA ID

11725936

Incident

Jan 1, 2026

The vehicle was recalled. I took the vehicle to the dealer where it was purchased. It was serviced. The engine issue was addressed, so we thought. The repair/replacement parts did not remedy the issue, despite it being in the shop for over 6 months. The problem persists. It is overheating in a 5 minute drive. The local service department is saying there is no other remedy. They keep asking we bring it in for another diagnosis, but the problem is the same as the 47,000 other vehicles that have been recalled by this same issue. We purchased the car and have not been able to use it.

NHTSA ID

11725234

Incident

Feb 25, 2019

I have been noticing that when my rear camera goes out that it takes out the heater controls, the maps and the radio and my screen goes totally blank, is this another issue or is it all related. Thank you.

NHTSA ID

11723237

Incident

Mar 18, 2021

ENGINE FAILURE DUE TO COOLANT INTRUSION TSB22-2229 DEALER SAID THIS TYPE OF FAILURE IS NOT COVERED BY MY EXTENDED WARRANTY AND FORD/LINCOLN CORP REFUSES TO PAY FOR THE REPAIR .

NHTSA ID

11722249

Incident

Jan 26, 2026

Purchased a 2019 Lincoln MKC from Mazda and Stokes on Ashley phosphate in North Charleston, South Carolina. I was told that the vehicle had recalls and they identify the recalls about the battery and the rear camera when I asked was there anything else wrong with the vehicle, they said no when I drove the vehicle home after a few days the engine light came on. After doing some diagnostics at the dealership, it will discovered that there was a misfire in the engine. They did a complementary repair. It took a couple of days when I received the vehicle. I took it home and after about a week, the engine light came back on for the same problem after further diagnostic come to find out that if this problem persist is because of coolant intrusion come to find out that this is common among engines that are 2.0 L Eco boost engine engines in the 2019 Lincoln MKC. I am making a complaint because I found out also that I will not get reimburse my money. Neither will they take the vehicle back. I called the Lincoln dealership and they will not do a Goodwill repair so I purchased a car about three weeks ago with them, knowing this problem and did not disclose it to me or told me about it cause this is common knowledge for this vehicle and they sold it to me and now I have payments on a broke vehicle, which I can’t afford $11,000 new engine or a long block.

NHTSA ID

11720797

Incident

Feb 26, 2026

Engine seizes while driving and chokes due to engine misfire. First occurence was at 34kmiles in 9/2023 and when brought for emissions check mechanic said needed new spark plugs/coil so had them replaced for $800. 3-4months later after only 1k miles check engine light goes on again and car hums/rattles like it will stall. My brother runs diagnosis and same issue and that’s when I started to do research and found that Lincoln MKC 2019 have known engine issues. As it was under warranty until dec 2024, I brought to Steven’s Ford in Milford CT and raised this engine issue and specifically asked for full repair to ensure issue is fixed. 18 months later on 11/12/2025, while driving car the engine starts to hum and rattle feel like it will seize and check engine light goes on again. Same issue from when I had repair under warranty but Lincoln dealer claims it’s a parts issue and not an engine issue. These vehicles are dangerous and can cause accident due to engine just stopping. Dealership and Lincoln refuse to provide any support.

NHTSA ID

11718003

Incident

Nov 12, 2025

Ford's 2.0L EcoBoost engine has seen recalls and technical service bulletins (TSBs) primarily for coolant intrusion leading to engine failure, affecting models like the 2017-2019 MKC with issues stemming from a block design flaw and faulty head gaskets that allow coolant into cylinders, causing overheating, corrosion, and potential engine fires. This vehicle is confirmed to have coolant intrusion in the cylinders, resulting in premature engine failure.

NHTSA ID

11716109

Incident

Feb 5, 2026

My 2019 Lincoln MKC has the widespread coolant intrusion engine defect acknowledged by Ford. This is a premature internal engine failure due to design.

NHTSA ID

11715842

Incident

Feb 5, 2026

Engine warning light went on. Replaced spark plugs and coil to cylinder # 2. Then, Traction control light indicated system off. Technician advised the need for dealership software upgrade to ABS. Dealership advised that engine block allowing coolant intrusion into #2 cylinder. Needs a new engine. And need for a new ABS module, also defective.

NHTSA ID

11715798

Incident

Jan 29, 2026

Vehicle overheated, due to collant entering #1 cylinder. This coolant intrusion is apparently a well documented issue, from an acknowledged engine defect. (TSB 19-2346, TSB 22-2133) Ford dealership recommended an $11,000 + tax engine replacement, with no relief, as car is past its warranty. The vehicle has 58540 miles. Lincoln customer service also declined any goodwill repair. Independent Service Dealer (Craig’s Auto Repair Service 281-469-5949) first diagnosed the issue, recommended taking the vehicle to Ford Dealership (Tomball Ford).

NHTSA ID

11715635

Incident

Jan 29, 2026