2019 Lincoln Mkc

1. What component or system failed or malfunctioned, and is it available for inspection upon request? Answer: Engine / Powertrain (Engine Block & Cooling System). The vehicle suffered an internal engine failure caused by coolant intrusion into Cylinder #4, requiring a full engine long block replacement per Ford Technical Service Bulletin (TSB) 22-2229. The vehicle and component are available for inspection upon request. ​2. How was your safety or the safety of others put at risk? Answer: The engine suffered a sudden and complete loss of power without warning in the middle of active, moving traffic, leaving the vehicle dead in a live travel lane. Because the engine stalled abruptly due to coolant flooding the cylinder, the vehicle became an immediate, stationary obstacle in harm's way, creating an extreme risk of a high-speed rear-end collision or chain-reaction pileup that easily could have resulted in severe injury or a fatality for myself and other motorists. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Answer: Yes. The problem was confirmed by a certified technician who pulled active diagnostic trouble codes P0304 and P0316. The technician performed a borescope inspection through spark plug #4 and visually verified coolant intrusion inside Cylinder 4. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Answer: Inspected and diagnosed by a servicing dealer/technician who generated an official repair estimate (#9,496.97) confirming the defect and recommending engine replacement per Ford TSB 22-2229. (Note: Mention if inspected by insurance/police, otherwise leave as dealership/facility only). 5. Were there any warning lamps, messages? Answer: The Check Engine Light (CEL) illuminated immediately before or during the engine shutdown. The diagnostic codes (P0316 and P0304) indicate startup misfires caused by coolant accumulating in the cylinder while parked.

NHTSA ID

11756258

Incident

Aug 9, 2026

Car started shaking roughly when started, check engine light came on for cylinder misfire. Known engine problem where coolant leaks in to the engine block due to a known defect from Ford for these 2.0L engines. There is a TSB 22-2229 ([XXX]) already issued for this. Dealer inspected and confirmed the problem. Now the entire engine long block needs to be replaced resulting in $10,000 repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755475

Incident

Aug 1, 2026

Component: Engine (2.0L EcoBoost) — coolant intrusion into cylinders What failed: The engine in my 2019 Lincoln MKC (2.0L EcoBoost, approximately 83,000 miles) failed due to internal coolant intrusion into the cylinders. This is a known defect in this engine, documented by the manufacturer in TSB 22-2229 (superseding TSB 19-2346), which acknowledges coolant leaking into the cylinders on 2.0L EcoBoost vehicles and specifies complete long block engine replacement as the only repair. My vehicle and the failed engine are available for inspection upon request. The car/engine is currently at the [XXX] Ford in Draper, UT. Safety risk: Coolant intrusion causes engine misfires and can cause sudden loss of engine power while driving, hydro-locking of the engine, and — per the manufacturer's own bulletins and pending litigation — overheating, cracked cylinder heads, and engine fires. The check engine light began flashing while I was on the highway. I am also a dialysis patient awaiting a kidney transplant, and a sudden engine failure or stall while driving to medical treatment poses a serious safety risk. Confirmed by a service center: Yes. On or about XXX, [XXX], a franchised Lincoln dealership, performed a borescope inspection of the engine and confirmed the failure, stating the engine must be replaced at a quoted cost of $7,897.45. I have the written diagnosis and repair estimate. Inspected by the manufacturer or others: No police or insurance inspection was involved, as this was a mechanical failure rather than a collision. Warning signs before failure: Unexplained low coolant level requiring repeated top-offs; white smoke from the exhaust, especially at cold start; check engine light, steady or flashing; rough running or misfire, often with codes P0300–P0304 or P0316; sweet coolant smell. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11751568

Incident

Jun 5, 2026

There is coolant intrusion into the cyl. It is a known concern and many complaints on line. Lincoln refuses to assist in the engine repair or replacement. Going down the road the engine misses and looses power causing difficulty controlling vehicle causing unsafe conditions for all traffic.

NHTSA ID

11750623

Incident

Jul 1, 2026

The engine on my 2019 Lincoln MKC has failed due to coolant intrusion. A known issue with this model car between 2017-2019. There are two cracked cylinders on the engine block. The dealership says that the engine must be replaced.

NHTSA ID

11745253

Incident

Jun 15, 2026

The contact owns a 2019 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention). The contact had not experienced a failure associated with the recall. However, the contact was concerned that the dealer intended to inspect the vehicle to determine whether there was an issue with the rearview camera instead of replacing the back over prevention camera. The contact believed that replacing the part regardless if a failure had occurred or not would be a more appropriate preventative measure due to the failure associated with the rearview camera. The manufacturer was not notified of the issue.

NHTSA ID

11744737

Incident

Sep 30, 2025

Engine has coolant intrusion at 57,000 miles. Mechanic recommends full engine replacement.

NHTSA ID

11742458

Incident

Jun 2, 2026

The contact owns a 2019 Lincoln MKC. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the following day, while attempting to start the vehicle, the contact noticed white smoke coming from the exhaust. The contact stated that while driving at an undisclosed speed, the vehicle idled and drove unusually rough. In addition, the contact stated that the vehicle misfired. The vehicle was taken to the dealer where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact referenced two Technical Bulletins, TSB 19-2346 and TSB 22-2133, which had similar failure descriptions. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 96,000.

NHTSA ID

11742022

Incident

May 4, 2026

Mileage

96,000 mi

Certain 2021-2024 Model Year Bronco, 2021-2024 Model Year Bronco Sport, 2020-2022 Model Year Corsair and Escape, 2016-2024 Model Year Explorer, 2019-2020 Model Year Fusion, 2016-2018 Model Year Focus RS, 2022-2024 Model Year Maverick, 2016-2019 Model Year MKC and 2019-2024 Model Year Ranger Vehicles Equipped with a 2.0L or 2.3L Engine and Engine Block Heater System Block Heater Replacement

Customer Satisfaction Program 25N15 - Supplement #1 Certain 2015-2019 Model Year Multiple Vehicle Lines Rear View Camera Inspection For One-Time Replacement

This article supersedes TSB 24-2165 to update the TSB Service Procedure. Some vehicles listed in the Model statement above may exhibit various SYNC performance related concerns including but not limited to:  Display operation concerns  Navigation inoperative  Voice recognition concerns  Phone connection issues  Dropped phone connections  Applink related performance  Travel Link not present or showing incorrect traffic  Slow system response NOTE: Ford has found some of the APIMs replaced and returned for inspection contained an outdated software level and the APIM did not require replacement. The customer concern may have been resolved by updating the APIM with latest level of software. The SYNC 3 universal thumb drive will be able to update the APIM software without the use of a scan tool and does not require the process to be monitored. Ford will be monitoring APIM replacements to confirm TSB directed software updates have been performed.

Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. Pinpoint test HK in the Powertrain Control and Emissions Diagnosis (PC/ED) or in Section 303-14 of the Workshop Manual (WSM) has been updated to address this concern.

"Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: • Customer concern of a vibration or rough idle in D or R • Shudder while driving • Lack of engine RPM • Low performance, lack of acceleration on take off"

While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.