2019 Dodge Charger

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Vehicle was sold by Westgate Crysler Jeep Dodge Ram of Raleigh with missing caliper bolt in front passenger brake system. This was detected by an independent service center while getting brake pads and rotors replaced, as they were very worn and causing the brake system to be jumpy and catchy, despite Westgate assuring they were fine. The lack of the bolt in the caliper put my entire family's life at risk from the second we drove off the lot a little over a month ago.

NHTSA ID

11753994

Incident

Jun 19, 2026

I was traveling 58 mph on hwy 270 in Malvern Arkansas. The power steering turned off, the emergency brake engaged and flashed, and the ABS shut off. I replaced the steering sensor with an original mopar part off of my vin number and if i turn tightly it still triggers a code. The entire sensor and spring has been relplaced. It was obvious the original part shorted out It is VERY SENSITIVE to heat, the hotter it gets the more shut down of power steering, and activating the emergency brake while driving is experienced. I bought this car new and have taken excellent care of it.

NHTSA ID

11751658

Incident

Jun 29, 2026

Vehicle: Dodge Charger GT Recall: SABIC Side Airbag Inflator Replacement Dealer: ourisman chrysler dodge jeep ram of clarksville, maryland Date of Recall Repair: feb 27, 2026 Complaint Description: After the dealer performed the SABIC inflator recall on my Dodge Charger GT, the vehicle immediately developed new electrical failures that were not present before the repair. As soon as I picked up the car, the interior dome/map lights stopped working, and the right‑side exterior front lighting also failed. These failures occurred directly after the recall repair, indicating the dealer likely damaged or disconnected wiring inside the A‑pillar/B‑pillar or roof harness while accessing the inflator. This creates a safety hazard, especially at night, because the right exterior lighting is inoperative and interior lighting does not function. The dealer has not acknowledged responsibility, and the vehicle was returned to me in an unsafe condition after a federally mandated recall repair.

NHTSA ID

11722901

Incident

Feb 27, 2026

Campaign 11701038 - Warping of door panels and driving shaft area. Worried this will affect airbag deployment.

NHTSA ID

11713844

Incident

Jan 1, 2024

- Crack at base of gas tank where fill tube attached causing fuel vapors around the car and a possible fuel leak. - Yes by independent service center. -White residue was built up around the crack in the fill tube. Independent service center confirmed the cause as - "Found plastic fuel tank leaking around the filler nipple that is plastic welded in. Also, the auxiliary pump has a dark spot like it may be sleeping as well. Need to replace the fuel tank and would recommend replacing the fuel pumps as a precaution." Final repair charge was $4437.03. Independent service center replace fuel tank and fuel pumps with Mopar parts from the closest Dodge dealer. In review with the service center they stated that fuel was dripping onto the heat shield above the exhaust and could have caused a fire. - No other agencies inspected the issue or repair. Attached a copy of the invoice and two pictures of the worn/cracked fuel tank. - No warning lights, just the smell of gasoline in my garage about 5 weeks ago. The smell would be the strongest when the tank was full but when below half tank the smell was not present.

NHTSA ID

11708098

Incident

Nov 1, 2025

Over 2 years ago I took my vehicle in for an oil change and asked them to drive it and see why it sometimes pulls the steering when going around a curve to the left. they drove it and said it never did pull. Since then, it now pulls to the right when going around curves to the right also. It is doing it more frequently and I am in fear that it will either cause me to go off the road or hit someone when it all of a sudden jerks, like it is catching on something in the tire or something. I wouldn't even let my grandson drive it when he got his learners permit. I have since then decided to look for a safer vehicle and will be trading it since no one can figure out the issue. It jerks hard all of a sudden and you have to make sure you are holding the steering wheel tight. I am reporting to hopefully prevent an accident.

NHTSA ID

11707706

Incident

Nov 13, 2023

The contact owns a 2019 Dodge Charger. The contact stated that while driving at an undisclosed speed, the headlights failed to function as intended. The headlights failed to activate as intended. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact replaced the light bulbs; however, the failure persisted. The contact was unable to drive the vehicle at night due to the failure. Upon further investigation, the contact found a recall issued by the manufacturer for the low beam headlights failing or the wiring harness melting. The manufacturer was not made aware of the issue. The failure mileage was unknown.

NHTSA ID

11703842

Incident

Aug 8, 2024

The interior door panel on my 2019 Dodge Charger began to separate/warp from the door frame on the Front drivers and Front Passengers door panels. The vehicle had approximately 32000 miles when the issue started. The plastic trim piece is lifting and peeling away from the door next to the window sill, creating a sharp edge and a gap. This separation is causing the door lock mechanism to bind and become difficult to operate. The window operation is also negatively affected, as the glass rubs against the warped panel. I have also had to replace the window motor a little over a year ago and it is again starting to fail. AJ Dohmann now Geaux Dodge in Plaquamian Louisiana replaced this. This defect poses an unreasonable risk to safety because it could impede egress from the vehicle in an emergency due to the malfunctioning door lock. It may also compromise the integrity of the side curtain airbag deployment area. I contacted the manufacturer/dealer on 02/2020, and they indicated this is a known issue but not a safety recall, so they refused to cover the repair under warranty. The issue has reoccurred/worsened and is present on multiple doors. There were no injuries or a crash as a result of this issue. Photos of the defect are attached to this complaint.

NHTSA ID

11701038

Incident

Feb 1, 2020

Backup Camera Poor Image Quality Inspection

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0111-00 - Intake Air Temperature Sensor 1 Circuit Range Performance Bank 1. (In Active or Stored status) ● P0071-00 - Ambient Air Temperature Sensor Performance. (In Active or Stored status) ● P0072-00 - Ambient Air Temperature Sensor Circuit "A" Low. (In Active or Stored status) ● P0073-00 - Ambient Air Temperature Sensor Circuit "A" High. (In Active or Stored status) ● P0011-00 - Bank 1 Camshaft 1 Position Timing Over Advanced Or. (In Active or Stored status) ● P25E4-00 - B Camshaft Position - Unable To Achieve Locked Position Bank 1. (In Active or Stored status) ● P05BD-00 - Stop-Start Mode Switch Range/Performance. (In Active or Stored status) ● P0116-00 - Engine Coolant Temperature Sensor 1 Performance. (In Active or Stored status) ● P062B-00 - Internal Control Module Fuel Injector Control Performance. (In Active or Stored status) ● P0604-00 - Internal Control Module Random Access Memory Ram Error. (In Active or Stored status) ● P060C-00 - Internal Control Module Main Processor Performance. (In Active or Stored status)** ● P018B-00 - Fuel Pressure Sensor "B" Circuit Range/performance. **(In Active or Stored status)** ● P1CEA-00 - Boost Side EVAP Purge System Performance. **(In Active or Stored status)** ● P06DD-00 - Engine Oil Pressure Control Circuit Performance/Stuck Off. **(In Active or Stored status)** ● P00C6-00 - Fuel Rail Pressure Too Low - Engine Cranking. **(In Active or Stored status)** ● P0300-00 - Multiple Cylinder Misfire. **(In Active or Stored status)** Customers may also experience one or more of the following: ● **Oil Level High Warning in the Instrument Panel Cluster (IPC).** ● Fully Autonomous Parking Assist (FAPA) is not deactivated when accelerator pedal is pressed. ● Vehicle is not heating up fast enough at freezi

Backup Camera Poor Image Quality Inspection

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On