2014 Dodge Charger

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.

The contact owns a 2014 Dodge Charger. The contact stated that while driving at an undisclosed speed, the vehicle started beeping with several unknown warning lights illuminated, and the steering wheel locked up. The contact stated that the windshield wipers activated, and the brakes locked up. The vehicle had experienced the failure in 2020, and the dealer replaced the alternator, which temporarily resolved the failure; however, the symptoms reoccurred. The vehicle was taken back to a dealer where it was diagnosed, and the contact was informed that the failure was not caused by the alternator. The technician informed the contact that there were other underlying issues with the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 103,995.

NHTSA ID

11753573

Incident

Jul 22, 2026

Mileage

103,995 mi

Driver steering wheel air bag cartridge separated from steering wheel mount plate during a accident airbag cartridge deployed on impact and is Protruding 3-4inches from outside the steering wheel

NHTSA ID

11734460

Incident

Apr 28, 2026

ABS module needs to be replaced and they stopped making the part. Lights are on all the time with no cruise control and the advanced brake system no longer works. Nobody has the part. They do not make it anymore.

NHTSA ID

11718567

Incident

Feb 16, 2026

The ABS module has malfunctioned which affects the cruise control, most of the dash controls on the steering wheel and has several lights on the dash that stay lit. The Dodge dealer is aware of this and states that right now there is no fix from Dodge. I'm putting an estimate date below due to ongoing issue.

NHTSA ID

11717711

Incident

Jan 1, 2024

The just went off on the dash and they stoped working abs traction control emergency brake light is on and idk what the problem is I scanned it and nothing

NHTSA ID

11715171

Incident

Dec 31, 2025

Alternator and battery have now had to be replaced three times within the past year. It appears to be the same issues, other Dodge chargers with a recall having. However, this VIN number is not on that recall list.

NHTSA ID

11688046

Incident

Sep 17, 2025

At 65 mph with the adaptive cruse on, all of a sudden, the FCW light came on and almost rear ended the car in front of me. I lost antilock,cruse, and fcw. I also have less brake pedal. Took to Dodge dealer in Emporia Ks. Said anti-lock brake hydraulic control unit was bad. Part #68236997aa. Dodge discontinued and no aftermarket replacement. I am probably not the only person with this safety problem.

NHTSA ID

11680721

Incident

Aug 8, 2025

The contact owns a 2014 Dodge Charger. The contact stated that while operating the vehicle, the message "Service Transmission" displayed, with a grinding sound coming from the transmission. The cause of the failure was not yet determined. The vehicle was taken to the local auto parts store and the message "Lost Communication with ECM and PCM" was displayed. The vehicle was not repaired. The local dealer was notified of the failure. Additionally, the cruise control was inoperable, and the ABS warning light remained illuminated while operating the vehicle. The cause of the failures were not yet determined. The manufacturer was not yet contacted. The failure mileage was 33,665.

NHTSA ID

11668823

Incident

Jun 21, 2025

Mileage

33,665 mi

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed

AIR BAG - SIDE CURTAIN