2018 Dodge Charger

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE IT WAS REQUESTED BY THE CONSUMER. DJR ******* DELETE VOQ *******

NHTSA ID

11734829

Incident

Apr 30, 2026

The contact owns a 2018 Dodge Charger. The contact stated that while driving at slow speeds, there was an abnormal, repetitive thud sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where the wheel bearings were replaced; however, after the repair, the failure persisted. The vehicle was taken back to the mechanic, where a diagnostic test was performed, and it was determined that the driveshaft needed to be replaced. The contact purchased the driveshaft and had the part replaced by the mechanic. Despite the repair, the failure returned after exiting the highway. Upon investigation, the contact discovered NHTSA Campaign Number: 18V281000 (Power Train) and associated the failure with the recall. The manufacturer was notified of the failure, and the contact was informed that the VIN was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 90,000.

NHTSA ID

11717796

Incident

Dec 15, 2025

Mileage

90,000 mi

The contact owns a 2018 Dodge Charger. The contact stated that while driving at an undisclosed speed, the contact noticed an abnormal sound, and the check engine warning light illuminated. The contact stated that the steering wheel was uncontrollable. The contact stated that the steering wheel turned independently in the unintended direction, and the contact had to pull the steering wheel back into the intended direction. The vehicle was driven to the shoulder of the road. The contact stated that a nearby driver pulled over and informed the contact that sparks of fire were coming from underneath the vehicle. The contact stated that the failure had occurred while his family was inside the vehicle. The vehicle was towed to the residence. The vehicle was then towed to an independent mechanic, where it was diagnosed with a failed drive shaft and hairline cracks in the transmission. The contact was informed that the drive shaft had detached and caused a hairline crack in the transmission. In addition, the contact was informed that the transfer case was leaking. The contact was informed that the transfer case and drive shaft needed to be replaced. The vehicle was being repaired. The vehicle was later towed to the dealer; however, the contact was informed that the repairs were not covered under a recall. The contact referenced two unknown recalls, which had similar failures; however, the contact was informed that the recall repairs had previously been performed, and the repair was not covered under warranty. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the recall repairs had been performed in 2018. The contact was advised to have the vehicle towed to the dealer for diagnostic testing. The failure mileage was approximately 180,000.

NHTSA ID

11709218

Incident

Dec 29, 2025

Mileage

180,000 mi

Back up camera not working. screen turns blue. tried resetting and had serviced. camera will not work. According to the Forum many others have the same issue

NHTSA ID

11691946

Incident

Apr 15, 2023

The drivers side headlight fuse melts continuously causing the headlights to go out specifically use 15 and few 16 for the HID headlights.

NHTSA ID

11690205

Incident

Apr 24, 2025

I have had to replace the vapor canister on 2 dodge chargers I have owned seems to be a common issue. Check engine light came on both instances one causing issues with inspection the other with emissions test and I had to replace the vapor canister on both in order to fix my issues delayed the process in getting my vehicle registered by the state. Seems there was a previous recall on the issue but has since lapsed the time period to have fixed with reimbursement had the issue checked by an auto services establishment and family member to confirm my issues and then repaired issues each time with a family member. I have also had several issues with the key fob the initial one I received the key itself was never cut for my vehicle so would not unlock my car had to have someone cut the key to access my doors, also the fob itself stopped working I had to pay to get replaced which stopped working several days later and they had issues when programming the key it had flagged issues in their systems giving issues programming since I still have not been able to have an operating key fob.

NHTSA ID

11664835

Incident

Feb 8, 2024

The unconnected touch screen spazzes out and I am unable to use it. I can’t even turn it off and the light flashing from it affects my eyes while driving at night.

NHTSA ID

11645097

Incident

Jan 1, 2025

The UConnect functions will not work and randomly initiates functions so it changes stations, adjusts heating/cooling, asks if I want to contact 911, etc. This is very distracting and unsafe. Most of these functions on the Uconnect inaccessible. The car began having intermittent problems in 2021 just after the "Warranty" expired. The dealer said it would cost about $2,200 to replace and Chrysler will not take responsibility. I see this issue is very common amongst other dodge owners. I am surprised there has not been a recall since it appears to be a common problem and it is unsafe. Been driving it over the past 2-3 years and it is totally non operable. I was hoping it would eventually be recalled. I keep same radio station on every tab so when it skips around, it at least stays on the same station. Only thing that works. If not recalled, Stellantis should at least bear some of the cost (not to make a profit) to assist in the replacement

NHTSA ID

11643662

Incident

May 18, 2022

Backup Camera Poor Image Quality Inspection

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders: Warranty, Mopar, Customer pay and Service contract. Order"68" part number for New unsold units only

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE