2019 Lincoln Nautilus

Transmission jerking/ stuttering in lower gears under 35 mph.

NHTSA ID

11764792

Incident

Aug 2, 2026

The contact owns a 2019 Lincoln Nautilus. After several days of rain, there was moisture inside the vehicle. The contact detected a foul odor and discovered water on the floorboard. A box in the rear of the vehicle was covered in water, and the inside front windshield was foggy, but the contact was unable to determine how the water had entered the vehicle. Later, while driving approximately 45-55 MPH in the rain, there was limited visibility, and the vehicle slid from left to right. The contact was unable to control the vehicle after the steering wheel became difficult to turn. The steering warning light illuminated, and the message "Steering System Failure Do Not Drive" was displayed. The contact arrived at the destination, but while restarting the vehicle, the messages "Advance Traction Assist," "Advance Hill," and "Lane Assist" were displayed, and the steering, traction control, and several other unknown warning lights were illuminated. The vehicle was towed to the dealer, who determined that the steering column control module had failed and that the steering assembly needed to be replaced due to water intrusion from the sunroof. The manufacturer was made aware of the failure. The failure mileage was approximately 98,222.

NHTSA ID

11761649

Incident

Aug 29, 2026

Mileage

98,222 mi

My 2019 Lincoln Nautilus (equipped with the 8F35 8-speed automatic transmission) has developed a severe, hazardous low-speed transmission shudder and hesitating vibration, primarily occurring under 35 mph. This vehicle has 85,000 miles on it. A certified dealership has diagnosed the vehicle with a failing torque converter, which is a known engineering defect heavily documented under manufacturer Technical Service Bulletin TSB 25-2154. This condition creates an immediate safety hazard. The vehicle intermittently hesitates and suffers from a sudden loss of power/acceleration when trying to accelerate from a stop or merge into low-speed traffic, risking a rear-end collision. Furthermore, the violent shuddering poses a risk of sudden powertrain lock-up or engine stalling while driving in active traffic. The manufacturer has not issued a recall despite knowing this component fails prematurely across this transmission family.

NHTSA ID

11759214

Incident

Aug 24, 2026

The car has started a jerking motion when it is at a stop sign, stop light, or and nu prolonged stoppage of the vehicle. It is worse when I have the auto-stop-start feature turned on. This started roughly 3 months ago.

NHTSA ID

11759173

Incident

Aug 24, 2026

There is a class action lawsuit regarding the transmission on my vehicle. The transmission is shuddering. My mechanic alerted me of the lawsuit, Lincoln Mercury has not put out a recall, but is aware of the problem. There are no error codes, tried a reset on the transmission. So it is not a software problem, but mechanical. I am concerned my transmission will go out while driving. This started at about 98000 miles, I am now at 106000 miles.

NHTSA ID

11758149

Incident

Feb 10, 2026

Left side climate control not working. Dashboard had to be removed in order to find the problem. Problem is a small plastic rod that operates the doors that direct the cold air. It is broken. My mechanic (Walkerton Auto Service) tried to order this part from the Ford dealer but was told that the entire box would have to be replaced. The cost of this part is just under $1600. This seems unreasonable. The plastic part seems in my opinion to be a design flaw. My vehicle has less than 100,000 miles on it. The part plus labor cost will be very expensive and just doesn't seem like a cost that I should be responsible for. I wonder if anyone else has had a similar problem. My vehicle is a 2019 Lincoln nautilus

NHTSA ID

11756920

Incident

Jul 15, 2026

2019 Lincoln Nautilus shudders between 20 to 45 MPH. We’ve had everything done from oil change, tire rotation, to Front end alignment to tune up. Only one mechanic suggested that there’s a bulletin about a torque. I don’t remember the bulletin #. He expressed that Ford knows about it but won’t service its customers. I called Planet Lincoln and the service guy acknowledged the bulletin and mentioned others who have had the same issue. They would diagnose for 135.00. When asked about estimates. He said without knowing the problem he really couldn’t but did say that having to replace torque/ transmission can run anywhere from 2800 to over 8-10,000.

NHTSA ID

11752234

Incident

Jan 10, 2026

Known structural defect Coolant intrusion into cylinder bores TSB 22-2229 Blown head gasket

NHTSA ID

11747915

Incident

Jun 25, 2026

This bulletin supersedes 26-2171. Reasons for update: update the Parts list to add a note to clarify the application of the part numbers W520102-S442 and 4S4Z-3N324-AA "FWD Only". Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder condition, most noticeable at speeds below 60 mph (100 km/h)  No relevant diagnostic trouble codes (DTC) present  Traceable shudder event with IDS/FDRS reading *(Figure 1)* This condition may be perceived/felt as an engine misfire. This may be due to a concern with the output planetary assembly.

This bulletin supersedes 26-2194. Reason for update: update the Parts list to correct a part description " Loctite 638", update the claim quantity for the drain/fill plug, update the claim quantity of the wheel hub bolts (Corsair) and limited the parts list for Edge/Nautilus to only the rear drive unit fluid. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid contamination.

This bulletin supersedes 25-2627. Reason for update: To add a Step to reprogram the all-wheel drive (AWD) module for Bronco Sport vehicles. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid contamination.

This article updates TSB 25-2154. Reasons for update: *Parts List *Service Procedure to replace the output planetary carrier assembly *Added 2023-2024 model year vehicles Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder condition, most noticeable at speeds below 60 mph (100 km/h)  No relevant diagnostic trouble codes (DTC) present  Traceable shudder event with IDS/FDRS reading *(Figure 1)* This condition may be perceived/felt as an engine misfire. This may be due to a concern with the output planetary assembly.

This article supersedes TSB 25-2466 to add Bronco Sport, Escape, Maverick and Corsair, as well as removing Expedition and Navigator. One time use parts for Corsair and Bronco Sport were also added to the parts list. Some of the vehicles listed in the Model statement above may exhibit a headliner rattle or sagging condition around the roof opening panel. This may be due to the adhesive separating from the headliner substrate.

Some 2019-2024 Ford and Lincoln vehicles equipped with SYNC3 may experience various connectivity concerns with The Ford App Lincoln App including but not limited to: missing activation prompt pop-upon the vehicle's center display screen when attempting to activate vehicle through The Ford App Lincoln App, incorrect location global positioning system GPS reported through The Ford App Lincoln App, problems with remote commands being performed through The Ford App Lincoln App and or incorrect data information reported on The Ford App Lincoln App. These symptoms will be accompanied by diagnostic trouble code DTC B156D 89 in the TCU. This may be due to the accessory protocol interface module APIM software. To correct the condition, update the APIM software.