1998 Lincoln Town Car

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.

THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.

There is no summary currently available

There is no summary currently available

all body frame has rust.

NHTSA ID

11541626

Incident

Aug 30, 2023

MAKES LOUD POPPING NOISE WHEN THE WHEEL IS TURNED TO THE EXTREME RIGHT OR LEFT WHETHER THE CAR IS BEING DRIVEN OR STANDING STILL. OCCASIONALLY, THE IGNITION WON'T TURN ON AND THE STEERING WHEEL IS LOCKED, CLOSING THE ENTIRE SYSTEM.

NHTSA ID

11084191

Incident

May 15, 2017

Mileage

150,000 mi

THE CRUISE CONTROL MODULE STOPPED WORKING ON MY VEHICLE AND NOW I'M TOLD IT CAN'T BE REPLACED. SUBSEQUENTLY, THE RADIO & A/C STOPPED WORKING. THIS CRUISE CONTROL MODULE HAD TO BE REPLACED BECAUSE OF IT'S ABILITY TO SPONTANEOUSLY COMBUST THE CAR IN FLAMES AS IT DID ON MY 1996 LINCOLN TOWN CAR. WHY DOESN'T THE GOVERNMENT ENFORCE THE RECALL LAWS? *TR

NHTSA ID

10552317

Incident

Jun 10, 2013

Mileage

72,534 mi

VEHICLE BEGAN TO OVER HEAT.ONCE IT GOT HOT, THE POWER OF CAR IS,WAS LOST. AFTER HAPPENING A FEW TIMES,I FOUND A VERY SMALL [PIN SIZE] HOLE IN THE THERMASTATE RECIEVING UNIT.THIS IS A PART OF THE MANIFOLD IT SELF. ALL ATTEMPS TO REPAIR THIS PROBLEM HAS FAILED.! TRYING TO FIX THIS PROVED IMPOSSIBLE.THIS PART IS IN FACT MADE OF SOME TYPE OF PLASTIC.AS IT HEATS UP THE PLASTIC EXSPANDS, AND RE-OPENS THE HOLE,WHICH HAS NOW BECOME A CRACK. ALL EFFORDS TO FIND A SEALENT TO STOP THE LEAK,HAS FAILED. TO HAVE THIS CRACK REPAIRED MEANS THAT THE ENTIRE TOP OF THE MOTOR [MANIFOLD] MUST BE RE-PLACED. FORD RE-PLACED THE TERMASTATE HOUSING UNIT IN 2000-2001, WITH AN ALUMINUM PIECE,PROBLEM SOLVED.THERE ARE NO RE-CALLS,NOR EVEN A NOTIFICATION,SENT OUT, TO ADDRESS THIS PROBLEM. I FEEL STORNLY THAT THIS IS IN FACT A KNOWN PROBLEM,WHICH FORD WAS AWARE OF,BUT DECIDED THAT IT DID NOT HAPPEN ENOUGH TO FIX IT.PLEASE NOTE::WHEN THE CAR OVRT HEATS IT SHUTS OFF THE POWER TO THE ENGINE!!! THIS COULD POTIENTIALLY BE AVERY DANGEROUS SITUATION,ESPECIALLY IN HIGH TRAFFIC,HIGH SPEED SITUATIONS!!!! *TR

NHTSA ID

10521255

Incident

Apr 17, 2013

Mileage

137,352 mi

I HAVE A 1998 LINCOLN TOWN CAR WITH LOW MILES (125,000). THE CHEAP PLASTIC THAT THE INTAKE MANIFOLD IS MADE OUT OF HAS CRACKED WERE THE HEATER HOSE CONNECTS IN THE BACK CAUSING THE VEHICLE TO NOT BE DRIVE-ABLE DUE TO OVERHEATING. *TR

NHTSA ID

10514652

Incident

May 31, 2013

Mileage

125,734 mi

TL* THE CONTACT OWNS A 1999 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE COMPLETING A TURN, THE FRONT DRIVER'S SIDE CONTROL ARM FAILED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 98V322000 (SUSPENSION: LOWER BALL JOINT), BUT THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 101,000 AND THE CURRENT MILEAGE WAS 110,000. *TR

NHTSA ID

10509556

Incident

May 8, 2012

Mileage

110,000 mi

TL* THE CONTACT OWNS A 1998 LINCOLN TOWN CAR. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND THE BATTERY WARNING LIGHT WAS ILLUMINATED. THE CONTACT WAS ABLE TO SUCCESSFULLY JUMP START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE ALTERNATOR WAS REPLACED BUT THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC WHERE THE CONTACT WAS THEN INFORMED THAT THE WIRING HARNESS WAS DAMAGED AND NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT RAIN WOULD LEAK IN THROUGH THE WINDOWS DURING RAINY WEATHER. THE MANUFACTURER WAS NOT MADE AWARE OF EITHER FAILURE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10448962

Incident

Jan 15, 2012

Mileage

150,000 mi

THE FUEL FILLER WILL NOT ACCEPT GASOLINE AT A NORMAL RATE. EVEN AT MINIMUM SPEED IT WILL SHUT OFF AND/OR SPIT FUEL BACK. HAVE USED DIFFERENT PUMPS, DIFFERENT STATIONS, DIFFERENT POSITIONS HAPPENS ALMOST 100% OF THE TIME. ALSO MAJOR WATER LEAKAGE AROUND WINDSHIELD ON PASSENGER SIDE OF CAR. *TR

NHTSA ID

10435185

Incident

Jun 22, 2011

FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. *PE

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

CUSTOMER SATISFACTION PROGRAM 05B31 - INFORMATION ONLY. A POSSIBILITY THAT DURING A HIGH SPEED / HIGH ENERGY REAR COLLISION, CERTAIN COMPONENTS HAVE AN INCREASED RISK OF PUNCTURING THE FUEL TANK ON VEHICLES WITH LIMO PREP PACKAGE LIMO PACKAGE UPGRADE KIT OFFERING. *TT SUPPLEMENT #1. *TT UPDATED SUPPLEMENT #2. *TT

EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIFOLD TO 7 YEARS FROM THE ORIGINAL WARRANTY START DATE OF THE VEHICLE, WITH NO LIMIT ON THE NUMBER OF MILES THAT THE VEHICLE HAS BEEN DRIVEN. *TT

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT