1998 Oldsmobile Cutlass

IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.

GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.

ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.

There is no summary currently available

TL* THE CONTACT OWNS A 1998 OLDSMOBILE CUTLASS. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 07E021000 (FUEL SYSTEM, OTHER). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 93,500.

NHTSA ID

10667719

Incident

Nov 24, 2014

Mileage

93,500 mi

GENERAL MOTORS RECENTLY RECALLED THE 1997-2005 CHEVROLET MALIBU FOR THE IGNITION SWITCH PROBLEM. I OWN THE SISTER VEHICLE WHICH IS A 1998 OLDSMOBILE CUTLASS. THIS VEHICLE IS THE IDENTICAL LAYOUT OF THE CHEVROLET MALIBU WHICH HAS BEEN RECALLED. I SENT A COUPLE OF E-MAIL MESSAGES TO THE GM CUSTOMER ASSISTANCE CENTER AND JUST RECEIVED A PHONE CALL EXPLAINING TO ME THAT AT THIS TIME THEY HAD NO INTENTION OF DOING A RECALL ON THE OLDSMOBILE CUTLASS FOR THE IGNITION SWITCH. EVEN THOUGH I HAVE NOT ENCOUNTERED A PROBLEM WITH MY IGNITION SWITCH AS OF YET, I DEEM IT A SAFETY ISSUE WHICH GM SHOULD FIX. I DO NOT KNOW IF ANYONE ELSE HAS COMPLAINED OF SIMILAR ISSUES AS MINE, BUT I WANTED TO INFORM YOU OF MY CONCERNS. I DO NOT KNOW IF THIS IS THE PROPER FORUM FOR THIS, SO IF NOT, PLEASE FORWARD MY CONCERNS TO THE PROPER AUTHORITIES. THANK YOU *TR

NHTSA ID

10609708

Incident

Jul 10, 2014

Mileage

117,000 mi

HAVE HAD IGNITION SWITCH JUST SHUT OFF DRIVING DOWN THE ROAD. EXACTLY AS DESCRIBED IN GM'S RECENT RECALL ON IGNITION SWITCHES ON NEWER CARS. LOSES ALL ELECTRICAL POWER AND ENGINE SHUTS OFF. HAS HAPPENED NUMEROUS TIMES WHILE I HAVE OWNED IT FOR THE LAST 10 OR SO YEARS. WHEN IT HAPPENS I JUST QUICKLY PUT IT IN NEUTRAL AND RESTART IMMEDIATELY. THIS IS A 1998 OLDS CUTLASS. IT IS APPARENT THAT GM'S PROBLEM WITH THEIR IGNITION SWITCH GOES BACK A LOT FARTHER THAN THEY CARE TO ADMIT. *TR

NHTSA ID

10576006

Incident

Mar 1, 2006

Mileage

70,000 mi

FRAME, WHERE STEERING RACK BOLTS TO, RUSTED OUT. STEERING RACK BECAME SEPARATED FROM THE FRAME CAUSING A DANGEROUS STEERING CONDITION. FRAME NEEDS TO BE REPLACED AT A VERY HIGH COST. *TT

NHTSA ID

10537788

Incident

Aug 28, 2013

Mileage

141,000 mi

98 OLDS CUTLASS. REAR BRAKE LINES RUSTED THROUGH IN VICINITY OF LR WHEEL . RESULTED IN SUDDEN TOTAL LOSS OF BRAKING DUE TO LOSS OF ALL BRAKE FLUID. NO SEPARATE RESERVOIR FOR FRONT BRAKE FLUID. HEARD OF SIMILAR EVENT WITH SAME MODEL STYLE CHEVY MALIBU. NO YEAR KNOWN. *TR

NHTSA ID

10315673

Incident

Jun 1, 2009

Mileage

120,000 mi

TL*THE CONTACT OWNS A 1998 OLDSMOBILE CUTLASS. THE CONTACT STATED THAT THE STEERING WHEEL WOULD TIGHTEN WHEN MAKING RIGHT AND LEFT TURNS. HE RECEIVED A RECALL LETTER PERTAINING TO THE STEERING RACK AND PINION, WHICH STATED THAT THE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY WERE NOT CRIMPED PROPERLY. THIS IS WHERE THE RETAINER TABS WERE LOCATED. THE FAILURE COULD ALLOW THE BALL BEARINGS TO ESCAPE. THE DEALER REPAIRED THE VEHICLE ACCORDING TO NHTSA CAMPAIGN ID NUMBER 03V527000 (STEERING:RACK AND PINION); HOWEVER, THE CONTACT FELT NO CHANGE IN THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER A SECOND TIME FOR REPAIRS, BUT THE FAILURES STILL PERSISTED. IN ADDITION, THE CONTACT HEARD A LOUD CONTINUOUS BANGING NOISE COMING FROM THE STEERING COLUMN. THE FAILURE MILEAGE WAS 66,051 AND CURRENT MILEAGE WAS LESS THAN 125,096.

NHTSA ID

10257421

Incident

Nov 10, 2003

Mileage

66,051 mi

I WORK FOR A IGNITION INTERLOCK COMPANY. I HAVE SEEN SEVERAL VEHICLES ENTER THE SERVICE CENTER WITH PROBLEMS WITH THE IGNITION SWITCH. THE KEY HAS TO BE SHAKEN SEVERAL TIMES IN ORDER TO GET THE KEY TO TURN TO START THE VEHICLE. THESE IGNITIONS ARE MOUNTED TO THE RIGHT OF THE STEERING COLUMN. I HAVE NOTICED IT ON ALMOST EVERY VEHICLE THAT HAS THE IGNITION MOUNTED TO THE RIGHT OF THE STEERING COLUMN NOT ON THE COLUMN. THAT IS AN OLDSMOBILE. I OWN THE 1998 OLDMOBILE CUTLASS. WAS THERE EVER A RECALL AS DEFECT OF THIS IGNITION AND IS THE DEALERSHIP RESPONSIBLE FOR REPLACEMENT? IF I EVER HAD AN EMERGENCY I WOULD NOT BE ABLE TO START MY CAR RIGHT AWAY AS IT AT TIMES TAKES UP TO FIVE TO TEN MINUTES TO GET THE KEY TO TURN. *TR

NHTSA ID

10250738

Incident

Dec 3, 2008

1) THE FAILURE OCCURRED UNDER NORMAL USE OF WIPERS IN HEAVY RAIN. 2) DURING NORMAL USE, THE PASSENGER SIDE WIPER ARM APPEARED TO BECOME DISLODGED AND BEGAN MOVING ERRATICALLY. AFTER INSPECTION OF THE WIPER ASSEMBLY IT WAS DISCOVERED THAT THE PLASTIC HOUSING THAT HOLDS THE WIPER ARM TO THE WIPER MOTOR WAS CRACKED AND BROKEN AWAY FROM THE LINKAGE TO THE WIPER MOTOR. THE CONSEQUENCES OF THIS FAILURE IS THAT NEITHER WIPER ARM OPERATES AND THIS CAUSES HAZARDOUS DRIVING CONDITIONS BY REDUCING VISIBILITY DURING RAIN OR FROST. 3) AFTER RESEARCHING THIS APPARENT DEFECT IN THE MANUFACTURERS ORIGINAL PART, I DISCOVERED AN OPEN RECALL IS ALREADY IN EFFECT FOR THIS PARTICULAR YEAR, MAKE, AND MODEL (NHTSA CAMPAIGN ID# 01V068000). THE DESCRIPTION UNDER THIS RECALL IS IDENTICAL TO THE PROBLEM I ENCOUNTERED AND IS FOR THE SAME VEHICLE. I CONTACTED THE MANUFACTURER, GM-OLDSMOBILE, AND THE OPEN RECALL WAS VERIFIED, BUT I WAS TOLD MY PARTICULAR VIN# WAS NOT ON THEIR LIST. I WAS TOLD THAT IF GM HAPPENS TO ADD OTHER VEHICLES FROM THE SAME YEAR, MAKE, AND MODEL TO THE LIST THEN I WOULD BE NOTIFIED, BUT NO REPAIRS WOULD BE OFFERED. *TR

NHTSA ID

10206993

Incident

Oct 10, 2007

Mileage

154,000 mi

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.