2002 Mercedes-Benz S430 Electrical Problems

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ S430. THE CONTACT STATED THAT ILLUMINATION OF THE INSTRUMENT CLUSTER WAS INADEQUATE TO SEE THE GAUGES. FLETCHER JONES IMPORTS (7300 W SAHARA AVE, LAS VEGAS, NV 89117, (702) 364-2700) WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WARRANTY EXPIRED IN 2012. THE CONTACT WAS INFORMED THAT A DIAGNOSTIC TEST NEEDED TO BE PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER TO BE DIAGNOSED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 209,000.

NHTSA ID

11377484

Incident

Sep 12, 2019

Mileage

209,000 mi

I HAVE APPROXIMATELY 104,000 MILES, I CANNOT SEE IT ANYMORE BECAUSE WHILE DRIVING HOME AT NIGHT FROM THE AIRPORT ON THE EXPRESSWAY DOING 65 MILES PER HOUR, IT WENT BLACK. ALL THE GAUGES WERE FOUND STUCK IN THEIR LOCATION THE NEXT MORNING AT WHAT THEY WERE AT WHEN THE CLUSTER WENT BLACK. THE CLUSTER HAS NEVER RECOVERED AND I HAVE TO DRIVE WITH NO IDEA OF SPEED, SIGNALS OPERATION, FUEL LEVEL, OR WATER TEMP. THE INFORMATION DISPLAY IS ALSO BLANK SO I DON’T KNOW WHAT MY MILEAGE IS OR IF THE VEHICLE HAS ANY OTHER INFORMATION TO GIVE ME. I HAD TO DRIVE HOME 60 MILES IN THE DARK. MY HEADLIGHTS GO ON ALL BY ITSELF WHENEVER I START MY CAR NOW. MY CLIMATE CONTROL ALSO REMAINS LIT AND CAUSES A BATTERY DRAIN OVER A PERIOD OF TIME. I WAS VERY LUCKY TO MAKE IT HOME BUT NOW I CAN ONLY DRIVE DURING THE DAYTIME UNTIL I CAN GET MY INSTRUMENT CLUSTER REPAIRED. MY COMFORT LEVEL DRIVING THIS VEHICLE HAS DIMINISHED GREATLY, THIS VEHICLE IS MY FAMILY VEHICLE, DOES MERCEDES BENZ NOT CARE ANYMORE. IF ONE OF THEIR FAMILY MEMBERS WERE TO PERISH IN AN ACCIDENT AS A RESULT OF THIS PROBLEM I’M PRETTY SURE THEY WOULD IMMEDIATELY FIND A SOLUTION TO FIX IT.

NHTSA ID

11150205

Incident

Nov 7, 2018

Mileage

104,400 mi

INSTRUMENT LIGHTS WENT OUT, CAN'T SEE SPEED OR OTHER DASH INFORMATION SUCH AS FUEL. REAR SUSPENSION LOOSES AIR, CAR SITS TO LOW TO DRIVE, BODY SITS ON REAR TIRES. HAPPENED WHILE DRIVING CITY STREET, TIRES SMOKED AND ARE PITTED.

NHTSA ID

11128840

Incident

May 29, 2018

THE BATTERY LOCATED IN THE TRUNK OF THE VEHICLE IS SITUATED NEXT TO THE GAS TANK. THERE ARE NO COVERS ON THE METAL PARTS ON THE TOP OF THE BATTERY LOCATED IN THE TRUNK OF THE VEHICLE, AND THE MAT THAT COMES WITH THE VEHICLE DOES NOT SUFFICIENTLY COVER THESE METAL POLES, LEAVING THEM VULNERABLE TO CATCH FLAME WHEN METAL ITEMS ARE IN THE BACK OF THE VEHICLE. THE REAR BATTERY CAUGHT FLAME, WHILE STATIONARY, DUE TO A METAL ROD USED FOR FURNITURE ASSEMBLY TOUCHING THE EXPOSED PORTION OF THE BATTERY.

NHTSA ID

11047153

Incident

Sep 2, 2017

Mileage

110,000 mi

WHILE DRIVING ON 12/10/2016, THE INSTRUMENT CLUSTER PANEL WENT VERY DARK. AT NIGHT THERE WAS NO ILLUMINATION EITHER. ALSO THE SPEEDOMETER WAS FLUCTUATING WILDLY FROM HIGH TO LOW AND BACK. I COULD ONLY SEE THIS WITH MY INTERIOR LIGHT ON, AS THE DASH PANEL WAS DARK. I REALIZED I COULD NOT READ ANY OF THE OTHER THE GAUGES INCLUDING THE SAFETY WARNING DISPLAY PANEL, NOR DID THE TURN SIGNALS INSIDE THE VEHICLE WORK OR THE VOLUME CONTROL ON THE STEERING WHEEL. THE VEHICLE WAS IN MOTION AT THE TIME. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING). ON 12/15/16 THE MANUFACTURER WAS NOTIFIED OF MY FAILURE. THE MANUFACTURER INFORMED ME THAT IT WAS NOT A RECALL BUT A "VOLUNTARY EXTENDED WARRANTY ISSUE". THE MANUFACTURER EXPLAINED TO ME THAT MY CAR WAS PART OF IT, BUT I WAS "OUT OF TIME" WITH MY REQUEST FOR REPAIR OR REPLACEMENT. AT THE TIME THE CAR HAD APPROXIMATELY 195,000 ON IT. THIS IS THE 5TH MERCEDES I HAVE OWNED, READING FROM THE BLOGS THIS IS A VERY COMMON PROBLEM, HENCE THE NHTSA INVOLVEMENT. MINE IS A DOCUMENTED FAILED CASE UNDER MERCEDES RECOGNIZED PROGRAM, BUT THEY FAIL TO FOLLOW-UP WITH THEIR EXTENDED WARRANTY COVERAGE BECAUSE IT IS OUT OF TIME. WHETHER IT IS IN TIME OR OUT OF TIME A SAFETY FAILURE IS A SAFETY FAILURE. ONE WOULD THINK THAT A COMPANY LIKE MERCEDES BENZ WOULD WANT TO KEEP ALIVE A 5 TIME OWNER OF MERCEDES AND PUT BRAND LOYALTY OVER PROFIT. I HAVE THREE CHILDREN NOW ENTERING THEIR CAR OWNING YEARS. THEY HAVE GROWN UP WITH MERCEDES BUT I GUESS IT IS NOW TIME TO SHOW THEM ANOTHER CAR BRAND SO THEY CAN BE A CUSTOMER FOR LIFE TO ANOTHER AUTOMOBILE COMPANY, ONE THAT WILL PLACE THEIR LIFE AHEAD OF THE PROFIT ON AN INSTRUMENT CLUSTER. I ASK THE NHTSA TO FORCE MERCEDES TO RECALL THESE SAFETY PRONE CARS SUCH THEY CANNOT HIDE BEHIND THEIR "OUT OF TIME" EXCUSE. *TR

NHTSA ID

10935564

Incident

Dec 10, 2016

Mileage

195,000 mi

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ S430. WHILE DRIVING 25 MPH, THE INSTRUMENT CLUSTER BECAME INOPERABLE AND THE VEHICLE LOST POWER. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 108,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10876363

Incident

Jun 19, 2016

Mileage

108,000 mi

WHILE DRIVING DURING DAYLIGHT HOURS ON FRIDAY, 6/17/2016, I NOTICED THE INSTRUMENT CLUSTER PANEL WAS VERY DARK. THE CAR WAS NOT DRIVEN AGAIN UNTIL DUSK, ON SATURDAY, 6/18/2016 AND I REALIZED ALL OF THE INSTRUMENT PANEL LIGHTS WERE OUT, THE GAUGES WERE NOT WORKING NOR DID THE TURN SIGNALS INSIDE THE VEHICLE OR THE AUTOMATIC LOCKS, WORK OR THE VOLUME CONTROL ON THE STEERING WHEEL. THE VEHICLE WAS IN MOTION AT THE TIME OF THIS DISCOVERY

NHTSA ID

10875334

Incident

Jun 17, 2016

Mileage

92,500 mi

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ S430. WHILE DRIVING 60 MPH, THE INSTRUMENT PANEL FAILED TO ILLUMINATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL CLUSTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,500.

NHTSA ID

10875241

Incident

Jun 16, 2016

Mileage

60,500 mi

INSTRUMENT CLUSTER FAILS TO FUNCTION OR LIGHT UP WHEN STARTED OR DRIVING.

NHTSA ID

10807357

Incident

Mar 18, 2015

Mileage

111,500 mi

WHILE DRIVING ON MY WAY HOME MY INSTRUMENT CLUSTER WENT COMPLETELY DARK THIS IS THE FIRST TIME THIS HAPPEN, PARK IT FOR 2 DAYS. TRIED TO OPEN MY DOOR BATTERY WAS DEAD REPLACE BATTERY FOUND 5 AMP FUSE BLOWN IN THE LEFT SAM, CLUSTER FLICKER AND WENT DARK. CHECK MY VIN NUMBER ON THE MB WEBSITE NO REAL LED ON MY INSTRUMENT CLUSTER

NHTSA ID

10758512

Incident

Aug 19, 2015

Mileage

100,200 mi

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S430. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE INSTRUMENT PANEL FLICKERED AND THEN FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS INFORMED THAT THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 129,000.

NHTSA ID

10747122

Incident

Aug 7, 2015

Mileage

129,000 mi

WHILE DRIVING, MY CAR INSTRUMENT CLUSTER BEGAN TO FLICKER. INITIALLY IT JUST DIMMED BUT AFTER A FEW MINUTES OF FLICKERING IT STOPPED. LATER THAT DAY IT WENT. *TR

NHTSA ID

10644902

Incident

Oct 7, 2014

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S430. THE CONTACT STATED THAT WHEN DRIVING AT NIGHT, THE INTERIOR, THE INTERIOR, AND THE INSTRUMENT PANEL FAILED TO ILLUMINATE. IN ADDITION, THE CONTACT STATED THAT THE AIRMATIC SHOCKS DROPPED CAUSING THE VEHICLE TO BECOME LOW AND DIFFICULT TO TURN THE WHEELS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 185,000.

NHTSA ID

10633719

Incident

May 14, 2013

Mileage

185,000 mi

FIRST INCIDENT IN OCTOBER 2013 INSTRUMENT PANEL SUGGESTED THAT REAR LIGHTS WERE MALFUNCTIONING. TOOK IN TO MECHANIC AND REPLACED FUSE, THEN APPROX. 3 WEEK LATER REPEATED MALFUNCTION, BUT NOW THE INSTRUMENT PANEL WENT DARK. REPLACED FUSE AGAIN, AFTER THIS TIME IT LASTED FOR ANOTHER COUPLE OF WEEKS. NOW IT'S DECEMBER 2013 AND THE ENTIRE INSTRUMENT PANEL IS DARK, NO MILEAGE, SPEEDOMETER, FUEL OR SAFETY GAUGES. MECHANIC TOOK ANOTHER LOOK AND ADVISED THAT IT WAS THE INSTRUMENT CLUSTER. I KNOW THERE IS A RECALL ISSUED ON THIS SAFETY ITEM. WOULD LIKE TO GET SOME HELP RESOLVING THIS ISSUE. *TR

NHTSA ID

10558888

Incident

Oct 30, 2013

INSTRUMENT PANEL BLANKED OUT WHILE DRIVING, CREATING AN EXTREMELY DANGEROUS SCENARIO. THIS SEEMS TO BE A REPETITIVE COMPLAINT ON LINE. SURPRISING THAT IT IS NOT PART OF THE RECALL. *TR

NHTSA ID

10546028

Incident

Sep 14, 2013

ALL LIGHTING ON INSTRUMENT PANEL BEGAN FLICKERING ON AND OFF ,PANEL REMAINED TOTALLY DARK, NO LIGHTS, NOTHING WORKED ON STEERING WHEEL. I WAS DRIVING ABOUT 50 MPH AND IT WAS DARK. COULD NOT SEE ANY LIGHTING ON GAUGES. TOOK VEHICLE TO DEALER WAS TOLD ABOUT RECALL ON INSTRUMENT CLUSTER .AFTER CHECKING FOUND OUT THAT MY VEHICLE WAS NOT INCLUDED IN RECALL. I FEEL THAT IT SHOULD HAVE BEEN INCLUDED BECAUSE MY VEHICLE HAD ALL INDICATIONS REFERRED TO IN PARTICULAR RECALL OF INSTRUMENT CLUSTER. THIS NEEDS TO BE INVESTIGATED FURTHER. *TR

NHTSA ID

10509995

Incident

Apr 8, 2013

Mileage

143,008 mi

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S430. THE CONTACT STATED THAT THE INSTRUMENTAL PANEL LIGHTS WOULD FLICKER ON AND OFF FOR SEVERAL MONTHS UNTIL THE BACK LIGHTS FINALLY FAILED. THE INSTRUMENT PANEL WAS COMPLETELY DARK AND THE CONTACT COULD NOT DETERMINE THE SPEEDS DRIVEN, FUEL LEVELS, ETC. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE AND ADVISED THAT THE INSTRUMENTAL CLUSTER HAD TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. THE CURRENT MILEAGE COULD NOT BE DETERMINED DUE THE INSTRUMENT PANEL FAILURE.

NHTSA ID

10481422

Incident

Aug 1, 2012

Mileage

140,000 mi

THE INSTRUMENT CLUSTER WENT DARK WHILE DRIVING BACK HOME ON A MAJOR HIGHWAY. YOU CANNOT READ THE VEHICLE'S GAUGES, SPEEDOMETER, AND WARNING INDICATORS, ETC. THE DRIVER WAS UNABLE TO READ THE GAUGES AND INDICATORS, SUCH AS SPEEDOMETER AND INCREASED THE RISK OF A CRASH AND MAJOR SAFETY IMPACT TO OCCUPANTS AND TO THE PUBLIC. THIS IS A KNOWN ISSUE WITH MERCEDES BENZ AND I WAS TOLD THAT, THE VEHICLE IS OUT OF WARRANTY. WOULD LIKE TO SEE DOT MAKE THIS ISSUE A 100% SAFETY RECALL ON VEHICLES REGARDLESS OF WARRANT PERIOD. *TR

NHTSA ID

10471497

Incident

Aug 17, 2012

Mileage

121,000 mi

THE GEAR SHIFTER HAD LOCKED INITIALLY OUT OF THE BLUE, I COULDN'T GET THE CAR OUT OF DRIVE. I TURNED IT OFF TO STOP IT AND THEN IT WOULDN'T GO INTO PARK. AFTER THE MERCEDES TECH CAME OUT IT WOULDN'T START AT ALL. THE TECH SAID IT WAS MOST LIKELY A SAFETY FEATURE WHICH HAD KICKED IN. THEN THE WHOLE RIGHT SIDE WENT DOWN. I AM TOLD THE AIRMATIC SUSPENSION WENT OUT. WHY? THE CAR SAID STOP AIRMATIC TO LOW. I HAVE NEVER HAD ANY PROBLEMS WHICH MAY HAVE LEAD UP TO THESE ISSUES. UNFORTUNATELY I CAN NOT AFFORD THE $2,000 TO REPAIR THIS ISSUE WITH THE AIRMATIC. IS THERE ANY KIND OF RECALL ON THIS VEHICLE OR WARRANTY WITH MERCEDES THAT IS RESPONSIBLE. THE ELECTRICAL PROBLEM IS THE RADIO GOING OUT FOR 2-3 MONTHS AND THEN COMING BACK ON OUT OF THE BLUE. THE DOOR OPEN SIGNAL NOT GOING OFF IN THE ALERTS. THE TRUNK SWITCH NOT WORKING TO OPEN THE TRUNK, IT CAN ONLY BE OPENED MANUALLY. LASTLY THE HEADLIGHTS CONTINUALLY GOING OUT AFTER REPLACING THE BULB FOR 1 MONTH. RUST AND DETERIORATION ON THE ROOF BY THE SUNROOF. *TR

NHTSA ID

10458206

Incident

May 10, 2012

Mileage

80,000 mi

CLUSTER IN DASH BLEW OUT. *TR

NHTSA ID

10457736

Incident

May 5, 2012

Mileage

100,230 mi