2009 Mercury Mariner Hybrid

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages

VEHICLE STEERING IS INTERMITTENTLY GOING OUT AND DRIVER IS UNABLE TO TURN THE VEHICLE. I HAVE CONTACTTED FORD AND THERE IS AN EXISTING RECALL (14S05) FOR THIS VERY ITEM AND MY VEHICLE (YEAR, MAKE & MODEL) IS LISTED BUT THEY SAY MY SPECIFIC VEHICLE DOES NOT QUALIFY.

NHTSA ID

11209102

Incident

May 20, 2019

Mileage

160,000 mi

POWER STEERING WENT OUT, COULDN'T TURN VEHICLE FAST ENOUGH TO AVOID CRASH. RECALL 14S05.

NHTSA ID

11186852

Incident

Feb 7, 2019

Mileage

128,400 mi

TL* THE CONTACT OWNS A 2009 MERCURY MARINER HYBRID. WHILE DRIVING APPROXIMATELY 25 MPH, THE POWER STEERING FAILED WITHOUT WARNING AND THE STEERING BECAME DIFFICULT TO TURN. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING). NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

NHTSA ID

11142526

Incident

Oct 24, 2018

Mileage

96,000 mi

ELECTRONIC POWER STEERING MODULE FAILURE, REPLACE ENTIRE MODULE & COLUMN FOR $1698.89. SAID PREVIOUS RECALL WAS PERFORMED AND FORD BEARS NO RESPONSIBILITY.

NHTSA ID

11132863

Incident

Sep 27, 2018

Mileage

66,000 mi

I WAS ON MY WAY TO DROP MY 3 MONTH OLD OFF AT DAYCARE AND THEN TO WORK. I WAS DRIVING DOWN THE HIGHWAY GOING 60 MPH WITH THE CRUISE CONTROL SET WHEN I FEEL THE CAR START TO JERK BACK AND FORTH A LITTLE. I LOOK AT MY GAUGES ALL ARE NORMAL EXCEPT THE RPM GAUGE IS JUMPING UP AND DOWN THEN ALL OF A SUDDEN IT IS KICK OUT OF CRUISE CONTROL, AND I LOSE ACCELERATION AND A WRENCH LIGHT CAME ON. I WAS ALMOST HIT BY 2 VEHICLES BECAUSE OF THE SUDDEN LOSE ON SPEED. AS I WAS LOSING ACCELERATION, I WAS TRYING NOT TO BRAKE BECAUSE I THOUGHT IT WAS GOING TO DIE. IT DID NOT DIE BUT I WAS NOT ABLE TO GO ANY FASTER THAN 25 -30 MPH. I DROVE IT STRAIGHT TO MY MECHANIC AND GOT THE CODE P2112. THIS IS FOR THE THROTTLE BODY. THERE WAS A RECALL ISSUED ON THIS FOR THE MERCURY MARINERS BUT IT DID NOT INCLUDE THE HYBRIDS. PLEASE HELP

NHTSA ID

11020561

Incident

Aug 29, 2017

Mileage

128,000 mi

STEERING TORQUE SENSOR IS FAILING, RESULTING IN LOSS OF STEERING CONTROL. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL THAT FORD ALREADY ISSUED FOR THE PROBLEM IN 2014 BUT SHOULD BE.

NHTSA ID

10956031

Incident

Feb 1, 2017

Mileage

119,000 mi

WHILE MAKING A SHARP LEFT TURN ON A CITY STREET THE POWER STEERING ASSIST SYSTEM FAILED COMPLETELY! I BARELY AVOIDED A COLLISION. APPARENTLY THERE HAVE BEEN THOUSANDS OF SIMILAR FAILURES. WHY HASN'T FORD PAID FOR A REPAIR ON A SYSTEM WHICH IS OBVIOUSLY FLAWED AND DANGEROUS WHEN IT FAILS!

NHTSA ID

10944964

Incident

Jan 12, 2017

Mileage

130,000 mi

THROTTLE BODY PROBLEM. ALL OF A SUDDEN I HAD NO POWER AND BARELY MADE IT HOME. I HAD TO BE TOWED TO RAMEY FORD IN PRINCETON, WV THEY REPLACED THROTTLE BODY BUT I HAD TO PAY $100 DEDUCTIBLE. THIS CAR WAS PART OF A CUSTOMER SERVICE ARRANGEMENT WORKED OUT WITH NHTSA BUT THE VIN WAS NOT INCLUDED AND I WAS TOLD IT WAS NOT COVERED FOR COST OF REPLACEMENT . THIS WAS A VERY DANGEROUS SITUATION AND COULD HAVE RESULTED IN AN ACCIDENT. I FEEL THE PART SHOULD HAVE BEEN REPLACED WITHOUT ANY CHARGE SINCE OTHER VEHICLES IN THIS CLASS HAD THE SAME PROBLEM. THERE WAS NO OFFER TO REIMBURSE ME FOR MY TOW SINCE THE VEHICLE WAS TOTALLY DISABLED. THIS WAS A PROBLEM THAT FORD AND THE NHTSA WERE AWARE OF AND MY VEHICLE HAD THE SAME PROBLEM AS OTHERS. I FEEL THAT I SHOULD NOT HAVE TO PAY FOR LABOR OR TOW TO CORRECT A DEFECT. *TR

NHTSA ID

10929802

Incident

Nov 3, 2016

Mileage

40,000 mi

FORD/MERCURY: SOME HYBRID VEHICLES MAY REQUIRE A UNIQUE BLEED PROCEDURE AFTER A REPLACEMENT FOR ONE OR MORE OF HYDRAULIC BRAKE SYSTEM COMPONENTS. *PE

FORD/MERCURY: TRACTION CONTROL LIGHT WITH DTC C1440. SOME VEHICLES BUILT MAY EXHIBIT THE TRACTION CONTROL LIGHT ON WITH DTC CODE C1440. IF THE VEHICLE IS OPERATED FOR AN EXTENDED PERIOD FOLLOWING THE ILLUMINATION OF THE TRACTION CONTROL LIGHT, A SLIGHT BRAKE DRAG CONDITION MAY BE OBSERVED. *PE