1998 Mercury Mountaineer Owner Complaints

AT THIS POINT ALL 4 DOOR LOCKS/LATCHES ARE MESSED UP. BOTH DRIVER &PASSENGER BACK DOORS WON'T OPEN FROM OUTSIDE OR INSIDE. DRIVER &PASSENGER FRONT DOORS WON'T OPEN FROM OUTSIDE UNLESS OPEN FROM INSIDE FIRST. KEY WON'T UNLOCK DOORS. BACK GLASS ON HATCH DOOR WON'T OPEN. BACK WIPER BROKEN. BACK HATCH WOULDN'T OPEN UNTILL I PAID TO HAVE IT FIXED. I CONTACTED THE MANUFACTURER THEY SAID MY TRUCK NOT ON RECALL LIST & WANTED ME TO PAY TO FIX IT. MY TRUCK HAS SAME ISSUES AS THE ONES BEING RECALLED. HOW DO THEY DETERMINE WHICH ONES TO RECALL?

NHTSA ID

11062659

Incident

May 20, 2015

UNDER MY HOOD STARTED SMOKING, I POPPED MY HOOD TO FIND FLAMES UNDER IT. I HAD TO GET MY KIDS OUT THE TRUCK AND PUT THE FLAMES OUT WITH AND EXTINGUISHER. THAT'S WHEN I NOTICED THAT MY BRAKE FLUID RESERVOIR WAS MELTED AND SO WERE THE WIRES THAT CONNECT TO THE CRUISE CONTROL SWITCH. NOT I AM WITHOUT A VEHICLE TO GET TO WORK AND GET MY CHILDREN TO SCHOOL.

NHTSA ID

11047281

Incident

Nov 18, 2017

Mileage

190,000 mi

DRIVERS SEAT BROKEN UNABLE TO ADJUST FOR PROPER VISION VIA WINDSHIELD.

NHTSA ID

10872444

Incident

Nov 6, 2015

Mileage

155,000 mi

ONE OF THE BRAIDED STAINLESS STEEL FUEL LINES THAT ATTACHES TO THE ENGINES FUEL RAIL DEVELOPED A LEAK. I KEPT SMELLING A STRONG ODOR OF GAS, BUT I COULD NOT FIND OUT WHERE IT WAS COMING FROM. AFTER TWO WEEKS OF SMELLING THE GAS, I TOOK IT TO A GARAGE AND THEY SHOWED ME THE GAS SQUIRTING FROM THE BRAIDED HOSE GOING TO THE ENGINE. I TOOK THE VEHICLE TO THE FORD DEALER AND SHOWED THEM THE LEAK. THEY TOOK THE VEHICLE IN THEIR SHOP AND REMOVED THE FUEL LINES. BECAUSE OF THE AGE OF THE VEHICLE, FORD DOES NOT PROVIDE ANY REPLACEMENT PARTS. I WAS UNABLE TO GET REPLACEMENT FUEL LINES FROM FORD. I CHECKED WITH "JUNK YARDS" ALL OVER THE COUNTRY. I HAD NO LUCK FINDING REPLACEMENT FUEL LINES. JUNK YARDS CUT THE FUEL LINE WHEN THEY PULL ENGINES. I FINALLY LOCATED A COMPANY IN NEW CASTLE, DE THAT SUPPLIES HYDRAULIC HOSES, ETC. I TOOK MY OLD FUEL LINES TO THEM AND THEY REMOVED THE FITTINGS AND INSTALLED THEM ON NEW STAINLESS STEEL BRAIDED LINES. I TOOK THE NEW LINES BACK TO THE FORD DEALER AND THEY INSTALLED THEM ON MY VEHICLE. THEY SAID THE NEW HOSES HAD NO LEAKS. THE FORD DEALER CHARGED ME OVER $400.00 TO REMOVE THE OLD HOSES AND INSTALL NEW HOSES. THE SHOP IN NEW CASTLE, DE ONLY CHARGED ME $40.00 FOR A PAIR OF NEW HOSES. I'M VERY LUCKY I DID NOT HAVE AN ENGINE FIRE. THESE STAINLESS HOSES ARE USED ON A LOT OF FORD VEHICLES. FORD SHOULD BE REQUIRED TO SUPPLY REPLACEMENT HOSES. *TR

NHTSA ID

10680325

Incident

Jun 18, 2013

Mileage

79,000 mi

TL* THE CONTACT OWNS A 1998 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIRE RODS, WHEEL BEARINGS, AND THE TIRES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 210,000.

NHTSA ID

10618577

Incident

Oct 5, 2011

Mileage

210,000 mi

HAD A WRECK COMING DOWN THE MOUNTAIN. EMERGENCY BRAKE DIDN'T WORK RAN INTO A TREE AND DAMAGED A MAILBOX (RELATED VEHICLE INFORMATION: MODEL YEAR=1998, MAKE=MOUNTAINEER , MODEL=MERCURY ). *TR

NHTSA ID

10618525

Incident

Feb 4, 2012

ALL OF A SUDDEN WITH NO WARNING MY INTERIOR DOME LIGHTS, POWER WINDOWS AND FRONT AND BACK WINDSHIELD WIPERS DIDN'T FUNCTION. I WAS DRIVING IT STARTED TO RAIN AND I COULD SEE VERY WELL WITHOUT FUNCTIONING WIPERS. I HAD TO PULL OVER TO THE SIDE OF THE ROAD. I FIGURE THAT A FUSE MIGHT HAVE BLOWN BUT WHEN I CHECKED ALL FUSES THEY SEEM TO BE OK. I WAS REVIEWING A RECALL FOR A 1999 MOUNTAINEER FOR A GEM PROBLEM. ALTHOUGH MY VEHICLE IS A 1998, COULD THIS PROBLEM BE SIMILAR TO THE 1999 RECALL. IT APPEARS TO HAVE ALL THE SIMILAR SYMPTOMS . IS IT POSSIBLE THAT MY 1998 MOUNTAINEER HAS A RECALL FOR THE SAME PROBLEM. THANK YOU *TR

NHTSA ID

10565323

Incident

Feb 17, 2014

Mileage

104,000 mi

1998 MERCURY MOUNTAINEER. ATTORNEY REPRESENTING CONSUMER REQUESTS LIST OF VEHICLE TIRE TREAD PROBLEMS. *SMD

NHTSA ID

10498621

Incident

Jul 3, 2012

AT 2 AM WE SMELLED SMOKE AND SAW IT COMING FROM GARAGE, WHEN I OPENED GARAGE DOOR FLAMES WERE COMING OUT OF FRONT OF CAR. MY MOTHERS CAR BURNT AND IT IS A TOTAL LOSS. WE HAD TO CALL FIRE DEPT. MY GARAGE WAS WRECKED. MY HOUSE HAS SMOKE DAMAGE. *TR

NHTSA ID

10458793

Incident

May 16, 2012

Mileage

102,000 mi

MOVED MY TRUCK TO LET ANOTHER CAR OUT OF THE DRIVE WAY. PULLED BACK IN TURNED THE TRUCK OFF CAME IN THE HOUSE AND HEARD A LOUD BOOM. LOOKED OUT THE WINDOW AND FIRE WAS SHOOTING UP BY THE WHEEL. *TR

NHTSA ID

10395782

Incident

Apr 13, 2011

Mileage

75,000 mi

1998 MERCURY MOUNTAINEER. THE DRIVERS DOOR WILL NOT UNLOCK FROM THE OUTSIDE WITH THE KEY AND MOST TIMES WILL NOT OPEN FROM THE INSIDE WITH THE LATCH HANDLE. I HAVE HEARD THAT THIS PROBLEM EXISTS WITH MOST 1998 - 2001 MERCURY MOUNTAINEERS, FORD EXPLORERS AND FORD RANGERS. IN THE EVENT OF AN EMERGENCY SUCH AS A CRASH, I MIGHT NOT BE ABLE TO GET OUT OF THE VEHICLE. *TR

NHTSA ID

10373161

Incident

Jun 20, 2009

Mileage

60,000 mi

TL* THE CONTACT OWNS A 1998 MERCURY MOUNTAINEER EQUIPPED WITH TURBO TECH RADIAL A/SR TIRES, LINE SIZE P235/75R15, DOT NUMBER UT1TT2E4305. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN A LOUD POP SOUNDED FROM THE EXTERIOR OF THE VEHICLE. THE CONTACT SUDDENLY LOST CONTROL OF THE VEHICLE. THE VEHICLE FLIPPED OVER TWICE AND LANDED ONTO THE CENTER LANE OF THE HIGHWAY. THE CONTACT SUSTAINED A MILD CONCUSSION AND INJURIES TO THE KNEE, BACK AND NECK. A POLICE REPORT WAS AVAILABLE. THE FAILURE WAS CAUSED BY THE REAR DRIVER SIDE TIRE EXPLODING. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE YARD. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000.

NHTSA ID

10361605

Incident

Jul 15, 2010

Mileage

149,000 mi

AT APPROXIMATELY 2:15 I PARKED MY 1998 MERCURY MOUNTAINEER ON THE STREET IN FRONT OF MY HOUSE. AT APPROXIMATELY 2:30 I HEARD THE VEHICLE THEFT ALARM GO OFF. WHEN I WENT TO SHUT OFF ALARM, I SAW FLAMES COMING FROM THE RIGHT FRONT WHEEL WELL. (I COULD NOT SEE WHAT WAS HAPPENING ON THE OTHER SIDE OF VEHICLE) I WENT BACK INTO MY HOUSE TO FETCH MY DRY CHEM FIRE EXTINGUISHER. I WENT BACK TO THE CAR AND ATTEMPTED TO EXTINGUISH THE FIRE. WHEN I WAS UNSUCCESSFUL, I HAD MY SON CALL 911 FOR FIRE DEPARTMENT ASSISTANCE. A FIRE TRUCK RESPONDED WITHIN 3-5 MINUTES AT WHICH TIME THE WHOLE FRONT END OF THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT PUT THE FIRE OUT WITHIN 5 MINUTES. UPON INSPECTION, I NOTICED THAT THE WHOLE MOTOR COMPARTMANT WAS CONSUMED BY THE BLAZE AND THE FIRE HAD STARTED TO BURN THE DASH AND INTERIOR OF THE VEHICLE. THE VEHICLE APPEARS TO BE A TOTAL LOSS.

NHTSA ID

10323594

Incident

Apr 3, 2010

Mileage

145,000 mi

TL*THE CONTACT OWNS A 1998 MERCURY MOUNTAINEER. EARLY IN THE MORNING, THE CONTACT SMELLED SOMETHING BURNING AND NOTICED THAT HER VEHICLE WAS ON FIRE. AS A RESULT, THE GARAGE AND PART OF THE HOUSE WERE BURNED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND STATED THAT IT ORIGINATED FROM THE ENGINE OF THE VEHICLE. THE CONTACT FEELS THAT THIS IS A SAFETY ISSUE BECAUSE SEVERE INJURIES COULD HAVE OCCURRED. THE MILEAGES WERE UNKNOWN.

NHTSA ID

10280474

Incident

Jul 22, 2009

TIMING CHAINS/TIMING CHAIN GUIDES FAILURE.*TR

NHTSA ID

10247089

Incident

Jun 2, 2008

Mileage

99,500 mi

TL*THE CONTACT OWNS A 1998 MERCURY MOUNTAINEER. WHILE CHECKING THE FLUIDS IN THE VEHICLE, THE HYDRAULIC SYSTEM FAILED THAT HOLDS THE HOOD. AS A RESULT, THE HOOD RELEASED AND NEARLY CRASHED THE CONTACTS HAND. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS ON THAT COMPONENT, HOWEVER, THEY WOULD INVESTIGATE THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 86,000. UPDATED 10/16/07 *TR

NHTSA ID

10204521

Incident

Sep 30, 2007

Mileage

86,000 mi

TL*THE CONTACT OWNS A 1998 MERCURY MOUNTAINEER. WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY ACCELERATED TO 90 MPH. THE CONTACT HAD TO PLACE HIS FOOT BEHIND THE ACCELERATOR PEDAL AND PULL IT UP IN ORDER TO STOP THE VEHICLE. HE PULLED THE VEHICLE OVER AND WAS STILL ON THE SIDE OF THE ROAD DURING THE TIME OF THIS COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 117,000.

NHTSA ID

10197027

Incident

Jul 19, 2007

Mileage

117,000 mi

TL*THE CONTACT OWNS A 1998 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THERE IS A CRACK IN THE CENTER OF THE EGR VALVE. THE VEHICLE IS MAKING AN UNFAMILIAR NOISE AND GAS FUMES ARE ENTERING THE VEHICLE. THERE WERE NO WARNING INDICATORS. THE VEHICLE HAS NOT BEEN DIAGNOSED. THE PURCHASE DATE, ENGINE SIZE, AND A VALID VIN WERE UNKNOWN. THE CURRENT MILEAGE IS 72,000 AND FAILURE MILEAGE WAS 69,000.

NHTSA ID

10195169

Incident

Aug 5, 2006

Mileage

69,000 mi

BEING THE SPACE IS LIMITED, I HAVE THE SAME PROBLEM WITH MY CAR AS FOLLOWS: MY CHECK ENGINE LIGHT HAS BEEN COMING ON. I HAVE HAD VARIOUS SHOPS USE THEIR COMPUTER TO FIND OUT WHY THE LIGHT WAS ON AND HAVE PAID FOR CLEANING VALVES, SENSORS, AND HOSES AS WELL AS HAVING NEW SENSORS INSTALLED. THE FIRST INSTANCE OCCURRED AT 90,000 MILEAGE ON MY VEHICLE. TODAY, THE SHOP WHERE I NOW TAKE MY VEHICLE FOR SERVICING USED THEIR COMPUTER TO SEE WHY THE CHECK ENGINE LIGHT WAS ON YET AGAIN AND IT GENERATED A TSB FROM FORD, ARTICLE 04-7-5 WHICH SUPERSEDES ARTICLE TSB 03-25-1. THIS ARTICLE STATES THE ISSUE AS "SOME 1998 EXPLORER/MOUNTAINEER VEHICLES EQUIPPED WITH THE 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE(S) P0420 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD-BANK 1) AND/OR P0430 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD - BANK 2). THE ACTION LISTED FOR CORRECTION OF THIS PROBLEM IS STATED AS "TO SERVICE, REPROGRAM THE POWERTRAIN CONTROL MODULE (PCM) TO THE LATEST CALIBRATION USING WDS RELEASE B28.3 OR HIGHER. REPLACEMENT OF CATALYST'S IS NO LONGER NECESSARY TO ADDRESS THE MOST COMMON CAUSES OF THIS CONDITION." THIS SOUNDS LIKE A PROBLEM FORD INSTALLED ON THESE 1998 MOUNTAINEERS AND I BELIEVE FORD SHOULD BEAR THE COST OF REPROGRAMMING THE COMPUTER IN THE VEHICLE FOR THE VEHICLE TO FUNCTION PROPERLY AND SAFELY. THE WORKER AT THE SHOP TOOK THE TIME TO EXPLAIN TO ME WHAT THIS ARTICLE MEANT AND THE POSSIBLE RAMIFICATIONS TO THE FUNCTIONING OF MY VEHICLE BECAUSE OF THE PROBLEM CAUSED BY FORD NOT HAVING THE CORRECT COMPUTER PROGRAM RUNNING IN THE VEHICLE. MY MECHANIC IS TELLING ME THAT THIS VEHICLE HAS 3 CATALYTIC CONVERTERS AND WILL COST ABOUT $3000 FOR THE PARTS ALONE. BECAUSE OF THIS PROBLEM MY VEHICLE WILL NOT PASS EMISSIONS OR INSPECTION. I WENT 1 YEAR WITH THIS PROBLEM AND NOW IT IS BACK AGAIN. *JB

NHTSA ID

10189929

Incident

Apr 21, 2007

Mileage

89,560 mi

TL* - THE CONTACT STATED THAT WHILE HER 1998 MERCURY MOUNTAINEER WAS PARKED, THE CONTACT HEARD A LOUD NOISE COMING FROM HER VEHICLE. SHE NOTICED THAT HER VEHICLE HAD FLAMES COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE CONTACT FEELS THAT THE CAUSE OF THE FIRE WAS DUE TO NHTSA CAMPAIGN ID NUMBER : 00V422000( VEHICLE SPEED CONTROL). THE CONTACT CAN PROVIDE PICTURES, AS WELL AS, COPY OF THE INCIDENT REPORT. *JB

NHTSA ID

10178921

Incident

Aug 25, 2006

Mileage

100,000 mi

1998 MOUNTAINEER'S TIRES WERE APART OF A RECALL AND CONSUMER IS REQUESTING REIMBURSEMENT. *TS THE VEHICLE WAS ORIGINALLY EQUIPPED WITH WILDERNESS AT TIRES WHICH WERE RECALLED. THE CONSUMER REPLACED THESE TIRE IN 2004 AFTER THE CONSUMER WAS ALMOST INVOLVED IN AN ACCIDENT AS RESULT OF THE FAULTY TIRES. *NM

NHTSA ID

10175374

Incident

Jan 7, 2004

Mileage

85,000 mi

DT*: THE CONTACT STATED RECALL LETTER # 02S28 WAS RECEIVED REGARDING THE SEAT BELT. WHEN THE VEHICLE WAS TAKEN TO A SERVICE DEALER TO REPLACE SEAT BELT BOLT, THE CONTACT REQUESTED TO HAVE A REMOTE DOOR OPENER INSTALLED ON THE VEHICLE, AS WELL. WHILE THE SERVICE DEALER WAS ATTEMPTING TO INSTALL THE REMOTE DOOR OPENER, THERE WERE PROBLEMS PROGRAMMING THE REMOTE WHICH RESULTED IN A MALFUNCTION OF THE DRIVER SIDE DOOR. THE DRIVER DOOR WOULD NOT LOCK OR UNLOCK. THE CONTACT EXPRESSED UNHAPPINESS WITH THE LONG WAIT AND THE RUN AROUND FROM THE DEALER IN REPAIRING THE VEHICLE.

NHTSA ID

10173066

Incident

May 15, 2006

Mileage

77,000 mi

CONSUMER COMPLAINT CONCERNING VEHICLE CATCHING ON FIRE . *TS THE VEHICLE CAUGHT ON FIRE ON 8/25/06. THE RECALL REPAIR FOR THE CRUISE CONTROL DEACTIVATION SWITCH WAS SCHEDULED FOR 8/28/06. THE CONSUMER FEELS THAT THE SWITCH WAS THE CAUSE OF THE FIRE. THE CONSUMER IS REQUESTING THE BLUE BOOK VALUE FROM THE MANUFACTURER. *NM

NHTSA ID

10173257

Incident

Aug 25, 2006

I AM THE ORIGINAL OWNER OF A 1998 MERCURY MOUNTAINEER, V8, AWD, VIN [XXX] WITH 142,000 MILES. I PARKED THE CAR IN MY DRIVEWAY ON FRIDAY EVENING, JULY 14, 2006 WHERE THE CAR REMAINED UNUSED UNTIL SUNDAY AFTERNOON, JULY 16, 2006. ON SUNDAY AFTERNOON, JULY 16, 2006, AROUND 1:00 PM THE CAR CAUGHT FIRE, ALSO CATCHING MY HOUSE ON FIRE. THE CAR WAS A TOTAL LOSS AND THE HOUSE SUSTAINED MAJOR DAMAGE IN ONE AREA. THE CAR WAS NOT USED BETWEEN THE TIME IT WAS PARKED AND CAUGHT FIRE. *NM UPDATED 07/12/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

10164700

Incident

Jul 14, 2006

Mileage

142,000 mi

I BOUGHT MY VEHICLE ABOUT 3 YEARS AGO. IT HAD 60,000 ON THE ODOMETER. THE BACK WINDSHIELD WIPER NEVER WORKED, AND DOES ONCE IN A WHILE AND THE RADIO LIGHT NEVER STAYS ON. ONCE IN A WHILE IT WILL SHOW THE STATION OR THE TIME. MY DRIVERS SIDE DOOR HANDLE HAS ALWAYS BEEN LOOSE. MY ENGINE LIGHT CAME ON A YEAR AFTER I GOT IT AND IT WILL NOT GO OFF. IT SAY EGR FLOW INSUFFICIENT AND YET I HAVE REPLACED ALL OF THOSE AND HAD THE COMPUTER RESET. THE PASSENGER SIDE DOOR DOES NOT LOCK UNLESS I LOCK IT BY HAND AND THEN YOU CAN'T OPEN IT. THE BACK SEATS SOMETIMES LOCK AND OTHER TIMES WON'T. MY SEAT WAS RECALLED AND I TOOK IT, AND NOW IT IS BROKEN. THESE CARS ARE NOT MADE VERY WELL AND I THINK WE SHOULD GET LETTERS ON THE RECALLS. I HAVEN'T RECEIVED BUT ONE LETTER AND I TOOK IT IMMEDIATELY, BUT I SEE THERE HAVE BEEN OTHER RECALLS AND I WASN'T NOTIFIED. WHAT SHOULD I DO NOW? *JB

NHTSA ID

10164421

Incident

Mar 1, 2003

Mileage

63,000 mi