2011 MINI Cooper Clubman

The contact owns a 2011 Mini Cooper Clubman. The contact received notification of NHTSA Campaign Number: 23V337000(Electrical system); however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was illuminated. The local dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.

NHTSA ID

11677155

Incident

Jul 1, 2025

My car has a problem with the FRM or foot control module the turn signal don’t work right, when putting the car in reverse the bulb will not work but it’s a brand new bulb, I know there is a recall for them 23V-337 but since my car has always been in Texas the recall doesn’t apply to it

NHTSA ID

11619919

Incident

Oct 15, 2024

I've just gotten a very common air bag seat mat sensor code (93c1) that Mini had a limited recall on - but alas my car did not get the code until it was outside the parameters of that repair program. What makes it worse is that the fix is over $1000 and there's very little concrete info on the actual danger (or not) of driving around with this code active. I've spend the better part of 2 days researching how to fix this & I'm still uncertain as to what to fully do.

NHTSA ID

11610832

Incident

Jul 18, 2024

Safety recall since 3/23/2023. It's 07/19/2024. With no solution yet , it's been over a year now with no solution. That is a un timely manner. Need to know what to do now . Can not drive vehicle, no blinkers or brake lights. Please help.

NHTSA ID

11603431

Incident

Jul 17, 2024

The contact owns a 2011 Mini Cooper S Clubman. The contact stated that while driving at an undisclosed speed, the instrument panel became inoperable, and the headlights started flickering. The contact related the failure to NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

NHTSA ID

11598358

Incident

Jun 30, 2023

Mileage

100,000 mi

The contact owns a 2011 Mini Cooper Clubman. The contact stated while driving at an undisclosed speed, the footwell control module became inoperable. The contact stated that the window motors, the turn signals, and the headlights were inoperable. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the footwell control module needed to be replaced and re-coded. The vehicle was repaired. The manufacturer was made aware of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 23V337000 (Electrical System). The failure mileage was approximately 45,735.

NHTSA ID

11546474

Incident

May 21, 2023

Mileage

45,735 mi

The contact owns a 2011 Mini Cooper Clubman. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11532668

Incident

Jul 17, 2023

At about 6:40AM on September 23, 2022, the 2011 Mini Clubman car caught on fire. The car was parked in the driveway, locked with everything off, key removed and unoccupied. It was last driven the evening of September 22nd. About 6:40AM the interior behind the steering wheel and dashboard erupted into flames. The car filled with smoke and flames. The fire burned for about 5 -10 minutes and self extinguished. Just prior to the fire the headlights were reported to be on. After the fire, the windshield wipers were operating with no way to turn them off. At a reasonable time after the flames were no longer visible (10-15min), the driver's door was opened by the emergency key to vent the smoke. Upon inspection, the area around the left footwell near the driver's door was heavily charred with insulation burned off all wiring and co-located electrical devices. The hood release latch was melted. The air vent to the left of the steering wheel was missing and all the ductwork to that vent was missing. There was a large deformation and hole in the dashboard above and slightly to the right of the steering wheel and the windshield was cracked about 2-3 inches above the dashboard. It appears that electrical components and wiring inside the dashboard were also engulphed in flames but no detailed inspection of the damage occurred. Significant smoke damage occurred to the entire interior. The local fire department was called and they were able to open the hood and disconnect the battery which stopped the windshield wipers. The car was a stock car with no modifications. Reasonably maintained by professionals. The odometer reading before the fire was approximately 103,000 miles. No problems were noted prior to the incident. Insurance has considered the car a total loss and unrepairable. In general it is assumed by the writer that Mini's or any other car should not experience electrical fires when unoccupied, all devices are off, no key is present. Kindly investigate.

NHTSA ID

11487831

Incident

Sep 23, 2022

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test module helps to localize these causes. This document covers important information for the dealer on how to handle “discharged battery” complaints. Without performing the energy diagnosis test plan, the root cause of a discharged battery cannot be identified. In order to properly repair the vehicle the first time, it is very important that the diagnostic test plan is performed to completion; with all results taken into consideration.

New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool when replaced or when depressurized (0 psi) for more than 2 minutes.

OC3 SEAT OCCUPANCY MAT - LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES: Component-Specific Limited Warranty Extension For the above-referenced vehicles, MINI USA, a division of BMW of North America, LLC (MINI USA) is extending the limited warranty for the front passenger's OC3 seat occupancy mat (shown) to: 10 years/120,000 miles as determined by the vehicle's original in-service date.

CLASS ACTION SETTLEMENT: N14 HIGH-PRESSURE FUEL PUMP (HDP) SERVICE BENEFIT CLASS VEHICLES: The MINI vehicle may experience a sudden engine operational failure reduced or loss of power while driving and the malfunction indicator lamp (MIL) may be illuminated along with high-pressure fuel pumprelated faults stored in the Engine Control Module (DME). PROCEDURE Perform the corresponding diagnosis/vehicle test and run the test plans to completion as applicable.