2011 Volkswagen Eos

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

Unable to drive vehicle ABS system failure - no braking is possible. ABS warning light and loss of braking control while attempting to drive. The module part recall 45F2 does not apply to my year 2011 vehicle. Though the previous year there is a recall for the part by VW. VW representatives will not offer recall or payment for part replacement saying recall does not apply to 2011. Vehicle is at risk. VW will not assume responsibility for faulty part. The vehicle is too dangerous to drive. Consumers should be informed.

NHTSA ID

11521427

Incident

May 9, 2023

My ABS/ ESC light was on and the brake light was flashing randomly. After diagnostics it appears the ABS module is intermittently not receiving power. Because of this the ABS/ESC system randomly does not work as it should. This seems to be the same issue as the 16V-913 safety recall, but my car was manufactured on July 14, 2010 which was 33 days after the June 11, 2010 cut off date.

NHTSA ID

11445178

Incident

Dec 26, 2021

I WAS DRIVING OUT OF TOWN AT APPROXIMATELY 50 MPH WHEN MY CAR SUDDENLY SLOWED TO APPROXIMATELY 20 MPH. I COULD NOT GET THE VEHICLE TO GO ABOVE 20 MPH. I PULLED IT OFF OF THE ROAD AND TURNED THE CAR OFF. I RESTARTED AND AGAIN IT WOULD NOT GET PAST 20 MPH. WHEN I SWITCHED THE CAR TO MANUAL MODE IT WOULD NOT GO PAST 2ND GEAR. AFTER A FEW HOURS OF SITTING THE CAR WORKED PROPERLY. I CONTACTED A DEALERSHIP IN THE AREA I WAS TRAVELING AND THEY SAID IT SOUNDED LIKE THE CAR WAS GOING INTO "LIMP MODE" AND THAT VW HAD HAD TONS OF COMPLAINTS ABOUT THAT OVER THE LAST SEVERAL YEARS. I DROVE THE CAR HOME. SEVEN DAYS LATER, THE EXACT THING HAPPENED AND I CONTACTED MY LOCAL DEALERSHIP ABOUT THE PROBLEM WHO INFORMED ME "THEY HAD NOT HAD ANY TYPE OF COMPLAINT SIMILAR TO WHAT I WAS DESCRIBING". THEY DID HOWEVER CONDUCT A SAFETY RECALL ON MY VEHICLE. I TOOK MY CAR TO ANOTHER MECHANIC BECAUSE MY CONCERN IS DRIVING ON THE INTERSTATE AND HAVING THE CAR ABRUPTLY SLOWING DOWN AND BEING STRUCK FROM BEHIND OR IF I AM TURNING, NOT BEING ABLE TO COMPLETE MY TURN BEFORE SOMEONE STRIKES ME FROM THE SIDE. THAT MECHANIC ALSO SAW WHAT I WAS EXPLAINING AND SAID THAT THE DEALERSHIP NEEDED TO FIX IT BECAUSE IT SHOULD BE COVERED UNDER A WARRANTY. IT DID THE SAME THING AS I WAS LEAVING THE SHOP SO I HAD IT TOWED TO MY LOCAL VW DEALERSHIP. AFTER DRIVING THE CAR SEVERAL DAYS THE MECHANIC AT THE DEALERSHIP FOUND THE PROBLEM AND SAID THAT THE DSG TRANSMISSION ASSEMBLY NEEDED TO BE REPLACED. WHEN I ASKED ABOUT A WARRANTY, THEY SAID I WAS NOT COVERED, HOWEVER IN THE LAST 10 YEARS THERE WERE OVER 53,000 VWS AND AUDIS THAT HAD THE SAME PROBLEM AND HAD A RECALL. I DON'T UNDERSTAND IF THIS IS HAVING THE SAME PROBLEM, WHY MINE IS NOT COVERED.

NHTSA ID

11194933

Incident

Mar 17, 2019

Mileage

76,000 mi

STARTED MY CAR AFTER WORK AND NOTICED HALF MY EXTERIOR LIGHTS DIDN'T WORK. CHECKED THE FUSES AND F16 FUSE WAS MELTED.

NHTSA ID

11088719

Incident

Apr 17, 2018

Mileage

100,114 mi

TAKATA RECALL. RECEIVE NOTICE THAT I HAVE FAULTY TAKATA AIRBAGS A FEW YEARS AGO. APPROXIMATELY ONE YEAR LATER I RECEIVED A NOTICE THAT A TEMPORARY REPAIR WAS AVAILABLE THAT WOULD SWAP THE ORIGINAL AIRBAG WITH A REPLACEMENT MODULE OF THE ORIGINAL DESIGN THAT DID NOT INCLUDE A DRYING AGENT. THAT NOTICE WAS CLEAR THAT THIS WAS ONLY AN INTERIM REPAIR UNTIL A REDESIGNED UNIT IS AVAILABLE. I HAD THE INTERIM REPAIR DONE ON MY VEHICLE. I NOTICED NOW THAT WHEN SEARCHING FOR RECALLS, IT SAYS THERE ARE NO ACTIVE RECALLS ON MY VEHICLE. THIS IS VERY CONCERNING BECAUSE THEY HAVE NOT ADDRESSED THE UNDERLYING DESIGN DEFECT, AND BECAUSE THERE IS NOT AN ACTIVE RECALL ON THE VEHICLE IT SEEMS THAT AT THIS TIME IT WILL NOT BE FIXED. PLEASE CONTACT VOLKSWAGEN AND ENSURE THAT THEY ARE ADDRESSING THE NEEDED REDESIGN OF THE AIRBAG MODULE. THANK YOU

NHTSA ID

11066170

Incident

Jan 1, 2018

THE CLOCK SPRING IN MY CAR HAS FAILED REQUIRING COMPLETE REPLACEMENT. THIS COMPLETE FAILURE COMES A SHORT 9 MONTHS AFTER THE INITIAL 'REPAIR' DONE FOLLOWING A VW RECALL ON THE PART- THEY SIMPLY PLACED A COVER OVER THE ORIGINAL CLOCK SPRING. THEY TELL ME THAT THEY WILL NOT COVER THE REPLACEMENT OF THE PART, BECAUSE I HAD THE INITIAL SAFETY CHECK DONE AT THE TIME OF THE INITIAL RECALL AND THE PART WAS DEEMED FUNCTIONAL AT THAT POINT- EVEN THOUGH THEY WERE AWARE IT WOULD MOST LIKELY EVENTUALLY FAIL.

NHTSA ID

11052812

Incident

Dec 1, 2017

I RECEIVED A LETTER IN APRIL 2016 REGARDING A TAKATA SDI DRIVER FRONTAL AIRBAG RECALL.. TO DATE NO ONE IS ABLE TO TELL ME WHETHER THE CAR HAS BEEN RECALLED AND IS IN NEED OF REPAIRS. I HAVE CHECKED THE WEBSITE PERIODICALLY BUT FIND IT UNHELPFUL AND CONFUSING. WHAT S GOING ON WITH THE RECALL??

NHTSA ID

10991037

Incident

Apr 1, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 VOLKSWAGEN EOS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10960275

Incident

Apr 9, 2016

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Instruction, how to lubicate engine before initial start.

Lubricating engine components before reassembly.

Inquiries

Volkswagen Engine Oil Standards