2009 Volkswagen Eos

THE SUBJECT VEHICLES ARE EQUIPPED WITH DIRECT SHIFT GEARBOX (DSG) TRANSMISSIONS, WHICH FEATURE A 6-SPEED AUTOMATIC GEARBOX WITH TWO WET RUNNING CLUTCHES (DUAL CLUTCH) IN WHICH THE CLUTCH MECHANISM AND GEAR CHANGES ARE ELECTROHYDRAULICALLY OPERATED BY A MECHATRONIC CONTROL UNIT.THE DSG MECHATRONIC CONTROLLER INCLUDES EXTENSIVE SELF DIAGNOSTIC FUNCTIONS AND STRATEGIES TO ENSURE SAFE OPERATION AND PREVENT SYSTEM/COMPONENT DAMAGE IN THE EVENT OF COMPONENT FAILURES OR HARSH OPERATING CONDITIONS.THE BASIC HIERARCHY OF FAULT MODES INCLUDES SOME THAT ONLY RESULT IN THE STORAGE OF A DIAGNOSTIC TROUBLE CODE (DTC) AND CAUSE NO LOSS OF FUNCTION, SOME THAT STORE A DTC AND REDUCE VEHICLE OPERATION TO A LIMP HOME MODE, AND SOME THAT STORE A DTC AND CAUSE AN INTERRUPTION OF MOTIVE POWER (I.E., OPEN CLUTCH).THE DRIVER IS ALERTED TO THE LATTER TWO MODES BY THE DASH GEAR POSITION INDICATOR (PRNDS) FLASHING. ONE OF THE CONDITIONS THAT RESULTS IN INTERRUPTION OF MOTIVE POWER IS EXCESS GEARBOX TEMPERATURE.THE SYSTEM INITIALLY RESPONDS TO INCREASED GEARBOX TEMPERATURE BY RAMPING DOWN ENGINE TORQUE.IF THE TEMPERATURE KEEPS RISING THE MECHATRONIC UNIT RESPONDS BY OPENING THE CLUTCH.IN A DEFECT INFORMATION REPORT SUBMITTED TO NHTSA ON AUGUST 20, 2009, VOLKSWAGEN DESCRIBED A POTENTIAL DEFECT IN THE WIRING HARNESSES OF THE DSG GEARBOX TEMPERATURE SENSORS USED IN APPROXIMATELY 16,000 MODEL YEAR (MY) 2009 AND 2010 VOLKSWAGEN (EOS, JETTA AND GTI) AND AUDI (A3 AND TT/TT ROADSTER) VEHICLES EQUIPPED WITH DSG TRANSMISSIONS AND BUILT FROM SEPTEMBER 2008 THROUGH AUGUST 2009 (NHTSA RECALL NO. 09V-333, VOLKSWAGEN RECALL NO. 37E3/S7 AND AUDI RECALL NO 37E4/J7). VOLKSWAGEN PROVIDED THIS DESCRIPTION OF THE DEFECT, THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DSG MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED BY THE CONNECTOR SUPPLIER DURING A LIMITED PRODUCTION PERIOD.WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL.IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH.IN ADDITION, THE DEPRESS BRAKE PEDAL INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.IN HEAVY TRAFFIC, THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.VOLKSWAGEN ESTIMATED THAT LESS THAN ONE PERCENT OF THE RECALLED VEHICLES MAY CONTAIN THE DEFECT CONDITION. ODI IDENTIFIED 40 COMPLAINTS THAT APPEAR TO BE RELATED TO THE TEMPERATURE SENSOR DEFECT CONDITION DESCRIBED BY VOLKSWAGEN.VOLKSWAGEN RECEIVED 139 COMPLAINTS RELATED TO THE CONDITION, WITH 7 INVOLVING VEHICLES REPORTED TO ODI, RESULTING A 172 TOTAL COMPLAINTS TO ODI AND VOLKSWAGEN.ALL OF THESE COMPLAINTS INVOLVE THE MY 2009 AN 2010 VEHICLES SUBJECT TO RECALL 09V-333. ODI ALSO IDENTIFIED COMPLAINTS OF HARSH/JERKY SHIFTING IN SOME VOLKSWAGEN VEHICLES WITH DSG.VOLKSWAGEN ATTRIBUTED THIS CONDITION, WHICH TYPICALLY OCCURS AT VERY LOW SPEEDS, TO EXCESSIVE WEAR IN THE BUSHINGS OF THE TWO SOLENOID VALVES IN THE MECHATRONIC UNIT THAT CONTROL CLUTCH OPERATION.VOLKSWAGEN DOES NOT BELIEVE THAT THE THIS CONDITION IS A SAFETY DEFECT BECAUSE THE CHANGES IN SHIFT QUALITY DEVELOP GRADUALLY OVER TIME, DO NOT CAUSE A LOSS OF MOTIVE POWER AND HAVE NOT RESULTED IN ANY FATALITIES, INJURIES OR SERIOUS CRASHES (THERE WERE THREE REPORTED PROPERTY DAMAGE INCIDENTS RESULTING IN MINOR BODY DAMAGE IN VERY LOW SPEED, PARKING MANEUVERS).VOLKSWAGEN ADDRESSED THIS PROBLEM IN THE FIELD WITH A CUSTOMER SERVICE PROGRAM THAT INCLUDES THE REPLACEMENT OF POTENTIALLY AFFECTED MECHATRONIC UNITS AS WELL

Car randomly turning off/on. Key stuck in ignition, cannot turn off or on. Bouncing from on to accessory mode without user control. Vehicle was taken to dealership, VW North America has not been very helpful. Could have gotten into an accident as this occured in the road turning into a restaurant. No lights came on about this. Dealership has had car for 3+ weeks "waiting for parts". VW North America does not want to get involved. To kill the engine I had to pull the fuel pump fuse.

NHTSA ID

11739271

Incident

Apr 30, 2026

approximately 6 years my daughter and her boyfriend were driving and she heard a loud pop sound, and thought it might be a tire but it wasnt behaving like it was and then all of the sudden people are driving next to her telling her to pull over cuz the car was on fire, she pulled it over and as soon as she got out the whole car caught fire. when they noticed the fire it had started near or under the passenger front seat, there was no warning lamps or any problems proir. The auto insurance company took the car and they said they inspected it but never gave me any answers, they simply paid off my loan and that was it. The fire department put out the fire, the car was burnt to a crisp, and the fire men were accusing my kid of smoking and starting the fire, so they did no investigation.

NHTSA ID

11732242

Incident

May 6, 2019

The contact owns a 2009 Volkswagen Eos. The contact stated that while the vehicle was parked, the contact became aware of a persistent oil leak on the ground. The vehicle had undergone three separate repairs to resolve the failure, but the oil leak persisted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the fuel was running lean. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 150,000.

NHTSA ID

11729062

Incident

Mar 26, 2026

Mileage

150,000 mi

While in slow traffic and transmission in Drive position, if I slow down or stop for traffic in front of me or a red light, the transmission does not engage again when given acceleration. I have shut the car off and restarted again, sometimes more than once to get it to engage and get me out of traffic. I have held up traffic behind me. There are also loud clunking noises coming from what I believe is the transmission at each start causing the PRNDL to flash and no power for reverse and drive. I believe all of this will eventually cause a collision as it appears to other vehicles that I should be moving. People have also become very frustrated with my vehicle holding up traffic, especially on the busiest of days and long lines waiting to advance behind me. People have become impatient and angry to the point of road rage. Thankfully, no one has actually tried to hurt me physically. The date below would be the latest incident.

NHTSA ID

11685828

Incident

Aug 28, 2025

I slowly at 5mph went over a bump and my car went automatically into neutral, all of the P R N D S lights on the dash started blinking and the car just kept revving when I tried to put it into gear. I had the car towed to the dealership and it is currently there. I looked on Kelly Blue Book and saw there was a recall for my vehicle type and the recall states exactly what happened to my car. Can my VIN number be added to this recall since it is the very same mechanical issue? Here is the information I found on the recall NHTSA CAMPAIGN ID: 09V333000 Report Date: AUG 20, 2009 Vehicles Affected: 16000 What You Should Do: VOLKSWAGEN WILL NOTIFY OWNERS, INSPECT THE DSG AND, IF NECESSARY, REPLACE AN AFFECTED DSG TEMPERATURE SENSOR FREE OF CHARGE. THE MANUFACTURER HAS NOT YET PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987. Summary: VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES. To see if your specific vehicle is affected 1-800-822-8987 or nhtsa.gov Please let me know if there is anything that can be done. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11551092

Incident

Oct 17, 2023

All of my lights on the right side of my dashboard is on..the traction light, brake light,steering wheel light and the speedometer is acting iradical..I put new speed sensors on it and it still haven't fixed the problem..alot of mechanics say it's and electrical problem..I bought the car from flow Mazda dealership a couple years ago it's been sitting since then

NHTSA ID

11543616

Incident

Aug 30, 2021

The vehicle has exhibited intermittent ABS, ESC, and Brake light. Code check revealed intermittent communication errors with various parts of the ABS system including the control module. Diagnostics varied, undiagnosable due to intermittent activity and varying codes. April 2021, ABS, ESC, Brake light, codes indicate communication error with the ABS control module. Codes and light reset after being cleared, the vehicle was operational and drives with no detectable issues other than lights/ and possible non-operational ABS. 06/29/2021, 10 minutes into drive vehicle speedometer begins to dance from zero to operating speed, to total fault intermittently in interstate traffic on I-10 west into Houston at Channel View, braking begins to engage automatically/intermittently, loss of engine power, check engine/flashing brake light , vehicle narrowly avoids collision. Vehicle parked and restarted, driven back home with check engine and flashing brake light and intermittent speedometer, no drivability issues. 6/30/21 internet search for similar issues reveals an abundance of similar issues without drivability problems and 2017 recall# Part 473 Safety Recall Report 16V-913. I would call attention to pages 3 and page 4 of this recall 1.) Considering the events of 6/28 and page 3 of the recall under Chronology, Volkswagen appears to admit the problem, and with a thorough understanding of its own systems should openly acknowledge the ability of this system to cause dangerous drivability conditions. 2.) Page 4, Recall Schedule, Description of Recall, Indicates that VW has still to provide dealers and owners with notification of this issue. As an owner and knowledgeable professional in automotive service I can assure you as of 7/1/2021, nearly five years after VW acknowledged the issue in Dec. 2016 to the NHTSA, and 11 years after addressing the concern in production with the 2010 models, we have not been notified.

NHTSA ID

11423072

Incident

Jun 29, 2021

THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

NHTSA ID

11423006

Incident

Jun 30, 2021

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards