2013 Volkswagen Eos

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

The contact owns a 2013 Volkswagen Eos. The contact stated while having a routine check at the dealer, the mechanic informed the contact that the horn was not functioning and that the clockspring needed to be replaced. The vehicle was repaired but the failure reoccurred. The vehicle was taken to an independent mechanic who stated that the clockspring needed to be replaced again. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle was not under warranty or recall. No further assistance was provided. The failure mileage was 108,000.

NHTSA ID

11521753

Incident

Oct 12, 2018

Mileage

108,000 mi

I pressed the steering wheel to activate the HORN. The HORN did not work. My VW dealer (Valenti VW, Watertown, CT) after 1.5 hours determined the the spring on the steering wheel that activates the horn and possibly the airbag is broken. The spring is broken and is back ordered since 12/20/2021. VW IS ACUTELY AWARE OF THIS ISSUE AND EXTENDED THE WARRANTY TO 10 years and 100,000 miles. This is a very serious safety issue.

NHTSA ID

11446708

Incident

Dec 20, 2021

The contact owns a 2013 Volkswagen Eos. The contact stated that while driving, the heater inside the front passenger seat erroneously activated and malfunctioned causing the seat to burn which also caused a burn to the bottom of the front passenger seat. There was a hole on the front passenger side seat and during the incident, it burned through the passenger's undergarments and jeans causing his burn injuries. Medical treatment was not provided due to the injured passenger not being able to sit and was being treated at home. During the incident, a burning odor was present inside the vehicle. The fire department was called to the scene and the electrical wire to the seat was deactivated. The cause of the failure was not determined. A fire report was taken at the scene. The manufacturer and local dealer were not notified of the failure. The failure mileage was 50,000.

NHTSA ID

11422905

Incident

Jun 26, 2021

Mileage

50,000 mi

IN NORMAL DRIVING, I TURNED STEERING WHEEL TO PULL INTO A PARKING SPACE AND THERE WAS A SNAP IN THE STEERING WHEEL. THIS SOUND WAS THE ELECTRICAL CONNECTION TO THE STEERING WHEEL BREAKING AWAY. I LOST KEY FUNCTIONS FROM THE STEERING WHEEL INCLUDING THE AIRBAG, HORN, AND STEERING MOUNTED CONTROLS.

NHTSA ID

11378310

Incident

Nov 23, 2020

Mileage

22,000 mi

THE SUNROOF STARTED FALLING APART WHEN MY CAR WAS A PROXIMITY 45000 MILES, AND I REPORTED, AND CALL TO VW CUSTOMERS SERVICE ROR SEVERAL TIMES FIX THE PROBLEM, AND THEY DENY TO DO THIS. FINALLY. I HAD TO DO ONOT MY OWN, BUT WHAT I LEARNED TROUGH ONE OF MY FRIENDS, IS THAT EXIST A RECALL FOR THAT. I WILL APPRECIATE IF YOU CONFIRM THIS FOR ME - THE SECOND ISSUE IS THE REAR CAMERA DIDN'T WORK PROPERLY WHEN MY CAR WAS 40000 MILES. I REPORTED THIS CASE SEVERAL TIMES, AND I DID THE SAME PROCESS CALLING CUSTOMERS SERVICES, AND THEY TOLD ME THAT THE POSSIBLE DAMAGE IS A CONSEQUENCE OF , MANUFACTURE, AND THEY FIXED 3 TIMES SAME PROBLEM. I PAI'D FROM MY PACKAGE, AND WHAT I LEARNED IS THAT EXIST A RECALLS FOR THIS. I WOULD LIKE TO BE CONFIRMED, BECAUSE THEY NEED TO REIMBURSE MY MONEY.

NHTSA ID

11307561

Incident

Jun 10, 2016

TL* THE CONTACT OWNS A 2013 VOLKSWAGEN EOS. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED AND THE HORN FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO HAMILTON VOLKSWAGEN (2200 NJ-33, HAMILTON SQUARE, NJ 08690, 609-587-76000) WHERE IT WAS DIAGNOSED THAT THE CLOCKSPRING FAILED. THE CLOCKSPRING WAS NOT REPLACED. THE MANUFACTURER STATED THAT THE CLOCKSPRING WAS ALREADY REPLACED UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 904,502.

NHTSA ID

11267712

Incident

Oct 3, 2019

Mileage

904,502 mi

TAKATA RECALL ON 10/19/18 I TOOK MY CAR TO THE DEALERSHIP SO THAT THEY COULD INSTALL THE NEW AIRBAG INFLATOR KIT DUE TO THE RECALL. A FEW DAYS LATER I NOTICED MY HORN WAS NOT WORKING. I RETURNED TO THE DEALERSHIP ON 11/9/18 ONLY TO BE TOLD I NEED TO REPLACE THE ENTIRE AIRBAG BECAUSE THE BRACKETS CONNECTING TO THE AIRBAG ARE NOT SENDING A GOOD SIGNAL TO THE HORN. HOWEVER I WENT ONLINE AND ONE OF THE ITEMS CLEARLY CALLED OUT WITH THE RECALL IS "DO NOT PULL ON THE HORN SWITCH FEED PIGTAIL WIRE TO DISENGAGE THE CONNECTOR FROM THE DRIVER AIRBAG HOUSING OR TO DISCONNECT THE HORN SWITCH TO STEERING WHEEL WIRE HARNESS CONNECTION. IMPROPER PULLING ON THIS PIGTAIL WIRE OR CONNECTION CAN RESULT IN DAMAGE TO THE HORN SWITCH MEMBRANE OR FEED CIRCUIT." ALTHOUGH I HAVE A WARRANTY I WAS TOLD MY ISSUE IS NOT COVERED AND THAT I NEED TO PAY $598.00 PRE TAX TO FIX THE ISSUE. BASED ON WHAT IS DOCUMENTED ONLINE IT WOULD SEEM AN ERROR OCCURRED WITH THE INSTALLATION OF THE AIRBAG INFLATOR KIT IMPACTING MY HORN. I DID ASK THE DEALERSHIP WHAT OTHER ISSUES COULD THIS CAUSE AND IF THE AIRBAG WAS IMPACTED THEY EXPLAINED SINCE THE AIRBAG INDICATOR LIGHT WAS NOT ON NOTHING WAS WRONG WITH THE AIRBAG. HOWEVER THE INDICATOR LIGHT WAS NOT ON WITH THIS RECALL EITHER BUT SOMETHING WAS HORRIBLY WRONG. I'D LIKE ANY ASSISTANCE TO CONFIRM THIS HORN ISSUE IS NOT RELATED TO THE REPLACEMENT DEALING WITH THE TAKATA RECALL. THANK YOU.

NHTSA ID

11150404

Incident

Oct 19, 2018

Mileage

45,408 mi

I TOOK THE CAR IN AS PART OF THE TAKATA INFLATOR RECALL. EVERYTHING IN THE CAR WAS WORKING WHEN I DROPPED OFF THE CAR. NOW THE DEALERSHIP WANTS $700 PLUS TO REPAIR THE HORN, IGNITION LOCK, CONTROLS ON THE STEERING WHEEL THAT CONTROL THE VOLUME AND MENU BUTTONS ON THE DISPLAY PANEL. THESE ITEMS WERE WORKING WHEN I DROPPED OFF THE CAR. VWOA HAS STATED DUE TO THE AGE OF THE CAR AND THE MILEAGE, THESE ITEMS ARE NOT COVERED UNDER WARRANTY. THEY WERE WORKING WHEN I BROUGHT THE CAR TO THE DEALERSHIP, MOMENTUM VOLKSWAGEN OF CLEAR LAKE. I DROPPED THE CAR OFF ON OCTOBER 16TH AT 9 AM FOR AN 9:15 APPOINTMENT, THEY CALLED AROUND 11 AM SAYING THE CAR NEEDED $700 PLUS TO REPAIR THE HORN, IGNITION LOCK, AND THE BUTTONS ON THE STEERING WHEEL. I WASN'T GOING TO PAY FOR IT, THEY WERE WORKING WHEN I DROPPED THE CAR OFF. THE DEALERSHIP CONTACTED MANAGEMENT AT VW AND THEY SAID THEY WERE NOT GOING TO PAY FOR IT. THE SERVICE SUPERVISOR IS CALLING SOMEONE ELSE AT THE DEALERSHIP TO SEE ABOUT GETTING THE PROBLEM RESOLVED. I CONTACTED VW OF AMERICA CUSTOMER SERVICE AT 800-822-8987, TALKED TO KAY C., THE LEADERSHIP TEAM AT VWOA SAID BECAUSE OF THE AGE OF THE CAR AND MILEAGE, THESE ITEMS ARE NOT COVERED UNDER WARRANTY. SO IT IS MY FAULT THAT THE RECALL TAKES OVER 5 YEARS TO GET TO MY CAR, WHAT IF I HAD BEEN IN AN ACCIDENT AND DIED DUE TO SHARDS SEVERING MY ARTERIES IN MY NECK AND I BLEED TO DEATH IN AN OTHERWISE BEIGN ACCIDENT, WHILE WAITING FOR THE AIRBAG TO BE REPLACED. IF I HAD NOT TAKEN THE CAR TO THE DEALERSHIP FOR THE AIR BAG RECALL, MY STEERING WHEEL CONTROLS AND HORN WOULD STILL BE WORKING. SO THIS FREE REPLACEMENT RECALL IS COSTING ME THREE DAYS WITHOUT A CAR, AND WHATEVER IT COSTS TO REPAIR WHAT THE DEALERSHIP BROKE..

NHTSA ID

11141092

Incident

Oct 16, 2018

Mileage

90,000 mi

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards