2008 MINI Cooper S Engine Problems

TIMING CHAIN JUMPED OUT OF TIMING AND CAUSED BENT VALVES.

NHTSA ID

11355604

Incident

Sep 17, 2020

Mileage

70,000 mi

MY CAR CAUGHT FIRE WHILE DRIVING. I HAD BEEN DRIVING FOR ABOUT AN HOUR ON THE HIGHWAY. THERE WAS NO WARNING. NO CEL OR ERRORS ON THE DASH DISPLAY. CAR WAS RUNNING NORMALLY. I NOTICED SOME SMOKE. AFTER PULLING TO THE SIDE OF THE ROAD FLAMES STARTED COMING FROM UNDER THE HOOD. THE CAR WAS STILL RUNNING NORMALLY. I SHUT OFF THE MOTOR AND GOT OUT. BYSTANDERS EMPTIED AN EXTINGUISHER THROUGH THE FRONT GRILLE BUT WITHIN MINUTES THE ENTIRE VEHICLE WAS ENGULFED. CAR WAS ALMOST COMPLETELY DESTROYED. FIRE BURNED THROUGH THE FIREWALL AND CONSUMED THE INTERIOR.

NHTSA ID

11298643

Incident

Dec 17, 2019

Mileage

144,000 mi

AT 32000 MILES AN OIL LEAK WAS NOTED ON THE GARAGE FLOOR. THE FOREIGN CAR REPAIR SHOP TROUBLESHOT THE LEAK. FINAL OUTCOME: REPLACE SUPERCHARGER ASSEMBLY, VACUUM BRAKE BOOSTER PUMP AND INTAKE MANIFOLD GASKET. TOTAL COST $3,014.78 FOR A VEHICLE THAT HAS A TRADE-IN VALUE OF LESS THAN $5,000. THE FOREIGN CAR EXPERT WAS AMAZED THAT THE TURBO HAD TO BE REPLACED WITH SUCH LOW MILEAGE.

NHTSA ID

11193140

Incident

Mar 18, 2019

Mileage

32,094 mi

WHILE DRIVING AT HIGHWAY SPEED ON I-71 N & N. BROADWAY EXIT IN COLUMBUS, OHIO ON MARCH 1, 2019 THE TIMING CHAIN BROKE AND CAUSED COMPLETE ENGINE FAILURE AND BENT ALL VALVES AND CYLINDER HEAD AND VALVES RESULTING IN $8821.97 IN DAMAGE TO MY ENGINE. THE CAUSE OF THE TIMING CHAIN FAILURE IS DUE TO THE PRINCE/PSA ENGINE DESIGN AND MANUFACTURING DEFECT ADMITTED TO IN THE CLASS ACTION LAWSUIT KNOW AS JOSHUA SKEEN AND LAURIE FREEMAN V. BMW OF NORTH AMERICA, L.LC. UNITED STATES DISTRICT COURT DISTRICT OF NEW JERSEY CIV. NO. 2:13-CV-1531-WHW-CLW. BMW DECLINED TO REPLACE MY ENGINE UNDER THE EXTENDED WARRANTY AGREED TO IN THE SETTLEMENT AGREEMENT OF THE ABOVE CITED ACTION. ALL AFFECTED VEHICLES SHOULD HAVE BEEN RECALLED AND MY ENGINE FAILURE COULD HAVE EASILY CAUSED LOSS OF LIFE. MY VEHICLE IS ONE OF THE CLASS VEHICLES, R56 N14 ENGINE PRODUCED BETWEEN 2006 THRU 2010. THIS IS A PRODUCT LIABILITY SAFETY CLAIM THAT IS NOT SUBJECT TO ANY STATUTORY/WARRANTY TIME LIMITATION. ALL CLASS VEHICLES SHOULD BE RECALLED DUE TO THE LOSS OF LIFE AND SAFETY RISKS. DO NOT WAIT FOR LOSS OF LIFE TO ENFORCE THE LIABILITY OF BMW FOR THEIR FAILURE TO SELF REPORT THE DESIGN DEFECT AND FAILURE TO VOLUNTARILY RECALL ALL AFFECTED VEHICLES.

NHTSA ID

11192292

Incident

Mar 1, 2019

Mileage

70,674 mi

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING 60 MPH, THE TIMING CHAIN FRACTURED, CAUSING A COMPLETE ENGINE FAILURE. ALL THE VALVES AND CYLINDER HEADS WERE BENT. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SHOULDER EVEN AFTER THE VEHICLE LOST ALL POWER. THE VEHICLE WAS TOWED TO THE DEALER (MIDWESTERN AUTO GROUP, 6335 PERIMETER LOOP RD, DUBLIN, OH 43017, (614) 889-2571 WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED AT A COST OF OVER $8,000. THE CONTACT NOTIFIED THE MANUFACTURER AND WAS PROVIDED A CLAIM NUMBER. THE MANUFACTURER DID NOT ASSIST WITH THE WARRANTY OR RECALL,S BUT OFFERED TO PAY $2,000 TOWARDS THE REPAIR COST. THE OFFER WAS GOOD FOR SIX MONTHS. THE FAILURE MILEAGE WAS 70,674.

NHTSA ID

11192254

Incident

Mar 1, 2019

Mileage

70,674 mi

MY MINI COOPER HAS A TIMING CHAIN PROBLEM IT RATTLES UPON STARTING AND I HAVEN'T DRIVEN IT .....I JUST FOUND OUT ABOUT THIS RECALL

NHTSA ID

11122106

Incident

Aug 24, 2018

Mileage

105,000 mi

THE VEHICLE LOST POWER WHILE DRIVING ON THE HIGHWAY AND A MINI DEALERSHIP HAS CONFIRMED THAT THE TIMING CHAIN IS THE PROBLEM ALONG WITH THE VALVES (POSSIBLY CAUSED BY THE TIMING BEING OFF). MULTIPLE CONVERSATIONS WITH MINI CUSTOMER RELATIONS HAVE GOTTEN NO WHERE AND THE MANUFACTURER REFUSES TO TAKE RESPONSIBILITY FOR THE KNOWN ISSUES WITH THE TIMING CHAIN IN THIS VEHICLE. DESPITE A CLASS ACTION LAWSUIT SPECIFICALLY ABOUT THE TIMING CHAIN, NO RECALL HAS BEEN ISSUED AND THE MANUFACTURER REFUSES TO ASSIST CUSTOMERS WITH NECESSARY REPAIRS TO THIS DEFECTIVE PART (AND OTHER DAMAGE CAUSED BY THE DEFECT). THESE TIMING CHAIN ISSUES ARE NOT ONLY AN UNDUE BURDEN ON THE CONSUMER, THEY CAN BE POTENTIALLY FATAL IF A TIMING CHAIN FAILS AT AN UNFORTUNATE MOMENT. MINI NEEDS TO ISSUE A RECALL.

NHTSA ID

11113824

Incident

Mar 9, 2018

Mileage

136,000 mi

WHILE TRAVELING ON I-10 IN TALLAHASSEE, FL AT HIGHWAY SPEED OF 70 MPH THE CAR SUDDENLY LOST POWER. BEING I THE CENTER LANE OF EIGHT (FOUR EACH DIRECTION) IT WAS ALMOST IMPOSSIBLE TO GET OUT OF TRAFFIC. SEVERAL VEHICLES MADE ABRUPT MANEUVERS TO AVOID A CRASH. ALSO AS I GOT OUT OF THE VEHICLE WAS NEARLY STRUCK BY OTHER CARS. I LATER FOUND OUT THIS WAS DUE TO A FAILED TIMING CHAIN WITH NUMEROUS COMPLAINTS AND NO RECALL. THERE WAS ALSO A CLASS ACTION SETTLEMENT AND STILL NO RECALL. THIS COULD HAVE WELL BEEN A FATAL INCIDENT.

NHTSA ID

11067188

Incident

Jan 29, 2018

Mileage

120,000 mi

CAR TAKES A WHILE TO "WARM UP" HOWEVER AFTER A VERY SHORT DRIVE THE HOOD IS HOT TO THE TOUCH. IT ALSO SMELLS HOT. I LOOKED ON LINE AND SEEN SEVERAL COMPLAINTS AND THERE IS ACTUALLY AN AFTER MARKET 'DEFLECTOR' TO CHANNEL HEAT FROM THE HOOD. I HAVE NOTICED THE PLASTIC HOOD SCOOP IS DEFORMED FROM HEAT. I FEEL IT IS A MATTER OF TIME BEFORE A FIRE OR OTHER REACTION, E.G., HEAT CAUSES ANOTHER PART TO FAIL AND CAR WONT STOP, ACCELERATE OR OTHER CAUSING A CRASH. I ALSO NOTICED THE HEADLIGHT WIRING TO BE FRAYED AS IF IT HAS BEEN HOT.

NHTSA ID

11057397

Incident

Nov 10, 2017

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V657000 (ENGINE AND ENGINE COOLING), BUT THE REPAIR WAS NOT COMPLETED BEFORE THE CONTACT OWNED THE VEHICLE. IN ADDITION, THE CONTACT EXPERIENCED A FAILURE CONCERNING NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHO PROVIDED AN OIL CHANGE AND CLEARED A DTC. THE CONTACT LATER EXPERIENCED EXTREME SMOKE EMITTING ON THE OUTSIDE OF THE VEHICLE TO THE INSIDE OF THE VEHICLE. THE VEHICLE WAS COASTED OVER TO THE SIDE OF THE ROAD AND TOWED TO A REPAIR SHOP. THE MECHANIC DIAGNOSED THAT THE WATER PUMP LEAKED, THE ENGINE OVER HEATED, THE CYLINDER HEAD WAS WARPED, AND THE OIL FILTER HOUSING GASKET WAS LEAKY. THE MECHANIC DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

NHTSA ID

10957776

Incident

Feb 1, 2017

Mileage

76,000 mi

THE TURBO OIL FEED LINE IS INHERENTLY FLAWED AND PREMATURELY FAILS BECAUSE OF A BAD DESIGN. THIS FAILURE CAUSES HOT OIL TO LEAK ALL OVER A HOT TURBO. I WAS LUCKY ENOUGH TO NOT HAVE MY ENGINE CATCH FIRE WITH THE FAILED O-RING ON MINE. I WAS DRIVING ON THE HIGHWAY WHEN LARGE CLOUDS OF SMOKE BEGIN TO FLOW FROM THE ENGINE COMPARTMENT. I WAS FORCED TO PULL OVER AND GET TOWED HOME. I WAS OUT OF WARRANTY BUT STILL VERY LOW MILEAGE (48K) WHEN MINE FAILED. *TR

NHTSA ID

10934179

Incident

Nov 26, 2016

Mileage

48,000 mi

PRISTINE CONDITION, LOW MILEAGE, DEALER SERVICED MINI COOPER S (OWNED SINCE NEW) BEGAN EXHIBITING A RATTLING NOISE FROM ENGINE AT 34K MILES. DEALER DIAGNOSED IT AS A TIMING CHAIN DEFECT AND TIMING CHAIN TENSIONER DEFECT. THIS IS A KNOWN ENGINE DEFECT. REFERENCE CLASS ACTION SUIT AND SETTLEMENT 338403. THIS SETTLEMENT BY BMW/MINI USA COVERS THIS FLAW AND BMW/MINI KNOWS THAT VEHICLES PRODUCED WITHIN THE 2007-2010 TIMEFRAME HAVE THIS FLAW. THIS FLAW CAN RESULT IN CATASTROPHIC ENGINE FAILURE. IN MY CASE, IT WAS NOISY UNDER ACCELERATION, AND WAS INTO THE DEALER FOR SERVICE WITHIN DAYS OF FIRST ISSUE. THIS IS A KNOWN FLAW. HOWEVER, BMW/MINI SETTLED THE CLASS ACTION LAWSUIT AND SET ASIDE MILLIONS OF DOLLARS FOR CLAIMS....BUT THOSE CLAIMS MUST BE FILED BY 7/1/16. I DID NOT HAVE THE ISSUE BEFORE THAT DATE, I HAD IT HAPPEN IN SEPTEMBER 2016 - TWO MONTHS LATER. I HAVE REQUESTED SOME ACCOMMODATION FROM BMW/MINI, HOWEVER THEY ARE REFUSING TO PARTICIPATE AT ANY LEVEL, EVEN THOUGH THEY KNOW THIS WAS A FLAWED PART AND COULD HAVE CAUSED SIGNIFICANT DAMAGE. I AM NOT EXPECTING FULL REIMBURSEMENT, BUT IF THEY KNOW THE CAR HAS A MAJOR FLAW, THEY SHOULD HAVE SOME COVERAGE IN PLACE FOR ANY OF THESE VEHICLES WITH THE FLAW. THUS FAR THE REGIONAL SERVICE MANAGER AND MINI USA HAVE INDICATED BECAUSE THIS HAPPENED AFTER 7/1/16 THEY WILL NOT ACCOMMODATE.

NHTSA ID

10914301

Incident

Sep 21, 2016

Mileage

34,400 mi

FUEL SMELL STARTED TO GET STRONGER IN THE CABIN AND OUTSIDE OF THE VEHICLE, BUT DID NOT SEE ANY LEAKS ON THE FLOOR TILL TODAY. I ALSO NOTICE THE GREEN TEMPERATURE NOTIFICATION COME ON TODAY. I HAD MY OIL CHANGED AT THE BMW/MINI DEALER IN ONTARIO LAST MONTH.

NHTSA ID

10905148

Incident

Sep 9, 2016

Mileage

97,000 mi

TIMING CHAIN AND TIMING CHAIN TENSIONER BROKEN AND DAMAGED THE ENGINE AT MILE 48544 - 48552

NHTSA ID

10872172

Incident

Jan 29, 2012

Mileage

48,544 mi

TL* THE CONTACT OWNED A 2008 MINI COOPER S. WHILE DRIVING APPROXIMATELY 70 MPH, AN ABNORMAL NOISE WAS HEARD AND THE CONTACT NOTICED THICK, GREY SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE OIL WARNING LIGHT ILLUMINATED. THE CONTACT OPENED THE HOOD AND NOTICED FLAMES IN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT AND A FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS TOWED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,777.

NHTSA ID

10852542

Incident

Mar 20, 2016

Mileage

85,777 mi

I OWN A 2008 MINI COOPER S AND IT HAS 62000 MILES ON IT. AS MANY OTHER MINI OWNERS, I HAVE " RATTLE NOISE" ISSUE WHEN COLD START AND POPPED UP "ENGINE OIL PRESSURE TOO LOW" WARNING YESTERDAY WHEN DROVE HOME ON CITY STREET. THIS VEHICLE HAS HAD THE TIMING CHAIN TENSIONER/GUIDE CHANGED ONCE BEFORE AT 18,942 BY A MINI DEALER.

NHTSA ID

10852027

Incident

Mar 27, 2016

Mileage

61,500 mi

ENGINE RATTLE UPON STARTUP. NEXT THING I KNOW IS THE TIMING CHAIN GUIDES BROKE AND THE VALVES BENT. THOUSANDS IN REPAIR AND MINI WON'T COVER A THING.

NHTSA ID

10819659

Incident

Dec 15, 2015

Mileage

109,000 mi

AS MANY OTHERS HAVE POSTED HERE, MY ENGINE BEGAN RATTLING LOUDLY WHEN I WOULD START IT UP. TO ALLEVIATE THIS, I WOULD TOP OFF THE OIL AND GET FREQUENT OIL CHANGES, IN FACT, MORE OFTEN THAN MINI/BMW SUGGESTED IT SHOULD GET AN OIL CHANGE. THIS WOULD USUALLY TAKE CARE OF THE RATTLE. ONE NIGHT, THE ENGINE RATTLE KEPT INCREASING AND SUDDENLY THE CAR STOPPED IN THE MIDDLE OF A BUSY STREET JUST 20 FEET FROM RAILROAD TRACKS WITHOUT ANY WARNING LIGHTS OR INDICATIONS WHATSOEVER. I HAD IT TOWED TO A NEARBY MECHANICS SHOP I TRUST (NOT THE DEALERSHIP). THE TIMING CHAIN HAD BROKEN AND BENT THE VALVES AND I'M IN THE PROCESS OF HAVING A NEW ENGINE PUT IN (WITH THE SAME FAULTY TIMING CHAIN) TO THE TUNE OF $6,500. I CALLED MINI/BMW USA BECAUSE MY MECHANIC SAID HE'S SEEN THIS PROBLEM FREQUENTLY IN MY MODEL. MINI SAID THEY WOULD NOT DO ANYTHING FOR ME UNLESS THE CAR WAS DIAGNOSED BY THE MINI DEALERSHIP, AND EVEN THEN THERE WOULD BE NO GUARANTEE THEY WOULD COVER ANYTHING BECAUSE OF "MY VEHICLE'S AGE." MINI/BMW USA WOULDN'T EVEN ACKNOWLEDGE THAT THERE HAVE BEEN FREQUENT REPORTS OF TIMING TENSIONER/CHAINS HAVING PROBLEMS. I'M EVEN MORE SURPRISED HOW FREQUENT THIS PROBLEM IS NOW THAT I'M LOOKING ON THE NHTSA WEBSITE. THIS NEEDS TO BE A RECALL AND SOMETHING THAT MINI/BMW SHOULD COVER AND RESPOND TO, SINCE THERE HAVE BEEN SEVERAL CLASS ACTION LAWSUITS AGAINST THE COMPANY BECAUSE OF THIS.

NHTSA ID

10807571

Incident

Nov 11, 2015

Mileage

90,000 mi

AFTER MINI/BMW REPAIRED THE TIMING CHAIN TENSIONER AND THE TIMING CHAIN, MY TURBO OIL SUPPLY LINE DEVELOPED A SIGNIFICANT LEAK (WITHIN A WEEK/ WITHIN 200 MILES OF MINI SERVICE) CAUSING SMOKE TO ESCAPE FROM THE BONNET, OIL TO COVER THE FRONT ENGINE/TURBO/EXHAUST. OIL NOW PUDDLES BENEATH THE CAR WHEN PARKED. THE CAR HAS 89,XXX MILES. I FIRST NOTICED THE SMELL OF BURNING OIL WHEN DRIVING ACROSS TOWN AT A SPEED OF 40MPH. WHEN PARKING THE VEHICLE, UPON IDLE THE SMOKE BILLOWED FROM THE BONNET OF THE CAR. ACCORDING TO MINI FORUMS, THIS PROBLEM OF A FAILED O-RING IN THE TURBO OIL SUPPLY LINE IS A KNOWN PROBLEM RESULTING IN NUMEROUS FAILURES THAT CAN LEAD TO CATASTROHIC DAMAGE TO THE TURBO, CATALYTIC CONVERTER, AND ENGINE.

NHTSA ID

10790749

Incident

Nov 13, 2015

Mileage

89,633 mi

WHEN STARTING CAR, I GET A GRINDING, RATTLING NOISE FROM THE ENGINE. I HAVE BEEN TOLD THIS IS THE CHAIN TENSIONER ON THE CAR

NHTSA ID

10787997

Incident

Jul 1, 2015

Mileage

45,000 mi

PURCHASED AT 61,000 MILES 9/9/14; HAD SYNTHETIC OIL CHANGE 5/15; 9/29/15 CAR BEGAN TO HAVE A RATTLE BUT UNSURE IF IT WAS FRONT OF CAR OR BACK OF CAR. RATTLING STOPPED ON ACCELERATION. NO WARNING LIGHTS CAME ON. 10/4/15 CAR DIED AT 69,362 MILES WHILE DRIVING ON A TWO LANE ROAD ON A CURVE. WAS ABLE TO COAST TO GETTING HALF THE CAR OFF THE ROAD. BYPASSERS PUSHED ME OFF THE REST OF THE WAY. TOWED TO MECHANIC WHO SAID IT WAS THE TIMING CHAIN GUARD THAT SPLIT OFF. CALLED MINI THEY SAID THEIR DEALERSHIP SERVICE DEPT HAD TO LOOK AT IT. HAD IT TOWED TO OH 70 MILES AWAY. THEY TOLD ME I HAD AN OIL LEAK WHICH CAUSED THE FOLLOWING TO BE DAMAGED - CRANK SHAFT, HARMONIC BALANCER, CYLINDER HEAD, TIMING CHAIN AND GUARD AND MAYBE OTHER STUFF BUT THEY COULDN'T TELL WITHOUT FURTHER EXAMINATION. TOLD $5,000 PLUS TO FIX, BUT I SEE MINI ESTIMATE STATES $3,500-4,500. MY LOCAL MECHANIC FOUND NO EVIDENCE OF AN OIL LEAK CAUSING THE TROUBLE, NOR DID I HAVE AN OIL SPOT WHERE I PARKED MY CAR IN THE GARAGE OR WORK PARKING LOT. NO OIL OR ENGINE LIGHT CAME ON.

NHTSA ID

10785948

Incident

Oct 4, 2015

Mileage

69,362 mi

TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT STATED THAT WHILE PARKED, THERE WAS AN ABNORMAL BURNING OIL ODOR FROM THE VEHICLE. THE FAILURE RECURRED CONSTANTLY. THE CONTACT PARKED THE VEHICLE AND NOTICED OIL LEAKING ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,000.

NHTSA ID

10780664

Incident

Sep 28, 2015

Mileage

59,000 mi

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE BEGAN TO DECELERATE AFTER THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS POWERED OFF AND BACK ON AND WAS ABLE TO BE DRIVEN; HOWEVER, THE VEHICLE WOULD NOT ACCELERATE PAST 55 MPH ON A 70 MPH HIGHWAY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT ONE OF THE CYLINDERS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

NHTSA ID

10731706

Incident

Jun 21, 2015

Mileage

62,000 mi

THE TURBO OIL FEED LINE IS A KNOWN FAILURE POINT ON THE ENGINES PUT IN THIS GENERATION OF MINI COOPER S MODELS. THE OIL LINE USES A "O" RING GASKET BEHIND A PINCH/CRIMP CONNECTION. THIS CONNECTION IS DIRECTLY IN CONTACT WITH THE HOT SIDE OF THE TURBO AND FAILS DUE TO EXCESSIVE HEAT. THIS ALLOWS ENGINE OIL TO LEAK OUT OVER THE TURBO AND DOWN THE FRONT OF THE ENGINE. THIS COULD CAUSE THE ENGINE TO RUN LOW ON OIL AT BEST. AT THE WORST IT COULD CAUSE A FIRE IF THE TURBO GETS HOT ENOUGH TO IGNITE THE OIL THAT IS LEAKING OUT. *TR

NHTSA ID

10705672

Incident

Apr 14, 2015

Mileage

99,610 mi

TURBOCHARGER OIL FEED LINE LEAKING. THE PART IS POORLY DESIGNED AND ACCORDING TO THE RESEARCH I'VE DONE PRONE TO FAILURE. THE DEALER WANTS $1200 TO REPLACE IT. WHEN I QUESTIONED THE SERVICE PERSON ABOUT THE HEAT SHIELD RECALL FROM JUST LAST YEAR TO PREVENT THIS ISSUE FROM OCCURRING, HE REASSURED ME THAT THE HEAT SHIELD RECALL WAS BECAUSE OF THE NUMBER OF PAINT JOBS THEY HAD TO DO ON HOODS FROM THE HEAT OFF THE TURBO DAMAGING THE HOOD PAINT. I THINK MINI SHOULD COVER THE COST OF REPLACING THE OIL SUPPLY LINE SINCE THEY ARE WELL AWARE THAT THIS PART IS FAULTY, IT GETS TOO HOT AND LEAKS. THE HEAT SHIELD RECALL DOESN'T STOP THE DAMAGE ALREADY DONE. IT SEEMS MY 2008 MINI IS NOT IMMUNE TO ANY OF THE "KNOWN" ISSUES THIS CAR HAS. EVERYTIME I VISIT THE MINI DEALERSHIP IT'S ANOTHER WELL KNOWN ISSUE/REPAIR. WHILE THE DEALERSHIP WAS VERY HELPFUL WITH THE LAST ISSUE (TIMING CHAIN), THEY WERE NOT WITH THIS LATEST ONE. THEY SAID BECAUSE IT WAS OUT OF WARRANTY THERE WAS NOTHING THEY COULD DO. *TR

NHTSA ID

10683258

Incident

Feb 13, 2015

Mileage

66,000 mi