2006 MINI Cooper Powertrain (other) Problems

THE AIR CONDITIONING HAD STOPPED BLOWING COOL AIR. THEN WHEN I WAS PARKED, AND IDLED, MY POWER STEERING STOPPED WORKING WHILE TRYING TO BACK OUT. AFTER WRESTLING WITH THE WHEEL FOR A MINUTE TO GET OUT OF A PARKING LOT AREA, THE POWER STEERING CAME BACK ON. THE MECHANIC SAID ONE OF MY COOLANT FANS DOES NOT WORK. THIS MAY BE PART OF A RECALL THAT AFFECT 2005 MINIS WITH COOLANT FAN/POWER STEERING, HOWEVER MY CAR WAS MADE JUST A FEW MONTHS PAST THE RECALL.

NHTSA ID

11337932

Incident

Jun 1, 2020

Mileage

68,000 mi

ONCE THE CAR WARMS UP THE AUTOMATIC TRANSMISSION LURCHES WHEN THE CAR SHIFTS FROM 1ST TO 2ND AND 3RD GEAR. THE ENGINE STILL ACCELERATES, HOWEVER, THE TRANSMISSION SIMPLY WHINES AND NO POWER IS DISTRIBUTED TO THE WHEELS. VERY UNSAFE WHEN PULLING OUT IN TRAFFIC. MINI ADVERTISED THESE VEHICLES AS NEVER REQUIRING TRANSMISSION FLUID CHANGES. THE VEHICLE HAS LESS THAN 100,000 MILES. NO RECALL EXISTS, HOWEVER, THE ISSUE IS WELL DOCUMENTED ON WEB FORUMS.

NHTSA ID

10853338

Incident

Apr 1, 2016

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING 40 MPH, THE VEHICLE STARTED LOSING POWER. THE ACCELERATOR PEDAL WAS BEING DEPRESSED WITH NO RESPONSE. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND WAS ABLE TO BE DRIVEN HOME AT A LOW RATE OF SPEED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

NHTSA ID

10823530

Incident

Nov 27, 2015

Mileage

90,000 mi

TO MAKE YOU AWARE OF A POTENTIAL SAFETY PROBLEM. THE 2006 MINI COOPER CVT TRANSMISSION HAS HAD NUMEROUS FAILURES. A CALIFORNIA JUDGE RECENTLY RULED IN FAVOR OF A CLASS ACTION SUIT AGAINST BMW(MINI COOPER). WE JUST BECAME AWARE OF THE TRANSMISSION GOING OUT IN OUR CAR. IT STILL RUNS AND SHIFTS BUT OUR CONCERN IS THAT IT COULD QUIT AT AN INOPPORTUNE TIME AND CAUSE AN ACCIDENT. MINI HAS SHOWN NO MORAL OR ETHICAL INTEREST IN REPLACING THE TRANSMISSION AT NO COST OR REDUCED COST TO THE CONSUMER.

NHTSA ID

10788091

Incident

Oct 30, 2015

Mileage

69,000 mi

DRIVING HOME FROM WORK AS USUAL, I WAS EXITING THE HIGHWAY WHEN I FELT A JOLT FROM THE ENGINE COMPARTMENT, THE ENGINE SEEMED TO SPUTTER AND AS SOON AS I SLOWED DOWN TO 30 MPH OR SO THE CAR WOULD NOT SHIFT BACK UP TO THE HIGHER GEARS. LUCKILY I WAS ONLY A QUARTER MILE FROM HOME SO I PUT THE HAZARD LIGHTS ON AND DROVE VERY CAREFULLY INTO MY DRIVEWAY. I PUT THE CAR IN PARK AND GOT OUT TO LOOK UNDER THE HOOD TO SEE IF ANYTHING WAS DRASTICALLY WRONG ( ANY LEAKS, SMOKE, ETC.). NOTHING APPEARED TO BE MALFUNCTIONING SO I PUT THE CAR BACK INTO DRIVE AND INSTANTLY STALLED THE ENGINE . I THEN CALLED A TOW TRUCK TO HAVE IT TOWED TO MY LOCAL MINI COOPER DEALERSHIP TO DIAGNOSE THE ISSUE. I WAS TOLD IT WOULD NEED AN ENTIRELY NEW CVT TRANSMISSION.

NHTSA ID

10763440

Incident

May 1, 2015

Mileage

100,000 mi

THE AUTOMATIC TRANSMISSION SEEMS VERY JERKY AND HESITANT. IT HAS DIED ON ME ONCE WHILE DRIVING AS IT STALLED OUT. I AM AFRAID THE TRANSMISSION IS CLOSE TO FAILURE. *TR

NHTSA ID

10573352

Incident

Mar 3, 2014

Mileage

79,000 mi

I HAVE A 2006 MINI COOPER CONV S, APROX 53,000 MILES, HAS A CVT AUTOMATIC TRANSMISSION, AT THIS TIME SHIFTING IN 1ST, 2ND AND 3RD GEARS HAS BEEN ERRATIC, WITH VERY JERKY SHIFTING AND SPEED. *TR

NHTSA ID

10548124

Incident

Oct 16, 2013

I WAS DRIVING ON THE FREEWAY AT 70MPH IN FAR LEFT LANE AND THE CAR JUST SHUT OFF. THE BRAKE AND STEERING WHEEL GOT STIFF AND WOULD NOT WORK RIGHT. THE AREA OF THE FREEWAY WAS CROWDED DUE TO CONSTRUCTION AND IT WAS IMPOSSIBLE TO GET TO THE SIDE. THE CAR BEHIND ME WAS ENTIRELY TO CLOSE AND IM SURPRISED I WAS NOT HIT. *TR

NHTSA ID

10522186

Incident

Jun 27, 2013

Mileage

88,170 mi

I HAVE AN '06 MINI COOPER AND NEVER HAD ANY ENGINE/TRANSMISSION ISSUES PRIOR TO TODAY. ALL SCHEDULED MAINTENANCE WAS DONE BY THE MINI DEALER. TODAY LEAVING TO GO TO WORK, I STARTED THE CAR, PUT MY SEAT BELT ON, CHECKED THE MIRRORS, ROLLED DOWN THE WINDOWS, PUT THE CAR GEAR IN "D" AND STARTED MOVING FORWARD OUT A PARKING LOT, AND AFTER A FEW SECONDS WHILE DRIVING, THE CAR LOST ALL ACCELERATION AND CAME TO A STOP. THEN THE CAR WON'T REVERSE NOR MOVE FORWARD WHILE IN ANY GEAR. TOWED TO THE DEALER AND LATER WAS TOLD IT'S THE CVT TRANSMISSION AND IT WILL COST THOUSANDS OF DOLLARS TO REPLACE THE CVT TRANSMISSION. *TR

NHTSA ID

10514390

Incident

May 30, 2013

Mileage

150,000 mi

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE DOWNSHIFTED AND STALLED. THE CONTACT HAD TO PULL TO THE SIDE OF THE ROAD AND SHIFT INTO MANUAL MODE TO SHIFT THE GEARS UP AND DOWN. THE CONTACT ALSO STATED THAT THE BATTERY LIGHT ILLUMINATED WHILE THE VEHICLE WAS PARKED. THE CONTACT ALSO STATED THAT THE ENGINE MALFUNCTIONED DUE TO THE COOLING SYSTEM EMITTING SMOKE FROM THE ENGINE AND CORROSION ON THE ENGINE ITSELF. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER FOR A DIAGNOSTIC TEST. THE FAILURE MILEAGE WAS 74,000.

NHTSA ID

10507482

Incident

Jan 16, 2013

Mileage

74,000 mi

I HEARD A WHIRRING SOUND AND A LIGHT CAME ON THE DASHBOARD. TOOK IT TO THE MINI COOPER DEALERSHIP BOB SMITH WHERE I HAD THE CAR SERVICED AND WHERE IT WAS ORIGINALLY PURCHASED. THE TECHNICIAN DID NOT PULL ANY CODES, JUST TOOK THE CAR FOR A RIDE. HE PRONOUNCED THAT THE TRANSMISSION HAD TO BE REPLACED AS IT IS A SEALED TRANSMISSION AS IT IS A "SEALED" TRANSMISSION AND THEREFORE IT COULD NOT BE REPAIRED AT A COST OF $9000! HE THEN TOOK OFF $1500 FOR A COST OF $7500! GOOGLED THIS PROBLEM TO FIND OUT THAT SO MANY MINI'S HAD THIS PROBLEM THAT A CLASS ACTION LAWSUIT HAD BEEN FILED. CONTACTED MINIUSA WHO SCOFFED AT THE PROBLEM AND OFFERED NO HELP OR RELIEF. HOPING THAT MINI WILL BE FORCED TO DEAL WITH THIS ISSUE AND THAT A RECALL WILL BE INITIATED BEFORE ANYONE IS SERIOUSLY INJURED. *TR

NHTSA ID

10493625

Incident

Jan 15, 2013

Mileage

71,000 mi

2006 MINI-COOPER. CONSUMER WRITES IN REGARDS TO TRANSMISSION FAILURE. *SMD THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE, BUT THEY DID STATE THE TRANSMISSION WAS IN THE PROCESS OF FAILING. THE CONSUMER STATED WHEN HE ATTEMPTED TO GET ON THE FREEWAY, THE VEHICLE WOULD NOT SHIFT INTO 2ND GEAR. THE MANUFACTURER OFFERED TO PAY 1/2 OF THE COST ON THE BILL, WHICH TOTALED $8,000. *JB

NHTSA ID

10489722

Incident

Dec 3, 2012

Mileage

48,000 mi

2006 MINI CVT TRANSMISSION MADE A WEIRD NOISES AND STOPPED MOVING, JUST PRIOR TO THIS THERE WAS HESITATION IN ACCELERATION AND VERY LOUD NOISE FROM THE TRANSMISSION. *TR

NHTSA ID

10482892

Incident

May 20, 2011

Mileage

69,000 mi

MINI COOPER TRANSMISSION FAIL. THE CAR DOES NOT GO BETWEEN 20 TO 50 MPH. IT HAS NO POWER AND THAT CAN BE DANGERS WHEN I AM GETTING INTO THE HIGHWAY AND CARS ARE GOING AT A HIGH SPEED. ON TOP OF IT MY CAR STALLED IN THE MIDDLE OF RUSH HOUR. LUCKY I GOT IT STARTED AND WAS ABLE TO MAKE IT HOME. SEEMS LIKE EVERYONE IS HAVING THIS PROBLEM THE CAR NEED TO BE RECALL AND GET IT FAXED BECAUSE SOMEONE CAN DIE. *TR

NHTSA ID

10472689

Incident

Aug 20, 2012

Mileage

114,000 mi

I PURCHASED A REBUILT LEFT HALF SHAFT FROM BESTSOURCE AUTO PARTS ON LINE FOR A 2006 MINI COOPER S. THE RE-BUILDER NAME ON THE BOX WAS FEQ. THE OUTER CV JOINT HOUSING EXPLODED INTO PCS AFTER ABOUT 3000 MILES. I WAS LUCKY IT HAPPENED DRIVING OFF FROM A STOP. IF IT HAPPENED ON THE HIGHWAY THE DAMAGE WOULD HAVE HUGE AND THE CAR MAY HAVE GONE OUT OF CONTROL. THIS FAILURE SHOULD HAVE NEVER HAPPENED. THE THICK STEEL HOUSING EXPLODED THEN RELEASING THE HALF SHAFT TO FLY IN A BIG ARC.SINCE I WAS DRIVING OFF FROM A A STOP IT WAS A LOUD BANG AND THEN CLANGING OF THE HALF SHAFT SMACKING THE WHEEL ETC. I WAS LUCKY BUT SOMEONE ELSE MAY NOT BE SO LUCKY. I WAS IN LAS VEGAS SO I TOOK THE CAR TO DESERT MINI AND THEY SAW IT FIRST HAND, I TOOK PHOTO'S I CAN SEND TO YOU. BESTSOURCE TELLS ME FEQ IS A QUALITY RATING "FIRST EQUIPMENT QUALITY" AND THAT THEY COULD NOT FIND THEM EITHER. FEQ HAS A SIMPLE ONE PAGE WEBSITE WITH NO CONTACT INFORMATION. I UNDERSTAND METALLURGY, THIS PART WAS FLAWED. YOU CAN TELL BY THE WAY THE BRAKE LOOKS.. DESERT MINI KEPT THE PART AND SENT IT BACK TO BMW LAST WEEK. WE CAN TRACK IT DOWN I AM SURE OF IT. I HAVE TRIED TO FIND THE VENDOR BUT NO LUCK. THIS IS WRONG. THEY NEED TO KNOW ABOUT THIS AND THEY SHOULD COVER MY REPLACEMENT EXPENSE. THE EXPENSE IS NOT AS IMPORTANT TO ME AS SAFETY TO OTHERS RIGHT NOW. THE PHOTOS I HAVE WILL MAKE ANY OF YOUR SAFETY ENGINEERS CONCERNED. *TR

NHTSA ID

10383100

Incident

Sep 8, 2010