2006 MINI Cooper Problems

BMW issued a Recall 15V-205 Safety Recall, to cover the Airbag sensor in the passenger seat of my vehicle, a 2006 Mini Cooper S. The failure error was in the airbag sensor in the passenger seat, and the system warned of potential hazard with the passenger airbag. My car had a recall fix in 2018 for this fault. Now some 4 years later the same fault has arisen in the same sensor and system. I returned to BMW Mini who carried out the previous recall to have this fixed again. They said that while their repairs and parts generally carry an 8-year warranty, they do not warrant Recall repairs. They wanted over $2,000 to fix this issue. As this is a repeat of the original fault, and the car has under 100,000 miles I believe it should be covered, as their repair and or part has again failed. The date below is when I took it for the recall and was refused the warrenty repair.

Blindsided Drive side impact car ignited I was cut from my car suffering emence Injuries due to the malfunction of the airbags . No air bags deployed.

Electronic power steering pump issue/failure. The steering wheel was so stiff when I tried to go right that I physically could not turn the wheel. This is extremely dangerous & it happens without warning. No lights come on. You are left in a moving vehicle, without much of a way to control the direction you need it to travel in. From what I have learned, it seems an extended warranty was initially offered, & then a forced recall was issued on the, 1st Gen, 2002-2005 Mini Coopers. Only part of the vehicles with these issues were included in the recall. I have the same size 1.6 engine, & the exact same electronic power steering pump that comes with the issues & failures that I have in my 06. I have seen it on vehicles up to 08. This is absolutely unacceptable. This is a documented manufacturing defect & design flaw that has been continually allowed to endanger people’s lives. I am unsure how BMW managed to only recall part of the vehicles with these electronic power steering pump issues. I contacted BMW who told me there were no extended warranties or recalls on my vehicle.

The contact owns a 2006 Mini Cooper. The contact stated that while driving at various speeds, the steering wheel was significantly difficult to turn. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 139,000.

TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING 70 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS TOWED TO NICK ALEXANDER MINI (6201 ALAMEDA ST, LOS ANGELES, CA 90001) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING PUMP, ALTERNATOR, AND RADIATOR COOLING FAN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 80,054.

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THERE WAS A LOSS OF POWER STEERING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE POWER STEERING PUMP WAS REPLACED HOWEVER THE FAILURE RECURRED THE NEXT DAY. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC AND UNKNOWN REPAIRS WERE PERFORMED. IN ADDITION, THE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. ON A SEPARATE OCCASION, THE ALTERNATOR FAILED AND WAS NOT REPLACED. THE CONTACT MENTIONED THAT THE ENGINE COOLING FAN ALSO FAILED TO FUNCTION, WHICH CAUSED THE RADIATOR TO BE REPLACED TWICE. THE ENGINE WAS REPLACED AT A DIFFERENT TIME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

THE AIR CONDITIONING HAD STOPPED BLOWING COOL AIR. THEN WHEN I WAS PARKED, AND IDLED, MY POWER STEERING STOPPED WORKING WHILE TRYING TO BACK OUT. AFTER WRESTLING WITH THE WHEEL FOR A MINUTE TO GET OUT OF A PARKING LOT AREA, THE POWER STEERING CAME BACK ON. THE MECHANIC SAID ONE OF MY COOLANT FANS DOES NOT WORK. THIS MAY BE PART OF A RECALL THAT AFFECT 2005 MINIS WITH COOLANT FAN/POWER STEERING, HOWEVER MY CAR WAS MADE JUST A FEW MONTHS PAST THE RECALL.

ONCE THE CAR WARMS UP THE AUTOMATIC TRANSMISSION LURCHES WHEN THE CAR SHIFTS FROM 1ST TO 2ND AND 3RD GEAR. THE ENGINE STILL ACCELERATES, HOWEVER, THE TRANSMISSION SIMPLY WHINES AND NO POWER IS DISTRIBUTED TO THE WHEELS. VERY UNSAFE WHEN PULLING OUT IN TRAFFIC. MINI ADVERTISED THESE VEHICLES AS NEVER REQUIRING TRANSMISSION FLUID CHANGES. THE VEHICLE HAS LESS THAN 100,000 MILES. NO RECALL EXISTS, HOWEVER, THE ISSUE IS WELL DOCUMENTED ON WEB FORUMS.

BMW issued a Recall 15V-205 Safety Recall, to cover the Airbag sensor in the passenger seat of my vehicle, a 2006 Mini Cooper S. The failure error was in the airbag sensor in the passenger seat, and the system warned of potential hazard with the passenger airbag. My car had a recall fix in 2018 for this fault. Now some 4 years later the same fault has arisen in the same sensor and system. I returned to BMW Mini who carried out the previous recall to have this fixed again. They said that while their repairs and parts generally carry an 8-year warranty, they do not warrant Recall repairs. They wanted over $2,000 to fix this issue. As this is a repeat of the original fault, and the car has under 100,000 miles I believe it should be covered, as their repair and or part has again failed. The date below is when I took it for the recall and was refused the warrenty repair.

AIR BAG SENSOR IN THE DETECTION MAT OF THE PASSENGER'S FRONT SEAT DOES NOT RECOGNIZE PASSENGER . THE AIR BAG LIGHT FOR THE PASSENGER IN THE FRONT PANEL IS INTERMITTENT, PUTTING AT RISK OF NOT DEPLOYING THE AIR BAG DURING AN ACCIDENT. THE LIGHT WILL COME UP EVEN WHEN I HAVE A PURSE ON THE SEAT OR WITH A FULL GROWN ADULT (OVER 150 POUNDS). I RECENTLY CALLED 2 LOCAL MINI DEALERS IN SOUTHERN CALIFORNIA (JULY 2015) REGARDING THIS AND BOTH STATED THE SAME: THAT THEY HAVE NOT RECEIVED THE SPARE PART REQUIRED FOR THIS RECALL AND CANNNOT PERFORM UNTIL MINI PROVIDES THEM WITH AN AUTHORIZATION LETTER. CALLED IMMEDIATELY THE MINI CUSTOMER SERVICE LINE FOR RECALLS (1-866-825-1525) TO FIND OUT WHEN THIS WILL BE SOLVED SINCE THIS HAS BEEN ON ONGOING ISSUE SINCE MID 2014. MINI'S CUSTOMER SERVICE REPRESENTATIVE STATED THAT WE NEEDED TO WAIT UNTIL A NEW RE-DESIGN OF THIS SENSOR IN THE DETECTION MAT IS AVAILABLE FROM THEM IN ORDER TO PROVIDE THIS SPARE PART TO THE DEALERS. IN THE MEANTIME, WE ARE PUTTING AT RISK ANY PASSENGER WHO WILL RIDE IN OUR CARS FOR AN ISSUE THAT HAS BEEN KNOWN BY MINI FOR OVER A YEAR!

BMW issued a Recall 15V-205 Safety Recall, to cover the Airbag sensor in the passenger seat of my vehicle, a 2006 Mini Cooper S. The failure error was in the airbag sensor in the passenger seat, and the system warned of potential hazard with the passenger airbag. My car had a recall fix in 2018 for this fault. Now some 4 years later the same fault has arisen in the same sensor and system. I returned to BMW Mini who carried out the previous recall to have this fixed again. They said that while their repairs and parts generally carry an 8-year warranty, they do not warrant Recall repairs. They wanted over $2,000 to fix this issue. As this is a repeat of the original fault, and the car has under 100,000 miles I believe it should be covered, as their repair and or part has again failed. The date below is when I took it for the recall and was refused the warrenty repair.

TL* THE CONTACT OWNS A 2006 MINI COOPER. AFTER THE CONTACT PARKED THE VEHICLE, SHE WAS ALERTED TO THE ODOR OF SMOKE DURING THE NIGHT. THE CONTACT APPROACHED THE VEHICLE, QUICKLY DISCONNECTED THE BATTERY, AND ROLLED THE VEHICLE HALFWAY DOWN THE DRIVEWAY OUT OF THE GARAGE. THERE WAS A TREMENDOUS AMOUNT OF HEAT FROM THE ENGINE, BUT THE VEHICLE COOLED DOWN. THE FIRE DEPARTMENT WAS NOT CONTACTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THERE WAS AN ELECTRICAL FIRE FROM THE STEERING WHEEL PUMP AND MASSIVE REPAIRS WERE NEEDED, WHICH WOULD TOTAL APPROXIMATELY $3,500. THE MANUFACTURER WAS CALLED AND STATED THERE WAS NO RECALL ON THE VEHICLE. THE DEALER WAS NOT CONTACTED. THE INSURANCE COMPANY WAS CONTACTED. THE MANUFACTURER OFFERED TO COVER THE $500 DEDUCTIBLE FOR THE MECHANIC TO PERFORM THE REPAIRS THAT THE CONTACT WOULD HAVE TO PAY FOR IF THEY DECIDE NOT TO COVER THE CLAIM. THE FAILURE MILEAGE WAS 105,000.

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT THE TRANSMISSION WOULD SLIP IN AND OUT OF GEAR. THE CONTACT TRIED TO ACCELERATE AND THE ENGINE RPMS INCREASED EXCESSIVELY, BUT THE VEHICLE WOULD NOT RESPOND. THE CONTACT'S MECHANIC ORIGINALLY ASSUMED THE PROBLEM WAS THE TRANSMISSION CONTROL SWITCH BUT AFTER SOON DISCOVERED THAT THE TRANSMISSION CONTROL SWITCH WAS NOT THE ISSUE. THE MECHANIC ADVISED HAVING THE ENTIRE TRANSMISSION REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 84,000. UPDATED 4/2/12 *CN THE CONSUMER STATED HE LOST CONTROL OF PADDLE SHIFTER AND THE TRANSMISSION WOULD NOT DOWN SHIFT. ONCE THE VEHICLE WAS TURNED OFF AND RE-STARTED, THE TRANSMISSION WOULD SHIFT UP AND DOWN IN ALL GEARS, UNTIL IS SLIPPED OUT OF GEAR. UPDATED 04/13/12

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT THE VEHICLE CLUTCH WAS DEFECTIVE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE CLUTCH AND FLY WHEEL NEEDED TO BE REPLACE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO OFFERED TO PAY FOR HALF OF THE COSTS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 47, 000 AND THE CURRENT MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT WARNING LIGHT AND THE AIR BAG DISABLED LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN APRIL 2015, THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS) WAS RECEIVED. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE GIVEN. THE FAILURE MILEAGE WAS 100,000. MA 10/5 UPDATED 10/06/15*LJ *CN

FROM MY RESEARCH, THE 2006 MINI HAS A FAULTY PASSENGER OCCUPANCY SENSOR IN THE PASSENGER SEAT BOTTOM REQUIRING A REPLACEMENT AT A COST OF OVER $1000. SINCE 2006 WAS THE FIRST YEAR FOR THIS REQUIREMENT, I BELIEVE THEY DID NOT PROPERLY TEST THE DEVICE BEFORE RELEASING THEM INTO PRODUCTION AS I HAVE RESEARCHED AND READ ON MANY FAILURES OF THIS DEVICE. I CANNOT DETERMINE CONCLUSIVELY IF THE AIRBAG WILL OR WILL NOT DEPLOY IN THIS SITUATION AND MINI WILL BE LIABLE IN A SITUATION IF IT DOES NOT DEPLOY THE AIRBAG PROPERLY WITH A PASSENGER SEATED. THIS IS A SITUATION THAT NEEDS TO BE REMEDIED THROUGH A RECALL. MINI EXTENDED THEIR AIRBAG SYSTEM WARRANTY ON THE 2002 - 2005 MODELS TO 10 YEARS OR 150,000 MILES AND SHOULD DO THE SAME FOR THE 2006+ MODELS. *TR

I HAVE HEARD FROM MORE THEN 3 DOZEN OTHER INDIVIDUALS OWNING BOTH THE MINI COOPER AND MINI COOPER S RANGING FROM YEARS 2006 TO 2010 THAT THERE HAVE BEEN PROBLEMS REGARDING THE AIR CV JOINT AXEL AND/OR POWER ARM CONTROL A CONSTANT PROBLEM REGARDING THE GENERAL MODULE ELECTRONIC COMPONENT. THIS ISN'T JUST A COINCIDENCE AND MAY END UP BEING THE CAUSE OF SERIOUS ACCIDENTS IF ONE OR TWO OF THESE COMPONENTS ARE DEFECTIVE. FOR THIS MANY CONSUMERS TO BE HAVING THE SAME ISSUES, SAME SOUNDS AND REVISITED VISITS TO MINI DEALER SHOPS AROUND THE GLOBE SOMETHING IS NOT RIGHT AND NEEDS TO BE INVESTIGATED. I KNOW FOR ONE THING THIS CONTROL ARM IS A HUGE PROBLEM IF IT FAILS CONSIDERING IT'S LOCATION COULD BE THE CAUSE OF MANY SERIOUS ACCIDENTS AND POSSIBLE DEATHS DEPENDING ON THE SPEED AND SEVERITY OF THE ACCIDENT WHEN IT TAKES PLACE. MY VEHICLE IS CURRENTLY NOT ON THE ROAD DUE TO THE SEVERITY OF THE NOISE AND REACTION TO THE VEHICLE WHEN BEING OPERATED AND IT IS A SCARY THING. THEY WANT TO CHARGE A ABSURD AMOUNT OF MONEY TO FIX SOMETHING THAT QUITE FRANKLY MAY HAVE BEEN SOMETHING RECALLED A LONG TIME AGO, AND WASN'T BECAUSE A LOT OF CONSUMERS ARE NOT AWARE OF THIS PROCESS SUCH AS MYSELF UNTIL RECENTLY WHEN AN ATTORNEY FRIEND OF MINE STARTED TO DIG AROUND A BIT AFTER HEARING MY STORY AND THE STORIES OF MANY OTHERS I HAVE SPOKEN TOO.

AIRBAG PASSENGER MAT SEAT SENSOR . THIS HAS BEEN A ONGOING PROBLEM FROM THE 2003 TO PRESENT. SEAT SENSOR TURNS AIRBAG LIGHT ON AND CAN DISABLE AIR BAG ON PASSENGER SIDE AND ACCORDING TO MINI DEALERSHIP, NOT ON FACTORY RECALL BUT THEY SAY GET HUNDREDS A YEAR AND CHARGE TO REPLACE SENSOR AT 1000.00. SAFETY ISSUE! SOMEONE REALLY NEEDS TO HAVE THEM FIX A KNOWN ISSUE AT ALL DEALERSHIPS AND PUT PEOPLES LIVES IN DANGER. *TR

I HAVE AN '06 MINI COOPER AND NEVER HAD ANY ENGINE/TRANSMISSION ISSUES PRIOR TO TODAY. ALL SCHEDULED MAINTENANCE WAS DONE BY THE MINI DEALER. TODAY LEAVING TO GO TO WORK, I STARTED THE CAR, PUT MY SEAT BELT ON, CHECKED THE MIRRORS, ROLLED DOWN THE WINDOWS, PUT THE CAR GEAR IN "D" AND STARTED MOVING FORWARD OUT A PARKING LOT, AND AFTER A FEW SECONDS WHILE DRIVING, THE CAR LOST ALL ACCELERATION AND CAME TO A STOP. THEN THE CAR WON'T REVERSE NOR MOVE FORWARD WHILE IN ANY GEAR. TOWED TO THE DEALER AND LATER WAS TOLD IT'S THE CVT TRANSMISSION AND IT WILL COST THOUSANDS OF DOLLARS TO REPLACE THE CVT TRANSMISSION. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING APPROXIMATELY 45 MPH, THE RPM READINGS INCREASED AS THE VEHICLE JERKED FORWARD ABNORMALLY. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

THERE IS A" LINE" CRACK IN THE WINDSHIELD STARTING IN THE MIDDLE OF THE WINDOW AND BEGINNING @ 4 INCHES FROM THE TOP OF THE WINDOW AND EXTENDING LEFT TOWARD THE DRIVER SIDE OF THE WINDSHIELD.. NO HEAD, OR ICE HAIL OR BODY HIT THE WINDOW, TO CAUSE THE BREAK.. *TR

CAR ACCIDENT CAUSE PROBLEMS , HAVING PROBLEMS WITH CLUTCH / FLYWHEEL WAS REPAIRED ONE TIME DRIVE SLOW WON'T MOVE FAST. NOT STEERING , HAS LEAKAGE , DAMAGE DENTS ON RIGHT SIDE FRONT END PAINT DAMAGES, NOT RIGHT COLOR. BACK BUMPER DAMAGE SCRATCHES , HATCHBACK LOCK NEEDS BE REPLACED. WHEELS DAMAGE LT RT . ABS SYMPTOM LIGHT ON, AIRBAG LIGHT ON, FRONT REAR HOOD LIGHT ON PROBLEMS NOT CLOSING. IN MOTION STREET .

CAR WAS PARKED IN DRIVEWAY WITH HAND BRAKE ENGAGED. 5 MINUTES LATER, THE CAR ROLLED DOWN DRIVEWAY AND HIT A DITCH. REAR SUSPENSION WAS DAMAGED. THE HAND BRAKE WAS STILL ENGAGED. *TR

THE SEAT SENSOR IS FAULTY. IT READS THAT SOMEONE UNDER 30LBS IS IN IT (DISABLING THE AIRBAG) THE DASH LIGHT VERIFIES IT IS OFF. THIS PROBLEM IS INTERMITTENT TO THIS DAY. SO IF A CRASH OCCURS THE SENSOR WON'T READ CORRECTLY IF ANYONE IS IN THE SEAT OR NOT, THE AIRBAG MAY NOT DEPLOY AND IF IT DOES WILL DO SO POSSIBLY WITH TOO MUCH FORCE. *TR

I HAVE HEARD FROM MORE THEN 3 DOZEN OTHER INDIVIDUALS OWNING BOTH THE MINI COOPER AND MINI COOPER S RANGING FROM YEARS 2006 TO 2010 THAT THERE HAVE BEEN PROBLEMS REGARDING THE AIR CV JOINT AXEL AND/OR POWER ARM CONTROL A CONSTANT PROBLEM REGARDING THE GENERAL MODULE ELECTRONIC COMPONENT. THIS ISN'T JUST A COINCIDENCE AND MAY END UP BEING THE CAUSE OF SERIOUS ACCIDENTS IF ONE OR TWO OF THESE COMPONENTS ARE DEFECTIVE. FOR THIS MANY CONSUMERS TO BE HAVING THE SAME ISSUES, SAME SOUNDS AND REVISITED VISITS TO MINI DEALER SHOPS AROUND THE GLOBE SOMETHING IS NOT RIGHT AND NEEDS TO BE INVESTIGATED. I KNOW FOR ONE THING THIS CONTROL ARM IS A HUGE PROBLEM IF IT FAILS CONSIDERING IT'S LOCATION COULD BE THE CAUSE OF MANY SERIOUS ACCIDENTS AND POSSIBLE DEATHS DEPENDING ON THE SPEED AND SEVERITY OF THE ACCIDENT WHEN IT TAKES PLACE. MY VEHICLE IS CURRENTLY NOT ON THE ROAD DUE TO THE SEVERITY OF THE NOISE AND REACTION TO THE VEHICLE WHEN BEING OPERATED AND IT IS A SCARY THING. THEY WANT TO CHARGE A ABSURD AMOUNT OF MONEY TO FIX SOMETHING THAT QUITE FRANKLY MAY HAVE BEEN SOMETHING RECALLED A LONG TIME AGO, AND WASN'T BECAUSE A LOT OF CONSUMERS ARE NOT AWARE OF THIS PROCESS SUCH AS MYSELF UNTIL RECENTLY WHEN AN ATTORNEY FRIEND OF MINE STARTED TO DIG AROUND A BIT AFTER HEARING MY STORY AND THE STORIES OF MANY OTHERS I HAVE SPOKEN TOO.