2006 MINI Cooper Owner Complaints

Electronic power steering pump issue/failure. The steering wheel was so stiff when I tried to go right that I physically could not turn the wheel. This is extremely dangerous & it happens without warning. No lights come on. You are left in a moving vehicle, without much of a way to control the direction you need it to travel in. From what I have learned, it seems an extended warranty was initially offered, & then a forced recall was issued on the, 1st Gen, 2002-2005 Mini Coopers. Only part of the vehicles with these issues were included in the recall. I have the same size 1.6 engine, & the exact same electronic power steering pump that comes with the issues & failures that I have in my 06. I have seen it on vehicles up to 08. This is absolutely unacceptable. This is a documented manufacturing defect & design flaw that has been continually allowed to endanger people’s lives. I am unsure how BMW managed to only recall part of the vehicles with these electronic power steering pump issues. I contacted BMW who told me there were no extended warranties or recalls on my vehicle.

NHTSA ID

11640971

Incident

Feb 5, 2025

The contact owns a 2006 Mini Cooper. The contact stated that while driving at various speeds, the steering wheel was significantly difficult to turn. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 139,000.

NHTSA ID

11563551

Incident

Dec 5, 2023

Mileage

139,000 mi

BMW issued a Recall 15V-205 Safety Recall, to cover the Airbag sensor in the passenger seat of my vehicle, a 2006 Mini Cooper S. The failure error was in the airbag sensor in the passenger seat, and the system warned of potential hazard with the passenger airbag. My car had a recall fix in 2018 for this fault. Now some 4 years later the same fault has arisen in the same sensor and system. I returned to BMW Mini who carried out the previous recall to have this fixed again. They said that while their repairs and parts generally carry an 8-year warranty, they do not warrant Recall repairs. They wanted over $2,000 to fix this issue. As this is a repeat of the original fault, and the car has under 100,000 miles I believe it should be covered, as their repair and or part has again failed. The date below is when I took it for the recall and was refused the warrenty repair.

NHTSA ID

11514006

Incident

Mar 18, 2023

Power Steering pump leaking failure

NHTSA ID

11493125

Incident

Nov 9, 2014

Blindsided Drive side impact car ignited I was cut from my car suffering emence Injuries due to the malfunction of the airbags . No air bags deployed.

NHTSA ID

11453963

Incident

Nov 5, 1984

It is very difficult to turn my steering wheel. It takes more energy than any other car I have ever driven

NHTSA ID

11436050

Incident

Jun 20, 2020

The electro-hydraulic power steering system stopped working on my 2005 Mini Cooper. The was a recall for 2002 to 2005 mini power steering pump failures but the problem continued thru 2011 because the fix that mini Cooper came up with was inadequate. The essentially put a band-aid on the problem and left car owners holding the bag. I, in fact, had the auxiliary pump that mini came up with replaced and the power steering problem continued because their fix was no good. I have an appointment with the Mini Cooper dealership to look at my car in about 2 weeks. They've told me that I'm not covered by the recall even though they ordered a recall of 86,000 cars for the problem in 2015. Not having power steering in any vehicle is very dangerous. The problem first occurred and remains after 2 years. The problem was reproduced by an independent repair service that I have used for years.

NHTSA ID

11423628

Incident

Jul 6, 2021

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT THE WHILE DRIVING APPROXIMATELY 50 MPH, THE POWER STEERING SUDDENLY MALFUNCTIONED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN IN EITHER DIRECTION. AFTER STOPPING THE VEHICLE, THE CONTACT NOTICED SMOKE BILLOWING FROM UNDER THE HOOD. AFTER OPENING THE HOOD, FLAMES WERE PRESENT COMING FROM THE ENGINE COMPARTMENT. THE NEIGHBOR ASSISTED IN EXTINGUISHING THE FLAMES. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER AND MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 186,000.

NHTSA ID

11363558

Incident

Oct 8, 2020

Mileage

186,000 mi

THE AIR CONDITIONING HAD STOPPED BLOWING COOL AIR. THEN WHEN I WAS PARKED, AND IDLED, MY POWER STEERING STOPPED WORKING WHILE TRYING TO BACK OUT. AFTER WRESTLING WITH THE WHEEL FOR A MINUTE TO GET OUT OF A PARKING LOT AREA, THE POWER STEERING CAME BACK ON. THE MECHANIC SAID ONE OF MY COOLANT FANS DOES NOT WORK. THIS MAY BE PART OF A RECALL THAT AFFECT 2005 MINIS WITH COOLANT FAN/POWER STEERING, HOWEVER MY CAR WAS MADE JUST A FEW MONTHS PAST THE RECALL.

NHTSA ID

11337932

Incident

Jun 1, 2020

Mileage

68,000 mi

AIR BAG SERVICE LIGHT ON. *TR

NHTSA ID

11330686

Incident

Feb 1, 2020

Mileage

187,900 mi

CAR ACCIDENT CAUSE PROBLEMS , HAVING PROBLEMS WITH CLUTCH / FLYWHEEL WAS REPAIRED ONE TIME DRIVE SLOW WON'T MOVE FAST. NOT STEERING , HAS LEAKAGE , DAMAGE DENTS ON RIGHT SIDE FRONT END PAINT DAMAGES, NOT RIGHT COLOR. BACK BUMPER DAMAGE SCRATCHES , HATCHBACK LOCK NEEDS BE REPLACED. WHEELS DAMAGE LT RT . ABS SYMPTOM LIGHT ON, AIRBAG LIGHT ON, FRONT REAR HOOD LIGHT ON PROBLEMS NOT CLOSING. IN MOTION STREET .

NHTSA ID

11269812

Incident

May 6, 2019

Mileage

141,342 mi

INTERMITTENT POWER STEERING FAILIURE DURING DRIVING, STIFF STEERING WHEEL CAN CAUSE A SERIOUS ACCIDENT

NHTSA ID

11254162

Incident

Sep 1, 2019

Mileage

119,500 mi

THE SEAT SENSOR FOR THE PASSENGER AIRBAG WAS REPLACED ONCE UNDER A RECALL. AFTER 2 YEARS, IT HAS FAILED AGAIN. THE DEALER STATED THAT THERE IS ONLY A TWO YEAR WARRANTY ON TEH PART. IT IS A SAFETY ISSUE THAT MAKES THE CARE UNSAFE AND UNUSABLE.

NHTSA ID

11218906

Incident

May 31, 2019

Mileage

170,000 mi

POWER STEERING PUMP PROBLEM FOR MINI COOPER R50 BOUGHT MY R50 PRE-OWNED 125000 KMS ON THE ODO FROM A DEALERSHIP(NOT A MINI DEALERSHIP) AS A PRESENT FOR MY DAUGHTER IN MARCH 2019. I ALREADY KNEW THERE WAS SOMETHING WRONG. OBSERVED A LEAK IN THE POWER STEERING RESERVOIR. DEALER SUPPOSEDLY FIXED THE PROBLEM BY REPLACING SOME HOSES. AFTER A MONTH, I TRIED STARTING THE CAR UP AND THE CAR WOULD NOT START. I WAS LUCKY TO STILL BE AT HOME THAT TIME. RECHARGED THE BATTERY AND STARTED THE CAR. TURNED THE ENGINE OFF AND NOTICED A SOUND. TRACED THE SOUND TO THE POWER STEERING PUMP NOT TURNING OFF EVEN IF THE ENGINE IS TURNED OFF. DISCONNECTED THE BATTERY SO IT WILL NOT DO A FULL DISCHARGE. BOUGHT IT BACK TO THE DEALERSHIP THAT I PURCHASED IT FROM AND THEY CONFIRMED THAT THE ISSUE WAS WITH THE PS PUMP. DID RESEARCH AND FOUND THAT THERE WAS A COMMON ISSUE RELATED TO THIS PUMP ALREADY AND BMW HAS OFFERED EXTENDED WARRANTY ON THE PUMP AND PERIPHERALS LIKE HOSES AND RESERVOIR COVERING 2003 TO 2005 MODELS DUE TO THE NUMBER OF COMPLAINTS AND POTENTIAL CATASTROPHIC ISSUES A FAILED PUMP CAN BRING. I ASKED THE LOCAL BMW SERVICE CENTER IF I COULD AVAIL BUT THEY SAID MY VIN WAS NOT PART OF THE COVERAGE. I NEEDED THE CAR TO WORK AND I WANTED IT DONE RIGHT SO I HAD THEM REPLACE THE PUMP. THIS COSTED ME 1500 CAD++ I BELIEVE THAT THIS SHOULD STILL BE COVERED BY THE EXTENDED WARRANTY BECAUSE THE SYMPTOMS ARE THE SAME AND THAT THE PUMP IS CONFIRMED TO BE AN ORIGINAL BY THE MINI SERVICE AND MAY VERY WELL STILL BE THE SAME ONE FROM THE PREVIOUS MODELS AND BMW SHOULD OWN UP TO THIS.

NHTSA ID

11207325

Incident

Apr 29, 2019

Mileage

78,603 mi

THE STEERING FEELS VERY STIFF. THIS IS MORE NOTICEABLE WHEN I START IN THE MORNING. IT IS EXTREMELY STIFF TO TURN.

NHTSA ID

11173616

Incident

Jan 15, 2019

Mileage

65,000 mi

TL* THE CONTACT OWNS A 2006 MINI COOPER. AFTER THE CONTACT PARKED THE VEHICLE, SHE WAS ALERTED TO THE ODOR OF SMOKE DURING THE NIGHT. THE CONTACT APPROACHED THE VEHICLE, QUICKLY DISCONNECTED THE BATTERY, AND ROLLED THE VEHICLE HALFWAY DOWN THE DRIVEWAY OUT OF THE GARAGE. THERE WAS A TREMENDOUS AMOUNT OF HEAT FROM THE ENGINE, BUT THE VEHICLE COOLED DOWN. THE FIRE DEPARTMENT WAS NOT CONTACTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THERE WAS AN ELECTRICAL FIRE FROM THE STEERING WHEEL PUMP AND MASSIVE REPAIRS WERE NEEDED, WHICH WOULD TOTAL APPROXIMATELY $3,500. THE MANUFACTURER WAS CALLED AND STATED THERE WAS NO RECALL ON THE VEHICLE. THE DEALER WAS NOT CONTACTED. THE INSURANCE COMPANY WAS CONTACTED. THE MANUFACTURER OFFERED TO COVER THE $500 DEDUCTIBLE FOR THE MECHANIC TO PERFORM THE REPAIRS THAT THE CONTACT WOULD HAVE TO PAY FOR IF THEY DECIDE NOT TO COVER THE CLAIM. THE FAILURE MILEAGE WAS 105,000.

NHTSA ID

11139623

Incident

Sep 26, 2018

Mileage

105,000 mi

GOOD MORNING, I HAVE A 2006 MINI COOPER AND THE POWER STEERING UNIT FAILED. I WAS DRIVING AND THE STEERING WHEEL BECAME VERY HEAVY (POWER STEERING FLUID WAS OK) THE UNIT JUST GAVE OUT. I READ THAT THE NHTSA ISSUED A RECALL FOR THE POWER STEERING UNIT FOR 2002 TO 2005 COOPERS RECALL 15V660000 (THE 2002 THRU 2006 ARE ALL FIRST GENERATION MODELS). MY QUESTION IS WHY WAS THE 2006 COOPER NOT INCLUDED SINCE IT IS ALSO FIRST GENERATION MODEL, AND IT IS THE SAME POWER STEERING UNIT USED FROM 2002 THRU 2006 ATLEAST ON THE BASE MODELS - NOT SURE ON THE COOPER S MODEL. COULD YOU PLEASE LET ME KNOW IF THIS IS SOMETHING THAT CAN BE ADDED TO THE RECALL SINCE IT AFFECTS MY CAR ALSO,, IT HAPPENED AT 110K MILES FOR ME, I DONT DRIVE TOO MUCH THUS THE LOW MILEAGE. THANK YOU SO MUCH.

NHTSA ID

11092178

Incident

May 1, 2018

Mileage

110,000 mi

2006 MINI COOPER. CONSUMER WRITES IN REGARDS TO PASSENGER FRONT SEAT OCCUPANT DETECTION MAT SENSOR FAILURE. *LD THE CONSUMER STATED THE VEHICLE EXPERIENCED A DETECTION MAT FAILURE. THE CONSUMER RECEIVED A RECALL NOTICE, BUT WAS IN ACCIDENT BEFORE IT COULD BE COMPLETED. THE AIR BAGS DID NOT DEPLOY. AS A RESULT OF THE FAILURE,THE CONSUMER RECEIVED A SKULL FRACTURE AND OTHER UPPER BODY DAMAGES. UPDATED 08/31/2017*JS

NHTSA ID

11019708

Incident

Mar 6, 2017

THE STREWING WHEEL GOT STUCK WHILE DRIVING ON A CITY STREET. IT IS VERY DIFFICULT TO TURN THE VEHICLE TO THE RIGHT, LEFT OR MAKE A U-TURN. WHILE RESEARCHING ONLINE, I DISCOVERED IT IS ON RECALL BUT THE NORTH AMERICA MINI COMPANY CUSTOMER SERVICE INFORMED ME TO CONTACT NATIONAL HIGHWAY INSTITUTION TO ASK FOR A RECALL LETTER TO BE ISSUED TO THE COMPANY.

NHTSA ID

11010223

Incident

Oct 15, 2016

TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING 70 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS TOWED TO NICK ALEXANDER MINI (6201 ALAMEDA ST, LOS ANGELES, CA 90001) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING PUMP, ALTERNATOR, AND RADIATOR COOLING FAN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 80,054.

NHTSA ID

11000470

Incident

Jun 17, 2017

Mileage

80,054 mi

TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING 20 MPH, THE AIR BAG INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS). THE APPROXIMATE FAILURE MILEAGE WAS 92,455.

NHTSA ID

10984242

Incident

May 6, 2017

Mileage

92,455 mi

I WAS PULLING OUT OF A PARKING SPOT AT A LOW SPEED THIS MORNING WHEN I LOST THE POWER STEERING IN MY 2006 MINI COOPER. THE STEERING WHEEL WAS VERY RIGID AND IT WAS HARD TO TURN. I TRIED TURNING MY VEHICLE OFF AND OFF AGAIN. I ALSO TRIED TURNING THE STEERING WHEEL TO LOOSEN IT UP. NOTHING HELPED THE ISSUE. I CONTINUED DRIVING FOR ANOTHER 30 MINUTES. AT A LOW SPEED MAKING SHARP TURNS WAS VERY HARD, IF NEARLY IMPOSSIBLE TO STAY IN MY LANE. IF SOMEONE WOULD HAVE BEEN IN THE OTHER LANE I WOULD HAVE BEEN IN AN ACCIDENT BECAUSE I COULD NOT MAKE THE TURN DUE TO THE LACK OF POWER STEERING WITH MY VEHICLE. THE STEERING WHEEL WAS VERY HARD TO TURN ALL THE WAY. EVEN AT HIGHER SPEEDS (30 TO 40 MPH) THE STEERING WHEEL WAS HARD TO TURN AND MAKE IT AROUND CURVES IN THE ROAD. STARTING FROM A DEAD STOP IT WAS VERY HARD TO TURN THE STEERING WHEEL TURNING LEFT OR RIGHT. I COULD BARELY PARK MY VEHICLE IN THE PARKING SPOT IN THE PARKING LOT BECAUSE THE STEERING WHEEL WAS SO HARD TO TURN MY VEHICLE AT SUCH A LOW SPEED. THIS IS THE THIRD TIME THE ISSUE HAS OCCURRED IN MY VEHICLE DURING THIS MONTH. BUT THE OTHER TIMES THE ISSUE HAS GONE AWAY AFTER RESTARTING THE VEHICLE TWICE. ONE TIME WAS TWO DAYS AGO IN THE MORNING. I WAS PULLING OUT OF A PARKING SPOT AND THE STEERING WHEEL WAS TIGHT AND HARD TO TURN. THE OTHER TIME WAS OVER A WEEK AGO AND THE VEHICLE WAS THIS TIME RESTARTING THE VEHICLE DID NOT FIX THE ISSUE.

NHTSA ID

10971858

Incident

Apr 11, 2017

Mileage

94,000 mi

I WAS A PASSENGER IN A MINI COOPER 2006, MY FRIEND WAS HIT HEAD ON BY A DRUNK DRIVER ON A CITY STREET. MY FRIEND'S MINI COOPER 2006 WAS TOTALED. THE AIRBAGS DID NOT DEPLOY AS A RESULT OF THE FRONT PASSENGER MAT SENSOR DEFECT. I SUFFERED MULTIPLE INJURIES TO MY CHEST, HANDS, ARMS, AND NECK THAT ARE VERY SERIOUS.

NHTSA ID

10970364

Incident

Sep 17, 2015

Mileage

57,988 mi

I REPLACED MY POWER STEERING PUMP FAN 2-3 YEARS AGO THEN ABOUT A YEAR AND A HALF AGO I HAD IT REPLACED UNDER WARRANTY. NOW MY POWER STEERING IS COMPLETELY GONE WITH NO PRIOR INDICATION THAT IT WAS FAILING AND I HAVE TO PAY A $1,400 TO GET IT REPLACED BY A CERTIFIED SHOP.

NHTSA ID

10928680

Incident

Nov 23, 2016

Mileage

111,000 mi

A EXTENDED WARRANTY WAS ISSUED FOR THE COOPER S R53 TILL 2005 MODEL YEAR .... THE R 53 WAS PRODUCED INTO THE 2006 MODEL YEAR FOR THE NORTHAMERICAN MARKET .... HAVE REPLACED TO PUMP ONCE AROUND 40-50 K ON THE CAR , OUT OF POCKET, AND PUMP HAS FAILED AGAIN AROUND 95K . THE WARRANTY ON MODELS TILL 2005 WAS EXTENDED TO 13 YEARS AND/OR 150K ..... WHY ARE THE FEW REMAINING MODELS OF THE 2006 RUNOFF NOT COVERED.. FIRST PUMP FAILED ON THE MY WASHINGTON AUTO ROAD..... NOT A GOOD PLACE TO SAY THE LEAST..... THE OTHER ON THE WASHINGTON, D.C. BELTWAY DURING THE AFTERNOON RUSH.... MANAGED TO KEEP SAFE BUT WAS NOT A GOOD SITUATION FOR ANYONE ... STEERING PUMP WOULD SURGE ON AND OFF-ROAD CAUSING INCONSISTENT POWER ASSIST IN TURNS WITH A EVENTUALLY NO ASSIST WAS MUCH MORE DRAMATIC THE FIRST TIME WAS ONLY SAVED BY RECOGNIZING THE PROBLEM AS IT OCCURRED THE SECOND TIME ... WHEN THE FIRST PUMP WAS REPLACED ALL LINES , COOLING FAN AND ITS DUCT WORK WERE REPLACED A WELL ......

NHTSA ID

10888667

Incident

Jul 15, 2016

Mileage

95,000 mi