RoadVitals

1997 New Flyer C40LF Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Apr 1, 2010
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1997 New Flyer C40LF, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Seat belts1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Seat belts

Reports naming seat belts, buckles, retractors and pretensioners.

1
report

From owner reports, verbatim

THIS IS IN REGARDS TO THE SHOULDER HARNESSES IN PIERCE TRANSIT BUSES, LAKEWOOD, WASHINGTON 98499. THE SHOULDER HARNESS IS A 2 PART SEAT BELT. DURING DRIVING CONDITIONS, THE SHOULDER HARNESS LOCKS UP RANDOMLY, AND PREVENTS THE SAFE OPERATION OF THE BUS. MANY BUS DRIVERS IN WASHINGTON STATE DO NOT WEAR THE SHOULDER HARNESS PART DUE TO THE INJURIES MANY DRIVERS HAS SUSTAINED WHEN WORN. USSC SEAT MANUFACTURER'S DEVELOP AND INSTALL THESE HARNESSES DIRECTLY ON THE SEATS. THERE ARE 4 MAJOR BUS COMPANIES WITH THESE SEATS AND THE SAME MALFUNCTIONS. THE COST TO REPAIR THEM IS MORE THAN THE COMPANIES WANT TO SPEND. THEREFORE BUSES WITH FAULTY EQUIPTMENT ARE ON THE ROAD DAILY. PASSENGERS AND FELLOW DRIVERS ARE AT SERIOUS RISK. POLICE AND WSP WILL NOT ENFORCE THE SEAT BELT LAW AND FORCE THE COMPANIES TO FIX THIS LETHAL PROBLEM. PLEASE INVESTIGATE AND FORCE COMPLIANCE UPON THE COMPANIES, AND THE MANUFACTURER.

NHTSA ID 10323371 · filed Apr 1, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .