2000 Nissan Frontier Suspension Problems

TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2000 NISSAN FRONTIER AT 45 MPH SHE HEARD A LOUD NOISE AT THE REAR OF THE VEHICLE. THE CONTACT WAS INFORMED THAT THE NOISE WAS DUE TO CORROSION OF THE BEARINGS. THE BEARINGS CORRODED BECAUSE OF INADEQUATE SEALING OF THE ANTILOCK BREAKING SYSTEM, WHICH CAUSED WATER AND MOISTURE TO REACH THE BEARINGS. THE DEALERSHIP REPAIRED THE LEFT SIDE AXLE ,AND INSTALLED BEARINGS. THE CONTACT STATED THERE WAS A RECALL FOR THE SAME PROBLEM. HOWEVER, WAS INFORMED BY THE DEALERSHIP THAT THIS VEHICLE WAS NOT APART OF THE RECALL. THE VEHICLE CURRENTLY HAD 63000 MILES. *AK UPDATED 03/19/07. *JB

NHTSA ID

10183629

Incident

Jul 1, 2006

Mileage

63,000 mi

REAR SHOCKS ON 2000 NISSAN FRONTIER RUSTED COMPLETELY OFF AT THE CONNECTION WITH THE FRAME WITHOUT ANY WARNING. HANDLING BECAME VERY UNSTABLE. FORTUNATELY OCCURRED AT LOW SPEED IN THE CITY AND VEHICLE REMAINED CONTROLLABLE. ON THE HIGHWAY, SITUATION WOULD HAVE BEEN MUCH WORSE. *JB

NHTSA ID

10154280

Incident

Jun 28, 2005

Mileage

19,000 mi

NOTICED THAT TRUCK HAD A LEAN TO THE PASSENGER SIDE. WHEN TAKING LEFT TURNS, TRUCK WOULD LIST AND LEAN EXCESSIVELY TO THE PASSENGER SIDE. THIS IS ESPECIALLY TROUBLESOME IN DOWNHILL TURNS OR UNDER ADVERSE WEATHER CONDITIONS. SOUGHT DEALER HELP MULTIPLE TIMES AS WELL AS NISSAN CONSUMER AFFAIRS. DEALER ADJUSTED RIDE HEIGHT, SAID THESE TRUCKS HAD A TORSION BAR ISSUE, NOTHING ELSE THEY COULD O. CONSUMER AFFAIRS DID NOTHING BUT REFER ME TO ANOTHER DEALER, SAME RESULT. A LETTER TO THE PRESIDENT OF THE COMPANY PRODUCED A LETTER BACK TELLING ME TO GO TO CONTACT CONSUMER AFFAIRS. TRUCK HAS ALSO BROKEN STABILIZER NUTS SEVERAL TIMES. TOOK VEHICLE TO AN ALIGNMENT AN SUSPENSION EXPERT, SAID THE TRUCK RIDE HEIGHT CANNOT BE ADJUSTER UP TO FACTORY SPECS, AND MAINTAIN ALIGNMENT. HE HAD TO LOWER THE VEHICLE TO ALLOW IT TO BE ALIGNED PROPERLY. IT IS MY GUESS THAT THERE IS A DESIGN ISSUE OR PART FAILURE. I BELIEVE NISSAN KNOWS THIS, AND LOWERED THE RIDE HEIGHT THEMSELVES TO ALLOW ALIGNMENT AT THE FACTORY, SACRIFICING BALANCE, DRIVEABILITY AND SAFETY. I NOTICE MOST MODELS OF THIS TRUCK HAVE THE SAME TILT TO THE PASSENGER SIDE. *JB

NHTSA ID

10144722

Incident

Mar 4, 2001

AT APPROX. 20,000 MILES VEHICLE STARTED TO MAKE A RATTLING/BUMPING NOISE IN LEFT FRONT. TOOK IT TO DEALER WHO SAID THIS WAS A COMMON PROBLEM WITH 2000 NISSIAN'S AND WOUILD BE REPLACED ONLY WHEN CONSUMER COMPLAINED. DEALER REPLACED LEFT STABILZER BUSHING AND REFUSED TO GIVE A COPY OF W/O SAYING IT "WAS RECORDED IN COMPUTER." AT APROX. 45,000 MILES LEFT STABILIZER BUSHING FAILED AGAIN AND WAS REPLACED BY MECHANIC WHO AGAIN STATED THAT THIS WAS A PROBLEM WITH NISSIAN. AT 67,000 MILES BOTH STABILIZER BUSHINGS HAVE FAILED AND NEED TO BE REPLACED. HAD VEHICLE CHECKED BY THIRD MECHANIC WHO REAFFIRMED THAT STABILIZER BUSHINGS ON NISSAN'S DID NOT HOLD UP WELL.*AK

NHTSA ID

10068144

Incident

Feb 15, 2004

Mileage

22,000 mi

THERE WAS A POPPING NOISE WHEN THE VEHICLE WAS TURNED OR GOING OVER A BUMP, THE DEALER DETERMINED A BOLT WHICH HELD THE SWAY BAR ASSEMBLY HAD COME OUT. ONE YEAR LATER THE BOLT ON THE OTHER SIDE CAME OUT. *JB

NHTSA ID

10010039

Incident

Mar 15, 2002

Mileage

32,000 mi

CONSUMER STATES THAT THE VEHICLE FAILED ITS MISSOURI STATE INSPECTION DUE TO THE BROKEN FRONT SWAY BAR STABILIZER CONNECTING ROD, NISSAN CHANGED THE DESIGN BY INCREASING THE DIAMETER OF THE BOLT AND INCREASING THE HARDNESS FROM A 5 TO AN 8, YET DENIED ANY PROBLEM TO THE CONSUMER. *SLC

NHTSA ID

567309

Incident

Jul 1, 2002

CONSUMER STATED DURING A STATE INSPECTION, A BOLT ON THE SWAY BAR WAS FOUND TO BE BROKEN, THE DEALER REPLACED THE STABILIZER CONNECTING ROD AND BUSHING.*JB

NHTSA ID

567308

Incident

Aug 8, 2002

WE OWN TWO 2000 FRONTIERS, AN BOTH TRUCKS HAVE THE BROKEN SWAY BAR SUSPENSION BOLTS. SINCE THE ORIGINAL PRODUCTION BOTS WERE USED NISSIAN HAS INCRESED THE REPLACEMENT BOLT IN DIAMETER AND FROM A #5 HARDNESS TO A # 8 HARDNESS BOLT. THE PROBLEM IS THEY ONLY REPLACE THE FAILED BOLT THAT FAILS IF IT IS IN WARRANTY. IN BOTH 2000 TRUCKS WE OWN THE LEFT FRON BOLTS HAVE FAILED WITH AFFECT SWAY CONTROL OF THE TRUCKS NISSAN CLAIMS THEE IS NOT A PROBLEM, BUT THE LOU FUSZ NISSAN DEALERSHIP IN ST. LOUIS ADMITTED THAT THE STOCK THE BOLTS BECAUSE THEY HAVE SUCH A HIGH FAILURE RATE WITH TE TRUCKS THAT ARE COMING INTO THEIR DEALERSHIP. PERHPS IT'S TIME TO FIND OUT HOW MANY TRUCKS ARE OUT THERE WITH BROKEN SUSPENSION SYSTEMS. THE FIRST FAILED TRUCK WAS DICOVERED BY AN ALERT SERVICE INSPECTION TECH WERE WE SERVICE OUR VEHICLES. THIS SEEMS TO BE A BIGGER PROBLEM THAN NISSAN IS WILLING TO ACKNOWLEDGE.*AK

NHTSA ID

765597

CONSUMER IS UNABLE TO BALANCE ALL TIRES, TRUCK BOUNCES.*AK CONSUMER STATES AFTER SOME WORK DONE ON THE TIRES, THEY WERE BOUNCY AND ROUGH RIDING, THE DISTRICT REPRESENTATIVE FOR MICHELIN TIRES INFORMED CONSUMER THAT HE DID NOT HAVE MICHELIN TIRES ON HIS VEHICLE-THAT THEY WERE AN INFERIOR TIRE MADE FOR CERTAIN DISCOUNT STORES, MICHELIN X RADIAL PLUS ALL SEASON XSE, SIZE P215/15R15. *YD

NHTSA ID

8007044

Incident

Oct 10, 2000

WHILE DRIVING 55-60 MPH VEHICLE FLIPPED AND WAS TOTALED. CONSUMER SUFFERED MINOR INJURIES.*AK

NHTSA ID

8002207

FRONTEND POPS AT LOW SPEEDS WHEN TURNING STEERING WHEEL TO THE RIGHT AND MAKES A CLICKING NOISE.CLICKING NOISE COMES FROM LEFT FRONT TIRE POPING AND SQUEAKING NOISE SEEMS TO COME FROM RIGHT FRONT TIRE.*AK

NHTSA ID

756559

THE TRUCK IS UNSAFE TO DRIVE AS THE BACK END "FISHTAILS" AFTER ANY BUMP IS A CURVE. THE DEALER DOES NOT HAVE THE PARTS TO FIX. *AK

NHTSA ID

755401

Incident

Dec 3, 2001

REPEATED DEFECT WITH SWAY BACK BUSHING IN NORMAL DRIVING CONDITIONS. DRIVING IN NORMAL CONDITIONS, AREA MOSTLY DRIVING FROM 4-8 MILES PER DAY.*AK

NHTSA ID

747238

Incident

Sep 1, 2000

VEHICLE IS PULLING TO RIGHT WHEN DRIVING AT ANY SPEED. DEALER CANNOT REMEDY PROBLEM. CONSUMER CONTACTED A FIRESTONE DEALER TO HAVE WHEEL ALIGNMENT DONE, THINKING TIRES WERE AT FAULT. MECHANIC STATED FRONT RIGHT CASTER CANNOT BE ADJUSTED.*AK CONSUMER STATED SEAT RATTLED. WINDOW MOLDING WAS REPLACED. PASSENGER SIDE AIR BAG WARPED, DEALER REPLACED AIR BAG MODULE. *SLC

NHTSA ID

890893

Incident

Apr 1, 2001

WHEN TURNING STEERING WILL GO ALL THE WAY TO THE RIGHT. STEERING WILL NOT AUTOMATICALLY CORRECT ITSELF, AND IS CAPABLE OF STAYING IN THAT POSITION TO MAKE A CIRCLE. DEALERSHIP HAS PROVIDED NO ASSISTANCE TO CONSUMER FOR THIS PROBLEM.*AK CONSUMER STATES THE POWER GEAR ASSEMBLY HAS BEEN REPLACED, THE FRONT END WAS ALIGNED TWICE, CONSUMER WAS TOLD THAT PROBLEM COULD NOT BE CORRECTED.*JB

NHTSA ID

888767

Incident

Aug 1, 1999

SINCE OWNERSHIP OF VEHICLE CONSUMER STATES HE FELT THERE WAS SOMETHING WRONG WITH STEERING WHEEL, AS HE WAS DRIVING HOME HE LET THE STEERING WHEEL GO AND SUDDENLY THE VEHICLE WAS PULLING TO THE RIGHT ALMOST CAUSING AN ACCIDENT, CONSUMER TOOK VEHICLE INTO DEALERSHIP TO BE INSPECTED AND DROPPED IT OFF WHEN HE RETURNED TO PICK VEHICLE UP AND DROVE AWAY CONSUMER STATES HE ALMOST HIT A CURB SO VEHICLE WAS RETURNED AND CONSUMER WAITED FOR VEHICLE AND WAS TOLD BY DEALERSHIP THEY COULD NOT FIND THE PROBLEM, CONSUMER REQUESTED THAT MECHANIC TAKE A TEST DRIVE WITH HIM, MECHANIC DID SEE WHAT IT WAS AND TOLD CONSUMER THAT WAS NORMAL, HOWEVER DEALERSHIP DID PERFORM A WHEEL ALIGNMENT AND 2 WEEKS LATER THE VEHICLE WAS PULLING AGAIN, CONSUMER TOOK VEHICLE TO ANOTHER DEALERSHIP AND ANOTHER WHEEL ALIGNMENT WAS PERFORMED, CONSUMER ALSO STATES DRIVESHAFT HAS RUSTED. *JB

NHTSA ID

561216

Incident

Mar 27, 2001

THE VEHICLE HAS GONE DOWN IN HEIGHT FROM 2 TO 3 INCHES OVERALL, THE VEHICLE HAS BEEN ALIGNED 3 TIMES AND THE TIRES HAVE BEEN BALANCED, THE VEHICLE IS STILL OUT OF ALIGNMENT CAUSING THE TRUCK TO SHAKE, RATTLE AND VIBRATE. NLM

NHTSA ID

785415

Incident

Oct 1, 2000

BOLT WHICH HOLDS FRONT END BUSHING HAS SHEARED IN HALF. DEALER NOTIFIED AND UNWILLING TO COMMENT ON THIS PROBLEM. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK

NHTSA ID

881876

Incident

Feb 23, 2001

CONSUMER HAS EXPERIENCED EXTREME WEAR ON TIRES AT ONLY 139 MILES ON 2 FRONT GENERAL TIRES, THE TIRES WERE REPLACED AND AGAIN AT ONLY 962 MILES THE TIRES STARTED WEARING AGAIN, THE CONSUMER HAS CONTACTED OTHER FRONTIER OWNERS WITH DIFFERENT TIRE MAKES/MODELS WITH THE SAME WEAR PROBLEM ON THEIR TIRES. *SLC

NHTSA ID

558417

TRUCK SQUEKS LOUD ON RT SIDE, LOUD THUNKING NOISE WHILE SLOWING DOWN AND TURNING, SHIVERS WITH THE NOISE, VERY APPARENT SUDDEN MOVEMENT UNDER PASS SIDE (LIKE SEAT IS GOING TO FALL OUT FROM UNDER YOU). *AK

NHTSA ID

735313

Incident

Sep 24, 2000

DUE TO MISALIGNMENT VEHICLE MOVED FROM SIDE TO SIDE WHICH CAUSED MORE WEAR AND TEAR ON THE TIRES. *AK

NHTSA ID

871648

Incident

Apr 18, 2000

REAR SUSPENSION TO SOFT, VEHICLE REACTS WITH BODY SWAY TO WIND TURBULENCE AROUND 60 MPH, SIDE WIND, SIDE AROUND SEMI-TRUCKS. FEELS LIKE TIRE BAD TIRE DRIFT, DEALER ROTATED TIRES, NO-HELP. BODY SWAY BAD ENOUGH IT'S SCARY TO DRIVE SOMETIMES, WIFE WON'T ON EXPRESSWAY. THERE HAS TO BE A FIX. *AK

NHTSA ID

724454