1998 Oldsmobile Intrigue

GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.

GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.

The engine had a fire and the ignition switch is very hard Do turn, it would be available for inspection. The fire happen while driving down the highway. I have an appointment set with dealership. No prior inspections have been made and no indications of anything.

NHTSA ID

11571241

Incident

Dec 15, 2023

JULY 17TH 2019 ENGINE DIES WHILE DRIVING AT HIGH SPEED WITHOUT WARNING. REPLACED CRANK SHAFT SENSOR. DIED IN MOTION AGAIN JULY 24TH, REPLACED ALTERNATOR. THIS SAME PROBLEM ORIGINALLY HAPPENED IN SEPT OF 2011, AGAIN IN MARCH OF 2015, AND MARCH OF 2017. DIFFERENT REPAIR SHOPS HAVE REPLACED MANY DIFFERENT PARTS ATTEMPTING TO FIX THIS OVER THE YEARS. IT IS EXTREMELY DANGEROUS WHEN THE CAR LOSES ALL POWER WHILE TRAVELING 65 MILES AN HOUR IN HEAVY TRAFFIC.

NHTSA ID

11241222

Incident

Jul 19, 2019

Mileage

121,682 mi

MY SON WAS DRIVING THE CAR AND IT STARTED MAKING A NOISE AND I PULLED OVER AND CHECKED AND DIDN'T SEE ANYTHING AND CONTINUED DRIVING. I NOTICED SMOKE COMING FROM UNDER THE HOOD AND PULLED INTO A GAS STATION AND NOTICED THE CAR WAS ON FIRE AND RAN INTO THE GAS STATION AND ASKED FOR A FIRE EXTINGUISHER. THE ATTENDANT HAD ONE AND WENT AND PUT THE FIRE. I HAVE CONTACTED GM AND WAS TOLD THIS WAS DUE TO A RECALL WHICH CAUSED OIL TO LEAK ONTO THE MANIFOLD AND THUS FAR THEY HAVE BEEN UNABLE OR UNWILLING TO HELP WITH THIS ISSUE. *JS - (RECALL RELATED INCIDENT) TS

NHTSA ID

11076564

Incident

Feb 28, 2018

Mileage

170,000 mi

VEHICLE CAN NO LONGER TURN TO THE LEFT OR RIGHT. I DON'T THINK RECALL 03052 WAS EVER DONE ON IT. CAN NO LONGER DRIVE THIS CAR BECAUSE IT'S UNSAFE FOR ME AS WELL AS THE PUBLIC.

NHTSA ID

11030251

Incident

Sep 25, 2017

Mileage

273,000 mi

TL* THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. THE CONTACT STATED THAT THE REAR DRIVER SIDE LOWER CONTROL ARM BRACKET FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR DRIVER SIDE LOWER CONTROL ARM BRACKET NEEDED TO BE REPLACED BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10923768

Incident

Nov 1, 2016

Mileage

150,000 mi

TL* THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. THE CONTACT STATED THAT THE WINDSHIELD WIPERS STOPPED WORKING WHILE DRIVING APPROXIMATELY 55 MPH IN THE RAIN. THE FAILURE OCCURRED THREE OTHER TIMES AND, SOMETIMES, THE WIPERS WOULD REMAIN IN THE UP POSITION AND WOULD NOT MOVE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED TWICE FOR THE SAME FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED AGAIN. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 01/11/2017*CT *TR

NHTSA ID

10914244

Incident

Sep 6, 2016

Mileage

70,000 mi

TL* THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. THE CONTACT STATED THAT THE ENGINE CAUGHT FIRE INDEPENDENTLY. THE CONTACT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES AND A FIRE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V116000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE. UPDATED 11/08/16*LJ

NHTSA ID

10907123

Incident

Nov 17, 2009

Mileage

148,000 mi

I HAVE CALLED MULTIPLE GM DEALERSHIPS IN ORDER TO GET MY IGNITION RECALL, OIL LEAK FROM VALVE COVER RECALL, AND REAR SEATBELT RECALLS TAKEN CARE OF AND SO FAR NONE HAVE RETURNED MY PHONE CALLS REGARDING THE ISSUES. I HAVE HAD THE APPOINTMENTS SET FOR AT LEAST 6 MONTHS AT 2 DIFFERENT DEALERSHIPS AND HAVE YET TO HEAR BACK ON ANY PARTS ARRIVING. THEY TOLD ME OVER THE PHONE AT BOTH DEALERS THAT IT WOULD TAKE A WEEK AND A HALF FOR PARTS TO ARRIVE AND THAT THEY WOULD RETURN MY CALL WHEN PARTS DID ARRIVE, BUT I HAVE YET TO HEAR ANYTHING.

NHTSA ID

10904582

Incident

Sep 7, 2016

Mileage

136,000 mi

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.