RoadVitals

2015 Peterbilt 579

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Apr 15, 2021
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
9
Latest Apr 6, 2020
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
2

Overview

Our database contains 4 NHTSA owner-reported complaints for the 2015 Peterbilt 579, most frequently naming the electrical, engine and fuel system categories. 9 safety recalls have been issued covering this model year; 1 NHTSA investigation names it; and 64 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Electrical120.0%
  • Engine120.0%
  • Fuel system120.0%
  • Powertrain (other)120.0%
  • Suspension120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

9 campaigns cover this model year

View all 9

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
20V199000

ELECTRONIC STABILITY CONTROL (ESC); SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT

Apr 6, 2020
460,515 units potentially affected
The defect: PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."
The risk: If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.
The remedy: PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB.
PACCAR IncorporatedManufacturer number 20pbc AND 20KWBView on NHTSA.gov
20V130000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Mar 4, 2020
35,671 units potentially affected
The defect: PACCAR Incorporated (PACCAR) is recalling certain 2015-2020 Peterbilt 365, 389, 567, and 579 vehicles equipped with a left-hand under hood jumper terminal (option code 2539410). The positive battery jumper terminal cable may be too long, allowing it to chafe against the left front suspension spring and result in an electrical short circuit.
The risk: An electrical short circuit can increase the risk of a fire.
The remedy: PACCAR will notify owners, and dealers will inspect the battery jumper terminal cables, and replace them as necessary, free of charge. The recall began April 30, 2020. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's number for this recall is 20PBA.
PACCAR IncorporatedManufacturer number 20PBAView on NHTSA.gov
18V816000

EXTERIOR LIGHTING

Nov 16, 2018
1,619 units potentially affected
The defect: PACCAR Incorporated (PACCAR) is recalling certain 2013-2019 Kenworth T680 and T880 and Peterbilt 579 trucks, greater than 30 feet long and equipped with side extender mounted intermediate marker lamp/turn signals that do not include a reflex reflector. Since both intermediate side marker lamps and reflex reflectors are required, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
The risk: Missing reflex reflectors can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
The remedy: PACCAR will notify owners and dealers will install reflex reflective tape, free of charge. The recall began January 15, 2019. Owners may contact PACCAR customer service at 1-918-259-3258. PACCAR's number for this recall is 18KWF, and 18PBC.
PACCAR IncorporatedManufacturer number 18KWF & 18PBCView on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

PE20006ClosedPreliminary Evaluation

Intermittent Loss of Power Steering Assist

Opened May 1, 2020
Closed Mar 27, 2024

On May 1, 2020, the Office of Defects Investigation (ODI) opened PE20006 to investigate complaints of intermittent loss of power steering assist in Daimler Truck North America (DTNA), Volvo Trucks of North America (Volvo) and PACCAR vehicles equipped with a ZF/TRW (TRW) THP60 steering gear.  The investigation focused on 2010-2020 DTNA Freightliner Cascadia, M2 and WST; Volvo VN, VAH and VHD and PACCAR 337, 365, 389, 567, 579 model vehicles.Field reports and interviews with fleet drivers allege that high power steering fluid temperatures could result in internal seal and bearing failures causing pressure fluctuation, affecting left and right-hand turns.  The inability of the driver to steer the vehicle as intended can increase the risk of a crash and injury. ODI analyzed data provided by TRW, DTNA, Volvo, and PACCAR in response to individual information request letters.ODI found that most failures occurred within the first two years and/or 50,000 miles of service.  The claim rate decreased with time and miles in service and remained less than 0.5%. ODI normalized data from each of the manufacturers and determined that there was not a substantial difference in the failures.Additionally, TRW improved a seal in the steering gear in December 2015.Trucks built on or after 2016 (as 2017 and newer model years) show a decreasing trend of failures. In view of the overall low failure rate, the nature of early-life failure, and failure rate trending downward for model years 2017 and newer, this Preliminary Evaluation (PE) is closed.  The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Filed Apr 15, 2021
Fire reported

WE PURCHASED THIS TRUCK ON 4/09/21 AND ON 4/13/21 WHILE IT WAS PARKED AT THE YARD IT CUT ON FIRE BY ITSELF, NO EXTERNAL CAUSE OTHER THAN SOMETHING WRONG WITH THE TRUCK THAT WE WERE NOT TOLD OR AWARE. IT LOOKS LIKE IT COULD BE SOME DEFECTIVE PARTS FROM MANUFACTURE THAT HAVE 3 RECALLS THAT CAUSE FIRE. I WOULD LIKE TO CONDUCT AN INVESTIGATION AND FIND OUT THE OFFICIAL CAUSE. WE LOST OUR RETIREMENT FUNDS AND NOW NOBODY WANTS TO BE RESPONSABLE FOR. A WITNESS RECORDED A VIDEO AND YOU CAN CLEARLY SEE WHERE THE FIRE WAS COMING

NHTSA ID
11408294
Incident
Apr 13, 2021
ElectricalEngineFuel system
Filed Oct 19, 2017

DRIVER WAS DRIVING AND TRUCK JUST SHUT OFF, FORCING HIM TO SIDE OF ROAD, HAD TO GET TOWED DUE TO FACT THAT COULD NOT REPAIR. AT DEALER I AM TOLD FUEL PUMP LEAKED INTO ELECTRICAL HARNESS AND ECM. CAUSING TRUCK TO SHUT DOWN AND NOT START.

NHTSA ID
11034567
Incident
Oct 17, 2017
Mileage
273,465 mi
Powertrain (other)
Filed Mar 4, 2016

LEAKING FITTINGS ON TRANSMISSION COOLER CAUSED FLUID TO RUN OUT AND SEIZED TRANSMISSION, WHILE DRIVER WAS IN MOTION ON HIGHWAY, DUE TO BAD INSTALLATION AT FACTORY. UPON INSPECTION FOUND 3 OUT OF 5 TRUCKS WITH SAME PROBLEM. WARRANTY COVERAGE WAS DENIED BY EATON AND PETERBILT CLAIMING DRIVER ERROR.

NHTSA ID
10839909
Incident
Dec 12, 2015
Mileage
60,000 mi
Suspension
Filed Feb 20, 2015
Fire reported

TL* THE CONTACT OWNS A 2015 PETERBILT 579. WHILE DRIVING 55 MPH, THE DRIVER NOTICED SMOKE COMING FROM THE PASSENGER SIDE OF THE VEHICLE. UPON FURTHER INSPECTION, THE DRIVER NOTICED THAT THE FRONT PASSENGER SIDE AXLE WAS ON FIRE. THE DRIVER WAS ABLE TO EXTINGUISH THE FIRE. IN ADDITION, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. THE CONTACT DID NOT DISCLOSE IF A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE FAILURE RECURRED AND BOTH FRONT AXLES CAUGHT FIRE. THE FIRE WAS EXTINGUISHED. THE VEHICLE WAS TOWED AGAIN TO A DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 43,000.

NHTSA ID
10689686
Incident
Nov 26, 2014
Mileage
43,000 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

02-177

ELECTRICAL SYSTEM

Troubleshooting procedures for 2.1m cab power windows are now available.

32-025

ENGINE

Info Only Unnecessary starter replacements can result from customer complaints regarding engine starting issues. A new Starter Troubleshooting Guide has been created to provide a comprehensive list of starting system checks, which should reduce unnecessary starter replacements and associated warranty claims. Engine starting system warranty claims now require a completed Starter Checklist, a Battery Pack Midtronics Report, and a Cable Drop Midtronics Report. Claims filed without these documents may be denied.

28-001

ELECTRICAL SYSTEM

For all Peterbilt chassis equipped with an air shifted PTO. Oil from the air shift cover of the PTO may leak into the air line, causing the EOA solenoid to become inoperative.

01-079

ENGINE AND ENGINE COOLING; VISIBILITY; VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Fix-as-Fail - HVAC Intermittently Stops Blowing Cold Air

14-043

SUSPENSION

Fix-As-Fail On certain chassis with Low Air Leaf Suspension or Low-Low Air Leaf Suspension, the Height Control Valve (HCV) arm may be rubbing on other components when the bend in the arm is facing outboard. Flipping the bend in the HCV arm inboard prevents the rub.

13-060

SERVICE BRAKES

The service information for Bendix Air Dryer maintenance is being updated to include new procedures.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Peterbilt 579 by model year
YearComplaintsRecallsInvestigationsIssue Index
2027020—
2026120—
2025070—
2024370—
20233110—
20226150—
2021190—
2020460—
2019282—
20187142—
20173133—
20163111—
2015Viewing491—
20142121—
20131131—
2012061—
2011040—
2010030—
2009020—
2008020—
2007010—
2006010—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.