RoadVitals

2012 Peterbilt 587 Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Feb 19, 2025
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
2
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Apr 11, 2013

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2012 Peterbilt 587. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

EngineFuel system
Filed Feb 19, 2025

The contact owns a 2012 Peterbilt 587. The contact stated while driving 65 MPH, the vehicle stalled. The contact was unaware of a warning light being illuminated. The contact pulled over to the side of the road where the vehicle failed to restart. The vehicle was towed to West Truck Services Center, where it was diagnosed and determined that the fuel pump had failed. The vehicle was then towed to the dealer, where it was diagnosed that the fuel pump plungers had fractured and intruded the engine. Additionally, the dealer informed the contact that there were metal shavings inside the oil filter. The dealer determined that the fuel pump and engine rod bearings needed to be replaced. The vehicle was being repaired. The contact related the failure to TSB Number: 140019. The manufacturer was notified of the failure and a claim was filed; however, the claim was denied. The failure mileage was 468,742.

NHTSA ID
11643608
Incident
Jul 26, 2024
Mileage
468,742 mi
Electrical
Filed Apr 22, 2013
Fire reported

2012 PETERBILT TRACTOR. CONSUMER WRITES IN REGARDS TO POTENTIAL FIRE DEFECT. *SMD THE CONSUMER STATED HE RECENTLY INVESTIGATED THE CAUSE OF A FIRE IN THE TRACTOR AND DETERMINED THE CAUSE TO BE RELATED TO A POTENTIAL DEFECT IN THE MANNER IN WHICH THE BATTERY CABLES WERE SUPPORTED. THE BATTERY CABLES PASSED FROM THE BATTERY BOX ON THE DRIVER SIDE OF THE TRACTOR, AT A POSITION BEHIND THE CAB, TO THE ENGINE COMPARTMENT. AT THE LOCATION WHERE THE BATTERY CABLES PASSED THE ELECTRONIC CLUTCH ACTUATOR, THEY WERE HELD IN PLACE BY A PLASTIC TIE. DUE TO DRIVE TRAIN VIBRATION AND MOVEMENT, THE PLASTIC TIE USED TO SECURE THE BATTERY CABLES TO THE CLUTCH ACTUATOR SHIELD WERE PRONE TO FAILURE. THE PLASTIC TIE BROKE AT SOME TIME DURING ITS SERVICE LIFE AND THE WEIGHT OF THE BATTERY CABLES CAUSED THEM TO MIGRATE TOWARD THE BOTTOM OF THE CLUTCH ACTUATOR SHIELD. MOVEMENT BETWEEN THE UNSECURED CABLES AND THE SHIELD, WHICH OCCURRED OVER TIME, ABRADED THE INSULATION OF ONE OF THE POSITIVE CABLES. ONCE THE ELECTRICAL INSULATION FAILED, THE CABLE ARCED AGAINST THE SHIELD, ENERGIZING THE ENGINE AND TRANSMISSION. UPDATED 7/1/13 ...UPDATED 10-24-13 *BF

NHTSA ID
10509048
Incident
Apr 1, 2013
Electrical
Filed Apr 11, 2013
Fire reported

TL* THE CONTACT OWNS A 2012 PETERBILT 587. THE CONTACT STATED THAT HE NOTICED SMOKE COMING FROM THE UNDERCARRIAGE. THE CONTACT EXITED THE VEHICLE AND DISCOVERED THERE WAS A FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. AFTER FURTHER INSPECTION, IT WAS DETERMINED THAT THE BATTERY CABLE HAD IGNITED. THE CABLES WERE ATTACHED TO THE ELECTRONIC CLUTCH ACTUATOR, WHICH HAD A PLASTIC COVER. THE PLASTIC TIE FRACTURED AND CAUSED THE BATTERY CABLES TO FAIL, ENERGIZING THE TRANSMISSION AND ENGINE BLOCK. THE HIGH HEAT CAUSED IT TO BECOME COMBUSTIBLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN BECAUSE OF THE FIRE DAMAGE. *TR UPDATED 7/2/13 *CN THE CONSUMER STATED DUE TO THE VIBRATION AND MOVEMENT, THE PLASTIC TIE USED TO SECURE THE BATTERY CABLES TO THE CLUTCH ACTUATOR SHEILD IS PRONE TO FAILURE. UPDATED 11/1/2013 *JS

NHTSA ID
10505965
Incident
Feb 4, 2013

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .