2007 Pontiac G6

On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.

The contact owns a Safety 1st Car Seat, Model Type: Grow & Go, Model Number: CC413-GYU, Manufactured Date: 01/29/2025. The contact stated that the car seat was installed in a 2007 Pontiac G6. The contact stated that the headrest pad had detached, and the foam in the car seat head rest was exposed. The manufacturer was not made aware of the failure. The car seat was not replaced.

NHTSA ID

11746029

Incident

Jun 15, 2026

My 2007 Pontiac G6 GT 3.9 l convertible has the same issue that a lot of the other g6s had with the Passenger Airbag Sensor (NHTSA 07V-146).

NHTSA ID

11735256

Incident

Sep 25, 2025

When driving the vehicle on the highway the vehicles steering wheel started shaking lightly and then all of a sudden the steering got hard and locked up the power steering and it also put a message on the stereo display saying “power steering”. I was able to pull aside of the highway and turn the car off and then back on. That seemed to reset it but the steering wheel kept shaking on its own. I drove it to the nearest car mechanic and explained the problem. I was told it’s very common on the Pontiac G6 and that there is a recall for this issue. Now unfortunately when we look up the car by VIN it says it doesn’t have a recall but the mechanic and myself have done research and there’s a notice about the Pontiac G6 have this exact same issue about the power steering. The problem is very concerning and is also very consistent as it does not go away unless a specific part is replaced which has been inspected and confirmed to be the exact part that is listed on the recall notice. Part #23232310.

NHTSA ID

11734190

Incident

Apr 20, 2026

The contact owns a 2007 Pontiac G6. The contact stated that while driving at an undisclosed speed, the steering wheel seized, with the air bag warning light and check engine warning light illuminated. The contact stated that the steering wheel became difficult to turn, and the vehicle was nearly involved in a T-bone crash. The contact forcefully turned the steering wheel to regain control of the vehicle. The vehicle was taken to the dealer; however, it was neither diagnosed nor repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 251,000.

NHTSA ID

11731908

Incident

Apr 17, 2026

Mileage

251,000 mi

The contact owns a 2007 Pontiac G6. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle, and the vehicle became difficult to maneuver. No warning lights were illuminated. The failure had occurred on several occasions. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the joint bearing was inoperable and that the steering assembly needed to be replaced. The contact researched and became aware of an unknown recall; however, the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 180,000.

NHTSA ID

11726331

Incident

Mar 23, 2021

Mileage

180,000 mi

The contact owns a 2007 Pontiac G6. The contact stated that while driving at undisclosed speeds, there was a gasoline odor coming from the vehicle. The odor was also outside the vehicle. The contact became aware of a fluid leak underneath the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, and a fuel leak was confirmed. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 13E043000 (Fuel System, Gasoline, Equipment). The manufacturer was notified of the failure and informed the contact that parts were not purchased from the manufacturer, so the VIN was not included in the recall. The failure mileage was unavailable.

NHTSA ID

11724789

Incident

Apr 9, 2025

POWER STEERING FAILURE. BY LOSING POWER STEERING IT PUTS ME AND OTHERS AT RISK BECAUSE THE VEHICLE IS VERY HARD TO STEER. WARNING LAMP STARTED COMING ON AND GOING OFF WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED. IT HAS SINCE STOPPED HAVING POWER STEERING AND THE LIGHT STAYS ON.

NHTSA ID

11716545

Incident

Nov 15, 2025

My power steering keep leaking making it hard to steer. Electric fuse keep blowing out,

NHTSA ID

11693521

Incident

Dec 10, 2024

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.