1997 Pontiac Trans Sport Problems

DT: THE CONTACT STATES WHEN THE VEHICLE WAS TAKEN TO DEALER FOR REPAIRS OF THE POWER STEERING RACK THE WELDS WHERE THE POWER STEERING RACK BOLTED TO THE FRAME CRACKED. THE VEHICLE HAS BEEN REPAIRED AT THE CONTACTED EXPENSE. *AK

I WAS TURNING THE STEERING WHEEL TO THE LEFT TO PARALLEL PARK NEXT TO THE CURB, THEN I HEARD A LOUD POP NOISE. WHEN I WENT TO TURN THE STEERING WHEEL TO THE RIGHT IT BEGAN VERY HARD TO TURN THE WHEEL. AFTER LEAVING THE STORE AND FROM THAT POINT ON EVERY ATTEMPT I MADE TO MAKE A RIGHT TURN, IT WAS EXTREMELY DIFFICULT. AFTER ARRIVING HOME I NOTICED LEAKING COMING FROM UNDER MY VAN. I CALLED THE LOCATION PONTIAC DEALERSHIP ABOUT THE MY STEERING PROBLEM AND THEY INDICATED THAT THE VAN HAD BEEN SERVICED FOR A RECALL IN FEBRUARY OF 2003 FOR THE RACK AND PINION RECALL SOMETHING RELATED TO THE STEERING. SO I CHECKED THE INTERNET FOR THE RECALL AND IT MENTIONED THE SAME EXACTLY PROBLEMS THAT I WAS HAVING NOW. I CALLED THE DEALERSHIP BACK AND THEY SAID THAT THE RECALL WAS ALREADY DONE ONCE. I TOLD THEM IT IS DOING THE SAME EXACTLY THING, AND WHEN I WENT TO CHECK THE STEERING ONE MORE TIME I NOTICED A HUGE PUDDLE UNDER MY VAN OF REDDISH BROWN FLUID. COME TO FIND OUT IT WAS TRANSMISSION LEAKING AND WHEN I TURN THE ENGINE ON THE FLUID CAME POURING OUT LIKE A FAUCET. I CONTACTED A TRANSMISSION SHOP TO TAKE A LOOK AT MY VAN AND THE MECHANIC TOLD ME THAT THE AXLE WAS PULLED OUT OF THE TRANSMISSION BY THE STEERING SYSTEM. THE MECHANIC ALSO MENTIONED THAT HE HAS DONE QUITE A FEW OF THESE SAME EXACTLY KIND OF MINI-VAN WITH THE SAME EXACTLY PROBLEM. HE SAID THAT HE KNEW EXACTLY HOW THE FIX THIS PROBLEM BECAUSE HE DOES IT QUITE OFTEN. THE REPAIR COSTED $1,800.00 DOLLARS AND THE MECHANIC TOLD ME NOW I NEED TO TAKE BACK TO THE DEALER TO HAVE THEM REPAIR THAT RACK AND PINION AGAIN. NOW THIS HAS ME VERY UPSET, I'M SO MAD ABOUT THIS BECAUSE THIS DEFINITELY SOUNDS LIKE A MANUFACTURE PROBLEM AND I SHOULD NOT HAVE TO PAY FOR THIS. I SENT THE VAN TO KARCO TRANMISSIONS IN LANCASTER, CALIFORNIA WHERE I LIVE AND THE PHONE NUMBER IS 661-723-1164. THIS DOES NOT MAKE ANY SENSE TO ME, SO THIS IS WHY I AM FILING THIS COMPLAINT.

IN NOV. OF 2007 I WAS HAVING A PROBLEM WITH MY VAN OVERHEATING AND WAS LOSING ENGINE COOLANT BUT COULD NOT SEE WHERE IT WAS GOING. I LATER FOUND OUT THAT I HAD A FAULTY INTAKE MANIFOLD GASKET, WHICH COST ME OVER 800.00 TO REPAIR. NOT LONG AFTER THE GASKET WAS REPAIRED THE VAN STARTED OVERHEATING AGAIN AND I DISCOVERED THAT THE WATER PUMP WAS BLOWN, THAT WAS ANOTHER 174.00 TO REPAIR. NOW I AM STILL HAVING THE SAME PROBLEM WITH THE VAN OVERHEATING AND COOLANT LEAKING AND I WAS JUST INFORMED THAT IT IS A HEAD GASKET WHICH IS GOING TO COST ME OVER 1700.00 TO FIX. THIS IS RIDICULOUS, I KNOW 3 OTHER PEOPLE WHO HAVE THE SAME MAKE AND MODEL VAN AS I DO WITH THE SAME ENGINE AND THEY ARE ALL ALSO HAVING THE SAME PROBLEMS WITH THEIR VANS. IT SEEMS TO ME THAT THIS IS TOO MUCH OF A COINCIDENCE AND THAT THEIR SHOULD HAVE BEEN A RECALL IN PLACE TO RECTIFY THE PROBLEMS WITH THESE FAULTY PARTS. THESE ARE EXTREMELY EXPENSIVE REPAIRS AND I PERSONALLY DO NOT HAVE AN EXTRA $1700.00 JUST LAYING AROUND, SO NOW I AM FACED WITH THE CHOICE OF JUNKING MY VAN AND TRYING TO GET A NEW ONE WHICH I CANNOT AFFORD OR FIXING IT WHICH I ALSO CANNOT AFFORD. *TR

OUR 1997 PONTIAC TRANSPORT HAS HAD 3 HEAD GASKET FAILURES. THE FIRST WAS AT 72000, SECOND AT 88,000 AND IS CURRENTLY DEAD IN FRONT DRIVE WITH WATER IN THE OIL AGAIN. HAD NEW HEADS PUT ON AT 72000. VEHICLE OVERHEATS AND DOES NOT SHOW ON GAUGES. YOU HEAR IT BUBBLING WHEN IT'S SHUT OFF. ALSO HAD TO REPLACE ALTERNATOR 3 TIMES AND VAN ONLY HAS 110,000 MILES ON IT. WE'VE HAD SINCE NEW. *TR

Sliding door on passenger side locked up trapping passenger inside. Door cannot be opened manually or electronically. A loud buzzing noise then a thud was heard prior. Can't open door any way now scary.

MY 97 PONTIAC TRANSPORTS HAS A SAFETY ISSUE. THE PASSENGER SLIDING DOOR IS INOPERABLE. THE DOOR WILL NOT OPEN AND APPERAS TO NOT BE CLOSED ALL THE WAY. THE DOOR IS TURNED OFF VIA THE SWITCH AND THE LOCK WILL NOT RELEASE VIA THE UNLOCK SWITCH OR THE MANUAL LOCK MECHANISM ON THE DOOR. IN THE EVEN OF AN ACCIDENT THIS DOOR COULD NOT BE USED AS AN EXIT. I ALSO HAVE CONCERNS OF THE DOOR POSSIBLE COMING OPEN WHILE THE VEHICLE IS IN MOTION.

MY WIFE'S 1997 PONTIAC TRANSPORT MINI-VAN HAS THE PLASTIC HEADLIGHT LENSES, THAT ARE NOW YELLOW AND CLOUDY, AND NIGHTTIME VISIBILITY IS SO POOR THAT SHE DOESN'T DRIVE AT NIGHT UNLESS SHE HAS TO. ALSO MY 2000 NISSAN FRONTIER TRUCK IS SUCCUMBING TO THE SAME PROBLEM, BUT IT IS NOT AS SEVERE YET. I HAVE TRIED HIGH-OUTPUT ZENON, BLUELIGHT, AND ULTRA WHITE BULBS BUT THE YELLOWING/CLOUDY PLASTIC LENSES GREATLY REDUCES THE PERFORMANCE QUALITIES OF THESE BULBS. I CANNOT SEE THE SAFETY BENEFITS OF HAVING PLASTIC HEADLIGHT LENSES THAT WON'T SHATTER LIKE GLASS IN AN ACCIDENT IF YOU CANNOT SEE MORE THAN 20 FEET IN FRONT OF YOUR VEHICLE AT NIGHT. I STILL BELIEVE GLASS IS THE BEST MATERIAL FOR HEADLIGHTS, I SEE CARS AND TRUCKS FROM THE 70'S, 80'S, AND EARLY 90'S THAT STILL HAVE GREAT WORKING HEADLIGHTS. *TR

MY TRANSMISSION HAS BEEN REPLACED ONCE AND I AM ALREADY HAVING PROBLEMS WITH IT AGAIN, IT'S ONLY BEEN A YEAR SINCE IT WAS REPLACED. BOTH OF MY FRONT WINDOWS ARE POWER WINDOWS AND I HAVE HAD TO REPLACE THE LITTLE MOTOR FOR THEM TO GO UP AND DOWN TWICE AND THE PASSENGER IS NOT WORKING AGAIN. MY LEFT FRONT SIGNAL LIGHT NEVER WORKS, IT GETS REPLACED AND A DAY LATER IS NOT WORKING AGAIN. I HAVE PROBLEMS WITH MY STEERING WHEEL, IT IS VERY HARD TO TURN RIGHT, THIS WAS ALREADY FIXED AND I'M HAVING PROBLEMS AGAIN. I NEED TO KNOW IF THERE ARE OR THERE WHERE ANY RECALLS RELATED TO MY PROBLEMS. I HAVE READ ABOUT OTHER PEOPLE HAVING TRANSMISSION PROBLEMS. THANK YOU. *JB

I HAVE OWNED BOTH A '92 AND A '97 TRANSPORT AND BOTH HAD THE SAME PROBLEMS. THE POWER WINDOW CONTROLS POP LOOSE OF THE DRIVER'S DOOR AND THE WINDOWS FAIL TO OPERATE. THE REAR DOOR LOCK FAILS. THE BLINKER AND CRUISE CONTROL LEVER SNAPPED OFF THE STEERING COLUMN SO THE BLINKER DOESN'T WORK. THE WINDOW WIPER CONTROL MODULE FAILED. THE TRANSAXLE HOSES SPRUNG A LEAK AT THE METAL CONNECTIONS CAUSING THE TRANSAXLE TO LOOSE FLUID AND THE VEHICLE TO BE STRANDED. *TR

VAN STARTED ON FIRE, IN DRIVER'S DOOR ORIGINATING FROM POWER WINDOW CONTROLS. PARKED IN DRIVEWAY NEXT TO HOUSE,NOT RUNNING. VAN WAS A COMPLETE LOSS,ONLY VEHICLE WAS ONLY ONE FOR A FAMILY OF FOUR. *TR

Sliding door on passenger side locked up trapping passenger inside. Door cannot be opened manually or electronically. A loud buzzing noise then a thud was heard prior. Can't open door any way now scary.

I HAVE OWNED BOTH A '92 AND A '97 TRANSPORT AND BOTH HAD THE SAME PROBLEMS. THE POWER WINDOW CONTROLS POP LOOSE OF THE DRIVER'S DOOR AND THE WINDOWS FAIL TO OPERATE. THE REAR DOOR LOCK FAILS. THE BLINKER AND CRUISE CONTROL LEVER SNAPPED OFF THE STEERING COLUMN SO THE BLINKER DOESN'T WORK. THE WINDOW WIPER CONTROL MODULE FAILED. THE TRANSAXLE HOSES SPRUNG A LEAK AT THE METAL CONNECTIONS CAUSING THE TRANSAXLE TO LOOSE FLUID AND THE VEHICLE TO BE STRANDED. *TR

DRIVING IN RUSH HOUR TRAFFIC, ON CONGESTED FREEWAY, AT 55 MPH THE BRAKE PEDAL WENT TO THE FLOOR WITHOUT ANY WARNING. THE TRAFFIC IN FRONT OF ME WAS SLOWING DOWN AND I ALMOST REAR ENDED THE CAR IN FRONT OF ME. DROPPED IT IN FIRST GEAR, APPLIED EMERGENCY BRAKE AND MADE AN EVASIVE LANE CHANGE TO GET TO THE SHOULDER AND LET IT SLOW DOWN BY ITSELF. PULLED OFF ON THE FREEWAY SHOULDER GOT OUT OF THE CAR AND I NOTICED THE BRAKE LINE RIGHT UNDERNEATH THE DRIVER SIDE LEAKING AT A HIGH RATE AND BRAKE FLUID PUDDLING UNDERNEATH THE VEHICLE. ONLY GOD'S GRACE THAT I DIDN'T REAR END ANYBODY OR GOTTEN INTO A CAR CRASH. DISAPPOINTED IS NOT A STRONG ENOUGH WORD TO USE FOR WHAT HAPPENED. I HAVE NEVER EXPERIENCED A BRAKE LINE BURST IN A VEHICLE. DOING SOME ONLINE SEARCHES ON GM BRAKE LINE FAILURES I FOUND A LOT OF REPORTED CASES OF GM VEHICLES HAVING SEVERELY RUSTED BRAKE LINES THAT HAD CATASTROPHIC FAILURE WITH THE BRAKE PEDAL GOING TO THE FLOOR. HOPE THAT YOU'LL OPEN AN INVESTIGATION INTO THESE CONCERNS IN ORDER TO AVOID ANY FUTURE INCIDENTS.

AT 51000 MILES THE 3.4L ENGINE HAD LOWER INTAKE GASKET FAILURE IN WHICH THE DEX-COOL ANTI FREEZE DUMPED INTO THE CRANKCASE MIXING WITH THE OIL. THIS ONLY HAD ONE WARNING A COUPLE MONTHS EARLIER AS THE LOW COOLANT LIGHT CAME ON AND I ADDED 1/2 GALLON DEX-COOL WITH NO SIGNS OF LEAKAGE. NEXT TIME IT HAPPENED WAS WHEN MY WIFE WAS TAKING DAUGHTER TO SCHOOL AND TEMP. LIGHT CAME ON. VAN WAS NOT DRIVEN OVER 2 MILES TO DEALER, AS LIGHT WENT OUT. DEALER SAID EXTREME MIXTURE IN BOTH CRANKCASE AND RADIATOR. RECOMMENDED REPLACE RADIATOR, WATERPUMP, INTAKE GASKETS, FLUSH BOTH SYSTEMS AT A COST OF 1500 NOT TO BE APPLIED TOWARD ENGINE REPLACEMENT IF FAILURE ON START UP. DEALER HAD JUST HAD VAN IN WEEK BEFORE FOR CHECK ENGINE LIGHT AND STEERING RECALL AND FOUND NOTHING WRONG !!!! WE TRADED IT IN AT A LOSS AS I CHECKED INTO THE PROBLEM AND LEARNED ABOUT THOUSANDS OF OTHER OWNERS WITH SAME PROBLEMS WITH TOTAL ENGINE FAILURES AFTER REPAIRS MADE. WE LOST OVER $3000 EQUITY BETWEEN WHAT TRADE VALUE WOULD HAVE BEEN IF NO PROBLEM WITH ENGINE AND LETTING DEALER FIX PROBLEM AFTER TRADE. VAN HAD MANY PROBLEMS SINCE WE BOUGHT IT NEW BUT WE ALWAYS HAD THEM FIXED AND WAS WELL MAINTAINED. LOOKED NEW WHEN WE TRADED WITH ONLY 50,000 MILES. PAINT ON HOOD BLISTERED TWICE, STEERING / BRAKES WOBBLED SINCE NEW AT VARYNG SPEEDS, ALWAYS HAD TICKING SOUND IN ENGINE DEALER SAID WAS "NORMAL", REAR SEATS WOULD JAMB UP IF YOU TRIED TO REMOVE, WIPER ARMS FAILED TWICE, SERPENTINE BELT TENSIONER BROKE OFF ON ENGINE START UP IN DEC. 2002. COST $375 WITH TOWING, POWER WINDOW SWITCH FAILED IN DOWN POSITION AT REPLACEMENT COST OF ABOUT $175. ENGINE UNDER WARRANTY WHEN IT HAD A SEVERE GAS SMELL THAT NEARLY CAUSED A FIRE IN ABOUT 1999. THEY KEPT IT A WEEK AND NEVER SAID WHAT THE PROBLEM WAS. THEY HAD JUST WORKED ON IT FOR TICKING SOUND. (PROBABLY INTAKE GASKETS THEN ALSO). GM WAS NO HELP AFTER WARRANTY WAS UP.

THE FUEL GUAGE GIVES FALSE READING, THE NEEDLE WILL POSITION WAY PASS THE "FULL". AFTER PUTTING IN FUEL, IT WILL MOVE TO THE "FULL" MARK OR SHOW JUST ANY AMOUNT WITHOUT THE TANK BEING FULL. IT IS AVERY HARD ACT TO FOLLOW ESPECIALLY IN THESE TIMES WHEN I CANNOT AFFORD TO TOP OFF THE TANK. IN OTHER WORDS, THIS FUEL GUAGE IS VERY UNRULY AND HAS ITS OWN WAY IN REGISTERING WHAT IT FEELS LIKE SHOWJNG ME. IS THERE A RECALL?. HOW CAN I CORRECT THIS EMBARASSING SITUATION?. *TR

CONSUMER COMPLAINED ABOUT HAVING ALL KINDS OF PROBLEMS WITH VEHICLE. FIRSTLY, TRANSMISSION MALFUNCTIONED, AND IT WAS REPAIRED. SECONDLY, POWER STEERING FLUID WAS LEAKING, AND CONSUMER KEPT REPLACING IT. THIRDLY, THERE WAS A GASOLINE LEAK, WHICH WAS REPAIRED.*AK

CONSUMER STATED THE PASSENGER'S SIDE SEAT BELT BUCKLE WILL NOT LATCH.*AK

THE DRIVERS AND PASSENGERS REAR SEATBELT LATCH DID NOT LATCH. THE VEHICLE WAS TAKEN TOTHE DEALER WHO STATED THAT THEY NEEDED TO BE REPLACED. *NLM SECOND ROW SEATS SEATBELT DID NOT LATCH PROPERLY.*TS

I HAVE OWNED BOTH A '92 AND A '97 TRANSPORT AND BOTH HAD THE SAME PROBLEMS. THE POWER WINDOW CONTROLS POP LOOSE OF THE DRIVER'S DOOR AND THE WINDOWS FAIL TO OPERATE. THE REAR DOOR LOCK FAILS. THE BLINKER AND CRUISE CONTROL LEVER SNAPPED OFF THE STEERING COLUMN SO THE BLINKER DOESN'T WORK. THE WINDOW WIPER CONTROL MODULE FAILED. THE TRANSAXLE HOSES SPRUNG A LEAK AT THE METAL CONNECTIONS CAUSING THE TRANSAXLE TO LOOSE FLUID AND THE VEHICLE TO BE STRANDED. *TR

MY TRANSMISSION HAS BEEN REPLACED ONCE AND I AM ALREADY HAVING PROBLEMS WITH IT AGAIN, IT'S ONLY BEEN A YEAR SINCE IT WAS REPLACED. BOTH OF MY FRONT WINDOWS ARE POWER WINDOWS AND I HAVE HAD TO REPLACE THE LITTLE MOTOR FOR THEM TO GO UP AND DOWN TWICE AND THE PASSENGER IS NOT WORKING AGAIN. MY LEFT FRONT SIGNAL LIGHT NEVER WORKS, IT GETS REPLACED AND A DAY LATER IS NOT WORKING AGAIN. I HAVE PROBLEMS WITH MY STEERING WHEEL, IT IS VERY HARD TO TURN RIGHT, THIS WAS ALREADY FIXED AND I'M HAVING PROBLEMS AGAIN. I NEED TO KNOW IF THERE ARE OR THERE WHERE ANY RECALLS RELATED TO MY PROBLEMS. I HAVE READ ABOUT OTHER PEOPLE HAVING TRANSMISSION PROBLEMS. THANK YOU. *JB

VAN STARTED ON FIRE, IN DRIVER'S DOOR ORIGINATING FROM POWER WINDOW CONTROLS. PARKED IN DRIVEWAY NEXT TO HOUSE,NOT RUNNING. VAN WAS A COMPLETE LOSS,ONLY VEHICLE WAS ONLY ONE FOR A FAMILY OF FOUR. *TR

FUSES BLOW WITHIN MINUTES OF BEING INSTALLED. REAR SIGNAL LIGHT DOES NOT FLASH. PH

PRIOR TO RECALL REPAIR 01V-067 FOR THE SLIDING DOOR ACTUATOR THE VEHICLE NEVER EXHIBITED ANY SYMPTOMS OF THE RECALL, AFTER THE RECALL REPAIR THE DOOR WOULD NOT OPEN AT TIMES, THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE A MODULE WAS REPLACED AT THE CONSUMER'S EXPENSE, THE DAY AFTER REPAIR THE DOOR FAILED TO OPERATE AGAIN, THE VEHICLE WAS RETURNED ON SEVERAL OCCASION BECAUSE THE DOOR WOULD NOT OPEN OR WOULD OPEN WHILE THE VHEILCE WAS IN MOTION. NLM

STEERING WHEEL WOULD LOCK UP WHEN MAKING A LEFT TURN. VEHICLE TAKEN TO DEALER FOR INSPECTION, AND INFORMED THAT RACK AND PINION STEERING WAS BROKEN ,AND NEEDED REPLACEMENT. *AK A NUT HAD BROKEN ON THE BOTTOM OF THE RACK AND PINION SYSTEM CAUSING IT TO FALL APART, THE AIR BAG COIL WAS TWISTED ALSO CAUSING A BIND UP IN THE STEERING WHEEL. *SLC

VEHICLE HAS THE LOAD LEVELLING SUSPENSION WITH AIR COMPRESSOR. THE COMPRESSOR GOES ON INTERMITTENTLY TO RELEVEL THE SUSPENSION DUE TO LEAK IN LOAD LEVELLING SUSPENSION HOSE. THIS KILLS THE BATTERY. HOSE HAS BEEN REPLACED TWICE OVER 7 YEARS. PROBLEM HAS RE-OCCURRED ABOUT EVERY 2 YEARS.*AK

THIS VEHICLE WAS VERY WELL MAINTAINED OILCHANGE EVERY 3K MILES, TRANSMISSION SERVICED EVERY 30,000 MILES. THE RACK&PINION WENT OUT IN OCTOBER 2003. THE TRANSMISSION WENT OUT IN MAY OF THIS YEAR AND NOW THE ENGINE. VAN WAS RUNNING HOT, WE REPLACED THE THERMOSTAT, WATER PUMP, OXYGEN SENSOR, MAIN RADIATOR HOSE AND FLUSHED RADIATOR, AND PURCHASED A NEW RADIATOR CAP. IT IS STILL RUNNING HOT. IT HAS A BLOWN HEAD GASKET, AND A WARPED HEAD, NO TELLING WHAT THIS WILL COST.

THE VEHICLE'S TRANSMISSION HAD TO BE REPLACED AND THE ENGINE HAD TO BE REPLACED DUE TO A FAULTY HEAD GASKET. *NM THE TRANSMISSION FAILED TWICE. *JB THE CONSUMER STATED THAT HE HAS HAD THE VEHICLE TOWED ON FOUR SEPARATED OCCASIONS. *TC

THIS VEHICLE WAS VERY WELL MAINTAINED OILCHANGE EVERY 3K MILES, TRANSMISSION SERVICED EVERY 30,000 MILES. THE RACK&PINION WENT OUT IN OCTOBER 2003. THE TRANSMISSION WENT OUT IN MAY OF THIS YEAR AND NOW THE ENGINE. VAN WAS RUNNING HOT, WE REPLACED THE THERMOSTAT, WATER PUMP, OXYGEN SENSOR, MAIN RADIATOR HOSE AND FLUSHED RADIATOR, AND PURCHASED A NEW RADIATOR CAP. IT IS STILL RUNNING HOT. IT HAS A BLOWN HEAD GASKET, AND A WARPED HEAD, NO TELLING WHAT THIS WILL COST.

TRANSMISSION PUMP WENT OUT WITH NO WARNING WHILE DRIVING ON A 4-LANE HIGHWAY. ENGINE STARTED RACING, NO PULL. NEW PUMP ASSEMBLY, TORQUE CONVERTER, PUMP SHAFT & VARIOUS OTHERS PARTS HAD TO BE REPLACED.*AK

CHECK THE ENGINE LIGHT CAME ON DUE TO GAS FILTER FAILURE. YH

THE RIGHT REAR FIRESTONE FR680 TIRE P215/70R15 DOT W2M3 EXPERIENCED TREAD SEPARATION, CONSUMER NOTICED THE LEFT REAR TIRE WAS WORN AND THE TREADS HAD BEGUN TO PULL AWAY FROM THE INSIDE, PREVIOUSLY IN MAY WHILE HAVING A SAFETY INSPECTION, THE 2 REAR TIRES WERE WORN BADLY AND FAILED INSPECTION. *SLC