2021 RAM Promaster Problems

The contact owns a 2021 Ram Promaster 2500. The contact received notification of NHTSA Campaign Number: 25V552000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the rearview camera displayed a distorted image. The approximate failure mileage was 80,000.

The contact owns a 2021 Ram Promaster 1500. The contact received notifications of NHTSA Campaign Number: 25V552000 (Back Over Prevention) and 25V720000 (Engine and Engine Cooling); however, the parts for the recall repairs were unavailable. The dealer was contacted, and the contact was informed that parts were not yet available. The manufacturer was contacted, and the contact was informed that parts were not yet available. The contact had not experienced a failure.

I had NHTSA recall for this generator done (23E-030) which was to solve the same problem I just had. Apparently, they just moved to a smaller diameter fuel line to fit the fuel pump better. However, this hose also came off my Cummins generator fuel pump and was spewing gas all over the generator and the ground when we ran it. This is a very unsafe condition and I'm surprised, after the recall was performed by a certified Cummins dealer (verified by Cummins) that this "new" fuel line has also come off the fuel pump.

My 2021 Ram ProMaster 2500 has two open safety recalls with no remedy available: NHTSA Recall 25V-552 (rearview camera FMVSS 111 compliance issue) issued August 26, 2025 NHTSA Recall 25V-720 (cooling fan fire risk) issued October 23, 2025 As of April 2026, no remedy has been provided for either recall. The vehicle is used commercially for rental income, and the lack of a repair has caused financial loss of approximately $500–$1,000 per month. One of the recalls involves a potential vehicle fire risk. The prolonged delay without a remedy is concerning for both safety and financial reasons.

The specific issue you are dealing with is Chrysler Recall 67C (NHTSA Campaign 25V720). This recall impacts nearly 300,000 Ram ProMaster vans (model years 2018–2026) due to an overheating radiator cooling fan circuit that poses a significant vehicle fire risk. More than 200 of these are from the VA. Edwards Auto Group In Council Bluffs, IA is trying to make the Veterans Health Administration pay labor for a safety recall that is stated above. I am reporting them because it is a safety recall and we should not have to pay for extra cost such as a 2x4. Please see below. It is my understanding that the Dealer is in the wrong here. •Absolute Free Labor: Dealerships enter franchise contracts with the manufacturer requiring them to execute recall repairs for free. Chrysler (FCA US LLC) is legally obligated to provide the instructions and billable labor hours to the dealership. •The "2x4" Tool Excuse: If a manufacturer's official technical service bulletin specifies a specific physical manipulation or tool—even a makeshift one like a 2x4—to complete the repair, that labor time is factored into the flat-rate time Chrysler pays the dealer. The dealer cannot pass "difficult labor" or tool costs onto you. •No Deductibles or Add-ons: A dealer cannot apply any separate fees or surcharges to offset their operational challenges while resolving a safety defect.

The contact owns a 2021 Ram Promaster 1500. The contact received notifications of NHTSA Campaign Number: 25V552000 (Back Over Prevention) and 25V720000 (Engine and Engine Cooling); however, the parts for the recall repairs were unavailable. The dealer was contacted, and the contact was informed that parts were not yet available. The manufacturer was contacted, and the contact was informed that parts were not yet available. The contact had not experienced a failure.

I had NHTSA recall for this generator done (23E-030) which was to solve the same problem I just had. Apparently, they just moved to a smaller diameter fuel line to fit the fuel pump better. However, this hose also came off my Cummins generator fuel pump and was spewing gas all over the generator and the ground when we ran it. This is a very unsafe condition and I'm surprised, after the recall was performed by a certified Cummins dealer (verified by Cummins) that this "new" fuel line has also come off the fuel pump.

While driving, the vehicle experienced a sudden and complete loss of motive power without warning. The driver coasted off the road into a swale and required a tow to an authorized RAM dealer, December 9 2025 to CDJR of Tampa Bay, Tampa FL. The dealer initially indicated the failure was covered under Recall 44A, then changed their position and characterized it as a powertrain warranty repair. Following that repair the vehicle was returned immediately in January 2026 when it would not engage reverse. In May 2026 the vehicle experienced a CV joint failure at 20,411 miles — approximately 1,000 miles after the January repair. The RAM ProMaster 3500 is front wheel drive and CV joints connect directly to the transmission. The recurring failures following the repair present a serious safety concern. The December repair receipt is 10 pages and January is 5 the unit is currently at an authorized mopar shop. Please let us know if you require those receipts.

Vehicle experienced severe, premature component failures posing direct safety hazards while operating a commercial work van: 1. Parking Brake Seizure (01/25/2025 @ 49,197 miles): The parking brake pivot assembly completely seized, causing the rear brake assembly to lock up and rendering the vehicle unsafe to operate on public roads. Replaced under Invoice #CHCS490962. 2. Catastrophic Transmission & Drivetrain Failure (05/15/2026 @ 66,082 miles): The transmission suffered recurring fluid leaks beginning at 49,197 miles (pan leak reseal) and 51,648 miles (complete front pump replacement). At 66,082 miles, the transmission suffered complete internal failure (burnt fluid, clutch metal material), resulting in total loss of reverse power and gear slipping while operating. Both front strut mounts failed on the same visit. Experiencing brake lockup and sudden total loss of transmission control under 66,000 miles on a commercial vehicle presents significant safety risks to vehicle operators and traffic.

While driving, the vehicle experienced a sudden and complete loss of motive power without warning. The driver coasted off the road into a swale and required a tow to an authorized RAM dealer, December 9 2025 to CDJR of Tampa Bay, Tampa FL. The dealer initially indicated the failure was covered under Recall 44A, then changed their position and characterized it as a powertrain warranty repair. Following that repair the vehicle was returned immediately in January 2026 when it would not engage reverse. In May 2026 the vehicle experienced a CV joint failure at 20,411 miles — approximately 1,000 miles after the January repair. The RAM ProMaster 3500 is front wheel drive and CV joints connect directly to the transmission. The recurring failures following the repair present a serious safety concern. The December repair receipt is 10 pages and January is 5 the unit is currently at an authorized mopar shop. Please let us know if you require those receipts.

Vehicle experienced severe, premature component failures posing direct safety hazards while operating a commercial work van: 1. Parking Brake Seizure (01/25/2025 @ 49,197 miles): The parking brake pivot assembly completely seized, causing the rear brake assembly to lock up and rendering the vehicle unsafe to operate on public roads. Replaced under Invoice #CHCS490962. 2. Catastrophic Transmission & Drivetrain Failure (05/15/2026 @ 66,082 miles): The transmission suffered recurring fluid leaks beginning at 49,197 miles (pan leak reseal) and 51,648 miles (complete front pump replacement). At 66,082 miles, the transmission suffered complete internal failure (burnt fluid, clutch metal material), resulting in total loss of reverse power and gear slipping while operating. Both front strut mounts failed on the same visit. Experiencing brake lockup and sudden total loss of transmission control under 66,000 miles on a commercial vehicle presents significant safety risks to vehicle operators and traffic.

My van began making a loud squeaky sound, louder at low speeds and less at higher speeds. It sounded like it was coming from the wheels or undercarriage. There were no dash warning lights, alarms, or any other indicator of a serious issue. I drove the van around town for a few days approximately 30 miles. The van is heavy and I live in a hilly area, so I use the parking brake fairly often. I applied the parking brake within that week on an incline, and when I released the parking brake and drove forward, the squeak was louder then ever, so much so, people stared. There were no error or warning message on the dash or elsewhere. The parking brake indicator had come on normally while engaged and went off when it was released. I drove it directly to the local Ram dealer, as it seemed worse, hoping it was just in need of minor lubrication. It had just been serviced at the same dealer a few months earlier and I was told "it was like new with its low 12,500 miles". I explained the new noise and that I didn't want to cause damage by driving it, although there were no warning lights on. My van is still under the original warranty for a few more months. Even though they were booked, an employee went out and felt by the rear driver's side wheel and said it was really hot and likely a frozen brake caliper. They were able to fit me in and discovered the parking brake was frozen, which was causing the noise. They ordered the parts to repair, disengaged the parking brake, and said it was safe to drive as the main brakes were a separate system. They said not to apply the parking brake again as it would hang up as before. -The dealer ordered the parts over a month ago, but said the brake parts are not only on back order, but with no estimated shipping date, meaning they aren't even manufacturing them. -I am driving without a parking brake in a heavy vehicle in a hilly area with no pending solution and heading into winter weather. This is a safety issue! Please help ASAP.

The 2021 Ram ProMaster 2500 I purchased from a dealer on 12/6/25 now has a serious safety defect. The transmission began grinding when shifting into Drive on 1/27/26. Immediately after, the vehicle started rolling backwards while fully in Park with the engine running. This indicates a failure of the parking pawl or internal gearset. The backup camera also does not function, there are coolant and power steering leaks, and the axle/wheel bearing is failing. The dealer claimed the van passed a “120-point inspection,” but it is clearly unsafe and unfit for operation. This defect poses a risk of rollaway injury, crash, and property damage.

The contact owns a 2021 Ram Promaster 2500. The contact stated that the driver’s and passenger’s side seat belts' webbing was frayed. The contact had not experienced a failure with the seat belts; however, due to the safety concerns, the vehicle was taken to the dealer, and the seat belts were replaced. The manufacturer was notified of the failure and confirmed that there was no recall associated with the failure. The failure mileage was unknown. The VIN was not available.

The contact owns a 2021 Ram Promaster 3500. The contact stated that the screen display was black and the back-over prevention camera was inoperable. Additionally, the speedometer was blinking and causing a distraction. The radio and hands-free calling were inoperable. The contact received notification of NHTSA Campaign Number: 25V552000 (Structure). The contact called an unknown local dealer and was referred to a Dodge dealer for assistance. The contact called the local dealer and was informed that there was no warranty coverage on the vehicle and the parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that parts were not yet available. The failure mileage was approximately 14,272.

The contact owns a 2021 Jayco Swift RV built on a 2021 Ram Promaster 3500 Chassis. The contact stated that while driving downhill at an undisclosed speed, the transmission failed to shift out of low gear, and the RPMS were significantly high. The vehicle was taken to the dealer, where it was determined that the motorhome standard weight had exceeded the transmission and engine capacity. The contact stated that the only equipment that was added to the RV standard weight was a spare tire. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.

The vehicle experienced a sudden and complete loss of steering control during normal driving on a public roadway. The steering wheel became extremely difficult to turn, and the vehicle became immobilized, creating a serious risk of collision and injury. The vehicle was towed to an authorized RAM dealership, where inspection confirmed a broken serpentine belt, abnormal alternator noise, and metal contamination throughout the entire power steering system. The dealer advised that the entire power steering system requires replacement. The presence of metal debris in a critical steering system indicates a pre-existing mechanical defect that could not reasonably develop within 27 days of normal use. No warning lights or messages appeared prior to the failure. At the time of sale, the vehicle was also subject to unresolved safety recall(s). The selling dealer refuses to rescind the sale or provide a refund.

The vehicle suddenly and without warning experienced a complete loss of steering control, rendering it undrivable and forcing it to stop on the side of a public roadway. This created a significant risk to my personal safety and to public safety. On the same day, the vehicle was towed to an authorized RAM dealership for inspection. The dealership confirmed that the serpentine belt had broken, there was abnormal noise from the alternator, and the entire power steering system was internally contaminated with metal shavings, requiring complete replacement of the power steering system. The selling dealer has refused to accept rescission of the sale and has also refused to cover the necessary repair costs. The vehicle was unlawfully sold to me while it was subject to an unresolved safety recall, demonstrating a serious disregard for my safety and the safety of others.

Vehicle experienced severe, premature component failures posing direct safety hazards while operating a commercial work van: 1. Parking Brake Seizure (01/25/2025 @ 49,197 miles): The parking brake pivot assembly completely seized, causing the rear brake assembly to lock up and rendering the vehicle unsafe to operate on public roads. Replaced under Invoice #CHCS490962. 2. Catastrophic Transmission & Drivetrain Failure (05/15/2026 @ 66,082 miles): The transmission suffered recurring fluid leaks beginning at 49,197 miles (pan leak reseal) and 51,648 miles (complete front pump replacement). At 66,082 miles, the transmission suffered complete internal failure (burnt fluid, clutch metal material), resulting in total loss of reverse power and gear slipping while operating. Both front strut mounts failed on the same visit. Experiencing brake lockup and sudden total loss of transmission control under 66,000 miles on a commercial vehicle presents significant safety risks to vehicle operators and traffic.

While driving, the vehicle experienced a sudden and complete loss of motive power without warning. The driver coasted off the road into a swale and required a tow to an authorized RAM dealer, December 9 2025 to CDJR of Tampa Bay, Tampa FL. The dealer initially indicated the failure was covered under Recall 44A, then changed their position and characterized it as a powertrain warranty repair. Following that repair the vehicle was returned immediately in January 2026 when it would not engage reverse. In May 2026 the vehicle experienced a CV joint failure at 20,411 miles — approximately 1,000 miles after the January repair. The RAM ProMaster 3500 is front wheel drive and CV joints connect directly to the transmission. The recurring failures following the repair present a serious safety concern. The December repair receipt is 10 pages and January is 5 the unit is currently at an authorized mopar shop. Please let us know if you require those receipts.

fuel tank leaking gasoline. vapors and liquid gasoline leaking from fuel tank

I had NHTSA recall for this generator done (23E-030) which was to solve the same problem I just had. Apparently, they just moved to a smaller diameter fuel line to fit the fuel pump better. However, this hose also came off my Cummins generator fuel pump and was spewing gas all over the generator and the ground when we ran it. This is a very unsafe condition and I'm surprised, after the recall was performed by a certified Cummins dealer (verified by Cummins) that this "new" fuel line has also come off the fuel pump.

I had to replace my backup camera as it was faulty and the newer models had a recall. My blind spot monitoring system cuts off randomly going down the road. We have paid out of pocket for a new camera and the dealership can't figure out why the blind spot indicator cuts off.

When driving on the expressway at highway speeds in this 2021 Ram 2500, the side mirrors started to vibrate and folded/slammed into the vehicle. Rear and blind spot visibility was eliminated. Fortunately, a passenger could adjust passenger side and driver could adjust driver sidemirror, but they are now damaged and do not properly stay in position. A online Dodge Ram Forum indicates this is a common problem. DANGEROUS!

The contact owns a 2021 Ram Promaster 1500 equipped with Nexen Tires, Tire Line: Rodian CT8, Tire Size: P225/75/R16, DOT Number: 8EAKHMEL3420. The contact stated that while driving at 65 MPH, the passenger’s side rear tire experienced tread separation. The contact was able to replace the tire with the spare. While driving, the driver's side rear tire also experienced tread separation, and the vehicle became difficult to control. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed, and determined that the tires needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The approximate tire mileage was 1,000. The vehicle failure mileage was approximately 13,304.

Tire size LT225/75R16. Tires are OEM on 2021 Ram Promaster 3500 - Purchased New in February 2022. Vehicle has 24,500 miles and tires are regularly rotated. Presure check of tires showed tires were at proper inflation for vehicle. TPMS did not issue a warning, because tire never lost pressure. On February 6, 2024 when driving southbound by mile marker 250 on Interstate 75 in Florida, the steering wheel started feeling funny like I was driving on a really rough road. When I looked out my rear camera, it appeared that tire tread scraps were coming from my vehicle. After slowing down to the breakdown lane, I inspected all four tires and found that tread had separated from the middle of the drivers side rear tire. I was able to slowly make my way to a nearby rest area, when I got help changing the tire out to the spare. The tread separated and caused the van to be unstable. The flying tread pieces were a danger to other vehicles on the road. If I had continued driving, the tire could have exploded causing damage to my van and to other vehicles on the road. Called dealer and was told these tires only have a 90 warranty.

When the vehicle is being driven, if a person is sitting in the rear seat of the RV while wearing the seat belt, any slight bump or uneven pavement causes their body to repeatedly bounce erratically up and down. The RV is sold stating that they have seats in the rear (2 lap belts in sofa) which is why I purchased the vehicle. From my first experience of sitting in this seat, it is not functional and cannot be used when the RV is in transit without compromising someone's safety. This was brought to the attention of the dealer and the warranty company. They went for a test drive and experienced the same situation. At my appointment with the warranty company , they inspected it and confirmed my problem. They said it was not something they were able to fix, nor was it covered under warranty. They did state "test drove...the rear pull out bed does seem bouncy, it unfortunately appears to be the quality of this design" and suggested I call the manufacturer to discuss further. When I called the manufacturer, Thor Motor Coach Inc., the representative was unaware of this problem but thanked me for letting them know and said they would look to fix this problem in future designs. They proceeded to tell me there is nothing they can do for me and denied offering any compensation or adjustments with my vehicle. Therefore, I'm reaching out to you to see if there is anything that can be done to resolve this issue. I worked hard my entire life, finally retired, and bought this RV so I could spend time with my grandchildren and bring them along with me on trips. Now I will not be able to do this because the seat cannot be used safely. I would appreciate your assistance with this matter as I feel this is a safety hazard and would not want to see anyone hurt while sitting in these seats.

The contact owns a 2021 Jayco Swift RV built on a 2021 Ram Promaster 3500 Chassis. The contact stated that while driving downhill at an undisclosed speed, the transmission failed to shift out of low gear, and the RPMS were significantly high. The vehicle was taken to the dealer, where it was determined that the motorhome standard weight had exceeded the transmission and engine capacity. The contact stated that the only equipment that was added to the RV standard weight was a spare tire. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.

The contact owns a 2021 Ram Promaster 2500. The contact stated that while driving at various speeds, the headlights were not producing adequate lighting while driving at night. There was no warning light illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact called Mopar and was referred to the dealer for assistance. The manufacturer was not contacted. The failure mileage was approximately 35,000.