RoadVitals

1999 Rexhall Aerbus Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
5
Latest Jul 25, 2012
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
3
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1999 Rexhall Aerbus, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Powertrain (other)360.0%
  • Brakes120.0%
  • Electrical120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

3
reports

From owner reports, verbatim

DRIVESHAFT FAILED. *SLC

NHTSA ID 784127 · filed Jun 7, 2000

ON FORD CHASSIS, BOLT THAT HOLD THE DRIVELINE WHICH GOES INTO THE TRANSMISSION, SHEARED OFF WHICH MAY CAUSE A CRASH. *AK

NHTSA ID 854877 · filed Feb 8, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

ANTI-LOCK BRAKING SYSTEM HAS CAUGHT OVERHEATED AND LOCKED UP A COUPLE OF TIMES. MASTER CYLINDER WAS REPLACED, BUT DID NOT STOP THE PROBLEMS. DEALER HAS BEEN CONTACTED. *AK

NHTSA ID 870845 · filed Sep 19, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

BATTERY DISCONNECT FAILED WHILE DRIVING OUR 20,200 POUND RV AT HIGHWAY SPEED. THE FAILURE RESULTED IN TOTAL LOSS OF CHASSIS POWER (ENGINE STOPPED, POWER STEERING CEASED, POWER STEERING CEASED, ALL DASH INDICATORS NON-OPERATIONAL, EMERGENCY FLASHER NON-OPERATIONAL, ETC.). THE FAILURE CAUSED US TO COAST TO A STOP AS THERE WAS NOTHING ELSE WE COULD DO. THE FAILED PART WAS LATER IDENTIFIED AS: BATTERY DISCONNECT SOLENOID (INTELLITEC 01-00055-002 04098 BCC RELAY (PRINTED ON STICKER PLACED ON TOP PORTION OF UNIT), 612-12V 797 (PRINTED ON BOTTOM OF UNIT). THE BATTERY DISCONNECT SERVICE MANUAL, P/N 53-00066-100, REV B, 030905 FAILS TO LIST TOTAL LOSS OF POWER WHILE IN MOTION AS A POTENTIAL PROBLEM. *TR

NHTSA ID 10467600 · filed Jul 25, 2012

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .