RoadVitals

1999 Rexhall Aerbus

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
5
Latest Jul 25, 2012
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Sep 5, 2007
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 5 NHTSA owner-reported complaints for the 1999 Rexhall Aerbus, most frequently naming the powertrain (other), brakes and electrical categories. 2 safety recalls have been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Powertrain (other)360.0%
  • Brakes120.0%
  • Electrical120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
07V417000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Sep 5, 2007
2,345 units potentially affected
The defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THE REFRIGERATOR MAY HAVE A DEFECT IN THE REFRIGERATOR BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
The risk: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
The remedy: REXHALL WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 4, 2008. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR REXHALL AT 1-661-726-0565.
REXHALL INDUSTRIES INCView on NHTSA.gov
01V163000

POWER TRAIN:DRIVELINE:DRIVESHAFT

May 9, 2001
823 units potentially affected
The defect: VEHICLE DESCRIPTION: MOTOR HOMES. THE DRIVE SHAFT BOLTS CAN COME LOOSE AT THE TRANSMISSION AND FALL OFF. WHEN THE DRIVE SHAFT SEPARATES FROM THE TRANSMISSION, THE FORWARD END OF THE SHAFT CAN DROP TO THE GROUND, OR COME THROUGH THE FLOORBOARDS OF THE MOTOR HOME.
The risk: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL AND/OR THE DRIVE SHAFT CONTACTING A FOLLOWING VEHICLE.
The remedy: DEALERS WILL REPLACE THE BOLTS. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2000. ALL VEHICLES HAVE BEEN REPAIRED.
REXHALL INDUSTRIESView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Electrical
Filed Jul 25, 2012

BATTERY DISCONNECT FAILED WHILE DRIVING OUR 20,200 POUND RV AT HIGHWAY SPEED. THE FAILURE RESULTED IN TOTAL LOSS OF CHASSIS POWER (ENGINE STOPPED, POWER STEERING CEASED, POWER STEERING CEASED, ALL DASH INDICATORS NON-OPERATIONAL, EMERGENCY FLASHER NON-OPERATIONAL, ETC.). THE FAILURE CAUSED US TO COAST TO A STOP AS THERE WAS NOTHING ELSE WE COULD DO. THE FAILED PART WAS LATER IDENTIFIED AS: BATTERY DISCONNECT SOLENOID (INTELLITEC 01-00055-002 04098 BCC RELAY (PRINTED ON STICKER PLACED ON TOP PORTION OF UNIT), 612-12V 797 (PRINTED ON BOTTOM OF UNIT). THE BATTERY DISCONNECT SERVICE MANUAL, P/N 53-00066-100, REV B, 030905 FAILS TO LIST TOTAL LOSS OF POWER WHILE IN MOTION AS A POTENTIAL PROBLEM. *TR

NHTSA ID
10467600
Incident
Jun 20, 2012
Mileage
28,084 mi
Brakes
Filed Sep 19, 2000

ANTI-LOCK BRAKING SYSTEM HAS CAUGHT OVERHEATED AND LOCKED UP A COUPLE OF TIMES. MASTER CYLINDER WAS REPLACED, BUT DID NOT STOP THE PROBLEMS. DEALER HAS BEEN CONTACTED. *AK

NHTSA ID
870845
Powertrain (other)
Filed Jun 7, 2000

DRIVESHAFT FAILED. *SLC

NHTSA ID
784127
Powertrain (other)
Filed Feb 8, 2000

ON FORD CHASSIS, BOLT THAT HOLD THE DRIVELINE WHICH GOES INTO THE TRANSMISSION, SHEARED OFF WHICH MAY CAUSE A CRASH. *AK

NHTSA ID
854877
Incident
Jan 10, 2000
Powertrain (other)
Filed Jan 31, 2000

FORD ENGINEER INSPECTION CONCLUDED THAT MANUFACTURER DID NOT FOLLOW FORD SPECIFICATIONS FOR EXTENDING CHASIS/ DRIVESHAFT WAS 3 INCHES TOO LONG AND NOT AT THE PROPER ANGLE. ALSO PARTS THAT SHOULD HAVE BEEN BOLTED WERE WELDED. I HAVE PROOF OF ALL THESE ALL. THE DRIVESHAFT FELL OFF ON THREE SEPARATE OCCASIONS DUE TO THIS DEFECT.

NHTSA ID
718109
Incident
Nov 5, 1999

Compare model years

Complaint and recall counts across every year of this model

Rexhall Aerbus by model year
YearComplaintsRecallsInvestigationsIssue Index
2005030—
2004110—
2003220—
2002120—
2001220—
2000120—
1999Viewing520—
1998221—
1997500—
1995410—
1994110—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.