RoadVitals

1995 Safari Sahara Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Aug 25, 2000
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1995 Safari Sahara, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Engine150.0%
  • Suspension150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

1
report

From owner reports, verbatim

WHEN THIS PART FAILS IT SHORT CIRCUITS TO THE STARTER SOLONOID CAUSING THE STARTER TO TURN THE ENGINE. THE ONLY SOLUTION IS TO DISCONNECT THE BATTERIES HOWEVER BY THAT TIME THE WIRING IS ON FIRE. ON MY VEHICLE, THE NEW FUEL CUT OFF PART FAILED ON THE SECOND OR THIRD START OF THE ENGINE, AGAIN BURNING OUT THE STARTER BUT NOT THE WIRING. IF THIS UNIT SHOULD FAIL WHILE DRIVING, AS THE REPLACEMENT DID, A SERIOUS ACCIDENT COULD OCCUR BECAUSE THE ENGINE DIES LEAVING THE DRIVER WITHOUT ANY POWER FOR STEERING AND THE ENGINE COMPARTMENT COULD BE ON FIRE. THERE IS NO WAY TO TELL. THIS PART SHOULD BE MADE TO FAIL IN A SAFEMODE RATHER THAN SHORT CIRCUIT TO GROUND VIA THE STARTER.

NHTSA ID 729088 · filed Aug 25, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Suspension

Reports naming suspension components — springs, struts, shocks, control arms and related hardware.

1
report

From owner reports, verbatim

FRONT SUSPENSION BOTTOMS CAUSING FRONT WHEELS TO HIT ON UNDERSIDE OF MOTORHOME FLOOR CAUSING MOMENTARY LOSS OF CONTROL. MAGNUM (CHASSIS MFG) STATES THAT 95 SAHARA WERE BUILT WITH WHEELS TOO CLOSE TO FLOOR. WITH LATER MODELS, WHEELS WERE LOCATED 1 INCH FURTHER AWAY FROM FLOOR. SAFARI IS AWARE OF PROBLEM AND HAS RETROFITTED 95 MODELS WITH LONGER "LEAF SPRING SHACKLE BRACKETS" ONLY FOR THOSE PEOPLE UNDER WARRANTY. SINCE I PURCHASED USED, CHASSIS WARRANTY IS VOID PER SAFARI. PROBLEM OCCURS AT ALL SPEEDS INCLUDING DURING BRAKING DOWN STEEP HILLS.

NHTSA ID 701115 · filed Dec 4, 1998

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .