1997 Saturn Sl Transmission Problems

TL* THE CONTACT OWNS A 1997 SATURN SL. THE CONTACT STATED THAT HE WAS REVERSING FROM A RESIDENTIAL DRIVEWAY WHEN HE SHIFTED TO FIRST GEAR AND THE SHIFTER CABLE BECAME DETACHED FROM THE SHIFTER LEVER. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THEY HAD TO REPLACE TWO SHIFTER CABLES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 127,000. UPDATED 7/26/12 *CN THE CONSUMER STATED THE ROOT OF THE PROBLEM WAS THE FAILURE OF A SMALL PLASTIC BUSHING USED TO JOIN THE SHIFTING LEVER TO THE SHIFTING CABLE IN A MANUAL TRANSMISSION. WHEN THE BUSHING FAILED, THE SHIFTING CABLE FELL OFF THE SHIFTING LEVER WHICH LEFT THE CONSUMER UNABLE TO SHIFT GEARS. THE CONSUMER STATED THE FAILURE HAPPENED WHILE HE WAS STOPPED IN HIS DRIVEWAY. THE DEALER WOULD NOT REPLACE THE BROKEN BUSHING, BUT INSTEAD REPLACED THE ENTIRE CABLE AS WELL AS AN ADJOINING CABLE. UPDATED 08/06/12

NHTSA ID

10463438

Incident

Jun 24, 2012

Mileage

127,000 mi

1997 SATURN SL, 4 DOOR SEDAN, MANUAL TRANSAXLE, 143000 MILES AT A PARKING LOT: SHIFTER CABLE PLASTIC BUSHING BROKE LOCKING MY TRANSAXLE IN REVERSE. PROBLEM FIXED WITH AN AFTERMARKET KIT SOLD BY NAPA AUTO STORES. *TR

NHTSA ID

10284235

Incident

Sep 16, 2009

Mileage

143,125 mi

TL*THE CONTACT OWNS A 1997 SATURN SL1. THE CONTACT STATED THAT WHEN ATTEMPTING TO SHIFT FROM 2ND TO 3RD GEAR THE SHIFT LEVER CABLE FRACTURED; THUS DISABLING THE VEHICLE FROM SHIFTING INTO 3RD GEAR. GEAR FAILURE WHILE DRIVING INCREASES THE RISK FOR VEHICLE CRASH. THE VEHICLE WAS TAKEN TO A DEALERSHIP IN WHICH THE SHIFT CABLE ASSEMBLY WAS REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 102000.

NHTSA ID

10281665

Incident

Aug 12, 2009

Mileage

102,000 mi

DRIVING ALONG COMMUNITY ROAD AND MANUAL SHIFT LINKAGE BECAME INOPERATIVE. FAILURE WAS TOTAL, SHIFTING WAS IMPOSSIBLE, WAS LUCKY TO BE ABLE TO GET TO THE SIDE OF THE ROAD. SATURN USED A PLASTIC PUSH-IN BUTTON TO RETAIN THE SHIFT MECHANISM TO THE EYELET OF THE SHIFT CABLE........A PLASTIC BUSHING FOR A PART OF THE CAR THAT IS CRITICAL! A REPLACEMENT WAS BUSHING FABRICATED OUT OF SUITABLE MATERIAL AND A TAPPED HOLE, AND BOLT, WAS ADDED TO THE SHIFTER ROD SO THAT COMPLETE FAILURE IS NOT POSSIBLE. TOO BAD DETROIT ENGINEERS SEEM TO HAVE FORGOTTEN THEIR RESPONSIBILITIES TO SOCIETY, THEY SHOULD BE ASHAMED TO PUT PEOPLES LIVES IN SUCH DANGER WITH SUCH A POOR DESIGN OF A CRITICAL PART. *TR

NHTSA ID

10273865

Incident

Jun 6, 2009

Mileage

82,000 mi

ON 13SEP2008, AT APPROXIMATELY 1400HRS I WAS OPERATING MY 1997 SATURN SL2 (MANUAL) AT LOW SPEED IN MY DRIVEWAY; WHEN THE VEHICLE FAILED TO ENGAGE IN GEAR. UPON FURTHER INVESTIGATION, I DISCOVERED THAT MY SHIFTING CABLE LINKAGE HAD BECOME DISENGAGED (SPECIFICALLY THE SHIFTING ROD AND THE PLASTIC BALL-JOINT COVER). AFTER ATTEMPTING TO LOCATE THE PART VIA LOCAL AUTO PART MERCHANTS I CONTACTED A LOCAL SATURN DEALERSHIP. I SPOKE TO A MEMBER OF THE SERVICE DEPARTMENT WHO INFORMED ME THAT THE DISENGAGEMENT OF THE SHIFTING ROD ASSEMBLY, AND CONCURRENT DAMAGE TO THE PLASTIC BALL-JOINT COVER WAS A COMMON PROBLEM. WHEN ASKED HOW MUCH IT WAS TO BUY THE PLASTIC BALL-JOINT COVER THE SERVICE EMPLOYEE INFORMED ME IT WOULD COST $195.00; BECAUSE ONE HAS TO BUY THE ENTIRE ASSEMBLY AND NOT JUST THE PLASTIC BALL-JOINT COVER. AT THIS TIME THE VEHICLE HAS YET TO BE REPAIRED. *TR

NHTSA ID

10242685

Incident

Sep 13, 1997

Mileage

133,000 mi

I RECENTLY PURCHASED A 1997 SL1 AND ON THE 3RD DAY OF OWNING IT THE SHIFTER BROKE CAUSING IT TO GO LIMP. AT THE TIME I WAS ON THE 101 FREEWAY STUCK IN TRAFFIC WITH MY THREE CHILDREN. I CALLED MY MECHANIC AND HE TOWED IT TO HIS SHOP FOR REPAIRS. AFTER MAKING THE NECESSARY REPAIR, HE DID A ROUTINE MAINTENANCE CHECK. THIS WAS WHEN HE DISCOVERED THE OIL HAD WATER MIXED IN WITH IT CAUSING A WHITE SMOKE ESCAPING FROM THE EXHAUST PIPE. I'M CERTAIN THIS PROBLEM WAS RECOGNIZED BY THE PREVIOUS OWNER AND MOST LIKELY WAS THE REASON FOR SELLING. AFTER READING THE FOLLOWING COMPLAINTS FROM CAR SURVEY, I BELIEVE SATURN ENGINEERED THIS VEHICLE "BY DESIGN" WITH THESE PROBLEMS AS A FORECAST FOR REVENUE. *TR

NHTSA ID

10223752

Incident

Apr 8, 2008

Mileage

118,075 mi

I RECENTLY PURCHASED A 1997 SL1 AND ON THE 3RD DAY OF OWNING IT THE SHIFTER BROKE CAUSING IT TO GO LIMP. AT THE TIME I WAS ON THE 101 FREEWAY STUCK IN TRAFFIC WITH MY THREE CHILDREN. I CALLED MY MECHANIC AND HE TOWED IT TO HIS SHOP FOR REPAIRS. AFTER MAKING THE NECESSARY REPAIR, HE DID A ROUTINE MAINTENANCE CHECK. THIS WAS WHEN HE DISCOVERED THE OIL HAD WATER MIXED IN WITH IT CAUSING A WHITE SMOKE ESCAPING FROM THE EXHAUST PIPE. I'M CERTAIN THIS PROBLEM WAS RECOGNIZED BY THE PREVIOUS OWNER AND MOST LIKELY WAS THE REASON FOR SELLING. AFTER READING THE FOLLOWING COMPLAINTS FROM CARSURVEY, (COMPLAINTS LISTED BELOW) I BELIEVE SATURN ENGINEERED THIS VEHICLE "BY DESIGN" WITH THESE PROBLEMS FORECASTING THEIR REVENUE. *TR

NHTSA ID

10223750

Incident

Apr 8, 2008

Mileage

118,075 mi

WHILE DRIVING 65 MPH IN FIRST GEAR TRANSMISSION SHIFTED TO FOURTH GEAR WITHOUT WARNING, AND CONSUMER TEMPORARILY LOST CONTROL OF THE VEHICLE. CONSUMER SHIFTED VEHICLE TO NEUTRAL, THEN BACK TO FIRST GEAR TO REGAIN CONTROL OF THE VEHICLE. DEALERSHIP MECHANIC TRIED TO REPAIR THE VEHICLE, BUT WAS UNABLE TO RESOLVE THE PROBLEM. *AK THE OCCUPANTS SUSTAINED MUSCLES PULLS, BUMPS, AND BRUISES. *NM

NHTSA ID

10050158

Incident

Nov 8, 2003

Mileage

44,409 mi

WE BROUGHT OUR SATURN INTO THE OAKLAND, CA DEALER FOR A TRANSMISSION DIAGNOSIS. AUTOMATIC TRANSMISSION HAS DEVELOPED SOME LEAKS AND CLUTCH / GEAR ASSEMBLY PROBLEMS. INITIAL QUOTE FROM THE DEALER SERVICE MANAGER FOR REPAIR IS $2600.00+. EXTENDED WARRANTY EXPIRED 12/31/02, AND THE CAR IS CURRENTLY AT THE 94,904 MILE MARK. AT THE 91,328 MILEAGE MARK, THE DEALER PERFORMED AN "87,000 MILE" SERVICE, NOT A "90,000 MILE" SERVICE. WHY DIDN'T THE SERVICE ADVISOR INFORM MY DAUGHTER THAT THE "90,000 MILE" SERVICE WAS DUE, WHICH INCLUDED A TRANSMISSION SERVICE? FROM MY PERSPECTIVE THIS APPEARS TO BE A CASE OF THIS DEALERSHIP NOT TRAINING THEIR SERVICE ADVISORS PROPERLY TO ADVISE A CUSTOMER REGARDING ROUTINE MAINTENANCE. THE CAR IS CURRENTLY AT THE 94,904 MILE MARK, AND IT SEEMS REASONABLE THAT IF THE DEALER HAD PERFORMED THE "90,000 MILE" SERVICE WHEN THE CAR WAS AT THE 91,328 MILEAGE MARK AND INSPECTED THE TRANSMISSION THESE PROBLEMS WOULD HAVE BEEN IDENTIFIED AND REPAIRED WHILE THE CAR STILL UNDER WARRANTY. SATURN HAS ISSUED AT LEAST ONE DOZEN SERVICE BULLETINS REGARDING MAINTENANCE OF THIS TRANSMISSION SEVERAL TARGETED TO THE SPECIFIC ISSUE OF TRANSMISSION LEAKS AND REPAIRS. DOES THIS SATURN DEALER HAVE A PATTERN OF NOT INFORMING FEMALE CUSTOMERS ABOUT RECOMMENDED MAINTENANCE? IS THIS AN ISSUE AT OTHER SATURN DEALERS? IS THIS A CASE OF GENDER BIAS SINCE THE MALE SERVICE ADVISOR DID NOT COMMUNICATE THE FACTORY RECOMMENDATIONS TO A FEMALE CUSTOMER? MAINTENANCE WORK BY THE SATURN OAKLAND (CA)DEALER:FUEL PUMP REPLACED, WATER PUMP REPLACED, WINDOW MECHANISMS REPLACED, DRIVE BELT REPLACED, IDLER PULLEY REPLACED, MOTOR MOUNTS REPLACED, ALTERNATOR REPLACED, THE POWER STEERING PUMP REPLACED. WE DON'T UNDERSTAND HOW THEY COULD HAVE INSPECTED/DIAGNOSED/REPAIRED ALL THESE ITEMS AND NOT HAVE INCLUDED THE TRANSMISSION MAINTENANCE AT KEY MILEAGE MILESTONES. *NLM

NHTSA ID

10018432

Incident

Nov 27, 2002

Mileage

91,328 mi

WHILE DRIVING, THE SHIFTED CABLE BUSHING (WHICH IS MADE OF PLASTIC) BROKE PREVENTING THE DRIVER FROM BEING ABLE TO SHIFT GEARS. NLM

NHTSA ID

566856

Incident

Jun 28, 2002

VALVE BODY IN AUTOMATIC TRANSMISSION NEEDS TO BE REPLACED. VEHICLE CANNOT BE PUT INTO REVERSE. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING. *AK

NHTSA ID

8004668

Incident

Feb 1, 2002

WAS DRIVING APPROXIMATELY 50MPH AND WAS MERGING INTO TRAFFIC WHEN TRANSMISSION LOCKED IN GEAR AND FAILED TO CHANGE.*AK CONSUMER STATED PRIOR TO PURCHASING VEHICLE SHE COMPLAINED OF A CLUNK NOISE WHEN CHANGED GEARS INTO REVERSE, ALSO THE DRIVER SIDE BRAKE LIGHT IS INOPERABLE, ALSO THE RIGHT SIDE MIRROR NEEDED TO BE REPLACED, ENGINE MOUNTS WERE REPLACED,BRAKES WERE REPLACED, SERPENTINE BELT WAS CRACKED, ENGINE OVERHEATS.*SLC

NHTSA ID

898710

Incident

Oct 20, 2001

DEFECTIVE TRANSMISSION, WHEN PUTTING VEHICLE INTO GEAR THERE WAS A CLUNKING NOISE. AN ADDITIONAL PROBLEM WAS THE FORWARD GEARS WHICH FAILED AND WERE NOT WORKING. DEALSHIP WAS AWARE OF PROBLEM. *AK

NHTSA ID

898687

Incident

Aug 1, 2001

LEAK DISCOVERED WHEN GETTING OIL CHANGED. TOOK IT TO DEALER, ADVISED NOT SAFE TO DRIVE, REPLACED SHIFT GEAR.. 5 MONTHS LATER LEAKS AGAIN. *AK

NHTSA ID

717177

Incident

Dec 27, 1999

ONGOING PROBEM WITH TRANSMISSION NOT CHANGING GEARS PROPERLY ON ANY SPEED, AND SLOW RESPONDING FROM A STOP POSITION/TAKE OFF, HESITATION. ALSO, BRAKE PEDAL WOULD INTERMITTENTLY GO TO THE FLOOR BEFORE VEHICLE STOPPED. DEALER NOTIFIED ON THREE OCCASIONS, AND WAS INFORMED THAT NOTHING COULD BE FOUND CONSUMER IS CONCERNED THAT THIS VEHICLE IS UNSAFE TO OPERATE, AND WILL BE TRADING IT IN WITHIN A FEW MONT ASKING NHTSA TO LOOK INTO THIS MATTER BEFORE PASSING IT ON . *AK

NHTSA ID

850779

Incident

Oct 15, 1997

DURING MINOR IMPACT THE PASSENGER SIDE AIR BAG DEPLOYED VIOLENTLY CAUSING FACIAL INJURY AND JAW PAIN TO PASSENGER. NLM

NHTSA ID

548632

Incident

Jun 1, 1999

TRANSMISSION--BUSHING WENT OUT. SPARK MISFIRE--COMPUTER MODULE WAS REPLACED BY DEALER.

NHTSA ID

609776

Incident

Jul 9, 1998

THE E- CLIP ON STICK SHIFT THAT HOLDS THE SHIFT CABLE KEEPS DISMOUNTING. WHEN THIS HAPPENS THE VEHICLE IS NOT ABLE TO BE PUT INTO GEAR. DEALER HAS BEEN CONTACTED. *AK

NHTSA ID

836899

TRANSMISSION REQUIRED REPAIR ON THREE OCCASIONS, VALVE BODY, CONNECTOR AND GASKET, FAILURES CAUSING SLIPPING. MJS

NHTSA ID

607972

Incident

Jul 28, 1997

SEAT BELT RETRACTOR EXPERIENCING FAILURE. *YC

NHTSA ID

606609

Incident

Oct 1, 1996

TRANSMISSION HAS NO POWER, THE GAS LEVEL IS VERY POOR ON A HILL, SOMETIMES WILL NOT GO UP HILL AT ALL, LOSING RPMS. DEALER CONTACTED, AND CANNOT REMEDY THE PROBLEM. PROBLEM STILL EXISTS. PROVIDE FURTHER INFORMATION. *AK

NHTSA ID

833565

Incident

Jul 1, 1997

TRANSMISSION FAILURE.

NHTSA ID

602568

Incident

Sep 6, 1996