2001 Saturn Sl Problems

I HAVE SOO MUCH PROBLEM WITH THIS CAR

MY SATURN THAT I'VE BEEN DRIVING FOR ABOUT A YEAR AND A HALF NOW, COMPLETELY CUT OFF IN THE MIDDLE OF ME DRIVING IT. LUCKILY I WAS AT A DRIVE THEY SO SO SERIOUS DAMAGE TO ME OR ANYONE ELSE. COULD NOT GET IT TO START BACK UP FOR A GOOD 5-10 MINS. ALSO THE TRANSMISSION IS GOING OUT IN IT AND I'M CONSTANTLY HAVING TO ADD FLUID SO IT DOESNT SKIP. THE REAR TAIL LIGHTS KEEP HAVING TO BE REPLACED BECAUSE THEY KEEP BLOWING OUT.

MY SATURN THAT I'VE BEEN DRIVING FOR ABOUT A YEAR AND A HALF NOW, COMPLETELY CUT OFF IN THE MIDDLE OF ME DRIVING IT. LUCKILY I WAS AT A DRIVE THEY SO SO SERIOUS DAMAGE TO ME OR ANYONE ELSE. COULD NOT GET IT TO START BACK UP FOR A GOOD 5-10 MINS. ALSO THE TRANSMISSION IS GOING OUT IN IT AND I'M CONSTANTLY HAVING TO ADD FLUID SO IT DOESNT SKIP. THE REAR TAIL LIGHTS KEEP HAVING TO BE REPLACED BECAUSE THEY KEEP BLOWING OUT.

1ST INCIDENT: I WENT IN TO THE SATURN DEALER FOR AN OIL CHANGE AND THE DEALER FOUND A FUEL LEAK BETWEEN THE TANK AND THE FILTER. THERE WAS FUEL ON TOP OF THE TANK TOP AND ALSO DRIPPING DOWN THE SIDE. THE DEALER SAID THERE WAS A CRACKED LINE IN THE FUEL SYSTEM CLOSE TO THE TANK TOP. I HAD TO REPLACE THE FUEL PUMP ASSEMBLY IN ORDER TO REPAIR THE LEAK OF MY POCKET AS IT WAS NOT COVERED BY THE WARRANTY. 2ND INCIDENT: YESTERDAY I WENT FOR A STATE INSPECTION AT THE LOCAL CHEVROLET DEALER THAT TAKES CARE OF MY SATURN AND THEY REPORTED THAT I HAVE A FUEL TANK LEAKING AND HAVE TO REPLACE THE FUEL PUMP. BECAUSE OF THIS IT FAILED THE STATE INSPECTION. MY CAR CURRENTLY HAS ONLY 41152 MILES ON IT AND IS DRIVEN MOSTLY FOR PLEASURE. IS THERE A CURRENT RECALL ON THE FUEL PUMP ASSEMBLY OR THE FUEL TANKS OF THE SATURN L300 SERIES? *TR

TL* THE CONTACT OWNS A 2001 SATURN SL1. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, HE HEARD A LOUD NOISE AND THE VEHICLE STARTED SHAKING EXCESSIVELY. NEITHER THE DEALER NOR THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INFORMED THE CONTACT THAT THE TRANSMISSION VALVE BODY WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE CONTACT WAS AWAITING REPAIRS. THE CURRENT AND THE FAILURE MILEAGES WERE 132,000. ....UPDATED 12/03/12 *BF UPDATED 01/11/12

SATURN 2001 SL1, MY GIRLFRIEND WAS DRIVING THE CAR AND CALLED ME SAYING THAT IT WAS KNOCKING SHE ONLY DROVE IT AROUND THE BLOCK DUE TO HER BEING SCARED OF THE SOUNDS. I THEN DROVE THE CAR AROUND TO ENSURE THAT IT WAS A TRANSMISSION PROBLEM. THE CAR HAS 97,000 MILES ON IT AND I JUST HAD THE O2 SENSOR CHANGED FOR AN IDLE HIGH ISSUE. I ALSO HAD TO CLEAN OUT THE IDLE AIR CONTROL VALVE DUE TO BUILD UP AND FAULTY OPERATION. I BROUGHT MY CAR TO AAMCO TO ENSURE THE TRANSMISSION IS TAKEN CARE OF PROPERLY. THEY HAVE TO REBUILD THE TRANSMISSION REPLACING EVERY PART INSIDE THE CASING. 2,480$ IN THE HOLE, SO I BETTER NOT HAVE ANYMORE ISSUES WITH THIS CAR AFTER THIS. ALSO THE DOOR LOCK GETS STUCK ON THE DRIVER SIDE, SO YOU HAVE TO MANUALLY PUSH OVER THE LEAVER EVERY TIME YOU EXIT THE VEHICLE. *TR

WHILE ACCELERATING FROM A LIGHT UP TO ~20MPH THERE WAS THE SMELL OF BRAKE FLUID/RUBBER BURNING. WHEN TRAFFIC SLOWED AGAIN BRAKES HAD NO RESPONSE EVEN WHEN PRESS ALL THE WAY TO THE FLOOR. CAR WAS STOPPED IN TIME TO AVOID ACCIDENT BY APPLICATION OF EMERGENCY BRAKE AND PLACING THE CAR IN NEUTRAL. PUMPING THE BRAKES FAILED TO REGAIN PRESSURE THOUGH AFTER DRIVING TO THE SIDE OF THE ROAD WITH EBRAKE AND RESTARTING CAR A HARD PUMP OF THE BRAKES HAD SOME RESISTANCE. FURTHER CAUTIOUS DRIVING AND PRESSURE REBUILT. AFTER INSPECTION AT THE SHOP NO EXPLANATION FOR THE EVENT COULD BE FOUND. *TR

THE CONSUMER STATED THE BRAKE PADS WEAR PREMATURELY. THE PART HAS BEEN REPLACED FIVE TIMES WITHIN ONE YEAR. THE CAUSE HAS NOT BEEN DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB

I HAVE SOO MUCH PROBLEM WITH THIS CAR

OUR DAUGHTER WAS INVOLVED IN A MOTOR VEHICLE ACCIDENT ON 10/9/2014. A VEHICLE PULLED OUT IN FRONT OF HER. OUR DAUGHTER WAS NOT ABLE TO STOP IN TIME AND HIT THE VEHICLE WITH THE FRONT END OF THE SATURN TO THE DRIVERS DOOR OF THE OTHER VEHICLE. AIR BAGS DID NOT DEPLOY BUT WE BELIEVE THEY SHOULD HAVE. OUR DAUGHTER SUSTAINED INJURIES. *TR

WHILE BEING DRIVEN 40 MPH, THE OWNER NOTICED A VEHICLE DRIVING ERRATIC AND SLAMMED ON THE BRAKES. THE DRIVER CLIPPED THE OTHER VEHICLE IN THE PROCESS. THE REAR SEAT BACK LATCH FAILED ALLOWING THE REAR SEAT BACK TO FALL ON TOP OF THE CHILD BELTED IN THE REAR. A MECHANIC, WAS UNABLE TO RELATCH THE SEAT BACK. PLEASE DESCRIBE DETAILS TS

THE DRIVER SIDE SEAT LOCK WILL NOT STAY IN PLACE IN ORDER TO LOCK THE SEAT DOWN. THE DEALERSHIP IS AWARE OF THE PROBLEM.*JB

I HAVE SOO MUCH PROBLEM WITH THIS CAR

SUNROOF MODULE TO BE REPLACED 2 YEARS AFTER THE MOTOR WAS REPLACED....*NM

The problem is with the Firestone Tempa Spare T115/70 R14 spare tire. This tire came with the car when new, and has never been used. Tire date of manufacture is 42 2000. I periodically check its air pressure, but it has never been out of the spare tire well. I checked the pressure 1 week ago, and found a large bulge in the tread, along with broken cords, both steel, and polyester (see photos). The inner tire liner has not ruptured, and the tire still holds air. One month ago I checked the pressure, and it looked completely normal. If I had a flat tire then, I would have put it on the car without hesitation. I suspect that it would have failed on the road leading to a possible disaster. My reason for alerting NHTSA is that I suspect there are many compact spare tires in people's trunks, in the same condition, just waiting to cause trouble. I brought it to a Firestone store and they showed no interest in it. I have removed the tire from the steel wheel, and you are welcome to have it to inspect. I live about 25 miles south of Chicago, IL. When you look at the attached photos, numbers 1-3 show the tire on the steel wheel with the tire inflated, number 4 shows the tire deflated, and off the wheel.

I AM SEEING A PATTERN OF SEVERE DRY ROT STRESS CRACKS IN ALL, NEARLY NEW (LESS THAN 12 MONTHS OLD) MICHELIN AND UNIROYAL TIRES IN THE TREAD AREA FIRST THEN LATER THE SIDEWALLS, AND EVEN GOODYEAR TIRES IN JUST 1-2 YEARS. ALL THESE TIRES CAME FROM WALMART. I HAVE THEM ON 6 VEHICLES, ALL WITH THE SAME PROBLEMS. I HAVE BEEN BUYING TIRES FOR OVER 38 YEARS, AND NEVER HAD THIS PROBLEM TILL THE LAST FEW YEARS. THIS NEEDS TO BE INVESTIGATED AND DEALT WITH QUICKLY. I AM A DEGREED CHEMICAL ENGINEER AND I DO ALL MY OWN AUTO REPAIRS, EVEN MAJOR REBUILDS, IN OTHER WORDS I AM VERY EXPERIENCED AND I SEE A VERY DANGEROUS SAFETY AND CONSUMER ISSUE HERE!!!! *TR

MY SATURN THAT I'VE BEEN DRIVING FOR ABOUT A YEAR AND A HALF NOW, COMPLETELY CUT OFF IN THE MIDDLE OF ME DRIVING IT. LUCKILY I WAS AT A DRIVE THEY SO SO SERIOUS DAMAGE TO ME OR ANYONE ELSE. COULD NOT GET IT TO START BACK UP FOR A GOOD 5-10 MINS. ALSO THE TRANSMISSION IS GOING OUT IN IT AND I'M CONSTANTLY HAVING TO ADD FLUID SO IT DOESNT SKIP. THE REAR TAIL LIGHTS KEEP HAVING TO BE REPLACED BECAUSE THEY KEEP BLOWING OUT.

2002 SATURN SL1. CUSTOMER STATED THAT THE LOW BEAM LIGHTS CUT OFF INTERMITTENTLY**CC THE VEHICLE HAS BEEN TAKEN TO THE DEALER BUT THEY HAVE BEEN UNABLE TO FIX THE PROBLEM. THE HIGH BEAM LIGHTS WORK FINE. THE DASH LIGHT ALSO STOPPED WORKING. *NM

SATURN 2001 ION IGNITION - CAR WON'T START BECAUSE KEY WON'T TURN THIS IS A KNOWN PROBLEM WITH SATURNS AND IS A BAD SAFETY ISSUE. PEOPLE ARE STRANDED WITH VEHICLES THAT WON'T START OR SOMETIMES EVEN TURN OFF. THIS IS AWFUL, AND SATURN KNOWS ABOUT IT, AND GM IS ASKING FOR A BAILOUT? THIS SHOULD BE A RECALL. IF GOVERNMENT WON'T FORCE A RECALL ON KNOWN ISSUES, THE COMPANY WINDS UP GOING EXTINCT DUE TO POOR QUALITY ISSUES. RECALL THIS! *TR

THE STEERING COLUMN BROKE WHILE THE VEHICLE WAS BEING DRIVEN. THE HEAT/AIR VENTS DID NOT WORK. *JB

AUTOMATIC WINDOWS DO NOT FUNCTION ON SATURN SL2. *TR

THE STEERING COLUMN BROKE WHILE THE VEHICLE WAS BEING DRIVEN. THE HEAT/AIR VENTS DID NOT WORK. *JB

THE 2001 SATURN SL1 GAS PEDAL CONSTANTLY STICKS. IT IS HARD TO PUSH DOWN EITHER DRIVING FORWARD OR REVERSE. THE BRAKES MUST BE APPLIED BEFORE YOU CAN ENGAGE THE GAS PEDAL WHICH HAS ALMOST CAUSED SEVERAL ACCIDENTS WHILE DRIVING UNDER THIS CONDITION. *JB

FREEZING ACCELERATOR ON 2001 SATURN SL1.ODAY I EXPERIENCED A FROZEN ACCELERATOR CABLE WHICH CAUSED THE CAR TO ACCELERATE VERY RAPIDLY. I HAD DRIVEN ABOUT 80 MILES AND STOPPED AT A STORE. WHEN I CAME OUT OF THE STORE, I STARTED THE CAR AND BACKED OUT OF THE PARKING SLOT. WHEN I THEN STARTED TO GO FORWARD, AND PRESSED THE ACCELERATOR, IT FROZE UP AT A RATHER HIGH SPEED. RELEASING THE PRESSURE ON THE PEDAL DID NOT CAUSE THE PEDAL TO RETURN TO IDLE . THE OUTSIDE TEMPERATURE WAS ZERO DEGREES. I WAS ABLE TO TURN THE KEY OFF AND AFTER WORKING THE ACCELERATOR PEDAL AND CABLE FOR ABOUT THREE OR FOUR MINUTES (FROM UNDER THE HOOD AND THE DRIVER SEAT-TOOK TWO PEOPLE) I WAS ABLE TO FREE UP THE CABLE. I WOULD LIKE TO KNOW IF THERE IS A RECALL OR TECH BULLETIN ABOUT THIS, AND IF NOT, SUGGEST THAT ONE BE ISSUED IMMEDIATELY. IT HAPPENED AGAIN A FEW HOURS LATER BUT I WAS PREPARED AND TESTED IT BEFORE I PUT THE CAR IN GEAR. THE CABLE APPEARS TO BE FREEZING INSIDE THE SHAFT. IT DOES NOT NECESSARILY DO IT THE FIRST TIME THE ACELERATOR IS DEPRESSED IN THE COLD WEATHER. I BROUHGT THE CAR HOME AND WILL NOT DRIVE IT AGAIN UNTIL THE WEATHER WARMS UP. I DID CALL SATURN CUSTOMER SERVICE AND THEY ARE NOT AWARE OF THE PROBLEM AND CAN NOT DO ANYTHING UNLESS A SATURN DEALER DIAGNOSES THE PROBLEM THE NEAREST SATURN DEALER TO ME IS 75 MILES AND SINCE THE WEATHER IS STILL MINUS 4 DEGREES TODAY, I WILL NOT DRIVE THE CAR TO THE DEALER DO TO THE PROBLEM. I SPOKE WITH A LOCAL GENERAL MOTORS DEALER AND HE HAS HAD OTHER SATURNS IN WITH THE PROBLEM. SUGGEST AN ALERT OR WARNING TO OWNERS AND DRIVERS BE ISSUED.*AK

1ST INCIDENT: I WENT IN TO THE SATURN DEALER FOR AN OIL CHANGE AND THE DEALER FOUND A FUEL LEAK BETWEEN THE TANK AND THE FILTER. THERE WAS FUEL ON TOP OF THE TANK TOP AND ALSO DRIPPING DOWN THE SIDE. THE DEALER SAID THERE WAS A CRACKED LINE IN THE FUEL SYSTEM CLOSE TO THE TANK TOP. I HAD TO REPLACE THE FUEL PUMP ASSEMBLY IN ORDER TO REPAIR THE LEAK OF MY POCKET AS IT WAS NOT COVERED BY THE WARRANTY. 2ND INCIDENT: YESTERDAY I WENT FOR A STATE INSPECTION AT THE LOCAL CHEVROLET DEALER THAT TAKES CARE OF MY SATURN AND THEY REPORTED THAT I HAVE A FUEL TANK LEAKING AND HAVE TO REPLACE THE FUEL PUMP. BECAUSE OF THIS IT FAILED THE STATE INSPECTION. MY CAR CURRENTLY HAS ONLY 41152 MILES ON IT AND IS DRIVEN MOSTLY FOR PLEASURE. IS THERE A CURRENT RECALL ON THE FUEL PUMP ASSEMBLY OR THE FUEL TANKS OF THE SATURN L300 SERIES? *TR

I SAW A RECALL ON YOUR WEB SITE THAT DESCRIBED THE SAME REPAIR I NEED TO PASS EMISSIONS ON MY 2001 SATURN SL1. IT IS A FUEL TANK VENT VALVE. I CONTACTED THE SATURN DEALER AND THEY SAY THERE IS NO RECALL ON MY VEHICLE AND REFUSE TO FIX. I CAN HAVE ANOTHER DIAGNOSTIC WHICH I HAD ALREADY AND IT WILL COST $85. I AM GOING TO PAY FOR THE WORK TO BE DONE NOW AND IT IS EXPENSIVE FOR A PROBLEM THAT WAS RECALLED ON NUMEROUS VEHICLES THE SAME AS MINE. I FEEL THIS IS WRONG. HOW CAN YOU HAVE A RECALL ON THE SAME ITEM AND NOT PUT IT ON ALL VEHICLES MADE WITH THE BAD PART? *TR

THE VEHICLE BRAKE ROTOR WARP SEVERAL TIMES WHICH CAUSED VIBRATION WHILE BRAKING. THE DEALER REPLACED THE ROTORS. WHEN THE VEHICLE WAS MOVED FROM A STOP THE VEHICLE JERKED FORWARD. THE VEHICLE ALSO ACTS AS IF IT WANT TO STALL WHEN SITTING IDLE. THE DEALER WAS UNABLE TO DUPLICATE EITHER CONCERN. THE RADIO LIGHT WAS INOPERATIVE THEREFORE THE DEALER REPLACED THE RADIO. *AK *CB *NLM

THE AXLE SQUEAKED WHILE THE VEHICLE WAS IN MOTION.*JB. FRONT LEFT AXLE HAS BEEN REPLACED, BUT NOISE CONTINUED. CONSUMER TOOK VEHICLE TO ANOTHER DEALER WHERE THE TECHNICIAN LOCATED THE PROBLEM-AXLE SEALS. TECHNICIAN REPLACED BOTH AXLE SEALS, AND PROBLEM HAS BEEN SOLVED. *AK

WHILE BACKING THE CAR OUT OF THE DRIVE WAY THE SPRING ON THE RIGHT FRONT STRUT BROKE COLLAPSING THE SUSPENSION. *JB

HOOD WAS DENTED UPWARDS, AND UPON EXAMINATION FOUND THAT FRONT LEFT STRUT TOWER DISCONNECTED AT AN UNKNOWN TIME. UPON EXAMINATION, CONSUMER NOTICED THAT LEFT STRUT TOWER ONLY HAD 3 SPOT WELDS AS OPPOSED TO 11 SPOT WELDS ON THE RIGHT FRONT STRUT TOWER. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK