2025 Subaru Forester Problems

Two occurences of rear hatch window shattering spontaneously while vehicle was parked, powered off. No symptoms, warning lamps, or messages were present. First incident, six months after production/purchase, factory-installed window shattered spontaneously while owner was seated in the car, parked, and engine turned off. Second incident, two months later, OEE replacement window shattered while vehicle was parked, powered off, unattended. Currently having third window installed by dealer and submitting report to Subaru of America.

On March 12, 2026, my 2025 Subaru Forester Hybrid, owned for less than 1 month at the time and purchased on 2/14/2026, sustained a star chip to the windshield during normal driving conditions. While the physical damage itself was minor, the vehicle is equipped with Subaru EyeSight, a camera-based advanced driver assistance system (ADAS) that relies on precise optical clarity through the windshield. I'm now required to have the windshield replaced, because the manufacturer and dealer requires it. According to both Subaru and the vehicle’s owner’s manual (page 15), windshield replacement must be performed using OEM (Original Equipment Manufacturer) glass to ensure proper calibration and safe operation of the EyeSight system. My insurance provider is attempting to authorize the use of aftermarket (non-OEM) windshield glass despite this. This presents a serious safety concern. The EyeSight system controls or assists with critical safety functions including pre-collision braking, adaptive cruise control, and lane keep assist. Aftermarket glass can introduce optical distortion or variation that can interfere with camera calibration and system performance. Using non-OEM glass in a vehicle designed around camera-based safety systems creates a risk that these features may not function as intended, potentially increasing the likelihood of a crash. This directly impacts federally recognized vehicle safety systems. There appears to be a gap between manufacturer safety requirements and insurance replacement practices. Consumers are being placed in a position where cost-saving measures may override safety-critical specifications. I'm requesting that NHTSA open a formal safety investigation into the use of non-OEM (aftermarket) windshields in vehicles equipped with camera-based ADAS systems. I further request that NHTSA establish clear regulatory guidance or requirements ensuring that windshield replacements follow manufacturer specifications, including the use of OEM glass.

The contact owns a 2025 Subaru Forester. The contact stated that while pulling into a parking space, the brake pedal was slightly released to move the vehicle forward; however, the vehicle unintendedly accelerated, failed to respond upon depression of the brake pedal, and crashed into a brick wall. The impact resulted in damages to the front bumper and caused a body panel to detach. No warning light was illuminated before or after the crash. The air bags did not deploy. There was no property damage, no reported injury, and no Police report was filed. The vehicle was driven to the dealer, where Subaru field technicians inspected the Event Data Recorder (EDR) and informed the contact that no data was recorded. The manufacturer was contacted and informed the contact that data was not logged because the vehicle was traveling at a significantly slow speed. The vehicle was not diagnosed or repaired. Additionally, the contact stated that a previously owned 2021 Subaru Forester had experienced the same failure, which also resulted in a crash, and a Police report was filed. The failure mileage was approximately 1,200.

I have been having problems with my 2025 Subaru Forester since I purchased it. It has failed multiple times to alert me of people and cars when I am backing up. I have RCTW on my vehicle .Sometimes it alerts me when there is a car or person is coming behind me ,sometimes it doesn't. I have a video dated June 4th 2026. Three times people walked right behind my car when I was backing up. I almost hit them! I decided to video tape it. The back up camera also doesn't always work and did not go off when I was backing into the curb until I hit it without an alarm going off. The lighting alert system was also messed up because the light was on green until I almost hit the curb. This also happened on June 4th and I have a video. I could have hit a small animal or child or damaged my car. I have brought this to the attention of my Subaru Service department and they claim they can not replicate this problem.This is of great concern for me and I have filed a Lemon Law Case as I am too fearful I will hurt someone or myself because of these issues. In addition to this, my headlights are aimed down at the ground and I live on curvy country roads. Hard to see at night. My service department said Subaru of America would have to approve the adjustment. They never got back to me on this issue. The tech specialist told the service department manager that I had electrical problems with my vehicle as she witnessed the HVAC working improperly. My radio, navigations, phone and sound systems also cause distracted driving. The Radio would blast on high volume randomly . The navigation, phone and radio volume would be blasting without being able to turn this down. There is no way to turn off the radio. If you do, the whole navigations screen won't work. My navigation system is not functioning properly and has blacked out . Subaru has seen my vehicle 6 times for these issues . They claim they can't replicate the problem. My car is sitting in the garage. It is too unsafe to drive.

Engine is misfiring, causing in ability to accelerate properly and loads multiple error codes. Upon taking it to the dealership for services, we were told that there is a significant amount of carbon built-up inside the engine. The car has only 6,800 miles on it. The dealership stated that it is an issue that Subaru engineering is aware of but has yet to figure a way to resolve it. The dealership informed us that hybrid engines have had severe carbon build-up on the in-take valves that causes misfiring, loss of power, bucking and stumbling of the engine. Apparently this has been reported all over different on-line forums. The dealer informed us that they would need to order a valve cleaning kit as referenced un service bulletin 02-193-24 and the engine would require walnut blasting. The vehicle was dropped off for service on 7/22 the work was completed, but upon restarting the engine more codes fired up and they stated that the Electronic Communication Module failed and it would now require an escalation to the Subaru Engineers called TechLine, "they now say that the ECM now needs replacement, still misfiring and has become a more complicated issue"

the gas cap O ring recall was repaired previously by Casey Subaru of Newport News, VA. (I live in [XXX], purchased the vehicle in [XXX] at Ourisman Subaru) I filled my gas tank the night before this leak occurred. I noticed the smell of gasoline in my car at approximately 08 AM on the way to work. It was mild No obvious exterior leak. I drove my 25 commute to Williamsburg, Va. Upon leaving work I noticed a strong smell of gasoline inside the vehicle. Inspection of the exterior revealed an obvious gas leak (the fuel door to the gas cap was not opened at this time). the paint was wet and the paint adjacent to the plastic guard on the bumper side had bubbled due to the leak. The outside temperature was nearing 100 with a heat index of 105. I drove the vehicle to the dealership in Newport News (not aware I should have had it towed due to the leak). It has not been driven since. The fuel door was opened and there was an obvious leak as the well in the gas cap space was wet and the odor of gasoline was very strong. I twisted the gas cap and it did not close any farther. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Significant issues with adaptive headlights having a large shadow in middle of beam as well as two smaller dark shadows at end of beam that are very distracting. It also dims very low at times severely reducing my visibility especially at different grades of the road. The headlights were so bad from the first week I tried to get the sales manager at Ciocca Subaru in Allentown to take this car back and to return my old car with no luck. I fear for safety driving this forester and I see it is a common complaint online for the 2025. Oncoming cars it shrinks the headlights significantly impairing my visibility for my side of road especially since in Pennsylvania we have a significant amount of deer that get hit and need clear visibility ahead of us. My coworker drove with me the one night and said how difficult it was for her to see at times and said I had to log a complaint because she was concerned for my safety. No car should have such significant shadows or adjusting the beam so significantly. I am afraid I will get into an accident because of the visibility of these headlights.

After my purchase of my 2025 Subaru Forester, I finally drove it for the first time at night. I was driving on local roads which have no street lights and is very hilly and dark. My headlights were on and I was shocked to see how poorly they were operating compared to my former 2016 Subaru Forester which I never had a problem with. My headlights even had strange dark marks projected onto the road surface. My headlights in the low beam settings, appears to be too low on the road surface especially if there’s a hill up ahead. There is a very dark area above the lit road surface and you can not see if there is a road hazard there or not. It’s very scary, especially when there are many deer in my area. This leaves me to have to keep my high beams on which I never had to do on my 2016. But my vehicle has a feature where my high beams automatically go on and off during night driving. At first, I did not realize I had this feature until I saw it operating on its own one night while driving on a dark lever road surface. The high beams would go on automatically and then go off when another vehicle was approaching from the opposite direction. But when I turned off to drive on hilly local roads, that feature stopped working and I didn’t understand why. That’s when I had to use the high beams manually. Being frustrated by this, on October 15, I took my vehicle to the dealership and had one of the salesman explain to me why my high beams do not always work. He then looked at the vehicles settings and everything was in proper order. He told me that the service department could possibly raise the headlights, but he said that doesn’t always work. All in all, I feel that these headlights are a hazard when driving at night on dark hilly road surfaces. I try not to drive at night because of this, but now that it’s getting darker earlier, that’s going to be difficult.

I have been having problems with my 2025 Subaru Forester since I purchased it. It has failed multiple times to alert me of people and cars when I am backing up. I have RCTW on my vehicle .Sometimes it alerts me when there is a car or person is coming behind me ,sometimes it doesn't. I have a video dated June 4th 2026. Three times people walked right behind my car when I was backing up. I almost hit them! I decided to video tape it. The back up camera also doesn't always work and did not go off when I was backing into the curb until I hit it without an alarm going off. The lighting alert system was also messed up because the light was on green until I almost hit the curb. This also happened on June 4th and I have a video. I could have hit a small animal or child or damaged my car. I have brought this to the attention of my Subaru Service department and they claim they can not replicate this problem.This is of great concern for me and I have filed a Lemon Law Case as I am too fearful I will hurt someone or myself because of these issues. In addition to this, my headlights are aimed down at the ground and I live on curvy country roads. Hard to see at night. My service department said Subaru of America would have to approve the adjustment. They never got back to me on this issue. The tech specialist told the service department manager that I had electrical problems with my vehicle as she witnessed the HVAC working improperly. My radio, navigations, phone and sound systems also cause distracted driving. The Radio would blast on high volume randomly . The navigation, phone and radio volume would be blasting without being able to turn this down. There is no way to turn off the radio. If you do, the whole navigations screen won't work. My navigation system is not functioning properly and has blacked out . Subaru has seen my vehicle 6 times for these issues . They claim they can't replicate the problem. My car is sitting in the garage. It is too unsafe to drive.

I have been having problems with my 2025 Subaru Forester since I purchased it. It has failed multiple times to alert me of people and cars when I am backing up. I have RCTW on my vehicle .Sometimes it alerts me when there is a car or person is coming behind me ,sometimes it doesn't. I have a video dated June 4th 2026. Three times people walked right behind my car when I was backing up. I almost hit them! I decided to video tape it. The back up camera also doesn't always work and did not go off when I was backing into the curb until I hit it without an alarm going off. The lighting alert system was also messed up because the light was on green until I almost hit the curb. This also happened on June 4th and I have a video. I could have hit a small animal or child or damaged my car. I have brought this to the attention of my Subaru Service department and they claim they can not replicate this problem.This is of great concern for me and I have filed a Lemon Law Case as I am too fearful I will hurt someone or myself because of these issues. In addition to this, my headlights are aimed down at the ground and I live on curvy country roads. Hard to see at night. My service department said Subaru of America would have to approve the adjustment. They never got back to me on this issue. The tech specialist told the service department manager that I had electrical problems with my vehicle as she witnessed the HVAC working improperly. My radio, navigations, phone and sound systems also cause distracted driving. The Radio would blast on high volume randomly . The navigation, phone and radio volume would be blasting without being able to turn this down. There is no way to turn off the radio. If you do, the whole navigations screen won't work. My navigation system is not functioning properly and has blacked out . Subaru has seen my vehicle 6 times for these issues . They claim they can't replicate the problem. My car is sitting in the garage. It is too unsafe to drive.

The contact owns a 2025 Subaru Forester. The contact stated that while pulling into a parking space, the brake pedal was slightly released to move the vehicle forward; however, the vehicle unintendedly accelerated, failed to respond upon depression of the brake pedal, and crashed into a brick wall. The impact resulted in damages to the front bumper and caused a body panel to detach. No warning light was illuminated before or after the crash. The air bags did not deploy. There was no property damage, no reported injury, and no Police report was filed. The vehicle was driven to the dealer, where Subaru field technicians inspected the Event Data Recorder (EDR) and informed the contact that no data was recorded. The manufacturer was contacted and informed the contact that data was not logged because the vehicle was traveling at a significantly slow speed. The vehicle was not diagnosed or repaired. Additionally, the contact stated that a previously owned 2021 Subaru Forester had experienced the same failure, which also resulted in a crash, and a Police report was filed. The failure mileage was approximately 1,200.

My new vehicle, with under 4,000 miles, has already suffered multiple chewed wires due to rodents attracted to the soy-based wire coatings used by the manufacturer. This is not a minor inconvenience — it is a serious safety issue. Damaged wiring can cause loss of power steering mid-drive, ABS and braking system malfunctions, airbag deployment failures, engine stalling on highways, and electrical fires — any of which can result in injury or death. The manufacturer knows soy-based coatings attract rodents, the consequences are safety-critical, and proven mitigations exist (capsaicin-infused coatings, hardened sheathing, metal conduit) yet are not implemented from the factory. If vehicles are engineered to withstand foreseeable environmental hazards like water intrusion, heat, and road debris, there is no justification for leaving critical wiring defenseless against a well-documented and predictable threat. A material choice known to invite damage, paired with insufficient physical barriers, is not an external cause — it is a design flaw.

On Wednesday, May 6, the vehicle was rear-ended by another vehicle while traveling on I-270. After the impact, the vehicle continued down the highway lane and crashed into the highway divider. During the crash, the front hood opened and fumes/smoke came out from the front of the vehicle. Despite the severity of the collision and secondary impact with the highway divider, the airbags did not deploy. The failure of the airbags to deploy placed the driver at significant risk of injury during the crash. Law enforcement officers at the scene also expressed concern that the airbags did not activate given the magnitude of the accident. The vehicle and airbag system are available for inspection upon request.

I was involved in a front-end motor vehicle collision while driving straight through an intersection. Another vehicle entered perpendicular to my path and stopped directly in front of me, resulting in a collision primarily impacting the front-left (driver’s side) of my vehicle. The impact appeared significant, and the front airbags did not deploy. Additionally, there appeared to be a partial or unclear deployment of the passenger-side airbag system, which did not resemble a full and typical deployment. The vehicle sustained substantial front-end damage, particularly on the driver’s side. I am concerned that the airbag system may not have functioned as expected for the severity and nature of the crash. I am requesting that this incident be reviewed to determine whether the airbag system, sensors, or deployment logic performed within appropriate safety standards. No warning lights or prior issues with the airbag system were observed prior to the incident.

The harness was missing stitching on one side. They're supposed to be two levels to connect the harness for a smaller child. One side had two levels. The other side it only had one. Safety first is sending me a brand new harness.

I purchased a brand new 2025 Subaru Forester Wilderness and immediately noticed a persistent vibration in the steering wheel, seat, and footwell area. The vibration is present at all times — while driving at various speeds and even while idling. It is very distracting and uncomfortable. This ongoing vibration creates a constant sensation of movement that affects my comfort and ability to stay fully focused on the road. I have arthritis in both hands, and the steering wheel vibration causes physical discomfort, pain, and fatigue, especially on longer drives. I previously owned a 2024 Subaru [same model], which did not have this issue. I have also spoken with other owners of the 2025 model who are not experiencing this problem, so I do not believe this is typical for the vehicle. Subaru of America sent an engineer to inspect the vehicle, but the evaluation was limited to measuring vibration levels. He did not place the vehicle on a lift or inspect any physical components, such as the suspension, wheels, or drivetrain. Despite this limited assessment, he concluded the vibration was “normal.” I respectfully disagree with this conclusion, as the vibration significantly affects the drivability, comfort, and confidence I feel while operating the vehicle. I am reporting this issue because I believe it may indicate a defect that deserves further investigation.

The vehicle will move from park to drive and reverse while the engine is off. It moves an good distance and only flashes a red light on the dash with a sound that the engine is not on. It is a huge safety concern and has happened multiple times. Also when moving it into park and taking your foot off the gas, shutting the car engine off, it has moved forward.

The contact stated that while pulling into a parking spot with the brake pedal pressed, the vehicle displayed unintended acceleration, crashing into the wall of the building in front of the parking space. The air bags did not deploy. The contact immediately placed the vehicle in reverse, with the brake pedal still pressed, and the vehicle accelerated at approximately 20 mph in reverse on its own. The vehicle suddenly came to a stop before crashing into a nearby tree. The contact immediately turned the vehicle off and exited the vehicle. The contact received no injuries, and no medical attention was needed. The police came and filed a police report. The vehicle was towed to an auto body shop. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure, and a case was opened. The failure mileage was approximately 2,000.

Engine is misfiring, causing in ability to accelerate properly and loads multiple error codes. Upon taking it to the dealership for services, we were told that there is a significant amount of carbon built-up inside the engine. The car has only 6,800 miles on it. The dealership stated that it is an issue that Subaru engineering is aware of but has yet to figure a way to resolve it. The dealership informed us that hybrid engines have had severe carbon build-up on the in-take valves that causes misfiring, loss of power, bucking and stumbling of the engine. Apparently this has been reported all over different on-line forums. The dealer informed us that they would need to order a valve cleaning kit as referenced un service bulletin 02-193-24 and the engine would require walnut blasting. The vehicle was dropped off for service on 7/22 the work was completed, but upon restarting the engine more codes fired up and they stated that the Electronic Communication Module failed and it would now require an escalation to the Subaru Engineers called TechLine, "they now say that the ECM now needs replacement, still misfiring and has become a more complicated issue"

My new vehicle, with under 4,000 miles, has already suffered multiple chewed wires due to rodents attracted to the soy-based wire coatings used by the manufacturer. This is not a minor inconvenience — it is a serious safety issue. Damaged wiring can cause loss of power steering mid-drive, ABS and braking system malfunctions, airbag deployment failures, engine stalling on highways, and electrical fires — any of which can result in injury or death. The manufacturer knows soy-based coatings attract rodents, the consequences are safety-critical, and proven mitigations exist (capsaicin-infused coatings, hardened sheathing, metal conduit) yet are not implemented from the factory. If vehicles are engineered to withstand foreseeable environmental hazards like water intrusion, heat, and road debris, there is no justification for leaving critical wiring defenseless against a well-documented and predictable threat. A material choice known to invite damage, paired with insufficient physical barriers, is not an external cause — it is a design flaw.

The contact owns a Chicco Keyfit 360 Convertible child seat installed in a 2025 Subaru Forester. The contact stated that the harness strap had detached from the T-bar in the rear of the child seat. The contact stated that the child was in the seat during the failure. The contact was unable to reattach the strap after speaking to the manufacturer. The manufacturer was notified of the failure and informed the contact that a replacement chest clip would be sent for the repair. The cause of the failure was not yet determined; however, the contact stated that the child seat manufacturer had not sent a replacement child seat. The VIN was not available.

While there were no reported incidents, it appears there may be manufacturing defects with this vehicle. The rear seat safety belts are reportedly quite difficult to fasten, as the receptacle is positioned deeply within the seats, sometimes making it impossible to secure the belt. This then triggers an alarm, which can be quite bothersome for the driver. Furthermore, there seems to be an issue with the fuel gauge, as it may display an inaccurate reading. For instance, upon filling the tank, the meter might show 470 ml, but while still at the gas station, it could indicate 330 ml. Additionally, the reading can fluctuate after a trip. Finally, the air conditioning vent on the driver's side does not seem to be functioning correctly. In one instance, despite a minor road hazard that was not immediately noticed, the left rear tire was completely damaged. Despite multiple attempts to address these issues at the showroom and contacting Subaru headquarters, the problems persist. Note the purchase of vehicle forced upon me ,in addition Hallmark Subaru refuse to address the issues with vehicle. I have reported the matter to AL state Attorney general. Still no response made by state AG. Thank you.

8/25/25: Seat Heater came on by itself on a hot day this Summer, it got so hot it burned my Right thigh. Seat Heaters are burning people. I drove directly to Subaru Dealership Service and the Service person, Dave confirmed the Seat heater was off and felt that the seat was hot and getting hotter as the heat began going up into the back of the seat. The service personnel inspected my car and could not duplicate the incident and everything tested "normal" ~ I requested they unplug the heater and they said they could NOT as it will effect the computer. Subaru Corporate connected me with a Customer Advocate who arranged inspection by a corporate service person. Scheduled 11/25/25: He did NOT drive my car -I dont know what he did besides remove my car seat covers, he left a message for me that everything tested normal he couldn't duplicate the issue and the seat covers were not allowed (Subaru sells the same type covers for my Forester :/ finding this odd I began researching and found others are getting burn by the SAME issue!! ) There were NO lights on- the Seat heater was in the OFF position ~Subaru Service personnel can confirm. I am requesting an emergency "Kill Switch" be installed in all vehicles with Seat Heaters to prevent further injury. Thank you

The contact owns a 2025 Subaru Forester Hybrid. The contact stated that the hatchback had opened independently while the vehicle was parked. The contact stated that the doors had opened unintendedly while the vehicle was being washed at the car wash. The contact stated that the door required to be slammed to close and to latch securely. Additionally, the contact stated that while reversing out of a 2-15 percent sloped driveway, the Reverse Automatic Braking (RAB) system's beeping sound engaged while there were no vehicles or objects in the proximity of the vehicle. The contact stated that the vehicle stopped abruptly, causing the driver's side seat headrest to hit the contact's head violently. The contact stated that the vehicle became inoperable. The contact exited and inspected the surroundings of the vehicle. The contact verified that the vehicle had not collided with an object. The contact returned inside the vehicle, and the vehicle responded as needed. The contact pulled into the driveway. The contact contacted the Doctor's office weeks later, and was referred to the ER. The contact went to the ER, where a CT scan, and other tests were performed, but internal bleeding was not found. The contact sustained a concussion and persistent headaches. Additionally, the contact underwent an MRI and was waiting for the neurologist to interpret the MRI test results. The vehicle was taken to the dealer, where the contact was advised to deactivate the reverse automatic braking(RAB) system. The manufacturer was notified of the failure and sent a field technician who inspected and test-drove the vehicle. The manufacturer later informed the contact that the vehicle had operated as designed while reversing on the sloped driveway. The vehicle was not repaired. The failure mileage was approximately 100.

Bought 2025 Subaru Forester in January 2025. Within 300 miles of driving brought it back to place I bought it, complained about constant vibraton in Sterring wheel at high speeds around 55 - 65 MPH. They said the wheels were out of balance, they re balanced them and the problem was resolved, BUT IT WASN'T. I brought it back to them At 600 miles they looked it over and took it for a ride they said they did NOT feel the wheel vibration. I said how could you NOT feel it. I brought it back a 3rd time at 800 miles. They took it for a ride with me in passanger seat . Even as I told them I could feel it in armrest they still said they did not feel it. I opened a case with Subaru of America Advocates. they advised me to take it to a different dealer which I did. The second dealer acknowledge the wheel vibration at high speeds. They had my SUV for about 10 days they tried several different brands of tires . They same result happended . Then they said one brand of tires the vibration was less but it is NOT less it is about the same. They are trying to get me some new tires but I don't think it is the tires. THe supension has been looked over by both Subaru dealers. They say it is safe to drive. BUT IT STILL VIBRATES it is NOT just road noise. I just want the vehicle fixed properly.

I purchased a brand new 2025 Subaru Forester Wilderness and immediately noticed a persistent vibration in the steering wheel, seat, and footwell area. The vibration is present at all times — while driving at various speeds and even while idling. It is very distracting and uncomfortable. This ongoing vibration creates a constant sensation of movement that affects my comfort and ability to stay fully focused on the road. I have arthritis in both hands, and the steering wheel vibration causes physical discomfort, pain, and fatigue, especially on longer drives. I previously owned a 2024 Subaru [same model], which did not have this issue. I have also spoken with other owners of the 2025 model who are not experiencing this problem, so I do not believe this is typical for the vehicle. Subaru of America sent an engineer to inspect the vehicle, but the evaluation was limited to measuring vibration levels. He did not place the vehicle on a lift or inspect any physical components, such as the suspension, wheels, or drivetrain. Despite this limited assessment, he concluded the vibration was “normal.” I respectfully disagree with this conclusion, as the vibration significantly affects the drivability, comfort, and confidence I feel while operating the vehicle. I am reporting this issue because I believe it may indicate a defect that deserves further investigation.