2015 Subaru Outback Problems

Cracked windshield out of nowhere, starts from the bottom passenger side.

The contact owns a 2015 Subaru Outback. The contact stated while driving at approximately 55 MPH, the front windshield suddenly developed a crack which quickly extended approximately 8 inches horizontally and later extended more than 35 inches across the windshield. The contact stated that the crack began on the passenger’s side and extended to the driver’s side of the windshield. The contact stated that the failure had occurred approximately 15 minutes after having the original windshield replaced after the same failure. The cause of the failure was not yet determined. The local service center and manufacturer were notified of the failure. The failure mileage was 71,000.

The Subaru's Starlink Radio has completely delaminated on the layer between the display and the digitizer, which does not allow the radio to be controlled in any way, shape, or form. This means that the touch screen is not working anymore, and because the radio is so delaminated, whenever the car is put into reverse during the daytime, the backup camera is nowhere near visible enough to be seen safely. The radio delaminated to the point where it was unusable after the 100k-mile warranty period. At the start of the issue, the radio developed a ghost touch on the bottom-left corner of the screen, and during a Bluetooth phone call, it would repeatedly hang up the phone, leading to distraction while driving.

Vehicle Component Affected: ELECTRICAL SYSTEM / FORWARD COLLISION AVOIDANCE / BACK OVER PREVENTION Description of the Safety Defect: The factory infotainment touchscreen in my 2015 Subaru Outback Limited (VIN: [XXX]) has suffered a severe manufacturing defect where the internal chemical gel adhesive has melted, creating large, oily liquid bubbles across the display. This physical degradation causes the screen to suffer from continuous "ghost touches," registering non-stop phantom inputs while the vehicle is in motion. This hardware failure creates three active, severe driving safety hazards: DANGEROUS OPERATOR DISTRACTION: The ghost-touching triggers a loud, high-pitched, non-stop audible dinging sound through the speakers that cannot be muted, severely compromising driver focus on the roadway. INOPERABLE NAVIGATION CONTROL: The system recently registered phantom touches that autonomously programmed a random destination into the factory GPS. The system then overrode all driver controls, preventing me from canceling the navigation instructions or turning off the screen audio while driving. OBSCURED BACKUP CAMERA VISIBILITY: The large, oily chemical delamination bubbles create a severe visual distortion on the screen. In direct or bright sunlight, the backup camera image is completely unreadable and obscured, creating an active striking hazard to pedestrians and vehicles behind me. This manufacturing defect began approximately in Jan 2023 and has gotten progressively worse over time, transitioning from minor cosmetic bubbling to severe, non-stop hardware malfunctions. This component failure is an active driving hazard that completely compromises driver attention and vehicle safety systems. Subaru of America is aware of this chemical breakdown across this generation of head units but is refusing to remedy the safety defect out of warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA issued a notice for a recall on the 2015 Subaru Outback for an exhaust pipe bellows crack which causes exhaust noise and odor which affects emission and engine performance. I had noticed our Subaru's exhaust smoke coming in through the air vents while idling and also a general loss of power for the vehicle. When I dug into the causes, I came across this recall and did the VIN look up on the NHTSA website and also the Subaru website for active recalls. The Subaru website states that the recall was completed. I then called the subaru retailer to check if there were any records for the recall work that was completed for NHTSA ID Number: 10199936. They could not find any records. I called in Subaru corporate to see if they could shed any light on the recall. Subaru corporate says that the recall work was performed on August 6th, 2020 but is unable to tell me where it was performed or even if it was actually replaced. My local Subaru dealer has no records and Subaru corporate says that the work was performed. I am stuck with an exhaust leak that is potentially dangerous as time goes on where it might fail emissions. Subaru corporate has not wanted to address this or investigate the discrepancy, but instead asks me to work with the dealer to get records. The dealer says there's no records of the work ever being done. So I'm in limbo with a particularly faulty car.

The contact owns a 2015 Subaru Outback. The contact stated that while driving at an undisclosed speed, the exhaust manifold detached from the vehicle. Due to the failure, the vehicle was towed to the residence. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The dealer advised the contact that a recall repair was previously performed on the vehicle, which was related to an exhaust pipe cracking, and that additional repairs would be at the owner's expense. The manufacturer was notified of the failure. The approximate failure mileage was 244,000.

Vehicle Component Affected: ELECTRICAL SYSTEM / FORWARD COLLISION AVOIDANCE / BACK OVER PREVENTION Description of the Safety Defect: The factory infotainment touchscreen in my 2015 Subaru Outback Limited (VIN: [XXX]) has suffered a severe manufacturing defect where the internal chemical gel adhesive has melted, creating large, oily liquid bubbles across the display. This physical degradation causes the screen to suffer from continuous "ghost touches," registering non-stop phantom inputs while the vehicle is in motion. This hardware failure creates three active, severe driving safety hazards: DANGEROUS OPERATOR DISTRACTION: The ghost-touching triggers a loud, high-pitched, non-stop audible dinging sound through the speakers that cannot be muted, severely compromising driver focus on the roadway. INOPERABLE NAVIGATION CONTROL: The system recently registered phantom touches that autonomously programmed a random destination into the factory GPS. The system then overrode all driver controls, preventing me from canceling the navigation instructions or turning off the screen audio while driving. OBSCURED BACKUP CAMERA VISIBILITY: The large, oily chemical delamination bubbles create a severe visual distortion on the screen. In direct or bright sunlight, the backup camera image is completely unreadable and obscured, creating an active striking hazard to pedestrians and vehicles behind me. This manufacturing defect began approximately in Jan 2023 and has gotten progressively worse over time, transitioning from minor cosmetic bubbling to severe, non-stop hardware malfunctions. This component failure is an active driving hazard that completely compromises driver attention and vehicle safety systems. Subaru of America is aware of this chemical breakdown across this generation of head units but is refusing to remedy the safety defect out of warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

January 25th, 2026 13:30 I was coming to a stop at an intersection with my foot on the brake pedal when suddenly my vehicle lurched forward potentially causing rear end collision with the truck in front of me that was stopped at the red light. My vehicle finally came to a stop when I pressed hard on the brake pedal. This problem happened today, so I have not reproduced it. I have not had it checked by a dealer (today is Sunday) I have a Low Tire Pressure light that came on two days ago when the temperatures suddenly dropped here in Tulsa, OK.

After a transmission replacement performed by Bud Clary Chevrolet, Inc. in Longview, WA on September 9, 2025, my vehicle was returned to me with critical components left unsecured. On November 19, 2025, an independent mechanic discovered loose suspension bolts connecting the ball joints to the spindles on both front wheels. On November 29, 2025, Subaru of Portland documented additional unsecured and unattached components related to the prior transmission replacement, including loose mounting hardware and a disconnected PCV hose. Subaru of Portland’s written inspection states that the loose bolts would have been unsafe if left uncorrected. These conditions were present after a major repair and created a potential safety hazard while the vehicle was being driven. This complaint concerns an unsafe condition caused by improper workmanship during a vehicle repair.

A transmission that was replaced in July of 2023 went bad un December of 2024 and dealership won't give reasons why transmission went bad or what caused a almost brand new transmission with less than 50,000 miles on it went bad. They are demanding we pay $5000.00 dollars on a transmission that was replaced under the extended warranty on cvt transmission from subaru. Which also extends to the brand new transmission. They are demanding their loaner car back and refusing to honor extended warranty on new transmission which the gave us which is bad. They will not give us anything other than it is bad. No information what so ever is being given to my husband or I as to why, how or what happened. My car will not move unless it is pushed by someone. They are refusing to honor their recall warranty or provide a loaner while dealing with their corporate offices on this issue. This is after in the past 1 and a half years my car has been in their shop for well over 8 months and I am still making payments on this vehicle. They will not even provide paperwork on the issues with my vehicle.

The contact owns a 2015 Subaru Outback. The contact stated while the vehicle was at the dealer for an oil change and snow tire replacement, the contact was informed that the sub frame and the brake lines were severely corroded and needed to be replaced. The vehicle was taken to a second dealer, 802 Toyota (30 Berlin Mall Rd, Berlin, VT 05602) for a Trade-In, and it was confirmed that the sub frame was corroded during the appraisal inspection. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the failure was caused by salt damage; however, the contact stated that the vehicle was used for leisure rather than commute since the contact was retired. The failure mileage was 86,801.

The front subframe on my 2015 subaru 3.6r has rapidly rusted in a few years to the point of a safety concern. The vehicle is lightly driven, with 91,000 miles on it after almost 10 years. We live in the Northeast. I take this car in for regular inspections and service every six months and the service center I work with has not alerted me of any issues until this past march when they found the subframe almost completely rotted in the middle. Subaru has had similar issues subject to recalls for the rear subframe. Notably, my rear subframe does not have this issue. Evidence is available that this is exact issue is happening to many cars in this generation, found upon scanning forums such as reddit [XXX] and the subaruoutback.org owners forum [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

January 25th, 2026 13:30 I was coming to a stop at an intersection with my foot on the brake pedal when suddenly my vehicle lurched forward potentially causing rear end collision with the truck in front of me that was stopped at the red light. My vehicle finally came to a stop when I pressed hard on the brake pedal. This problem happened today, so I have not reproduced it. I have not had it checked by a dealer (today is Sunday) I have a Low Tire Pressure light that came on two days ago when the temperatures suddenly dropped here in Tulsa, OK.

The contact owns a 2015 Subaru Outback. The contact stated while the vehicle was at the dealer for an oil change and snow tire replacement, the contact was informed that the sub frame and the brake lines were severely corroded and needed to be replaced. The vehicle was taken to a second dealer, 802 Toyota (30 Berlin Mall Rd, Berlin, VT 05602) for a Trade-In, and it was confirmed that the sub frame was corroded during the appraisal inspection. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the failure was caused by salt damage; however, the contact stated that the vehicle was used for leisure rather than commute since the contact was retired. The failure mileage was 86,801.

NHTSA issued a notice for a recall on the 2015 Subaru Outback for an exhaust pipe bellows crack which causes exhaust noise and odor which affects emission and engine performance. I had noticed our Subaru's exhaust smoke coming in through the air vents while idling and also a general loss of power for the vehicle. When I dug into the causes, I came across this recall and did the VIN look up on the NHTSA website and also the Subaru website for active recalls. The Subaru website states that the recall was completed. I then called the subaru retailer to check if there were any records for the recall work that was completed for NHTSA ID Number: 10199936. They could not find any records. I called in Subaru corporate to see if they could shed any light on the recall. Subaru corporate says that the recall work was performed on August 6th, 2020 but is unable to tell me where it was performed or even if it was actually replaced. My local Subaru dealer has no records and Subaru corporate says that the work was performed. I am stuck with an exhaust leak that is potentially dangerous as time goes on where it might fail emissions. Subaru corporate has not wanted to address this or investigate the discrepancy, but instead asks me to work with the dealer to get records. The dealer says there's no records of the work ever being done. So I'm in limbo with a particularly faulty car.

Within the last few months, my 2015 Outback has been unreliable with the fuel gauge indicator, causing me to run out of gas three times, stranded roadside, with supposedly 30 miles in rank. Fortunately, there were no accidents, but two out of three times, I was left stranded on highways, that put me at risk of being struck.

My car horn stopped working. The dealership said the clock spring (steering roll connector) component has failed, confirmed by the resulting complete loss of the horn function. The dealership did not communicate the fact that my drivers airbag would not function properly in an accident. I couldn’t afford the repair at the time, putting my life in danger should an accident occur. Returning to the dealer they still state it is not a covered item, and I need to pay to repair the part so my horn and airbag functions as intended.

The clock spring (steering roll connector) component has failed, confirmed by the resulting complete loss of the horn function. SAFETY HAZARD: The component failure has resulted in the loss of the electrical connection to the Driver's Airbag System, rendering the primary airbag inoperable. This creates an unreasonable, life-threatening risk in the event of a collision. The problem has been diagnosed based on common failure patterns for this vehicle platform and confirmed via manufacturer correspondence. The problem first occurred on or about [Input Approximate Date] with the simultaneous failure of the horn and subsequent inoperability of the driver's airbag. The manufacturer, Subaru of America (SOA Case #251013-1700910), was contacted and acknowledged the concern but refused to cover the repair under a Goodwill Adjustment, citing an expired warranty, despite the component's direct link to the critical airbag safety system

The clock spring (steering roll connector) component has failed, confirmed by the resulting complete loss of the horn function. SAFETY HAZARD: The component failure has resulted in the loss of the electrical connection to the Driver's Airbag System, rendering the primary airbag inoperable. This creates an unreasonable, life-threatening risk in the event of a collision. The problem has been diagnosed based on common failure patterns for this vehicle platform and confirmed via manufacturer correspondence. The problem first occurred on or about [Input Approximate Date] with the simultaneous failure of the horn and subsequent inoperability of the driver's airbag. The manufacturer, Subaru of America (SOA Case #251013-1700910), was contacted and acknowledged the concern but refused to cover the repair under a Goodwill Adjustment, citing an expired warranty, despite the component's direct link to the critical airbag safety system

The clock spring that controls the steering wheel, horn and other electrical accessories doesn’t work. This put my life and family’s lives at risk. This is a known issue for Subarus 2015-2019. There’s multiple videos online, I have spoken to multiple owners personally that have encountered the same issue. I spoke to the Subaru dealer and they said due to no recall has been issued for the vin number of my vehicle they can’t replace it and it cost about $1,000 dls. We need the NHTSA to step in and ask Subaru to issue a recall to start replacing the defective units at no cost to the owner.

Wheel Lug bolts continue to snap off. Have had 5 so far and this could effect the ability of the wheel to stay attached to the vehicle. I have several friends with the same vehicle (different years) that have had the same issue multiple times. In 50 years of vehicle ownership have never had this happen once, let alone 5 times.

Failure on multiple lug nuts due to rust and corroding bolts. The vehicle is mostly garaged, and exposed to the elements only when driven. For a < 68000 mile vehicle, this type of failure is on the higher side. Additionally, the lug nuts break when trying to open using company specific torque. The repair facilities advise me that it is a known Subaru issue. This is a safety hazard in that, if I am stranded due to a flat tire, I will not be able to change my tire.

When braking the car shuts down!!!

The front subframe on my 2015 subaru 3.6r has rapidly rusted in a few years to the point of a safety concern. The vehicle is lightly driven, with 91,000 miles on it after almost 10 years. We live in the Northeast. I take this car in for regular inspections and service every six months and the service center I work with has not alerted me of any issues until this past march when they found the subframe almost completely rotted in the middle. Subaru has had similar issues subject to recalls for the rear subframe. Notably, my rear subframe does not have this issue. Evidence is available that this is exact issue is happening to many cars in this generation, found upon scanning forums such as reddit [XXX] and the subaruoutback.org owners forum [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driver's seat started peeling off approximately a year after purchase. Notified dealer, they said to contact Subaru of America via social media. Now almost all peeled off, have to cover with towel possibly interfering with airbags. Steering column lock will not lock in top position. Dealer repaired once under warranty, now out of warranty. Unsafe when column moves when driving. Transmission started slipping or behaving strangely around 90,000 miles. Never received notice of extended warranty I read about on Subaru forums [XXX] ) Paid $531.43 for fluid change at dealership because of the problem on 7/27/23 and no mention was made about extended warranty. It has not solved the problem. If transmission fails, that is a safety problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AUTOMATIC FRONT SEATS. WHEN WIFE OPENS THE PASSENGER DOOR FIRST (BEFORE THE DRIVER) THE DRIVER SEAT ADJUSTS TO HER SET POSITION. AN D IF I DON'T PAY ATTENTION THE DRIVER SEAT WILL PUSH/CRUSH ME INTO THE STEERING WHEEL. I HAVE A BAD BACK AND DROP FOOT, SO I DON'T HAVE THE STRENGTH OF A YOUNGER PERSON. MY ONLY SALVATION IS TO SQUEEZE OUT OR HIT THE POSITION BUTTON ON THE DOOR PANEL. ALSO, THE PRESETS GO OUT ALL THE TIME. I HAVE ASKED IF THEY COULD DISABLE THE PASSENGER SIDE DOOR SENSOR. NOTHING. REAR GATE OPENING: IT HAS HAPPENED SO MANY TIMES. I HAVE COMPLAINED DIRECTLY TO SUBARU ABOUT THE SEAT AND GATE PROBLEM. NO RESULTS. THE REAR GATE HAS OPENED WHILE RAINING OUTSIDE DURING THE NIGHT. IT HAS OPENED WHILE IN THE GARAGE JAMMING THE OVERHEAD GARAGE DOOR. I AM AFRAID ON TRIPS TO HAVE STUFF STOLEN OUT OF MY CAR IS SUCH AN INCIDENT. HAPPENED ONCE. ALSO... THEY HAVE A CUTE PRESET SO YOU CAN SET THE MAX HEIGHT OF THE GATE OPENING. TWICE MY WIFE HAS WALKED INTO THE REAR GATE AND LITERALLY FLIPPED BACKWARDS TO THE PAVEMENT! SUBARU DENIES ANY PROBLEMS ABOUT THE GATE. FUNNY, ONE DAY I WAS HELPING A FRIEND AND HER MOM WAS THERE. AS THEY HELPED ME UNLOAD MY SUBARU WE DISCOVERED THAT MOM HAD ALSO A SIMILAR MODEL. THE FIRST QUESTION SHE ASKED ME "HAVE YOU ANY PROBLEM WITH YOUR REAR GATE"!!! IT'S NOT JUST ME. SUBARU NEEDS TO STEP UP AND FIX THESE PROBLEMS BEFORE SOMEONE REALLY GETS HURT OR HAVE LOSS OF ITEMS FROM THE CAR.

Repeated dead batteries. Replaced OEM battery in year 2, new battery also comes up dead regularly. There is clearly a parasitic battery drain happening. Burning oil, this car burns more oil than any car I have ever owned. Subaru claims it is within specification, but their specification is 1 quart between changes, this is a ridiculous claim in 2021. Heat shield and exhaust noise. Always a new noise or exhaust leak. Lights are not adequate for country driving, it is dangerous.

TAPPED THE ACCELERATOR. THE CAR SUDDENLY LURCHED BACKWARD. I PUT IT IN NEUTRAL AND HIT THE BRAKES. NOTHING HAPPENED.I DIDNT WANT TO HIT THERE GARAGE OR MY SON IN LAWS CAR SO I SWERVED TO THE RIGHT. I HIT THE BRAKES AND AGAIN NOTHING HAPPENED. THE CAR HIT THE NEIGHBOR BUSH AND EVENTUALLY CAME TO REST WHEN IT HIT THE NEIGHBORS HONDA RIGHT DOOR. I THEN PUT IT DRIVE AND PULLED BACK ONTO MY DAUGHTERS DRIVEWAYS AND HAD A DIFFICULT TIME STOPPING THE VEHICLE. IT DID APPROX. $2200 DAMAGE TO MY SUBARU OUTBACK SENDING IT TO THE COLLISION SHOP FOR TWO WEEKS.

SUBSTANTIAL RUST HAS DEVELOPED AT THE ATTACH POINT OF THE DRIVER'S SEAT-BELT TO THE DRIVER'S SEAT AND OF THE ATTACH-POINT OF THE DRIVER'S SEAT TO THE CAR. WE'RE THE ORIGINAL OWNER AND THE CAR WAS NEVER FLOODED OR EXPOSED TO WATER IN ANY OTHER WAY. I TOOK IT TO THE DEALER TWO WEEKS AGO AND THEY DIDN'T KNOW WHAT TO MAKE OF IT OR DO ABOUT IT. THEY REACHED OUT TO SUBARU AND (AS OF 4/24) THE DEALER HASN'T RECEIVED A RESPONSE. THE PASSENGER SIDE DOESN'T HAVE THIS PROBLEM, BUT THE DESIGN IS ENTIRELY DIFFERENT -- NO EXPOSED METAL. INTERESTINGLY, WHEN THE SERVICE ADVISOR CHECKED OTHER LATER-YEAR GEN 5 OUTBACKS THE DESIGN HAD CHANGED: THERE WAS NO LONGER ANY EXPOSED METAL IN THE EQUIVALENT LOCATION. THE NEWER DESIGN FOR THE DRIVER-SIDE ATTACH-POINT MIMICS THE PASSENGER SIDE - NO EXPOSED METAL. A 2016 OUTBACK IN FOR SERVICE HAD THE SAME EXPOSED METAL DESIGN ON THE DRIVER-SIDE SEAT. IT ALSO HAD RUSTING AT THE SAME LOCATION (ALTHOUGH NOT NEARLY AS SEVERE AS ON MINE). IT DOES NOT SEEM SAFE TO HAVE THIS KIND OF RUST AT SUCH A KEY ATTACH-POINT FOR THE SEAT AND A CRITICAL SAFETY DEVICE LIKE A SEATBELT. WE LIVE IN A WARM/TEMPERATE PART OF CALIFORNIA AND THE CAR HAS ALWAYS BEEN "HOMED" IN PART OF CALIFORNIA, SO IT HAS NOT BEEN EXPOSED TO HARSH WEATHER.

I WAS SLOWING PULLING INTO A PARKING SPACE AND JUST STRAIGHTENING OUT THE CAR WHEN I HEARD A STRANGE SOUND COMING FROM THE ENGINE. IMMEDIATELY AFTER THAT I HEARD A VERY LOUD ENGINE REVVING SOUND AND THEN SUDDENLY THE VEHICLE SHOT FORWARD LIKE A ROCKET, WENT OVER THE CEMENT BARRIER AND INTO THE WALL OF A BUILDING. IT SEEMED LIKE A VERY HIGH RATE OF SPEED, THOUGH THE DISTANCE WAS ONLY ABOUT 8 FEET. THE SEAT BELT DID NOT RESTRAIN ME AND MY CHEST SLAMMED INTO THE STEERING WHEEL. IT WAS DETERMINED LATER AT THE HOSPITAL THAT I HAD A CRACKED STERNUM AND SEVERAL BROKEN RIBS. I BELIEVE THERE WAS SOME SORT OF MECHANICAL, ELECTRICAL OR SOFTWARE PROBLEM THAT CAUSED THIS UNINTENDED ACCELERATION, AND THE SEAT BELT ALSO WAS DID NOT FUNCTIONING AS INTENDED. *TR

2015 SUBARU OUTBACK. CONSUMER WRITES IN REGARDS TO ROUGH IDLING IN VEHICLE. *LD THE CONSUMER STATED THE VEHICLE ANNOYINGLY VIBRATED WHEN THE AIR CONDITIONER WAS ON. *JS