2021 Subaru Outback Brakes Problems

The contact owns a 2021 Subaru Outback. The contact stated while driving approximately 40 MPH, the check engine, ABS, and brake warning lights illuminated. The contact pulled over to the side of the road. The contact turned off the vehicle and waited for several minutes before restarting the vehicle; however, upon restart the transmission failed to shift into the desired gear. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the vehicle was not covered under warranty due to a third-party damage to the rear brake cable. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 24,000.

NHTSA ID

11623437

Incident

Oct 27, 2024

Mileage

24,000 mi

As I was approaching a T intersection and preparing to stop at the stop sign, I started to apply my brakes when all of a sudden my car accelerated and lunged forward almost into the path of oncoming traffic on the intersecting road. As I had originally started to apply my brake, it felt as if the brake dropped slightly under my foot but, as the car lunged forward, I immediately jammed on the brake so I am not 100% sure about that dropping sensation. It all happened within a matter of seconds. Anyway, jamming on the brakes stopped the forward momentum and the car stopped before actually entering the path of an oncoming car. If I had started to brake any closer to the intersection, I may not have had time to stop the car in time to avoid a broadside collision with the oncoming car. I have owned this car about a year and a half and this is the first time anything like this has happened. There was no warning lamps, messages etc at the time or prior to the incident. After the incident, my husband checked online and saw that others have described a similar experience with their Subarus and, apparently, there is an ongoing lawsuit involving this problem. This just happened last evening so I have not yet taken my car to the dealer to be inspected but plan to do so soon.

NHTSA ID

11572939

Incident

Feb 19, 2024

I have experienced premature rear brake wear and excessive tire wear. Issues with infotainment system and pre-collision braking system. (1) Regarding Tires: Performed all dealer recommended tire rotations and aligned vehicle when recommended. Needed new tires at 31,169 miles. Tires showed excessive inside wear. Bought new tires from a 3rd party shop and had alignment done with hunter alignment system. Showed rear right camber at -2.0. Subaru recommends -1.8 to 0.3. Rear camber is not adjustable on this model. Took vehicle back to dealer for brake job and they said camber was fine...there is a spec for a reason. Did not want to attempt to bring it in spec with aftermarket kits (i.e. adjustable cam bolt) or fix under warranty. (2) Regarding Brakes: Needed new brakes at 31,169 miles. Not covered under warranty and not what I would consider typical wear based on my driving style and my past experience with Subaru vehicles. If this is an expected side affect of the EBD system I would highly recommend Subaru consider ways of improving brake life on their vehicles. (3) I have the Onyx XT trim with navigation. Infotainment system is constantly glitchy. Examples include booting with blank black screen, failing to load, excessive lag while operating system or will freeze and beep repeatedly while buffing a menu selection. Also, had my car battery replaced under warranty within the first two years due to a bad battery. (4) Issues with ADAS system, specifically pre-collision breaking. This system is extremely sensitive and will over-react / take control in certain situations where I didn't need it to even when I was in the process of braking. Have had this system activate on the highway at high speeds while switching lanes on the highway or when having a vehicle merge quickly into my lane in front of me. Constantly, have to turn off this system which is a chore as this system is defaulted to always being on. Do not feel safe driving with this system on.

NHTSA ID

11557430

Incident

Nov 2, 2023

On Sunday, August 20, 2023 I was pulling into a parking spot in front of an Anytime Fitness at a local strip mall. As I applied the brake, the motor raced and accelerated driving me into a pillar outside of the fitness center. I was in shock, not understanding what had happened. Had I chosen to park one stall to the right, the car would have gone through the window of the business instead of the pillar. Considerable damage was done to the pillar and to my 2021 Subaru Outback, but I was not injured, and no one else was injured. I had the brakes checked at my vehicle service center and was told the brakes were functioning as they should be. The vehicle has not been inspected by the manufacturer, police, insurance representatives or others. No warning was provided by the vehicle. The crash occurred in two seconds.

NHTSA ID

11542645

Incident

Aug 20, 2023

With 22,000 miles my front rotor brakes need replacing and I don’t have a heavy foot! This is my 5th Outback and so my history vouches that I’m not a driver that wears down brakes or tires. When I did some online searching, there are a number of people posting with the same experience. Subaru knows there is a problem because they are quick to replace under warranty. But this is dangerous. In my case, the brakes were checked just a few thousand miles ago and the were “ very good”, scored 8. Fortunately a friend was sharing the driving on a long trip and they caught that there was a problem. I made a service appointment while we were on the road. Please investigate and have them come up with a better solution than resurfacing the breaks after just 22000 miles

NHTSA ID

11540130

Incident

Aug 10, 2023

I have had this vehicle since @ 6/30/21, under 4,000 miles. Sometimes when I'm driving, the car will suddenly brake or lurch when I am not near another object or person. I drove down the highway once when this happened and it was very concerning. I have also been in the middle of an intersection when this occurred, as I was turning left. It has happened approximately 10 other times since I've had the vehicle. Today it happened and a truck was behind me; thankfully I did not get hit.I brought this into the dealereship twice and they claim there is nothing wrong with the car. There is definitely something wrong with the car; it's dangerous. My car is available for inspection upon request. I and others are at great risk for an accident. I remember flashing lights on a few occasions, not today. When I went online to check for recalls, I noticed many other Subaru owners having the same issues.

NHTSA ID

11460739

Incident

Apr 14, 2022

Your form would not allow me to chcek all applicable issues. I believe the computer system and brakes are the major issues. The start/stop system engaged when I was turning in the middle of an intersection. When driving at cruising speeds (foot on the gas pedal), the car suddenly felt as if the brake was being engaged. The forward and rear collision warning signals do not work. The blind spot warning does not work. There is grinding coming from the undercarriage at times (random), while my foot is on the gas. The car bucks for no reason. The battery is draining (less than 2,000 miles on the car). Sometimes I have to turn the ignition twice in the morning. I turn everything off when I get out of the car. My safety and safety of others is definitely at risk. What I didn't realize until recently is that prior to accepting the vehicle, the salesman must have turned the start/system off, because when I went for a test drive, the start/stop did not engage once and I drove in city traffic with multiple stops. Immediately upon diving off lot, the car stopped and I had issues. The salesman told me I had to get used to the start/sytem. This is a dangerous situation. My car is currently being looked at by the dealer.

NHTSA ID

11436737

Incident

Jun 26, 2021

While moving forward slowly with foot lightly on the brakes and pulling into a parking space at local shopping center the car accelerated and the steering wheel turned to the right. The result of the cars actions made the car jump the curb, drive across the sidewalk and then across small hedges in the landscaped area. Car finally came to a stop about 20 feet later, with me pushing hard on the brake, just prior to entering parking lot roadway cross traffic. There was no alarm, warning or any other indication from any of the safety systems. As far as the automobile was concerned, nothing wrong had happened. Luckily there were no other vehicles or pedestrians on sidewalk or in the landscaped area between the parking space and roadway. There was no vehicle damage as the shrubs were all fairly short and the car simply drove over them. My husband disabled the lane departure system and I continue to operate the car. Based on all the previous incidents reported on this site, my husband indicates that Subaru will blame operator error. I have a perfect driving record and this incident was not caused by me incorrectly stepping on the gas.

NHTSA ID

11421481

Incident

Jun 4, 2021