2021 Subaru Outback Problems

I was driving when I heard a loud explosion sound. I first thought a rock or gunshot hit my car and pulled over to examine my car. I checked all around the car and didn't notice any damage on the side of my car but then I noticed that my sunroof was shattered. The glass was pushed outward which meant that it was not hit by an object. Luckily, my interior cover to my sunroof was closed at the time so I was not harmed.

Since owning this vehicle, we have replaced the windshield at least once a year. The first due to a 1/16th inch chip that evolved into a 10 inch crack over the course of a day. The second was a crack from driver side pillar that appeared overnight, no chips prior. Third was a 8" crack from passenger pillar that appeared overnight while garage parked, after a day, it grew to reach the center of the windshield. I think it's unacceptable that windshields can just crack overnight less than a year after install. It's beyond concerning knowing that our windshield could crack at anytime, or that superficial chips must be taken care of IMMEDIATELY or we run the risk of replacing the entire windshield.

Vehicle's Auto Start-Stop system shut the engine off while stopped at a red light in [XXX], in rainy conditions in late XXX at approximately 29,000 miles. When the brake was released after the light turned green, the engine did not restart, leaving it stopped in the travel lane in live traffic. The driver had to use a portable jump starter to get it running again. This was not isolated — repeated failure-to-start incidents in prior weeks had already prompted carrying a portable jump starter in the vehicle. At the time we believed this was a failing 12V battery. The original battery was replaced XXX with a new aftermarket AGM battery. Despite that replacement, the vehicle has continued to have multiple complete battery drain if left parked for multiple days (but less than a week), indicating the restart failures were likely caused by an underlying parasitic electrical draw rather than a simple worn-out battery. Subaru's own Technical Service Bulletin 07-199-21R, "Measurement of Dark Current (Standby Current Draw)," describes this exact failure pattern (batteries/vehicles going dead over time due to standby current traced to the VDC module and/or Power Rear Gate control module) for this model and model-year range. A pending federal class-action lawsuit, [XXX] v. Subaru of America, Inc., Case No. XXX (D.N.J., filed XXX), alleges an electrical-system defect preventing one or more control modules from entering a proper low-power sleep state, causing parasitic battery drain, and specifically names 2021-2022 Outback vehicles. We are concerned this defect can cause the Auto Start-Stop system to fail to restart the engine at a stop in live traffic, creating a real risk of being rear-ended or blocking an intersection, as happened in the incident described above. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a serious and intermittent steering safety issue with my 2021 Subaru Outback. On two separate occasions, the vehicle suddenly lost what appeared to be power-steering assistance while the vehicle was in motion, causing the steering wheel to become extremely difficult to turn. The first incident occurred while I was driving on the highway and going down a ramp. The steering suddenly became extremely difficult to operate and a warning symbol illuminated on the dashboard. I was able to maintain enough control of the vehicle to safely pull over to the side of the road. I turned the vehicle off and restarted it, and the warning light disappeared and normal steering operation returned. The second incident occurred while I was making a turn into a neighbor. The same problem occurred: the steering suddenly became extremely difficult to turn and a warning light appeared on the dashboard. After turning the vehicle off and restarting it, the steering returned to normal. The intermittent nature of this problem is concerning because restarting the vehicle temporarily restores normal steering, but the failure has now occurred more than once without warning. One of the incidents occurred while traveling on the highway, creating a significant risk of loss of vehicle control and a collision. I am concerned that this may involve the vehicle’s electric power-steering system or related electrical components. I am reporting this to NHTSA because a sudden loss of steering assistance while a vehicle is moving presents a serious safety risk, particularly while turning or traveling at highway speeds. I am requesting that NHTSA document this complaint and evaluate whether similar steering failures have been reported by other owners of 2021 Subaru Outback vehicles.

The contact owned 2021 Subaru Outback. The contact stated that while driving at 5 MPH turning a right hand corner into a shopping center, the vehicle began to accelerate without the contacts consent. and the contact proceeded to frantically apply the brakes. The vehicle came to a stop upon impact with a brick wall impacting the front drivers side of the vehicle. All of the airbags were deployed. The vehicle was going 43 mph at the time of the crash. The was towed to a junk yard. No warning lights or strange sounds were emitted prior to the crash. A police report was filed. The contact was injured while seated in the drivers seat. No one outside of the vehicle was injured. The contact sustained whip lash and bruising from the seat belt. Medical treatment was needed for the injuries. The local dealer was contacted, and the black box was inspected. The manufacturer was notified of the failure. The failure mileage was 70,000.

I was already parked in a spot in a public parking lot. I tapped the accelerator pedal to move the car a few inches. The vehicle responded by violently accelerating, hitting a vehicle directly in front of me in another parking space. I applied my brake but the car would not stop. The force of the acceleration pushed the car out of the it's spot and it hit a curb and tree appox 30 ft away. In defensive move I turned my wheels to the right and continue to try and brake. This caused my car to hit the car on the right side of me. Property Damage occured. No injuries. Vehicle defect.

Good Day! I bought my 2021 Subaru Outback XT Onyx in Jan 2021. I had waiting 6 yrs for Subaru to use the Turbo Motor in the Outback again. I've had this car for 5 years with my warranty running out Jan 2026, but I only drive 5000-7000 miles per/yr. Current odometer is 29,901 miles. At my most recent oil change service at the Dealer, they showed me a video of my cars drivetrain from underneath. There were two bad seal leaks. One at the transmission pump housing and the other at the Upper Oil Pan. I had been there for an oil change a year earlier for the same service and there was no mention of these issues! After speaking with the service advisor, he said to call Subaru Customer Advocates. They listened to my situation and a few days later offered a $1400 credit for a $4000 job that involves the removal of my cars engine (upper oil pan) to replace it because it's bolted to the frame there. The other leak seal involves dropping the transmission. These are major repairs that following will dampen my ownership experience after decades of Subaru praise by Americans. I researched this issue online and found out there was a manufacturing defective regarding the silicone liquid seals they used for 2020-2022 Outback, Ascent, & WRX! This procedure was used throughout the driveline with the Turbo Motor & CTV Trans. There are 1000s of accounts of this defect placing burden on the owners of these cars who bought them in good faith. I did the research, called the dealer & Subaru with the discovery & overall complaint! I asked for 80% to 100% help with these repairs because how many more will I have to deal with after these two are repaired??? I have received zero responses from either after expressing that this was a known defect, Bullitens went to all the dealers, nothing was mentioned to the owners, and they've just covered those cars still under warranty. Since I didn't drive enough, the seal issues on my car took longer to start leaking, and then out of warranty. HELP!

Thermo Control Valve Failure- Contact Subaru of Cherry Hill, NJ for Inspection 177,4XX Miles P26A5 code Check engine Light on, Disabled Safety Systems (Eyesight System), Car may have overheated if not pulled over and turned off. Part of warranty extension but did not qualify due to mileage.

We are VERY concerned about the failure of some very important safety features of our 2021 Subaru Outback Touring Edition. We were involved in a bad car accident caused by a person under the influence who was in handcuffs when we were taken away by ambulance. As you can see by the photos, there was MAJOR damage to the other car and significant damage to ours. What is most concerning is the fact that NONE of the airbags deployed and the safety and security plan also failed - it did not call 911. I had to find my phone on the floorboard and call 911 myself. I am not sure if the insurance company will call it a total loss but I really don't think I want the car back BECAUSE of the failures of these very important safety features. I truly feel like Subaru has some explaining to do on this.

The airbag light came on in my car even though the cars airbags have never deployed. The code that the scanner is bringing up is B1784. The description for this error is Right front occupant detection sensor collision detection, Subaru has a safety recall for this exact issue for this exact year and type of car but are stating my vin does not have the recall. I have contacted them and they stated there is nothing they can do for me to fix this recall because my car's vin is not showing to have this recall.

Good Day! I bought my 2021 Subaru Outback XT Onyx in Jan 2021. I had waiting 6 yrs for Subaru to use the Turbo Motor in the Outback again. I've had this car for 5 years with my warranty running out Jan 2026, but I only drive 5000-7000 miles per/yr. Current odometer is 29,901 miles. At my most recent oil change service at the Dealer, they showed me a video of my cars drivetrain from underneath. There were two bad seal leaks. One at the transmission pump housing and the other at the Upper Oil Pan. I had been there for an oil change a year earlier for the same service and there was no mention of these issues! After speaking with the service advisor, he said to call Subaru Customer Advocates. They listened to my situation and a few days later offered a $1400 credit for a $4000 job that involves the removal of my cars engine (upper oil pan) to replace it because it's bolted to the frame there. The other leak seal involves dropping the transmission. These are major repairs that following will dampen my ownership experience after decades of Subaru praise by Americans. I researched this issue online and found out there was a manufacturing defective regarding the silicone liquid seals they used for 2020-2022 Outback, Ascent, & WRX! This procedure was used throughout the driveline with the Turbo Motor & CTV Trans. There are 1000s of accounts of this defect placing burden on the owners of these cars who bought them in good faith. I did the research, called the dealer & Subaru with the discovery & overall complaint! I asked for 80% to 100% help with these repairs because how many more will I have to deal with after these two are repaired??? I have received zero responses from either after expressing that this was a known defect, Bullitens went to all the dealers, nothing was mentioned to the owners, and they've just covered those cars still under warranty. Since I didn't drive enough, the seal issues on my car took longer to start leaking, and then out of warranty. HELP!

Thermo Control Valve Failure- Contact Subaru of Cherry Hill, NJ for Inspection 177,4XX Miles P26A5 code Check engine Light on, Disabled Safety Systems (Eyesight System), Car may have overheated if not pulled over and turned off. Part of warranty extension but did not qualify due to mileage.

SUDDEN AACCELERATION: Cold started the car in garage, all OK. Then backed out and into turn around where I placed foot on the brake. At that moment suddenly accelerated and engine revved to 2000rpm (sounded like). I had to push down very hard on the brake pedal (where my foot already was) to stop the car before crashing into a tree. Foot was clearly on brake pedal at incident (that was the only way I could stop the car). It was not on or close to accelerator pedal and no floor mat or other objects was on or near the accelerator pedal. Very concerned about safe vehicle with this sudden acceleration. Appointment with Subaru dealer made for full diagnostic check. Dealer is White Bear Subaru, [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ON thursday night at about [XXX] i was driving in the carpool lane going north.in the [XXX] , with full tank of gas ; suddenly i felt and here a noise, and the vehicle (2021outback base) start losing power, at the point that totally stop. call 911, and few minutes after the hway patrol came and push us out of the freeway, there was not any shoulder to be safe out. when the police officer try to turn it on the vehicle star but no power was available even when the vehicle was on.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Subaru Outback. The contact stated while driving approximately 40 MPH, the check engine, ABS, and brake warning lights illuminated. The contact pulled over to the side of the road. The contact turned off the vehicle and waited for several minutes before restarting the vehicle; however, upon restart the transmission failed to shift into the desired gear. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the vehicle was not covered under warranty due to a third-party damage to the rear brake cable. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 24,000.

As I was approaching a T intersection and preparing to stop at the stop sign, I started to apply my brakes when all of a sudden my car accelerated and lunged forward almost into the path of oncoming traffic on the intersecting road. As I had originally started to apply my brake, it felt as if the brake dropped slightly under my foot but, as the car lunged forward, I immediately jammed on the brake so I am not 100% sure about that dropping sensation. It all happened within a matter of seconds. Anyway, jamming on the brakes stopped the forward momentum and the car stopped before actually entering the path of an oncoming car. If I had started to brake any closer to the intersection, I may not have had time to stop the car in time to avoid a broadside collision with the oncoming car. I have owned this car about a year and a half and this is the first time anything like this has happened. There was no warning lamps, messages etc at the time or prior to the incident. After the incident, my husband checked online and saw that others have described a similar experience with their Subarus and, apparently, there is an ongoing lawsuit involving this problem. This just happened last evening so I have not yet taken my car to the dealer to be inspected but plan to do so soon.

Sunroof exploded driving home in 90 degree sunny and clear weather. It sounded like a gun went off right over my head. It scared me so bad I jerked my steering wheel into the other lane. Thank God no one was in that lane. I had to get it replaced at Mid State Glass company. according to what I found on the internet this happens rather frequently. No notification by Subaru that this was even a possibility. I have the receipt the replaced sunroof and photos of the sunroof after it exploded.

The car flashed “eye sight off” before flickering and shutting off while I was braking at a stop light. I tried putting my car into park and then turning it off and restarting it but it would not turn back on. I tried this a few more times but I was in the middle lane of a heavily trafficked street. The steering wheel was locked and I was not able to immediately remove it from the road and maybe an hour later it was able to be shifted into neutral and moved out of the street. However, it would still not turn on and when I did open my power gate, the gate would not secure closed. I took it to the dealership that I purchased it at and where it is also regularly serviced (with the last service date only over one week ago,) and they were not able to determine what happened but instead mentioned that my car had no internal data of any errors occurring and that the car was able to be started when they serviced it. I took a picture of the dash as it was flashing with all of the error codes and submitted that to the tech that was working on my car, but they asked me if I’d had someone “clear my codes” which is not something I’m familiar with or even capable of doing- I don’t even know anyone that would be capable of doing that for me. The whole ordeal cost me a day of work and now my peace of mind as I am unsure of if this may happen again and now I am worried it may happen while my kids are in the car. I’ve had similar issues with my center console messing up but nothing as urgent as my whole car shutting down and my steering wheel locking in the middle of traffic.

The car was built & sold new, with the rear suspension not aligned properly, and cannot be aligned to factory specifications. The car has been taken to 4 service stations, 3 Subaru dealer service repair shops, without being able to be aligned.after further investigation, I’ve found this to be a common problem for this vehicle type. I consider this Safety related due to the unusual tire wear & risk of tire failure.

I have experienced premature rear brake wear and excessive tire wear. Issues with infotainment system and pre-collision braking system. (1) Regarding Tires: Performed all dealer recommended tire rotations and aligned vehicle when recommended. Needed new tires at 31,169 miles. Tires showed excessive inside wear. Bought new tires from a 3rd party shop and had alignment done with hunter alignment system. Showed rear right camber at -2.0. Subaru recommends -1.8 to 0.3. Rear camber is not adjustable on this model. Took vehicle back to dealer for brake job and they said camber was fine...there is a spec for a reason. Did not want to attempt to bring it in spec with aftermarket kits (i.e. adjustable cam bolt) or fix under warranty. (2) Regarding Brakes: Needed new brakes at 31,169 miles. Not covered under warranty and not what I would consider typical wear based on my driving style and my past experience with Subaru vehicles. If this is an expected side affect of the EBD system I would highly recommend Subaru consider ways of improving brake life on their vehicles. (3) I have the Onyx XT trim with navigation. Infotainment system is constantly glitchy. Examples include booting with blank black screen, failing to load, excessive lag while operating system or will freeze and beep repeatedly while buffing a menu selection. Also, had my car battery replaced under warranty within the first two years due to a bad battery. (4) Issues with ADAS system, specifically pre-collision breaking. This system is extremely sensitive and will over-react / take control in certain situations where I didn't need it to even when I was in the process of braking. Have had this system activate on the highway at high speeds while switching lanes on the highway or when having a vehicle merge quickly into my lane in front of me. Constantly, have to turn off this system which is a chore as this system is defaulted to always being on. Do not feel safe driving with this system on.

I am filing this complaint regarding multiple serious safety defects in my 2021 Subaru Outback purchased in July 2021, currently at 48000 miles THERMO CONTROL VALVE FAILURE (26,307 miles) While traveling in the center lane on [XXX] southbound in [XXX] the evening of 1/6/2024 my vehicle suddenly experienced a complete loss of control. It seemed that the car was accelerating and braking at the same time without driver input making it impossible to operate safely. It started shaking and several lights were illuminated on the dashboard, power steering was not working. The car coasted to the right shoulder and starlink was used to call for help. The car was towed to the dealership for repairs. The diagnosis was a failed thermo control valve and related sensor circuit. There were no dashboard lights before the incident that fore shadowed this event. This failure rendered the vehicle completely inoperable at highway speed and posed and extreme risk to the safety of the driver, passenger and other motorists. I am aware that Subaru has extended the warranty on the thermo controls valve to 15 years/150000 miles for 2020-2022 Outback’s which suggests that Subaru had knowledge of the defect. Since the incident several other premature “wear” defects have presented under 48000 miles on a 2021 vehicle: - 41,402 miles: driver side rear strut replaced - 41,402 miles: rear brake pads and rotors - 41,402 miles: driver side front window motor, regulator and run Chanel - 41808 miles: rear knuckle assembly, rear wheel bearing and backing plate replaced - 45,768 miles: front brake pads and and rotors replaced - 48,000 miles: complete exhaust system - 48,000 miles: passenger side front window motor, regulator and run chanel This vehicle has proven to be uncharacteristically unreliable for a Subaru Outback. The intended use for this vehicle is for my children to drive to college nearly 600 miles from home in the fall. This car is not appropriate for this purpose. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

The car flashed “eye sight off” before flickering and shutting off while I was braking at a stop light. I tried putting my car into park and then turning it off and restarting it but it would not turn back on. I tried this a few more times but I was in the middle lane of a heavily trafficked street. The steering wheel was locked and I was not able to immediately remove it from the road and maybe an hour later it was able to be shifted into neutral and moved out of the street. However, it would still not turn on and when I did open my power gate, the gate would not secure closed. I took it to the dealership that I purchased it at and where it is also regularly serviced (with the last service date only over one week ago,) and they were not able to determine what happened but instead mentioned that my car had no internal data of any errors occurring and that the car was able to be started when they serviced it. I took a picture of the dash as it was flashing with all of the error codes and submitted that to the tech that was working on my car, but they asked me if I’d had someone “clear my codes” which is not something I’m familiar with or even capable of doing- I don’t even know anyone that would be capable of doing that for me. The whole ordeal cost me a day of work and now my peace of mind as I am unsure of if this may happen again and now I am worried it may happen while my kids are in the car. I’ve had similar issues with my center console messing up but nothing as urgent as my whole car shutting down and my steering wheel locking in the middle of traffic.

I purchased a new 2021 Subaru Outback Onyx Edition XT in May of 2021. The headlights have been a continual problem and I cannot get a solution from the dealer. They are way too bright. It’s a safety hazard to oncoming drivers. I also believe it’s a personal security risk to me from angry drivers. And there's nothing I can do about it because I don't have my high beams activated. The headlights need to have two separate intensity settings, one for low beam and one for high beam, but they do not. Currently, the low beam and high beam use the same intensity LED. The switch between high and low beams does not change the intensity or brightness. It merely activates a motor that moves a metal plate. The plate acts as a shutter that changes the angle the lights shine so the driver has a broader field of vision. The intensity of the lights do not change. The high beams are always on even when not activated. No wonder oncoming drivers are flashing their high beams and getting angry. I have voiced my concerns to the Subaru dealer who checked my headlights and said they were properly aimed. I have voiced my concerns on the Subaru forum and found many other drivers are experiencing the same problem. Some people on that forum suggest re-aiming the headlights so they point lower. This does not solve the problem. Doing so limits visibility to a very short distance ahead of the vehicle creating a different safety issue, not being able to see objects, animals, or people in the roadway. FMVSS No. 108 requires 2 intensity settings for motor vehicle headlights. Subaru has not provided that and is in violation of that federal regulation. I am requesting that NHSTA exercise whatever regulatory authority it has to enforce this requirement including issuing a recall on the Subaru Steering Responsive Headlights. Watch 18:45 to 21:30 of this YouTube video to see the inner workings of these headlights: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle was on highway in stop and go traffic when brake was applied. Auto stop-start feature engaged which turned engine off. On release of brake the auto stop-start feature failed to restart vehicle. Engine tried and failed to turn over and all console lights flashed on and off continuously. Ignition was turned off and attempted to restart car unsuccessfully. Four way hazard light button was activated and showed on dashboard as on. However, hazard lights on outside of vehicle were not on causing cars behind to not realize car was immobilized. Hazard lights malfunctioning on an immobilized vehicle on the highway is extremely unsafe.

I am filing this complaint regarding multiple serious safety defects in my 2021 Subaru Outback purchased in July 2021, currently at 48000 miles THERMO CONTROL VALVE FAILURE (26,307 miles) While traveling in the center lane on [XXX] southbound in [XXX] the evening of 1/6/2024 my vehicle suddenly experienced a complete loss of control. It seemed that the car was accelerating and braking at the same time without driver input making it impossible to operate safely. It started shaking and several lights were illuminated on the dashboard, power steering was not working. The car coasted to the right shoulder and starlink was used to call for help. The car was towed to the dealership for repairs. The diagnosis was a failed thermo control valve and related sensor circuit. There were no dashboard lights before the incident that fore shadowed this event. This failure rendered the vehicle completely inoperable at highway speed and posed and extreme risk to the safety of the driver, passenger and other motorists. I am aware that Subaru has extended the warranty on the thermo controls valve to 15 years/150000 miles for 2020-2022 Outback’s which suggests that Subaru had knowledge of the defect. Since the incident several other premature “wear” defects have presented under 48000 miles on a 2021 vehicle: - 41,402 miles: driver side rear strut replaced - 41,402 miles: rear brake pads and rotors - 41,402 miles: driver side front window motor, regulator and run Chanel - 41808 miles: rear knuckle assembly, rear wheel bearing and backing plate replaced - 45,768 miles: front brake pads and and rotors replaced - 48,000 miles: complete exhaust system - 48,000 miles: passenger side front window motor, regulator and run chanel This vehicle has proven to be uncharacteristically unreliable for a Subaru Outback. The intended use for this vehicle is for my children to drive to college nearly 600 miles from home in the fall. This car is not appropriate for this purpose. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

The car was built & sold new, with the rear suspension not aligned properly, and cannot be aligned to factory specifications. The car has been taken to 4 service stations, 3 Subaru dealer service repair shops, without being able to be aligned.after further investigation, I’ve found this to be a common problem for this vehicle type. I consider this Safety related due to the unusual tire wear & risk of tire failure.

This is 3 years old with 27000 miles. The driver's side seat has cracked and tear. This is what subaru is putting out there for the public. Cheap material and poor workmanship.