2000 Suzuki Esteem

TL* THE CONTACT OWNS A 2000 SUZUKI ESTEEM. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE MADE A LOUD GRINDING NOISE AND SMOKE APPEARED FROM THE FRONT PASSENGER SIDE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE FRONT CROSS MEMBER BAR FRACTURED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

NHTSA ID

10638725

Incident

Sep 19, 2014

Mileage

80,000 mi

2000 SUZUKI ESTEEM. CONSUMER WRITES IN REGARDS TO VEHICLE FRONT END PROBLEMS AND SEEKS REIMBURSEMENT FOR UNAUTHORIZED REPAIRS. *SMD THE CONSUMER STATED HE TOOK THE VEHICLE TO A REPAIR SHOP FOR FRONT END PROBLEMS. WHILE THERE, HE WAS INFORMED A RECALL HAD BEEN ISSUED FOR A FRAME PROBLEM. THE CONSUMER THEN CONTACTED THE DEALER, AND THEY CONFIRMED, THAT IN FACT, THE VEHICLE WAS COVERED. THE VEHICLE WAS THEN TOWED TO THE DEALER. THE NEXT DAY, THE CONSUMER RECEIVED A CALL FROM THE DEALER, STATING A MISTAKE HAD BEEN MADE, AND THE VEHICLE WAS NO LONGER COVERED UNDER THE RECALL. ACCORDING TO THE DEALER, THE VEHICLE WAS NOT COVERED BECAUSE IT WAS FIVE MONTHS OLDER THAN THE RECALLED COVERED. THE DEALER INFORMED THE CONSUMER THE COST FOR THE REPAIR WAS $603.26 AFTER DEDUCTING $300 FROM THE ORIGINAL BILL. THE CONSUMER STATED HE NEVER AUTHORIZED THEM TO PERFORM THE WORK, SINCE THE RECALL WAS NO LONGER VALID.

NHTSA ID

10500361

Incident

Nov 2, 2012

VEHICLE BROKE DOWN AND RUMBLED UPON TURNING... APPARENTLY SUZUKI KNOWS OF THE RECALL BUT IS NOT WILLING TO REPAIR OUTSIDE MARCH 2012. *TR

NHTSA ID

10475269

Incident

Aug 22, 2012

Mileage

153,000 mi

TL* THE CONTACT OWNS A 2000 SUZUKI ESTEEM. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE INSPECTED, SHE WAS NOTIFIED THAT THE SUB FRAME WAS CORRODED. THE VEHICLE WAS TAKEN TO A DEALER WHO STATED THAT THE SUB FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 125,000.

NHTSA ID

10457516

Incident

Apr 26, 2012

Mileage

125,000 mi

2000 SUZUKI ESTEEM SEDAN. THE SUBFRAME AND FRONT PASSENGER SIDE AXEL RUSTED THROUGH AND COLLAPSED WHILE TURNING CORNER. LOUD GRINDING OF TIRES. THIS CAUSED THE FRONT PASSENGER SIDE WHEEL TO BE PUSHED BACK INTO THE WHEEL WELL. REPAIRED COST OF $1200. FORTUNATELY NO ONE WAS HURT AS THE VEHICLE WAS SLOWING DOWN, BUT IF THESE PARTS HAD FAILED AT HIGHWAY SPEEDS, IT IS QUITE LIKELY A FATAL ACCIDENT WOULD HAVE OCCURRED. I HAVE SEARCHED ON LINE AND FOUND THAT OTHER SUZUKI OWNERS HAVE REPORTED THIS SAME PROBLEM. I WROTE TO CORPORATE RELATIONS AT SUZUKI IN BREA CALIFORNIA, THEY CONTACTED ME AND LEFT A MESSAGE THAT THEY WERE NOT GOING TO REIMBURSE ME FOR THE COST OF REPAIR AND THAT THE WARRANTY FOR THIS KNOWN PROBLEM WAS NO LONGER IN EFFECT AS OF DEC 21, 2011. HOWEVER, THE WARRANTY THEY SENT TO OWNERS SAID THIS REPAIR WOULD BE FOR 12 YEARS FROM THE DATE THE CAR WAS ORIGINALLY PUT IN SERVICE OR 180,000. MY CAR MET THE CONDITIONS BUT THEY REFUSE TO HONOR THE COVERAGE EXTENSION WARRANTY. I HOPE THIS VEHICLE IS RECALLED OR AT LEAST OWNERS SHOULD BE NOTIFIED OF THIS DEFECT BEFORE A FATAL ACCIDENT OCCURS. *TR

NHTSA ID

10457250

Incident

Apr 19, 2012

TL* THE CONTACT OWNS A 2000 SUZUKI ESTEEM. THE CONTACT WAS DRIVING 40 MPH WHEN A DEER CRASHED INTO THE FRONT PASSENGER SIDE OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY AND A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHO DIAGNOSED THAT AS A RESULT OF THE CRASH, THE FRONT AXLE, CV JOINT, HOOD, RADIATOR, HEADLIGHTS AND THE FRONT PASSENGER SIDE FENDER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,931.

NHTSA ID

10418281

Incident

Aug 2, 2011

Mileage

125,931 mi

TL* THE CONTACT OWNS A 2000 SUZUKI ESTEEM. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT DROVE OVER A POT HOLE AND THE STEERING WHEEL BECAME UNCONTROLLABLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC ADVISED THAT THE AXLE AND THE A-FRAME WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10386680

Incident

Feb 22, 2011

2000 SUZUKI ESTEEM WAGON. SUBFRAME AND FRONT PASSENGER SIDE AXEL RUSTED THROUGH AND COLLAPSED WHILE COMING TO A STOP.. THIS CAUSED THE FRONT PASSENGER SIDE WHEEL TO BE PUSHED BACK INTO THE WHEEL WELL. THE CAR NEEDED TO BE TOWED AND IS BEING REPAIRED FOR A COST OF $1000. FORTUNATELY NO ONE WAS HURT AS THE VEHICLE WAS SLOWING DOWN, BUT IF THESE PARTS HAD FAILED AT HIGHWAY SPEEDS, IT IS QUITE LIKELY A FATAL ACCIDENT WOULD HAVE OCCURRED. I HAVE SEARCHED ON LINE AND FOUND THAT OTHER SUZUKI OWNERS HAVE REPORTED THIS SAME PROBLEM. I HOPE THIS VEHICLE IS RECALLED OR AT LEAST OWNERS SHOULD BE NOTIFIED OF THIS DEFECT. *TR

NHTSA ID

10346277

Incident

Jul 27, 2010

Mileage

90,000 mi

Reminder of the importance to conduct safety inspections for rust damage to suspension and related parts that could be caused by road salt or other chemicals applied to the roadway.

This Service Bulletin was sent by Suzuki Motor Corporation to its authorized Suzuki automobile distributors in the U.S., explaining the importance of proper inspection and maintenance of suspension lower arm ball joints to prevent the ball stud from becoming separated from the suspension lower arm.

SERVICE MANUAL UPDATE - IMPROPER TORQUE SPECIFICATIONS. *TT

SOME VEHICLES MAY HAVE DAMAGE TO THE VAPOR CONTROL VALVE. *SLC

THIS BULLETIN CONTAINS THE REVISED CLAIMS SUBMISSION PROCEDURES FOR REPLACEMENT BATTERIES UNDER WARRANTY. *TT

CORRECT COOLANT USAGE. *EH