2023 Tesla Model 3 Interior & seats Problems

The contact owns a 2023 Tesla Model 3. The contact stated that upon starting the vehicle and shifting to drive(D), the front trunk opened inadvertently, blocking the visibility of the roadway. The contact stated that the failure had recurred several times upon shifting to drive(D), which required the contact to exit the vehicle and manually close the trunk. The vehicle was taken to a Tesla service center and to Tesla Service Sunnyvale(680 E El Camino Real, Sunnyvale, CA 94087), where unknown repairs were performed several times; however, the failure persisted. Additionally, the contact stated that while attempting to reverse out of the garage, the contact was unaware that the garage door was closed, and the vehicle hit the garage door. The contact did not recall whether the rearview camera activated; however, the contact stated that the rearview camera pedestrian warning alert failed to engage prior to the incident. The contact stated that the garage door and the rear end of the vehicle were damaged. The manufacturer was contacted through the Tesla mobile app and advised the contact to take the vehicle to a Tesla service center for service. The vehicle was not diagnosed or repaired. The failure mileage was approximately 10.

NHTSA ID

11686613

Incident

Dec 22, 2023

Mileage

10 mi

Rear seat safety restraint system fault

NHTSA ID

11681752

Incident

Dec 10, 2024

The contact owns a 2023 Tesla Model 3. The contact stated that while the vehicle was parked, the contact attempted to open the trunk and the trunk inadvertently closed on the contact's finger. The contact was taken to a medical specialist and sustained an injury to a finger that required stitching, causing medical leave. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 19,500.

NHTSA ID

11672299

Incident

Jul 9, 2025

Mileage

19,500 mi

My pant leg got caught on the plastic seat trim under the seat. Kept my leg trapped so I fell out of the car on the ground in the parking lot. Happened again the same day, but I caught myself before I fell. The incident caused a hole and rip in my clothing, but the rest of my body went to the ground leaving my knee and other leg caught until the end. Had a different outfit on today and it caught again! I did not fall this time either. The time I did fall I hyperextended my wrist and landed on my hip and leg, creating bruising and a sore pelvis, knee and back. Went to massage therapist soon after. Currently, following up with doctor

NHTSA ID

11662611

Incident

May 1, 2025

On 5/28/24, while pulling up the driveway, the car suddenly accelerated and it’s so fast that we couldn’t react. The car crashed into the garage, knocked down one wall along with the main electrical panel. It stopped because it got stuck on 10 in foundation’s of garage structure. The collision mitigation feature did not get triggered and didn’t give any alert or helped to stop the car from crashing into the garage. Airbags on both driver and passenger sides did not deploy. Prior to this accident, the car already had issue with the driver’s profiles and the seat just moved back and stuck at the easy entry mode. The car became inoperable because the driver’s seat can’t be moved forward to a position where I could reach the gas and brake pedal. I contacted Tesla service and was told to delete the driver’s profile and create new one , power off the screen, power cycled the car. I’ve done all of that but the problem kept happening on and off. The car was scheduled to be looked at by Tesla on 6-20-24 but the accident happened on 5-28-24. We’d like to find out the root cause of the accident whether the car has any malfunction that could’ve triggered the sudden unintended acceleration. We’ve reported the accident to both Tesla and my insurance company. Tesla confirmed that the data was downloaded and being reviewed and there is no available information to be shared with me at this time

NHTSA ID

11596070

Incident

May 28, 2024

Driver seat will adjust itself while driving down the road. While the seat is moving by itself it will also roll the da window down and no way to roll it up. While all things happening the heat will also stop working.

NHTSA ID

11566722

Incident

Jan 20, 2024

When involved in a rear-end collision the drivers seat malfunctioned. It went into a laid down position and twisted causing a back injury.

NHTSA ID

11565545

Incident

Jan 12, 2024

On July 5, 2023 my front passenger seat assembly was replaced due to a passenger safety restraint system fault. Two days ago I discovered two black self tapping bolts sitting behind the front passenger seat on the floor mat. The front passenger seat assembly was only connected to the car chassis by the two front mounting bolts. It was possible to tip the seat forward by pushing on the headrest. I am now able to screw these two bolts almost completely back into the chassis using fingertip pressure only. Either these bolts were never installed during seat replacement or they simply rattled loose and fell out. This attachment hardware needs to be designed for repeated installation removal cycles over the life of the vehicle and should require considerable torque for installation and removal. Something is seriously wrong!

NHTSA ID

11552431

Incident

Jul 5, 2023

I just purchased this new 2023 Tesla Model 3. I am not reporting a failed or malfunctioning component but I have a safety concern. After taking delivery I noticed that there are no emergency door latch releases on the rear seats like there are on the front seats. This could make exiting the back seats very difficult or even impossible in the event of an emergency with loss of power to the vehicle. I cannot believe that this feature was omitted. I worry that people will die because they will not be able to escape a burning vehicle quickly enough. This seems like the door could be easily modified to correct this issue and make this vehicle much safer.

NHTSA ID

11543982

Incident

Aug 26, 2023

On August 5, 2023, my car charge got too low for me to make it to a charging station in Lafayette Louisiana. I had the vehicle towed on a flat bed. I put the car in Tow Transportation mode. While we were towing the car, I opened the car to check the battery level and somehow the frunk was activated (perhaps I accidentally hit it, I'm not sure). The frunk opened while we were going about 60 mph down the highway, the wind lifted the trunk up and it crushed my front windshield and the frunk and opening mechanics were damaged. Had we not immediately pulled over the frunk hood could have been ripped off the car by the wind and caused a major accident. This seems to be a flaw in the Tesla electronics/app system - you should not be able to open the Frunk once it is put into Tow Transportation mode.

NHTSA ID

11536774

Incident

Aug 5, 2023

The rear door jammed shut. It would not open and we discovered there is no mechanical way for a passenger to open the back doors of a Tesla model 3. The car’s electrical system has to be on and functioning properly in order to exit from the back. This is terrifying.

NHTSA ID

11534463

Incident

Jul 10, 2023

Brand new Tesla Model 3 delivered a week ago. Passenger seat, front inside mounting bolt is not tight. Corner of the seat rail can move up/down 1/8-1/4". Can't tell how well attached it is. Potential safety concern. Passenger side back seat cushion also exhibits up/down movement 1/8-1/4" but likely not a safety issue.

NHTSA ID

11511484

Incident

Mar 12, 2023

My Tesla Model 3 was delivered with the rear attachment bolts missing for both front seat rails. The rear seat rail end will lift up at least an inch when the seat is pushed gently from behind.

NHTSA ID

11497310

Incident

Nov 21, 2022