2025 Tesla Model 3 Problems

The contact owns a 2025 Tesla Model 3. The contact stated that while driving 13 MPH and making a right turn, the Full Self-Driving mode engaged unintendedly, and the vehicle suddenly veered to the left, accelerated unintendedly, and struck a median curb. The vehicle then veered to the right and struck another curb before driving onto the grass near the hospital. The vehicle was towed to a collision center. The insurance company inspected the vehicle. The dealer service center was contacted and sent an email to the manufacturer regarding the failure; however, there was no response. The vehicle was repaired. The failure mileage was unknown.

while waiting on left signal i changed my destination address when signal turned green car take straight on red signal .car is on fsd mode . happend on sep-19 at south ridding junction

Statement Regarding My 2025 Tesla Model 3 Accident I was driving my 2025 Tesla Model 3 when the accelerator pedal appeared to become stuck, causing the vehicle to continue accelerating. The vehicle reached approximately 70 mph, and I was unable to regain control. I attempted to stop the vehicle by applying the brakes, but the brakes felt hard or would not respond, and the vehicle would not stop as expected. I was driving the vehicle myself and was not using Autopilot or Full Self-Driving. Because I could not bring the vehicle to a stop, I collided with three other cars. I believe the suspected accelerator and braking malfunction contributed to the accident. The police responded to the accident and prepared a report. My Tesla was towed from the scene to a tow yard. I reported the accident to my insurance company, which provides full coverage on my vehicle. At this time, my insurance company has not yet declared the Tesla a total loss, and I still have an outstanding car loan. I sustained bruising to my hand and ribs and went to the emergency room for medical evaluation. I am requesting that the vehicle be preserved for an independent inspection so the cause of the accident can be investigated, including the reported accelerator and braking problems and any relevant electronic vehicle data. This statement reflects my recollection of what happened and is provided so the accident and suspected vehicle malfunction can be properly investigated.

On XXX, at approximately 8:10 PM PDT in [XXX], I was driving my 2025 Tesla Model 3 (VIN [XXX]) with Full Self-Driving (Supervised) engaged. While FSD was actively steering a right turn at an intersection, the vehicle turned too wide, crossed into the oncoming lane, and collided head-on with another vehicle. Both vehicles were totaled and the airbags deployed. Tesla's own Vehicle Data Report for this crash confirms the FSD system (state: ACTIVE_FSD) was engaged and steering the vehicle in the seconds before impact at approximately 20-26 mph, and that FSD disengaged less than one second before the collision. I was lightly pressing the accelerator (Tesla's documented method to confirm proceeding through an intersection) while FSD controlled steering. No automatic emergency braking prevented the vehicle from entering the oncoming lane during the FSD-executed turn. I sustained injuries requiring six months of psychological treatment. I believe FSD's intersection turning behavior is defective: the system executed a turning maneuver that placed the vehicle into oncoming traffic, causing a head-on collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

See attached document for complaint.

After an informal, photo-based preliminary repair estimate for minor cosmetic damage at Tesla Collision Center Fort Lauderdale in late XXX (estimate never finalized, no repair performed), Tesla's internal system flagged my 2025 Tesla Model 3 (VIN [XXX]) as salvage/total loss, revoked Supercharger access, and voided the manufacturer warranty. Tesla confirmed the salvage designation in writing on XXX. Neither the DMV nor any insurer declared this vehicle salvage or a total loss: DMV records show a clean title, Tesla Insurance canceled the claim (accident not my fault) with no total-loss declaration, and the at-fault driver's insurer, [XXX], confirms it never issued a salvage title. As a result, the vehicle cannot use the Supercharger network and cannot receive warranty service or maintenance. My household has no home charging, so the vehicle cannot be charged sufficiently for longer trips, creating a risk of being stranded with a depleted battery. Tesla has not corrected the flag despite my XXX email to Customer Service and multiple in-app Service chats that were closed without resolution. I am concerned that an erroneous internal designation is disabling charging access and blocking safety-related maintenance on an otherwise roadworthy vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Statement Regarding My 2025 Tesla Model 3 Accident I was driving my 2025 Tesla Model 3 when the accelerator pedal appeared to become stuck, causing the vehicle to continue accelerating. The vehicle reached approximately 70 mph, and I was unable to regain control. I attempted to stop the vehicle by applying the brakes, but the brakes felt hard or would not respond, and the vehicle would not stop as expected. I was driving the vehicle myself and was not using Autopilot or Full Self-Driving. Because I could not bring the vehicle to a stop, I collided with three other cars. I believe the suspected accelerator and braking malfunction contributed to the accident. The police responded to the accident and prepared a report. My Tesla was towed from the scene to a tow yard. I reported the accident to my insurance company, which provides full coverage on my vehicle. At this time, my insurance company has not yet declared the Tesla a total loss, and I still have an outstanding car loan. I sustained bruising to my hand and ribs and went to the emergency room for medical evaluation. I am requesting that the vehicle be preserved for an independent inspection so the cause of the accident can be investigated, including the reported accelerator and braking problems and any relevant electronic vehicle data. This statement reflects my recollection of what happened and is provided so the accident and suspected vehicle malfunction can be properly investigated.

While operating the vehicle at low speed (~35 MPH reducing to a stop) on August 1, 2026, at approximately 10:38 AM under normal road and weather conditions, the vehicle experienced a catastrophic and simultaneous loss of primary braking capability and steering responsiveness. > Detailed Description of Failure: > * Brake Failure: Upon pressing the brake pedal, the vehicle failed to decelerate or stop adequately despite continuous application, nearly causing a collision. > * Steering Loss / Disconnection: Concurrently, while the steering wheel could physically be turned, it offered no directional control—turning the wheel had no effect on the vehicle's path, feeling as if the steering linkage or assist was entirely disconnected or disengaged. > Vehicle Warnings / Diagnostic Codes: > The vehicle's onboard display immediately registered critical active safety and chassis failures, specifically displaying: > * "ABS (anti-lock braking system) disabled - Drive with caution" > * "Automatic Emergency Braking is unavailable - Feature may be restored on next drive" > Dashcam video and system screen captures documenting the exact speed, timestamp, and error messages have been saved and are available upon request. No crash occurred, but the sudden, simultaneous failure of core braking and electronic steering systems presents an extreme safety hazard. >

This vehicle doesn't come with a turn signal stalk. To engage the turn signal, I have to use push-buttons on the steering wheel. Nearly every time I use them, I get the wrong direction, even after a year of ownership. It's functionally impossible to use them legally to exit a roundabout, and I really want you to reflect, it is impossible to use them to legally exit a roundabout -- I can not obey the law using them. It's functionally impossible. Additionally, they're too close to the edge of the steering wheel, causing light brushes to trigger a false turn signal, confusing nearby drivers. About 8 to 9 out of 10 turn signals I make are false or in the incorrect direction. This feature is dangerous and embarrassing. One last thing I want to note, this car disables the turn signal automatically after I exit a lane, or if it simply thinks I have. The car should never disengage the turn signal for any reason.

The design of the turn signals has several severe driver distracting safety issues. This is ultimately a design issue due to the choice of buttons on the steering wheel instead of a turn signal stalk. The buttons do not always activate the turn signals. Deactivation of the turn signals is counter intuitive, pressing the opposite direction does not deactivate them, instead activating the direction pressed. The significant departure from a standard stalk is dangerous. This is opposed to the other digital modifications tesla has made, as they are not in, or do not need to be in active use during driving activity, but the turn signals are a different matter.

On April 23, 2025, at approximately 8:15 PM, I activated Tesla's Smart Summon feature to retrieve my vehicle from a parking spot. While operating autonomously under Smart Summon, the vehicle failed to detect a pole in the parking area and drove into it, causing approximately $11,000 in damage to the vehicle. I was not inside or manually controlling the vehicle at the time. The vehicle's autonomous driving software failed to identify and avoid a stationary obstacle.

I purchased a new 2025 Tesla Model 3. During normal driving conditions, the rear bumper detached without any collision or impact. The bumper became loose while the vehicle was moving, creating a potential safety hazard. Tesla Service inspected the vehicle but declined warranty coverage and refused to properly repair the issue. The bumper was only temporarily reattached and remains misaligned. Additionally, shortly after purchasing the vehicle, the seat belt assembly had a failure and had to be repaired by Tesla under warranty. While Tesla addressed that issue, it adds to my concern about the overall quality and reliability of a brand-new vehicle. Because the vehicle is new and the failure occurred during normal driving, I believe this may indicate a defect. I am requesting assistance in reviewing this situation. Vehicle: 2025 Tesla Model 3 VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

A front wheel of this vehicle and/or its suspension is undergoing extremely dangerous vibrations at highway speeds (65-70+ mph). It is enough to shake the entire vehicle multiple times per second. The local service center, without looking at the vehicle, stated it "would be fine to drive on until your appointment" and scheduled an appointment nearly a month out into the future after I brought up concerns that the vehicle is unsafe to drive. They also would not recommend any third party service centers to look at the vehicle in order to address the concern more urgently, nor offered any alternatives such as rentals or loaner vehicles to use in the meantime. I understand that car issues will come up; my complaint is due to how it is being handled (long wait time for an appointment, dismissal over safety concerns, no alternatives to drive safely in the near month-long wait for the appointment).

Lately I keep getting the following concerning message on the dashboard of almost brand new 2025 Tesla 3 car, even after reset the screen : Steering Assist Reduced Steering may require Increased Effort See the attached picture of this message, I took this photo On Dec 25, 2025 at 12:56 pm with parked car. I am pretty concerned with potential safety issue with the important steering-function while driving on highway and other roads. The car has only 804 miles as of Dec 26, 2025. The new car was picked up on May 31, 2025 with 15 miles. I have the FSD on monthly subscription. I have sent a message to Tesla. It has provided me with a service appointment at its West Bloomfield Township Center in Michigan on Jan 26, 2026 at 10:30 am. At the time of setting the appointment an estimate of about $450 was provided. It is concerning since the new car is under warranty. I am submitting this concerning safety related issue to NHTSA - to please investigate.

The carpet floor mat on the driver's side accordions up under the accelerator and brake pedals creating a driving hazard. The driver side floor mat is supposed to be secured in place by an approximately 1 inch wide strip of velcro running the length of the floor mat under the edge closest to the seat. The Velcro is secured to the mat on three exterior edges. The Velcro is not secured on the interior edge allowing the Velcro to fold upwards and lose grip with the underlying carpet. Once the Velcro detaches and folds from the mat, it loses all grip and begins to slide. I informed two different Tesla dealers about the incident and they simply suggested I buy an identical replacement mat. They did not consider it a warranty issue and didn't admit that the mats were inherently defective even though this identical problem has been clearly documented and discussed on numerous internet forums.

A front wheel of this vehicle and/or its suspension is undergoing extremely dangerous vibrations at highway speeds (65-70+ mph). It is enough to shake the entire vehicle multiple times per second. The local service center, without looking at the vehicle, stated it "would be fine to drive on until your appointment" and scheduled an appointment nearly a month out into the future after I brought up concerns that the vehicle is unsafe to drive. They also would not recommend any third party service centers to look at the vehicle in order to address the concern more urgently, nor offered any alternatives such as rentals or loaner vehicles to use in the meantime. I understand that car issues will come up; my complaint is due to how it is being handled (long wait time for an appointment, dismissal over safety concerns, no alternatives to drive safely in the near month-long wait for the appointment).

I was on the freeway in the fast lane approaching a tunnel and vehicle came with warning vehicle shutting down. Code DL_a063. Vehicle stopped in fast lane would not move to shoulder. No prior warning there was any issue. State police came and had vehicle towed. Lucky the car behind me was able to stop in time.

After the High Voltage Battery Contactor recall service, my 2025 Tesla Model 3 Performance suffered a sudden 13% drop in range (from 303mi to 264mi at 100% charge). An official Tesla Battery Health Test confirms the battery health is at 92% in less than a year of ownership. This degradation happened immediately following the recall procedure, indicating a hardware or software defect caused by the service.

The contact owns a 2025 Tesla Model 3. The contact stated that while the vehicle was parked, the front windshield fractured independently. In addition, the contact stated that there was no evidence of impact on the front windshield. The contact stated that the failure occurred while the vehicle was parked in an underground parking garage. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 4,050.

I am submitting this complaint to report a safety issue with the turn-signal buttons on my steering wheel of the 2024–2025 Tesla Model 3 Highland. The turn-signal buttons are located on the steering wheel surface instead of a traditional stalk. When the steering wheel is turned at any angle, the buttons are difficult to locate by feel, often requiring the driver to look down to activate them and take his eyes off the road. Trying to signal during turns, lane changes, or roundabouts is not intuitive, and I have nearly had several collisions. This design presents a potentially dangerous safety hazard and could increase the risk of collisions. Tesla should be required to recall and retrofit these vehicles with turn signal stalks on the steering wheel column.

I was on the freeway in the fast lane approaching a tunnel and vehicle came with warning vehicle shutting down. Code DL_a063. Vehicle stopped in fast lane would not move to shoulder. No prior warning there was any issue. State police came and had vehicle towed. Lucky the car behind me was able to stop in time.

After the High Voltage Battery Contactor recall service, my 2025 Tesla Model 3 Performance suffered a sudden 13% drop in range (from 303mi to 264mi at 100% charge). An official Tesla Battery Health Test confirms the battery health is at 92% in less than a year of ownership. This degradation happened immediately following the recall procedure, indicating a hardware or software defect caused by the service.

I purchased a new 2025 Tesla Model 3. During normal driving conditions, the rear bumper detached without any collision or impact. The bumper became loose while the vehicle was moving, creating a potential safety hazard. Tesla Service inspected the vehicle but declined warranty coverage and refused to properly repair the issue. The bumper was only temporarily reattached and remains misaligned. Additionally, shortly after purchasing the vehicle, the seat belt assembly had a failure and had to be repaired by Tesla under warranty. While Tesla addressed that issue, it adds to my concern about the overall quality and reliability of a brand-new vehicle. Because the vehicle is new and the failure occurred during normal driving, I believe this may indicate a defect. I am requesting assistance in reviewing this situation. Vehicle: 2025 Tesla Model 3 VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On June 7, 2025, I was a passenger in a 2025 Tesla 3. Driver of Tesla made an unsafe lane change coming off an Interstate and my side was struck almost T-bone style by an oncoming vehicle going between 45-55mph. Our seatbelts did not lock us in place causing the driver to hit his head on steering wheel and then on driver side window causing lacerations and possible concussion. My side tool the impact and no side curtain airbags deployed and neither did the dash airbags. I am concerned that the location and speed with which we were hit could have been much worse up to and including death as the airbags did not deploy nor seatbelts firmly lock us in place. The car was deemed a total loss and all 4 panels on passengers side were impacted in the collision. I have pictures, Tesla video, police report I can provide. I want this looked into for defect of the Tesla sensors. All public data indicates that at a minimum the side curtain airbags should have deployed as there isnt much of a wrinkle zone and the speed of impact should have deployed them. I was unable to get out passenger side door and had to crawl across driver seat to get to EMS assistance. I was then transported along w Tesla driver to local hospital.

Description of Issue: The car displayed error code DI_a137 and unable to drive/pull over safely. The vehicle became undrivable and had to be towed to the Tesla service center. The service center diagnosed a rear drive inverter failure and replaced the entire inverter assembly. Safety Concern: It is alarming for a critical drivetrain component to fail completely within the first year of ownership and at such low mileage. A sudden loss of power while driving poses a serious safety risk to the driver and passengers.

On June 19, 2025, while parking my brand new 2025 Tesla Model 3 in a residential lot, the vehicle unexpectedly accelerated forward over a curb, crashed through a iron fence, and struck an outdoor A/C unit and patio furniture on the back of a neighbor’s unit. The car became stuck and had to be towed. On June 19, 2025, while parking my newly delivered Tesla Model 3, the vehicle suddenly and unexpectedly lurched forward, resulting in a crash. I was parking slowly and cautiously with my foot on the brake at all times. According to a neighbor who witnessed the incident, I was moving at a very slow speed when the vehicle suddenly surged forward without warning. I did not intend to accelerate, and I firmly believe this may have been the result of a system malfunction—possibly involving the vehicle’s sensors, software, or misinterpretation of pedal input. Tesla Service reviewed the driving log and stated that it showed I “stepped on the accelerator.” I respectfully dispute this conclusion, as the vehicle’s behavior was completely inconsistent with my actions. I am a careful, experienced driver with no prior accidents in over 30 years of driving. This incident raises serious concerns about Sudden Unintended Acceleration (SUA), a known issue that has been reported by other Tesla drivers in past years. If the vehicle misinterprets driver input or experiences a sensor/software glitch, this can lead to property damage or bodily injury, especially in tight parking situations or near pedestrians. I am submitting this complaint to ensure this matter is documented and investigated appropriately. Safety should not rely on logs alone — real-world behavior, driver feedback, and potential software/hardware flaws must be examined carefully.

While driving on the interstate my passenger was attempting to connect their phone to the bluetooth when they accidentally selected the driver profile. I was in the drivers seat and the seat immediately started moving back and I couldn't reach the gas or brake. I pulled over immediately and was able to reset it. The driver profile should be locked and not accessible while driving to prevent this.

Since leasing this car in April of 2025, it has been services 8 times totaling over 30 days of down time. The issues occured in order from oldest to newest/current: May of 2025 - Headliner trim falling down, unsuccessfully repaired by mobile technician June of 2025 - Windows stopped working. Center console door stopped shutting. Headliner still falling down. July of 2025 - Front wiring harness melted and took out the AC - the car didn't provide a single warning. The AC just stopped working. Passenger seat replaced for cosmetic defect August of 2025 - Continued issues with AC and turn signal buttons December of 2025 - Steering Wheel Rattle and Clunking, Suspension noises June of 2025 - Suspension still rough and making grinding noises, turn signal buttons still not functioning consistently, front passenger fold down mirror shattered because the passenger seat calibration allows it to slide into the mirror. Tesla has shown zero empathy towards any of these issues. A buyback was requested, but the offer would have left us without a car and with a huge pay off. We asked for help moving into another car, and we are ghosted.

On June 7, 2025, I was a passenger in a 2025 Tesla 3. Driver of Tesla made an unsafe lane change coming off an Interstate and my side was struck almost T-bone style by an oncoming vehicle going between 45-55mph. Our seatbelts did not lock us in place causing the driver to hit his head on steering wheel and then on driver side window causing lacerations and possible concussion. My side tool the impact and no side curtain airbags deployed and neither did the dash airbags. I am concerned that the location and speed with which we were hit could have been much worse up to and including death as the airbags did not deploy nor seatbelts firmly lock us in place. The car was deemed a total loss and all 4 panels on passengers side were impacted in the collision. I have pictures, Tesla video, police report I can provide. I want this looked into for defect of the Tesla sensors. All public data indicates that at a minimum the side curtain airbags should have deployed as there isnt much of a wrinkle zone and the speed of impact should have deployed them. I was unable to get out passenger side door and had to crawl across driver seat to get to EMS assistance. I was then transported along w Tesla driver to local hospital.

I sent following to Tesla I had an accident at around 6:30 PM on Sunday, March 2nd with my Tesla Model 3 and asking to see if you can conduct a diagnostic check into this incident. I was coming home at that time with the Tesla and about 100 yards from my house, I experienced a sudden acceleration with the car going from about 20mph to, I think, over 40 mph and crashed into the garage area of my house. Around the time I started experiencing that unwanted acceleration, I heard a whining sound. As it started that sudden acceleration, I checked below to make sure my right foot was pressing on the brake pedal and it was. Since I have the regenerative braking with my tesla, the car should have decelerated but, instead, it sped up. I continued to press the brake pedal but I could not mitigate my car’s continual acceleration. It eventually crashed through the lowered garage door and went through the right side of the garage wall about half way out and came to the stop. I was driving myself and not engaged in self-driving feature. I like to see if the Tesla has any resources available to retrace last few seconds and be able to glean more information of why that sudden acceleration might have happened. The car is still located in my garage but currently the car is disabled and powered off. The car’s power was on and it automatically turned on emergency light for about 30 minutes after the accident before it eventually powering off. I am also curious to know why none of the airbags were deployed in this accident. I have many photos available of the accident. The fire department and police came and assisted. I do not know if this matters but the couple of nights before the car had one of those over the air updates by Tesla and also about couple of minutes before the accident I drove through about a minute of hard rain in otherwise light rainy drive. I also wonder why auto-braking did not engage against the house.

The contact owns a 2025 Tesla Model 3. The contact stated that the vehicle was vibrating while driving at 60 MPH, and the vibration was going to the contact's head. There were no warning lights illuminated. The vehicle was taken to the local Tesla service center, where it was diagnosed with needing the four tires balanced, and the passenger’s side rear tire was replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to another local Tesla Service Center at 9950 NW 25th St, Doral, FL 33172) on four occasions. The dealer determined that the tires were unbalanced. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the Tesla Service Center, where the suspension torque was adjusted. The tires were rebalanced, but the failure persisted. The vehicle was taken to the Service Center, and it was determined that the failure was related to the front suspension. The vehicle was taken to the same Service Center, where it was diagnosed and determined that the steering column was the cause of the failure. The electric steering column and steering wheel were replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 8,434.