2022 Thor Motor Coach Scope

This is a Thor Scope RV built on the Promaster 1500 platform. The incident involves the Onan gasoline powered generator, which is directly connected to the fuel tank. Next to the generator in the fuel line, there is a small white inline fuel filter connected by the fuel hose going over a nipple on the filter and reinforced by a hose clamp. In my case, the hose clamp was not installed sufficiently over the nipple (far enough back on the fuel hose that it did not completely engage the nipple), and presumably from vibration associated with the generator operation and driving, the hose fully detached from the nipple and spilled fuel in an uncontrolled manner until I smelled/noticed it coming out from under the vehicle. There was certainly sufficient fuel to have started a major fire if it had reached an ignition source. Fortunately, I was able to get under the vehicle and push the parts back together once the problem was noticed. But, this would not have been possible if there were any ignition sources nearby. Fortunately, the vehicle was parked and off when the spill occurred. Had I not been able to stop the leak, it is my understanding that 3/4 of the tank would have drained since I've been told that the intake is located at the 1/4 full level of the tank to prevent the generator from running the vehicle completely out of fuel. Photos attached show the part after I pushed the hose back on and tried to reposition the hose clamp closer to the center of the filter. This was very difficult to do while laying on the ground under the vehicle, so I didn't get it on as far as I would have preferred until I was able to get the vehicle to a place where I could elevate it and get better access.

NHTSA ID

11703377

Incident

Mar 15, 2025

Rear passenger seat/couch, had passengers in back, hit bump and had to break…couch came apart as it was held together by two wood screws, once it came apart, seatbelts became useless as they became loose. Metal that holds them is cut in half and in a crash, passengers would go forward into driver.

NHTSA ID

11581283

Incident

Apr 4, 2024

Rear exit door on driver side will not open. THOR has placed a cabinet on the side that blocks the emergency exit in case of a kitchen fire. Manufacturer should have reversed the cabinetry or made it where both doors open in case of emergency.

NHTSA ID

11581281

Incident

Apr 5, 2024

I bought this THOR Scope with a recall on the awning. I reported to you that the fuel leaked from line to generator. I also reported all lines, propane/fuel/electrical touching everything sharp. THOR has tried to fix my awning recall 3 times in less than one year. Each time they say they’ve fixed it, it comes out going down the road. I have to pull the fuse. So does EVERYONE who has bought these. Read the forums. THOR will not provide me a copy of paperwork of what they’ve done. They fly someone in to work on it at a dealer, but won’t say what they’ve done. No record. This RV has so many electrical issues, safety issues that are being ignored. The water filter behind a cabinet has two screws and flops into the back window-eventually breaking it out going down the road. The mounts on the roof solar panel are not thick enough, they will crack and break. Solar panel moves wile going down the road. The couch/rear seat does not have proper construction to hold anything in place. It has two screws holding it in. In a crash, the couch will come apart and impale all those setting on or in front. THOR had the dealer wrap everything under my vehicle after I complained of everything touching sharp objects. Dealer had to replace propane lines after I reported that propane lines curved in a 90deg will crack and eventually break. Mine were bad.. I have documentation. I also had THOR replace the straight fittings from propane tank, with 45-90deg copper fittings. To keep from damaging the new hoses. I had THOR remove zip tied lines to break lines. Look, I worked at the weight stations for years, I used to own two tractor trailers… I know what right looks like…this thing is not safe all the way around and I can’t get the manufacturer to do what’s right. Maybe you can request the records of repair as by law they are supposed to have for you for this exact situation.

NHTSA ID

11580034

Incident

Mar 1, 2023

While traveling on the highway, the solar panel situated atop the van flew off as a result of strong winds. Fortunately, there were no injuries, but this issue poses a significant risk of severe harm or even fatalities. The solar panel remains unaccounted for. It is noteworthy that other owners of the same vehicle have reported similar problems. I am in contact with a representative of the manufacturer, Thor, but an inspection has not been conducted yet. There were no warning indicators or messages to notify me that the solar panel had detached; instead, it was a passing motorist who alerted me to inspect my roof.

NHTSA ID

11551505

Incident

Oct 22, 2023

The contact owns a 2022 Thor Motor Coach Scope. The contact stated while driving approximately 35 MPH, the awning opened independently and then detached from the vehicle. The contact pulled over to attempt to reattach the awning but was unable to do so. The contact called the dealer however, the contact was unable to take the vehicle to the dealer. The vehicle had not been repaired. The contact found that the failure was related to NHTSA Campaign Number: 23V068000 (Equipment) however, the vehicle was not included. The contact was unsure if the manufacturer had been contacted. The approximate failure mileage was 10,000.

NHTSA ID

11514647

Incident

Mar 4, 2023

Mileage

10,000 mi

The contact owns a 2022 Thor Motor Coach Scope constructed on a 2021 Ram Promaster 1500 Chassis. The contact stated that while the awning was closed, the awning extended unintentionally. Additionally, the awning made an abnormal sound. The contact related the failure to NHTSA Campaign Number: 23V068000 (Equipment). The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 102,600.

NHTSA ID

11513080

Incident

Mar 18, 2023

Mileage

102,600 mi

The Awning extends and retracts several times in a row, at about 1 foot extension, on intermittent occasions. If it goes fully out at highway speeds it could release from the van and potentially hit another vehicle, causing serious damage up to and including death. Thor has not issued a recall on this vehicle but other vehicles (Travato) with this same Awning have been recalled. This is an accident waiting to happen, actually it has happened numerous times already.

NHTSA ID

11501923

Incident

Nov 17, 2022

Revision to TSB 22-09 adding additional steps to make the repair easier and a time adjustment was made for the repair time.

Rize/Scope A/C not installed correctly.

The Generator and battery tray hangs down below the rear axle line of the vehicle and may contact road obstacles, such as speed bumps, at low speeds.

The Generator and battery tray hangs down below the rear axle line of the vehicle and may contact road obstacles, such as speed bumps, at low speeds.

This document refers to corrective actions for the repair and sealing of roof systems identified by the OEM.