Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 161 NHTSA owner-reported complaints for the 1996 Toyota 4Runner. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 161 · page 1 of 7
I have noticed that my vehicle doesn’t seem to be balance and most of the time i am afraid the tires will fall off by the movement of the vehicle. And the metal parts that attachment part it looks very bad on the metal parts like it rusted so bad. I hope they will be able to figure out whats wrong and if i am the only one who is experiencing this issue.
TL* THE CONTACT OWNS A 1996 TOYOTA 4RUNNER. THE CONTACT STATED WHILE DRIVING 70 MPH, THE SUN ROOF DETACHED AND FLEW OFF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT SHE WOULD RECEIVE A CALLBACK. THE FAILURE MILEAGE WAS APPROXIMATELY 256,000.
MY VEHICLE HAS BEEN SLIPPING A LOT CAUSING ME TO LOSE CONTROL OF THE VEHICLE IT'S NOT THE FIRST TIME IT HAS HAPPENED JUST RECENTLY IT HAPPENED AGAIN AND I WAS TOLD TO CHECK IF THERE WAS A RECALL ON THE VEHICLE BUT THERE WASN'T BUT AFTER RESEARCHING MY 4RUNNER I'VE READ THERE WAS SOME RECALLS ON THE CAR ABOUT THE REAR SUSPENSION.
THE REAR AXLE/SUSPENSION IS COMPLETELY RUSTED OUT. JUST TOOK IT TO MY AUTO SHOP FOR AN OIL CHANGE AND THEY WILL NOT PUT IT UP FOR AN OIL CHANGE BECAUSE THEY ARE AFRAID IT WILL COLLAPSE.
THE AXEL SUPPORT RUSTED OFF CAUSING IT TO SEPARATE FROM THE FRAME. THIS RESULTS IN A DANGEROUS CONDITION
AXEL SUPPORTS RUSTED OFF THE FRAME MAKING IT DANGEROUS TO DRIVE
FRAME IS RUSTING VARY BADLY, IN TWO YEARS THE FRAME THAT IS THE DRIVE TRAIN WILL BE ALL GONE RUST! AND AUTO WILL NOT BE DRIVABLE THEN
1996 TOYOTA 4RUNNER, THE FRAME IS RUSTTING OUT TOTALLY. THE TOTAL FRAME IS RUST OR GONE. THIS 4RUNNER WAS ZEBARTED WHEN NEW. I HAVE BOUGHT THIS 4RUNNER NEW FROM SUNSHINE TOYOTA BATTLE CREEK,MI
EXCESSIVE FRAME CORROSION. VEHICLE UNSAFE TO DRIVE.
TAKATA RECALL. ANTILOCK BRAKES SLIPPED AND DIDNT STOP. THE AIR BAGS OPEN UNTIL AFTER THE TRUCK WAS TOWED AND PARKED BACK AT MY HOUSE WHEN NO ONE WAS IN IT.
MY 1996 TOYOTA 4RUNNER SUFFERS FROM EXCESSIVE RUST THAT CAUSED ME TO BE HAVE A HORRIBLE LOSS OF VEHICLE CONTROL DUE TO THE FRAME EXCESSIVELY CRACKING. THE CRACKING WAS DUE TO WHAT AN INDEPENDENT RESEARCH COMPANY STATING THAT THE RIGHT-REAR FRAME RAIL CRACKED AND SEPARATED FROM THE FRAME DUE TO EXCESSIVE RUSTING. THE INDEPENDENT RESEARCH COMPANY POINTED TO NUMEROUS KNOWN REPORTING'S ON THE INTERNET AS A COMMON OCCURRENCE OF THIS VEHICLE. I MADE A PERSONAL CALL TO TOYOTA CUSTOMER CARE AND WAS TOLD THAT THEY LOGGED MY COMPLAINT BUT THAT THEY WOULD NOT COVER ANY CLAIMS HEREIN TO HELP IN FIXING THE ISSUE. MY VEHICLE ONLY HAD APPROXIMATELY 137,000 MILES AT THE TIME OF THE INCIDENCE. THE OCCURRENCE HAPPENED WHEN I WAS TRAVELING ON AN INTERSTATE AT APPROXIMATELY 65 MILES PER HOUR. I CROSSED AN AREA THAT HAD STANDING WATER (NOT DEEP BY ANY MEANS MIND YOU) AND THE REAR END COMPLETELY SHIFTED OUT TO THE RIGHT OF ME AND CAUSED ME TO SPIN. THIS WATER WENT ACROSS ALL THREE LANES AND NO ONE ELSE EXPERIENCED ANYTHING LIKE I DID. THE VEHICLE COMPLETELY SPUN AROUND AND I ENDED UP IN THE EMERGENCY LANE FACING HEAD ON AT ONCOMING TRAFFIC. I WAS FORTUNATE THAT NO ONE WAS INJURED OR HIT IN THE INCIDENT. HOWEVER, THE VEHICLE WAS NOT SAFE TO DRIVE DUE TO THE SEPARATION FROM THE FRAME AFTER THIS. I AM UPLOADING THE RESULTS OF THE INDEPENDENT ASSESSMENT STATING THEIR FINDINGS AND SHOWING PICTURES OF WHAT HAS HAPPENED.
I AM THE SOLE OWNER OF MY 1996 TOYOTA 4RUNNER. I HAVE ALL SERVICE AND MAINTENANCE RECORDS. NEW TOYOTA PARTS HAVE BEEN USED IN ALL REPAIRS PERFORMED BY MY LOCAL TOYOTA DEALERSHIP. WHILE DRIVING MY 4RUNNER THIS SPRING, I NOTICED IT STARTING TO SWAY ON THE HIGHWAY. A REAR SWAY BAR BROKE OFF. I CAN FEEL THE VEHICLE SWAY WHEN ACCELERATING AND DECELERATING. NOT ONCE DID MY TOYOTA DEALERSHIP SERVICE DEPARTMENT MENTION THAT MY FRAME WAS DETERIORATING FROM RUST. IT HAS BEEN ON THE LIFT A HUNDRED TIMES FOR MAINTENANCE AND REPAIRS, SOME EXTENSIVE, AND NOT ONE MENTION OF A RUSTING FRAME. NOW, IT MAY BE TOO LATE TO REPAIR DUE TO THE EXTENSIVE RUST. I HAVE SPENT THOUSANDS OF DOLLARS MAINTAINING MY 4RUNNER OVER THE YEARS. I FEEL TOYOTA HAS KNOWINGLY DECEIVED ALL 4RUNNER OWNERS OF THIS SAFETY ISSUE. ALL CURRENT OWNERS OF EARLY MODEL 4RUNNERS SHOULD BE ALERTED OF THIS SAFETY ISSUE AS LOSS OF CONTROL OF YOUR VEHICLE ON THE HIGHWAY IS IMMINENT.
FRAME RUST, A FAIR AMOUNT OF RUST IS CAUSING CONCERN AND MAKES ME QUESTION HOW TRUSTWORTHY VEHICLE IS. THE DATE LISTED ISNT THE DATE OF THE INCIDENT ITS ROUGHLY AROUND THE TIME THE EXTENT OF THE RUST HAD BEEN NOTICED.
FRAME IS RUSTING FROM INSIDE OUT. HOLES IN FRAME BIG ENOUGH TO PUSH YOUR WHOLE ARM THROUGH. AREAS OF FRAME CONNECTED TO SUSPENSION PREMATURELY RUSTING OUT. THIS REST OF THIS VEHICLE IS IN EXCELLENT CONDITION, BODY PANELS INCLUDED. WELDER TOLD ME ENTIRE FRAME IS RUSTING AWAY AND REPAIR TO THE FRAME IS VERY DIFFICULT ANF EXPENSIVE EVEN IF POSSIBLE. VEHICLE HAS UNDER 185,000 MILES AND RUNS GREAT. I HEAR CREAKING DEVELOPING AND AM AFRAID CAR MAY SPLIT IN HALF. WHY IS TOYOTA NOT STEPPING UP AFTER ADMITTING TO BADLY MANUFACTURED FRAMES.
SHOCK ABSORBER COMPLETELY WENT THREW THE FRAME CAUSING THE 4 RUNNER TO GO SIZE TO SIZE WHILE DRIVING. FRAME IS RUSTING FROM INSIDE OUT. VERY VERY DANGEROUS. THE SAME EXACT FRAMES ON THE TACOMATACOMA GOT A RECALL, THEY REPLACED THEM. WHY WASNT THIS RECALLED ON THE 4RUNNER? AND THE SEATBELTS JUST POP OUT OF THE BUCKLE WHILE YOUR JUST DRIVING. SOMETHING HAS TO HAPPEN SOON OR SOMEBODY IS GONNA GET VERY HURT ,OR KILLED. 1 MORE THING. I HAD A WHEEL POP OFF ALSO FROM THE BALL JOINT BREAKING LUCKILY THAT WAS IN MY DRIVEWAY, LUCKILY I WASN'T ON THE MAIN ROAD I COULD'VE KILLED SOMEBODY.
I WAS GETTING ON THE HIWAY RAMP AND WAS TRAVELING 60PMH WHEN MY VEHICLE FELT LIKE IT WANTED TO MOVE OVER TO THE NEXT LANE WHILE THE STEERING WHEEL WAS HELD STEADY. I TOOK THE VEHICLE TO NORTHPARK TOYOTA IN SAN ANTONIO TEXAS ON AUGUST 29,2017. IWAS TOLD THE PARTS WERE ORDERED AND WOULD TAKE 2WEEKS TO COME IN. I CALLED 2WEEKS LATER AND COULD NOT GET ANY INFO ON THE PARTS ORDERED. TODAY IS 10/16/2016 AND STILL NO INFO. I HAVE BEEN DRIVING THE VEHICLE LITTLE BECAUSE IT HAS WANTED TO MOVE OVER TO THE NEXT LANE SEVERAL TIMES EVEN THOUGH I HOLD THE STEERING WHEEL STRAIGHT.
THE FRAME HAS PREMATURELY RUSTED THROUGH IN FRONT OF THE RIGHT, REAR TRAILING ARM. MY SHOP TELLS ME THE FRAME IS TOO RUSTED TO REPAIR IT.
TAKATA RECALL I'M SUPER DISAPPOINTED IN THE RUST PROBLEM WITH TOYOTAS, I'VE OWNED NOW THREE TACOMAS, ALL RUSTED OUT, I RECENTLY GAVE UP AND TRIED BUYING A 1996 4RUNNER, GOT A REALLY GOOD DEAL ON IT, I CAN SEE WHY ANYWAYS I BOUGHT IT AND IT TURNS OUT THE WHOLE FRAME WAS COATED SO I COULDN'T SEE RUST, WITH FURTHER INSPECTION THERE'S A BIG CRACK IN THE FRAME FROM RUST, AND THE WHOLE FRAME IS RUSTED. THE CRACK IS RIGHT BESIDE THE EXHAUST, I CONTACTED TOYOTA AND THEY SAID BRING IT IN FOR INSPECTION AND THEY SAID IT WOULD NEED REPLACED, BUT WOULD COST 14-16 THOUSAND DOLLARS. THEN THEY CHARGED ME FOR THE INSPECTION 60 DOLLARS, WHEN THEY DIDN'T EVEN TELL ME I'D BE CHARGED. TOYOTA REALLY NEEDS TO STEP UP!!! FEEL FREE TO CALL ME AT [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
THERE WAS A RECALL FOR THE SUN VISOR HOWEVER THE TOYOTA SERVICE DEPARTMENT WAS UNABLE TO FULFILL THE RECALL DUE TO THE PART NOT BEING AVAILABLE.
TAKATA RECALL I HAVE A BAD RUST PROBLEM ON THE CHASSIS FRAME UNDERNEATH
WHILE CORNERING IN CITY DRIVING I HEARD A CLUNKING NOISE AND INVESTIGATED WHEN I ARRIVED HOME. THE FRAME HAS CORROSION AT THE RIGHT REAR TRAILING ARM BRACKET. THE BRACKET WAS RUSTED AWAY FROM THE FRAME AT THE TOP BUT STILL ATTACHED AT THE BOTTOM. THE BRACKET AND FRAME WERE WELDED WITH ADDTIONAL METAL. I CHECKED THE REST OF THE FRAME AND NOTICED THERE IS ALSO A HOLE IN THE CROSSMEMBER BELOW THE DRIVERS SEAT AND OTHER LARGER RUSTED HOLES ALONG THE FRAME. THIS IS A MAJOR SAFETY CONCERN. I WILL HAVE TO TAKE IT TO A FRAME SHOP AS TOYOTA SAYS THERE IS NO RECALL ON THE 4RUNNER ONLY THE TACOMA AND TUNDRA. I KNOW MANY OTHER 3RD GENERATION 4RUNNER OWNERS WHO HAVE THE SAME PROBLEM. THE VEHICLE BODY HAS NO RUST OTHER THAN A SMALL SURFACE AREA AT THE DRIVERS DOOR ROCKER PANEL AND NEAR THE WINDSHIELD. THE VEHICLE IS VERY WELL MAINTAINED.
FRAME BADLY ROTTED CROSSMEMBER FOR TRANSMISSION AND LEFT REAR ARE WORST .
I OWN A 1996 TOYOTA 4RUNNER THAT HAS FRAME IS RUSTED WITH LARGE HOLES. IT HAS NOT CAUSED AN ACCIDENT YET BUT I BELIEVE THE MANUFACTURER SHOULD BE HELD ACCOUNTABLE. ESPECIALLY WHEN THE SAME COMPANY HAS REPLACED FRAMES AND BOUGHT BACK OTHER MODELS FOR THE EXACT SAME ISSUE. HOW AM I (AS A 4RUNNER OWNER) JUST OVERLOOKED AND BRUSHED ASIDE.
FRAME IS SO ROTTED IT WON'T PASS INSPECTION. SEEMS TO BE A COMMON PROBLEM WITH TOYOTA. THEY REPLACED FRAMES ON THE TACOMA AND A FEW OTHERS, WHY NOT THE 4 RUNNER.
TRAVELING NB APPROACHING GREEN LIGHT AND A CAR RAN RED LIGHT IN INTERSECTION. THE CAR ON SB SWERVED ON MISS THEM, HIT THEM ANYWAY AND HIT ME HEAD ON. BOTH ON THEIR AIR BAGS WENT OFF AND MINE DID NOT. I AM STILL IN PHYSICAL THERAPY FOR PARTIAL ROTATOR CUFF TEAR, SPRAINED NECK, BACK, SHOULDER, ELBOW AND I STILL CANNOT USE RIGHT ARM FROM ELBOW DOWN. I HAVE NOT WORKED SINCE THE ACCIDENT. I WANT TO KNOW WHY MY AIR BAGS DID NOT GO OFF.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .