1998 Toyota Avalon Suspension Problems

Tie rods detached from frame, along with steering parts became unsafe on minor highway speed turnes

NHTSA ID

11528799

Incident

May 12, 2022

ELECTRICAL SYSTEM SHUT DOWN IN TRAFFIC AT THE LIGHT, ALTERNATOR WAS TESTED. BATTERY LIGHT STAY ON, LIGHTS DIMMED OUT, LOST SPEED. HAD TO GET PUSHED OUT THE ROAD AT A BUSY INTERSECTION IN ATLANTA GEORGIA ON CLEVELAND AVENUE.. BOUGHT A SECOND ALTERNATOR, SAME EXACT INCIDENT . ONCE HEADLIGHTS ARE TURNED ON AT NIGHT, CAR LOOSES TOTAL POWER. I HAD TO DRIVE FIVE BLOCKS AT NIGHT WITHOUT LIGHTS ON RALPH DAVID ABERNATHY BLVD, ATLANTA GEORGIA, EVEN THE HAZARD LIGHTS DRAINED A BRAND NEW BATTERY PURCHASED 12/02/2018.

NHTSA ID

11155533

Incident

Nov 9, 2018

Mileage

131,000 mi

THE FRONT SUSPENSION RATTLES REALLY LOUD WHEN GOING OVER SMALL WASHBOARD TYPE BUMPS OR ANY DISTURBANCES IN THE ROAD. THIS IS CAUSED BY A FAULTY STRUT MOUNT. *JB

NHTSA ID

10151265

Incident

Feb 26, 2006

Mileage

105,000 mi

THUNKING NOISE WHEN GOING OVER ROUGH PAVEMENT FROM AREA OF FRONT WHEEL ON PASSENGERS SIDE DETERMINED BY INDEPENDENT MECHANIC TO BE A STRUT MOUNT, WHICH APPARENTLY IS A PROBLEM KNOWN BY TOYOTA. CAR HAS ONLY 55,000 MILES ON IT.*AK

NHTSA ID

10105762

Incident

Dec 1, 2004

Mileage

54,700 mi

LOUD NOISE COMING FROM FRONT OF VEHICLE. WAS INFORMED BY TOYOTA THAT FRONT STRUTS NEEDED TO BE REPLACED WITH ONLY 50,000 MILES ON VEHICLE. THEY KNOW THIS IS A COMMON PROBLEM BUT ARE UNWILLING TO HELP.*AK

NHTSA ID

10025256

Incident

Jun 16, 2003

PREMATURE FAILURE OF LEFT FRONT STRUT AT 63000 MILES ALONG WITH BOTH STRUT SUPPORTS.

NHTSA ID

10003537

Incident

Jan 27, 2003

REAR SPRINGS/STRUTS ARE SO WEAK THAT IF I HAVE TWO PEOPLE IN THE BACK SEAT, OR SEVERAL SUITCASES IN THE TRUNK, THE REAR SUSPENSION BOTTOMS OUT. THIS CAUSES A VERY UNCOMFORTABLE WIGGLE WHEN IT COMES BACK UP. MY NEW TIRES ARE STARTING TO FLAT SPOT AS DID MY LAST SET. I BROUGHT THIS TO COURTESY TOYOTA WHEN IT WAS UNDER WARRENTEE. THEY CLAIMED NO PROBLEM AND READJUSTED MY HEADLIGHTS. I HAVE CONTACED CAPITOL TOYOTA IN CHATANOOGA, TN. A COUPLE OF TIMES. THEY SAID THEY HAVE HAD SEVERAL COMPLAINTS ABOUT THIS BUT COULDN'T DO ANYTHING ABOUT IT UNLESS SOMETHING WAS WORN OR DAMAGED. I CALLED TOYOTA. THEY SAID THE SAME. BUT TOOK MY NAME AND SAID THAT IF ENOUGH PEOPLE COMPLAINED THEY MIGHT ADDRESS THE PROBLEM. *AK

NHTSA ID

757072

THERE WAS A LOUDER THEN USUAL THUMP IN THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS IN THE ROAD. TO VEHICLE TO DEALER REPAIR SHOP, AND MECHANIC NOTED THAT FRONT STRUT WAS BREAKING. CONSUMER CONTACTED DEALER, AND DEALER KNEW ABOUT THE PROBLEM WITH THE STRUT, BUT WA SNOT WILLING TO DO ANYTHING.*AK

NHTSA ID

8002221

Incident

Jan 1, 2000

FRONT SUSPENSION CREAKED AND GROANED. THE UPPER STRUT MOUNTS WERE REPLACED BY DEALER (BOTH SIDES) AT 3000 AND AGAIN AT 32000 MILES.

NHTSA ID

756602

Incident

Feb 1, 1999

WHEN DRIVING OVER ROUGH ROADS WITH PASSENGERS IN REAR SEAT, THE REAR SUSPENSION REPEATEDLY "BOTTOMS OUT" CAUSING UNPREDICTABLE VEHICULAR MOVEMENTS AND LOUD NOISE. DEALER SAYS THERE IS NOTHING WRONG. THIS PROBLEM HAPPENS FREQUENTLY WITH VEHICLE LOADED NEAR DESIGN LOAD LIMITS.*AK

NHTSA ID

756601

Incident

Apr 11, 2000

PREMATURE WEARING OF FRONT STRUTS EVENTUALLY CAUSED TIRES TO PREMATURELY WEAROUT. ALSO, VEHICLE BEGAN TO PULL TO LEFT OR RIGHT WHICH WAS ALSO A RESULT OF PROBLEM WITH FRONT STRUTS. *AK *SLC

NHTSA ID

878816

Incident

Nov 1, 2000

FRONT STRUT BRACKET FAILURE CAUSING FRONT SUSPENSION NOISE, POOR RIDE, AND UNEVEN TIRE WEAR. PREVIOUS TSB'S WERE NOTED BY OWNER. PROBLEM FIXED BY DEALER UNDER EXTENDED WARRANTY. I HAVE CONCERNS ABOUT THIS MAJOR COMPONENT FAILURE AT RELATIVELY LOW MILEAGE FOR SUSPENSION COMPONENTS AND WOULD HAVE HAD TO PAY OVER $500 IF NOT COVERED BY EXTENDED WARRANTY. DO TO NUMEROUS COMPLAINTS OF THIS NATURE IN TOYOTA CARS, WOULD THINK THIS IS LIKELY MANUFACTURING OR ENGINEERING DEFECT AND DUTY OF TOYOTA TO FIX.

NHTSA ID

738718

Incident

Jan 3, 2001

NOISE AND THUMP IS COMING FROM SUSPENSION WHILE DRIVING OVER WASHBOARD TYPE BUMPS, DEALER REPLACED A LOOSE HEADLINER, HOWEVER THE THUMP AND NOISE IS STILL PRESENT. *SLC

NHTSA ID

785129

Incident

Jan 1, 1999

THE CAR HAS BEEN RE-ALIGNED NUMEROUS TIMES AND IS CONSTANTLY GOING OUT OF ALIGNMENT. TIRES HAVE ALSO WORN EXCESSIVELY. INDEPENDENT ALIGNMENT (GOODYEAR) REPORTED THAT SIMILAR PROBLEMS WITH OTHER AVALONS.*AK

NHTSA ID

726785

FRONT SUSPENSION BANGS AND CLANKS GOING OVER ANY SIZE BUMP AT ANY SPEED. ABNORMAL TIRE WEAR DEVELOPING EVEN WITH ROTATION. DEALER STATES CONDITION IS "NORMAL" NO RESOLUTION AFTER NUMEROUS COMPLAINTS. *AK

NHTSA ID

722676

Incident

Jul 11, 1999

REAR SUSPENSION BOTTOMS OUT GIVING THE FEELING OF TEMPORARY LOSS OF CONTROL DUE TO INADEQUATE REAR STRUTS. YH

NHTSA ID

551116

WHILE DRIVING DOWN THE HIGHWAY VEHICLE CONSTANTLY PULLS TO THE LEFT . *AK

NHTSA ID

851195

Incident

Oct 20, 1999

FRONT SUSPENSION NOISE, SIX ATTEMPTS TO TRY TO FIX, HOWEVER NOT REMEDIED. MJS

NHTSA ID

547436

FRONT SUSPNSION MAKES AN "UNDAMPENED" CLUNK WHEN GOING OVER SLIGHTLY ROUGH ROAD. MANUFACTURER REFUSES TO HONOR WARRANTY

NHTSA ID

703618