2006 Toyota Highlander Driver assistance Problems

The dashboard on my Highlander Hybrid 2006 (AWD) had all its check lights on suddenly. I was not driving then. The car was in my parking lot for a few hours before which it had no signs on. The warning message said: Vehicle Stability Control (VSC). I took it to my nearest Toyota service center for diagnosing the issue. They reported that the ABS systems have started to fail. Specifically, the ABS actuator is losing pressure and should be replaced. They quoted a price of $2700 approx. which includes about $2000 for parts. Turns out that this same part had been replaced in 2016 during a recall - but they cannot attend to this again without charging the customer. What I was never told about was that a whirring sound - which has always been an issue with this car - was always from the ABS actuator. The same service center has checked and diagnosed this car multiple times - so I am surprised that they did not find the ABS actuator noise a problem on earlier occasions. I have been reading about this on this forum and Toyotanation and this seems to be a consistent issue with the older Toyota hybrid highlanders and other hybrids as well - with the same diagnosis and approximately the same price quoted by the service centers. I have not currently fixed this issue since I cannot afford this price. It also seems that I will be paying for manufacturer's or service center's negligence since this actuator seemed to be faulty all along and I was not warned about this.

NHTSA ID

11423140

Incident

Jun 25, 2021

THE BRAKE ACTUATOR IS FAILING AND IS MAKING LOUD NOISES. THE CAR DOES NOT BRAKE NORMALLY. I HAVE REPORTED BRAKING PROBLEMS SINCE I BOUGHT THE VEHICLE IN 2007. WHEN IT HITS A BUMP IT ACCELERATES AND I MUST STAND ON THE BRAKES SO I DO NOT HIT SOMEONE. IT LURCHES FORWARD WHEN IT HITS A POTHOLE OR SOME KIND OF OBSTRUCTION IN THE ROAD. WHEN I WORKED DOWN NEAR THE BUS STATION I WOULD HIT THE AREAS IN THE ROAD WHERE THE BUSES CREATED BUMPS IN THE ROADWAY AND IT WOULD LURCH FORWARD. I REPORTED THIS NUMEROUS TIMES AT NORTH BAKERSFIELD TOYOTA. I RECENTLY WENT IN TO REPORT THE NOISE I WAS HEARING AND THEY FINALLY FIGURED OUT THAT THE BRAKE ACTUATOR IS FAILING. I WAS TOLD THAT IT WAS NOT A HAZARD BUT THEY COULD NOT TELL ME WHEN IT WILL TOTALLY FAIL. I BELIEVE IT IS A SAFETY HAZARD AND THERE HAS BEEN A PROBLEM FROM DAY ONE

NHTSA ID

11413884

Incident

Dec 18, 2020

MY ABS, VSC, (I), AND EMERGENCY BRAKE DASH LIGHTS ARE ON CONTINUOUSLY. IT IS VERY HARD TO STOP THE CAR AS IT FEELS LIKE THE BRAKE ISN'T ENGAGING. WHEN IT DOES ENGAGE YOU ARE JERKED FORWARD.

NHTSA ID

11412982

Incident

Apr 19, 2021

Mileage

182,000 mi

THE VSC LIGHT, ABS LIGHT, CHECK ENGINE LIGHT AND SOUND IS ARE ON. THE CODE IS BACK AS WELL C1391 FOR THIS BRAKE ACTUATOR. IT IS A WELL KNOWN PROBLEM WITH TOYOTAS . THIS WAS FIXED ONCE ALREADY BY TOYOTA DEALER AND FAILED AFTER 40K MILES AGAIN. HOW CAN A PART HAS FAILED AGAIN IN SUCH A SHORT TIME AND MILES? THIS IS A COMMON PROBLEM AND WE CAN'T GET HELP FROM TOYOTA COMPANY OTHER THAN TO PAY FOR THEIR LACK OF QUALITY ON PARTS? I CAN'T AFFORD $4000 PLUST TO FIX A PART THAT ONLY LASTED 40,000 MILES. WHEN IS TOYOTA GOING TO DO A RECALL ON THIS PART AND FIX IT FOR GOOD?

NHTSA ID

11405584

Incident

Mar 24, 2021

Mileage

199,000 mi

THE BRAKE ACCUMULATOR/ACTUATOR IS A DEFECTIVE PART AND TOYOTA HAS REFUSED TO HONOR THE REPAIR. THEY MANIPULATED OWNERS BY HAVING A WARRENTY SUPPORT PROGRAM WITH END DATES, INSTEAD OF HAVING A RECALL ON IT. WHICH IS WHY WHEN I RESEARCHED BEFORE I BOUGHT, IS NOT LISTED ON CAR FAX. THE WARRANTY SUPPORT WAS BEFORE I PURCHASED VEHICLE AND PREVIOUSLY IT WAS EITHER IGNORED OR MISSED BETWEEN OWNERS. THEY HAVE HAD MANY OF THESE AND GET AWAY WITH IT. RIGHT NOW THERE IS A CLASS ACTION FILED IN OHIO OVER THIS SAME ISSUE WITH OTHER CARS. IT IS A $3000 DOLLAR PART AND NOT A KNOB ON RADIO. IT IS A SAFETY ISSUE DUE TO IT BEING PART OF THE BRAKING SYSTEM. I'VE SEEN WHERE THE SUPPORT PROGRAM SAID MILES DIDN'T MATTER BUT WHEN TALKING TO TOYOTA THEY SAY 114,000 MILES. THE CAR IS A 2006, YEAH THAT'S REASONABLE, EVEN FOR 2017/18 LETTER. WHILE DRIVING THE VSC ALARM SYSTEM COMES ON AND THE BRAKING BECOMES DIFFICULT. THE PUMP HAS ALWAYS MADE A SOUND BUT WAS TOLD BY DEALER IT WAS THE SECURITY ALARM SYSTEM MAKING THE NOISE. IT HAPPENED IN 2019 ALSO, THE ALARM, BUT REPAIR SHOP SAID IT WAS CALIPERS, SO PAID $800 TO HAVE THEM REPLACED WITH PADS. ITS ALWAYS MADE NOISE BUT THE ALARM SYSTEM STARTED BACK UP AGAIN LAST MONTH. NOW WITH RESEARCH ON MY OWN, I KNOW EXACTLY WHAT IT IS BUT TOYOTA SAID THEY SENT LETTER TO PREVIOUS OWNER AND SORRY ABOUT MY LUCK! THIS HAS RENDERED THIS VEHICLE WORTH $5500, WORTHLESS. CANT TRADE IN A VEHICLE LIKE THIS AND LOST MY INCOME FROM DELIVERY WITH IT. I HAVE CHECKED OFF EVERYTHING THAT WOULD APPLY IF IT WAS A RECALL BUT SINCE THE SUPPORT PROGRAM HAS AN END DATE TO GET OUT OF TOYOTA EVER BEING RESPONSIBLE FOR THEIR DEFECTIVE PART, THEY PUSH IT OFF ON OWNERS. I'M JUST LUCKY, I HAVE A CDL AND GOOD DRIVER AND HAVE NOT HAD AN ACCIDENT WITH IT. I FILED A COMPLAINT WITH TOYOTA AND THEY JUST SWIPED ME AWAY AS ANOTHER POOR SUCKER THAT DIDN'T FIGURE IT OUT BEFORE I PURCHASED.

NHTSA ID

11343839

Incident

Jul 20, 2020

Mileage

233,000 mi

THE BRAKE ACTUATOR ASSEMBLY HAS GONE OUT AT 135000 MILES. IT INTERFERS WITH BRAKING. THE BRAKES LOCK UP FREQUENTLY AND CAR WILL ALMOST HOP TO A HALT. IT IS QUITE CONCERNING AND SCARY WHEN IT OCCURS.

NHTSA ID

11338207

Incident

Jul 6, 2020

Mileage

135,000 mi

ONCE AFTER PARKING AND THEN TWICE WHILE DRIVING ON A HIGHWAY, THE CHECK HYBRID SYSTEM LIGHT, THE VSC LIGHT, THE CHECK ENGINE LIGHT, AND THE CAUTION LIGHT ALL ILLUMINATED AND THE VEHICLE LOST ALL POWER INCLUDING STEERING ASSISTANCE . EACH TIME REQUIRING MULTIPLE KEY TURNS TO RESTART THE VEHICLE INTO LIMP HOME MODE. THIS VEHICLE HAS BEEN REPAIRED ONCE BEFORE FOR A SIMILAR ISSUE WHICH OCCURRED WHILE DRIVING UP A HILL IN MODERATE TRAFFIC. THE TANK IS FULL OF FUEL, THE TIRES ARE LESS THAN A YEAR OLD, AND THE VEHICLE UNDERGOES REGULAR MAINTENANCE(WHICH INCLUDES A NEW BATTERY AS THE ONE BOUGHT FROM TOYOTA HAD A FEW DEAD CELLS AFTER ONLY A YEAR OR TWO). I'VE READ MULTIPLE COMPLAINTS ABOUT THIS ONLINE WHILE SEARCHING FOR THE UNDERLYING ISSUE AND THERE SEEMS TO BE A RELATED RECALL THAT DOESN'T INCLUDE MY VIN. *TR

NHTSA ID

11325484

Incident

May 21, 2020

Mileage

172,560 mi

ONGOING ISSUE WITH GENERATION 1 HIGHLANDER HYBRIDS AND PRIUS FROM SAME DATE RANGES. A WARRANTY ADJUSTMENT HAS ALREADY BEEN ISSUED AND ENDED. THE ABS BRAKE ACCUMULATOR GETS AN INTERNAL LEAK CODE C1391. REDUCED BRAKING, ESC, BRAKE AND OTHER LIGHTS COME ON. MANY OF THOSE REPAIRED UNDER WARRANTY ARE ALREADY FAILING A SECOND TIME. VEHICLE IS DANGEROUS TO DRIVE SINCE IT CAN BE DRIVING PERFECTLY AND FAIL WHILE IN MOTION CAUSING DANGEROUS BRAKING CONDITIONS.

NHTSA ID

11297471

Incident

Dec 16, 2019

Mileage

177,000 mi

I WAS DRIVING STRAIGHT ON THE MAIN ROAD COMING TO A STOP LIGHT.THE VEHICLE WOULD NOT STOP AFTER PRESSING ON THE BRAKES SEVERAL TIMES. THERE ARE SEVERAL LIGHTS ON THE DASH:BRAKES,TRACTION CONTROL, 2 YELLOW EXCLAMATION MARKS ONE INSIDE A TRIANGLE AND THE ,ABS. THE MECHANIC IS SAYING THE BRAKE ACTUATOR IS FAULTY AND NEEDS TO REPLACED.

NHTSA ID

11185662

Incident

Mar 8, 2019

Mileage

15 mi

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE MAKING A TURN AT 5 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE ACCELERATED AT AN UNKNOWN SPEED. AS A RESULT, THE VEHICLE STRUCK A PEDESTRIAN. A POLICE REPORT WAS FILED. THE PEDESTRIAN SUFFERED INJURIES AND MEDICAL ATTENTION WAS REQUIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. *JS

NHTSA ID

11139259

Incident

Jun 27, 2016

THE VEHICLE ACCELERATES SEEMINGLY ON IT'S OWN. WHILE DRIVING IT PICKS UP SPEED THEN SLOWS DOWN SOME.

NHTSA ID

11100158

Incident

Jun 6, 2018

Mileage

208,000 mi

2006 TOYOTA HIGHLANDER. CONSUMER WRITES IN REGARDS TO VEHICLE SUDDEN ACCELERATION ACCIDENT. *SMD THE CONSUMER STATED THE VEHICLE ACCELERATED AND JUMPED A CURB AND HIT A BUILDING WHILE THE BRAKES WERE BEING DEPRESSED. *JS

NHTSA ID

10845498

Incident

Jan 1, 2016

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. ON SEVERAL OCCASIONS, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND LOST POWER. THE CONTACT STATED THAT ALL OF THE WARNING INDICATORS ILLUMINATED ON AND OFF. THE CONTACT CALLED STEVENS CREEK TOYOTA SAN JOSE AT (408) 984-1234 (LOCATED AT 4202 STEVENS CREEK BLVD, SAN JOSE, CA 95129) WHERE IT WAS CONFIRMED THAT NO RECALLS WERE ASSOCIATED WITH THE VIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

11067113

Incident

Mar 15, 2017

TAKATA RECALL. CHECK ENGINE LIGHT WON'T GO OFF ALONG VSC LIGHT. ON THE STREET WHEN THE CAR STOP RUNNING.

NHTSA ID

10991549

Incident

Apr 4, 2017

Mileage

79,670 mi

STEERING RECALL: I HAVE A 2006 TOYOTA HIGHLANDER HY WITH THE P/S (POWERS STEERING) LIGHT ON. I'VE BEEN TO TOYOTA TWICE IN THE PAST WEEK AND ONLY OWNED THE VEHICLE FOR 2 WEEKS. THEY SAY THEY CANNOT DO ANYTHING WITHOUT KNOWING THE PROBLEM AND I'VE TOLD THEM THE PROBLEM. THE VEHICLE ALSO TRIES TO ACCELERATE ON ITS ON WHEN AT A COMPLETE STOP.

NHTSA ID

10970680

Incident

Mar 26, 2017

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. AS SOON AS THE VEHICLE WAS STARTED, THE VSC LIGHT AND CHECK ENGINE WARNING INDICATOR ILLUMINATED SIMULTANEOUSLY AND REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT COULD NOT BE DIAGNOSED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 240,000.

NHTSA ID

10778433

Incident

Sep 29, 2012

Mileage

240,000 mi

DRIVING VEHICLE WHEN WARNING LIGHTS FOR ABS AND SKID CONTROL CAME ON. CHECK VSC SYSTEM IN DASH. WHEN BRAKE IS APPLIED RIGHT FRONT TIRE LOCKS AND CAUSES VEHICLE TO SPIN. SLOW SPEED IS THE ONLY REASON FOR NO ACCIDENT. TOOK VEHICLE TO DEALER AND WAS TOLD "BRAKE ACCUATOR " ELECTRONICS HAD FAILED AND NEEDED TO BE REPLACED FOR $3800. RESEARCH SHOWS THIS IS AN ISSUE ON THE HIGHLANDER, THE LEXUS AND THE CAMRY SO WHY HAVE THE HIGHLANDERS NOT BEEN INCLUDED IN THE RECALL?

NHTSA ID

10762674

Incident

Sep 5, 2015

Mileage

75,000 mi

AFTER AN SYNTHETIC OIL CHANGE AND REAR BRAKE JOB AT FIRESTONE A FEW DAYS EARLIER IN ATLANTA, I WAS DRIVING ALONG AND MY CHECK VSC SYSTEM LIGHT CAME ON. I THEN TOOK IT BACK TO FIRESTONE AND THEY PUT IT ON THE COMPUTER AND THERE WERE NO CODES; SUBSEQUENTLY THEY SUGGESTED THAT I TAKE IT TO THE DEALER FOR DIAGNOSIS. THE DIAGNOSIS AT THE DEALER REVEALED THAT I NEEDED A NEW ABS ACCUMULATOR AND THIS COULD BE REPAIRED FOR $3,118. I WAS NOT INTERESTED IN SPENDING THIS AMOUNT SINCE THE PART HAS A KNOW DESIGN MANUFACTURERS DEFECT. I DECIDED TO DO SOME RESEARCH ON CLEARING THE CHECK VSC SYSTEM LIGHT AND FOLLOWED THE INSTRUCTIONS AND THE CODE CLEARED FOR ABOUT 9 DAYS AND REAPPEARED ON YESTERDAY FOR SOME REASON. WHAT CAN I DO? *TR

NHTSA ID

10702733

Incident

Mar 19, 2015

Mileage

151,247 mi

I WAS BACKING OUT OF MY DRIVEWAY, STOPPED WAITED FOR TRAFFIC,BACKED UP, GOT STUCK ON A SMALL PILE OF SNOW, LEFT REAR TIRE STARTED TO SPIN I PULLED FORWARD AND BACK AGAIN THE TRACTION LIGHT CAME ON, HAD NO TRACTION. IT HAPPENED AGAIN, BACKING OUT OF MY DRIVEWAY. *TR

NHTSA ID

10702210

Incident

Feb 17, 2014

Mileage

69,547 mi

WAS DRIVING IN TRAFFIC WHEN AN ALARM SOUNDED AND SEVERAL DASHBOARD LIGHTS LIT UP. CENTER DISPLAY SAID "CHECK VSC SYSTEM". I TOOK IT TO THE DEALER WHO SAID THE ABS MODULE NEEDS TO BE REPLACED AT A COST $2,800. OTHER THAN A VIBRATION UNDER THE HOOD WHILE SLOWING DOWN THE CAR APPEARS TO BE OPERATING NORMALLY. THE ABS WARNING LIGHT IS ON WHICH LEADS ME TO BELIEVE THE ABS MAYBE DISABLED. I WAS ABLE TO RUN A VSC DIAGNOSTIC AND PULLED CODE 45. GIVEN THE NUMBER OF REPORTED INCIDENTS FOR THIS FAILURE IT APPEARS TO BE A WIDE SPREAD PROBLEM. *TR

NHTSA ID

10670837

Incident

Jan 5, 2015

Mileage

150,500 mi

COMPLAINT: 2006 BASE HIGHLANDER, FWD, 4 CYLINDERS. BRAKE SYSTEM (VSC, TRAC OFF, ABS & BRAKE) AND TPMS LIGHTS ON, DISABLING SAFETY FEATURES. 1)TPMS FLASHING LIGHT. ISSUE MAY HAVE BEEN IN-PROCESS SINCE DAY 1. IT REGULARLY CAME ON, RESET BY DEALERS AND EVENTUALLY SHOWED US HOW TO RESET OURSELVES. 2)BRAKE SYSTEM LIGHTS. ALL (4) CAME ON, DIAGNOSED AS LEFT REAR WHEEL SENSOR. DEALER QUOTED COST: $1000. REPLACEMENT DIDN'T WORK, WOUND UP REPLACING WHEEL HUB ASSEMBLY PIGTAIL. LASTED TWO (2) WEEKS, RE-DIAGNOSED AS ABS PUMP/CONTROL MODULE ASSEMBLY. DEALER QUOTED COST: $2500. WHILE THIS ITSELF IS RIDICULOUS, THE REPAIR COSTS WOULD EXCEED 1/8TH (13%) THE COST OF THE VEHICLE NEW! NOW, IN 2014, IT'S APPROXIMATELY (50%) OF THE CURRENT VEHICLES VALUE. THIS ISSUE HAS RECENTLY RESULTED IN SCREECHING TO A HALT IN DANGEROUS TRAFFIC. IT ESSENTIALLY NEGATES THE STAR SAFETY SYSTEM FEATURES, FOR VARIOUS ENVIRONMENTAL AND DRIVING CONDITIONS. THIS ISSUE CANNOT BE IGNORED ANY LONGER, SINCE IT'S THE TOPIC ON NUMEROUS WEB SITE FORUMS AND INQUIRIES AND EVEN SALVAGED USED PARTS ARE BEING SOLD BY MANY SITES FOR THIS PROBLEM. RECOMPENSE: REMUNERATION OF EXPENSES TO DATE AND FUTURE REPAIRS TO CORRECT THIS PROBLEM IS REQUESTED. REVIEW OF TSB AND/OR INVESTIGATION INTO RECALL CAMPAIGN TO FIX ALL AFFECTED VEHICLES. *TR

NHTSA ID

10643291

Incident

Apr 18, 2012

Mileage

85,000 mi

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE BRAKE PEDAL WAS DEPRESSED CONTINUOUSLY HOWEVER, THE VEHICLE CONTINUED TO ACCELERATE RAPIDLY. THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE, CAUSING A CHAIN REACTION CRASH. THE AIR BAGS DEPLOYED AND BRUISED THE CONTACT'S LEFT ARM, CHEST AND NECK. THE CONTACT ALSO SUSTAINED MULTIPLE BRUISES FROM THE SEAT BELT. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS TOWED TO A COLLISION CENTER FOR INSPECTION OF THE MASSIVE FRONT END DAMAGES. THE MANUFACTURER WAS NOT NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.

NHTSA ID

10514769

Incident

May 30, 2013

Mileage

99,000 mi

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 2 MPH, THE VEHICLE ERRONEOUSLY ACCELERATED AND THE CONTACT CRASHED INTO A POLE. THE PASSENGER SUSTAINED BRUISING TO THE CHEST. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000......UPDATED 06-19-13 *BF UPDATED 06/27/2013 *JS

NHTSA ID

10505933

Incident

Apr 4, 2013

Mileage

200,000 mi

VEHICLE HESITATES OR STALLS ON ACCELERATION. VERY DANGEROUS SITUATION TO BE IN IF PULLING INTO TRAFFIC AND NOT ABLE TO ACCELERATE. VEHICLE WILL ALSO LUNG OR OVER ACCELERATE ON SOME OCCASIONS AFTER HESITATION. *TR

NHTSA ID

10504761

Incident

Aug 2, 2011

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE WOULD MOMENTARILY SURGE FORWARD WHEN THE BRAKES WERE APPLIED. THE FAILURE OCCURRED ON AN INTERMITTENT BASIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THE CONTACT WAS INFORMED THAT A BRAKE MODULE AND THE TRANSMISSION WERE DEFECTIVE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHERE THE CONTACT WAS INFORMED THAT CLIPS ON THE FLOOR MATS WERE RESPONSIBLE FOR THE FAILURE. THE VEHICLE WAS AGAIN REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000 AND THE CURRENT MILEAGE WAS 60,000.

NHTSA ID

10422432

Incident

Dec 29, 2010

Mileage

55,000 mi