2023 Toyota Highlander Problems

Tailgate stays open; sensors seem to fail. It will work one day and not work on another day. My wife is short and handicapped and she can’t close it manually.

The lift gate will not close, especially during temperatures below 35 degrees. The litigate will go down a few inches, beep, then go back up. In colder temperatures below 25 degrees the lift gate will not open.

The contact owns a 2023 Toyota Highlander. The contact stated that while driving at lower speeds, pulling into an uphill driveway, the vehicle had independently accelerated while the accelerator pedal was depressed. In addition, the contact stated that she was not able to depressed in time and had crashed into the left side of the house, causing damage to the front driver-side bumper and quarter panel. The contact stated that the accident caused property damage to the garage of the house, which was covered by the insurance provider. A police report file. No injuries were sustained, and no medical attention. The vehicle was taken to a local independent mechanic, where it was diagnosed that the accelerator pedal was depressed throughout the accident; however, the brake pedal was depressed after the crash had occurred, according to the electronic data. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 59,000.

weather conditions were severe due to a snowstorm, causing ice buildup on the road, low visibility, and slippery pavement. Despite driving cautiously, I lost control of the vehicle, which resulted in going off the road, down an embankment, and crashing into a tree. Immediately after the impact, I called 911 emergency services for assistance. I attempted to exit the vehicle, but the driver’s door was blocked due to the position of the tree. I remained inside the vehicle until a passerby stopped and helped me get out. As a result of the impact, my vehicle sustained significant damage The shocking thing about it all is that the vehicle did not activate the airbags and that is worrying to me because it could have been unfortunate.

The contact owns a 2023 Toyota Highlander. The contact stated that while driving at lower speeds, pulling into an uphill driveway, the vehicle had independently accelerated while the accelerator pedal was depressed. In addition, the contact stated that she was not able to depressed in time and had crashed into the left side of the house, causing damage to the front driver-side bumper and quarter panel. The contact stated that the accident caused property damage to the garage of the house, which was covered by the insurance provider. A police report file. No injuries were sustained, and no medical attention. The vehicle was taken to a local independent mechanic, where it was diagnosed that the accelerator pedal was depressed throughout the accident; however, the brake pedal was depressed after the crash had occurred, according to the electronic data. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 59,000.

I was in an accident today in this vehicle . Upon impact, traffic was suddenly stopped on the highway. The air bags didn’t deploy and the automatic emergency breaks didn’t engage. Impact was so hard three vehicles were Involved.

2023 Toyota Highlander Hybrid Regenerative Brake Transition loss of brake pad pressure resulting in acceleration of the vehicle under downhill conditions. Have momentarily experienced the loss of braking frequently during braking when going downhill. This results in the vehicle gaining speed during this 1 or 2 second period before braking returns. In one case it allowed our car to get dangerously close to the vehicle ahead of us but fortunately I was able to push the brakes harder to prevent an accident but did require aggressive braking. Luckily no one was behind us which may have resulted in the person following us braking hard or possible hitting us. This was a known issue for previous year Toyota Highlander models and Toyota issued service bulletin T-SB-0059-23 which is stated to only be for model years 2020 - 2022. So, Toyota dealers say they do not have a fix that applies to the 2023 model. It has been indicated that the dealer is unaware if any action is being taken by Toyota to address this issue in the 2023 and later models. We have multiple people driving this vehicle and this sudden loss of braking power is very concerning. The loss of braking force occurs upon the transition from regenerative braking to standard hydraulic breaking. Below are words from the Toyota Technical Service notice concerning the problem. "Highlander Hybrid vehicles may be sensitive to the momentary transition from regenerative braking to hydraulic braking under certain driving conditions, such as while driving downhill, or turning with light brake pedal application. The brake actuator control module can be updated to improve brake feeling for this condition. Follow the Repair Procedure in this bulletin to address this condition."

When applying brake, in sporadic and unpredictable circumstances, the vehicle seems to switch from regenerative braking to brake pump braking. During this switch, braking power is lost completely. The vehicle was inspected by the Dealer, they stated no issues found / unable to reproduce. This issue, if unresolved, increases risk of vehicle collision. No warning lights, no messages, no other symptoms of the problem. This issue has been present for ~1.5 years.

I have a 2023 Toyota Highlander XSE with 77,015 miles on it. Last week we noticed that when pushing on the gas pedel to accelerate that the car started making a terrible whinning noise that did not go away. i scheduled a service call with dealership i purchased it from and where i take it for all of its scheduled service and they canfirmed that the transmission was failing and needed to be replaced so the problem has been confirmed by the dealership. In addition i contacted the toyota help line and asked for a Goodwill Warranty Assisstance case to be opened which is now under review. prior to the noise there were no indication of an issue such as warning lights messages or other symptons. To date there was no harm done to me or other individuals

The transmission developed hesitations at take off, a whine at low speeds and over time got louder. Diagnosis by the dealer confirmed yet another bad eight speed transmission failure. This vehicle has 41K miles.

Vehicle has strong gas smell and has gas vapor streaming out from under rear driver side wheel well and gas cap area.

This 2023 Toyota Highlander XLE AWD has a recurring gasoline/fuel odor that began while the vehicle was still within the basic warranty period. The concern was reported to Toyota/dealer multiple times. At first, the odor was intermittent and difficult to duplicate, but the problem continued after repeated dealer visits. The fuel smell was later duplicated/confirmed while the dealer was open, before approximately 60,000 miles, but the vehicle was still not properly repaired. The odor has continued and recently occurred multiple days in a row. The smell has been noticed around/inside the vehicle and creates a safety concern because gasoline odor may indicate fuel vapor leakage or a fuel-system problem. Possible sources could include the fuel tank, fuel pump module or seal, filler neck, fuel lines, EVAP system, charcoal canister, purge valve, injectors, fuel rail, or another related fuel-system component. The vehicle has been inspected by a Toyota dealer multiple times, but the cause has not been identified or corrected. No warning light has clearly identified the source of the problem. The concern is especially serious because it involves fuel odor, possible vapor exposure, possible fire risk, and possible fuel-system failure. Occupants and others could be placed at risk if the odor is caused by a leak or defective fuel-system component. The dealer is now recommending removal/drop of the fuel tank for further diagnosis and quoted approximately $1,500 for that step. My concern is that full fuel-system diagnosis, including tank removal if needed, should have been performed earlier when the complaint was repeatedly made during warranty. The issue is not a new complaint; it is a continuing unresolved fuel odor concern that started during warranty and remained unresolved despite repeated dealer involvement. The vehicle and related components should be available for inspection upon request.

The contact owns a 2023 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 26V128000 (SEATS); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the second-row seat failed to lock in position as designed. The failure mileage was 39,000.

Unknown. Toyota has recalled the recliner assembly in the second row seats. My car has been at the dealership for more than 60 days waiting for a remedy. There is still not one listed yet. I cannot safely drive my car as I have 2 children at home that must be with me as a sole parent.

I WAS IN A HEAD ON COLLISION AND SEAT BELT DIDN'T HOLD ME IN PLACE AND AIRBAG DID NOT DEPLOY. I HIT THE STEERING WHEEL.

The contact owns a 2023 Toyota Highlander. The contact stated that while driving at 60–65 MPH, the contact's vehicle crashed into the passenger's side of an oncoming vehicle. The air bags did not deploy. In addition, the contact stated that it was a very hard impact on an older model vehicle. The contact stated that the older model vehicle was made of steel. The vehicle was towed to a local tow yard. The contact was transported to the local medical center. The contact sustained severe sternum bruising, full spine whiplash, severe pain in the neck, both shoulders, and the upper back area. A Police report was filed. The vehicle was not inspected by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 34,125.

The contact owns a 2023 Toyota Highlander. The contact stated that the instrument panel had been inoperable for approximately 5 months. The contact received notification of NHTSA Campaign Number: 25V595000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 149,000.

My Toyota Highlander 12.3 inch display of the instrument panel may be blank at startup. Operating the vehicle with this display blank reduces the ability to see certain malfunction indicators. This Safety Recall that has been active since September 11, 2025. The problem been acknowledged and confirmed by Millers Toyota, in Anaheim, California and Toyota in Bueno Park, California dealers. Their answers, Toyota currently does not have a remedy as of to date, February 17, 2026. The screen goes blank every time I start my car, while driving, or trying to access the applications on my screen. I would greatly appreciate help regarding this recall.

I was at a gas station and enter car wash, the machine didnt wash my car and distriy my front right tire

On November 24, I took the vehicle into Gene Messer Toyota in Lubbock, TX to have them diagnose a noise in the front end. They confirmed hearing the noise but assured me the vehicle was safe to drive. No repairs were performed. 10 days later, on December 10, the front driver wheel detached while my husband was driving at highway speed.

2023 Toyota Highlander XLE, Bridgestone Alenza Sport A/S 235/65R18. This is the 2nd time we had a side wall tire blow out. First incident 08/2023 and today 03/06/2025 happened again with 3 slit/cracks/holes(not sure how describe it, attached picture) in the side wall.

-Tire Sidewalls are cracked within 2 years of use and more than half of tread is unused -Cracking sidewalls leads to blowouts as complained about by prior consumers -Went to goodyear service center for inspection as requested for warranty claim -No warning lamps

The contact owns a 2023 Toyota Highlander. The contact stated that while attempting to start the vehicle, the driver’s and passenger’s side mirrors moved downward independently, causing the contact to manually adjust the side mirrors. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 28,000.

The rear window on my car spontaneously shattered as I was driving. This was in light rain on the freeway. I had turned the rear-window defrost on at the beginning of my 20 minute drive to work in the dark at 5:30AM . When I was almost at my destination, I heard a noise and looked in the rear view mirror to see my rear window had shattered. My car is just three years old with about 30,100 miles on it. I drove to the dealer, waited until they opened, and they evaluated - saying it would take $1300 and three days to fix. They said it would not be covered by my bumper to bumper warranty as that had expired in the prior week. They said it would not be covered by my Toyota extended care warranty. As much rain was expected later in the day, I fixed paying for the repair myself as I found a third party installer who could do it for a fraction of the dealer's asking price on the same day. There were no warnings, messages or other symptoms. I had only turned on the rear defroster one other times in the three years I owned the vehicle. This happened without warning.

I WAS IN A HEAD ON COLLISION AND SEAT BELT DIDN'T HOLD ME IN PLACE AND AIRBAG DID NOT DEPLOY. I HIT THE STEERING WHEEL.

The contact owns a 2023 Toyota Highlander. The contact stated that while starting the vehicle, and driving at an undisclosed speed, the seat belt alarm chimed while the seat belts were properly buckled. The contact turned off and restarted the vehicle, and released and fastened the seat belt securely however, the failure persisted. The vehicle was taken to the dealer twice, but the dealer was unable to duplicate the failure. The failure recurred, and the vehicle was taken back to the dealer a third time; however, the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 21,000.

The contact owns a 2023 Toyota Highlander. The contact stated while driving at an undisclosed speed, the steering wheel was excessively difficult to steer. The power steering malfunction and pre-collision warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed with power steering and rack and pinion failure. The contact was informed that the power steering rack and pinion needed to be replaced. The vehicle was not repaired. The parts were ordered to complete the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,050.

The fact that the dealership was able to sell this car with a recall on is crazy, yes I have blame for not looking as well but now we are having issues with the front bumper hitting the tires when you turn and making a grinding noise. We were told that there’s nothing they could do as of yet but as I see this recall has been open for a while now? This is a big concern to us what if they don’t find anything wrong or so they say and something happens? They need to speed up the process to find a solutions loosing a front bumper while your on the highway is a big risk.