2007 Toyota Prius Owner Complaints

2007 Toyota Prius touring edition WILL NOT TAKE ANY FUEL PROPERLY AND WILL OVERFILL AND "BURP" CAUSING GAS TO FLOW EXPLOSIVELY OUT OF THE FILLER NECK AND HOLE. Tank will not fill, at all, causing risk of running out of gas while on highway. FUEL GAUGE DOES NOT WORK AT ALL. FUEL TANK will not fill properly, if at all, overfills and burps causing fuel to blow out of the filler hole with force. THIS IS A FIRE HAZARD as gas can spill all over near the filler area and possibly catch fire. Stopping the filler hose will not help, as the tank refuses to take any gas, even when close to empty. People need to put gas in, not guess. The car will ONLY TAKE BARELY 2 gallons in winter without overflowing. THIS IS A LIFE SAFETY AND FIRE HAZARD AS THIS OVERFLOWING GAS AND REVERSE FUEL FLOW CAN IGNITE, or catch fire. THE BLADDER IN THE TANK STOPS WORKING AND WILL NOT ALLOW FUELING ANS SPITS FUEL BACK OUT OF THE FILLER NECK AND HOLE.

NHTSA ID

11711145

Incident

Jan 15, 2026

The brake actuator failed. When the car was diagnosed by the Toyota dealership, they identified the problem as an internal leak within the brake actuator. Luckily, nobody has been hurt attempting to drive the car, but it is still being driven to get it from home to the repair shop so anything is possible. The first symptom I could link to this was in 2023, when the car would not accelerate via the gas pedal after the brakes were pressed during cruise control. Turning off the car and turning it back on fixed the problem. Afterwards, the red brake symbol was turned on. From that point on, the brake light would only shine sometimes. leading me to believe there must not have been something wrong with the car, since nothing else happened after that. 2024 is when the red brake light and ABS symbol both lit up. The only information that I could find in the manual was to take the Prius to the Toyota dealership. I could not find details on the problem. I continued to drive the car regardless because there seemed to be no problem. After letting the car sit for a few months in 2025, I began driving it again, and it was fine. A month later, I turned on my car and was met with a loud beep that did not end. This was my final sign to take it to get repaired. The car has exceeded 200,000 miles. This fix is $3,205.40 at the dealership. My 2007 Toyota Prius is valued between $2k to $4k. The repair would cost more than simply buying another Prius.

NHTSA ID

11664994

Incident

Apr 17, 2025

Check engine light came on with codes C 1256 & C 1300. Primary issue is Brake actuator failure. Toyota is ignoring this known and repeated issue and it may lead to a dangerous/ deadly situation if brakes go out while driving.

NHTSA ID

11650664

Incident

Mar 25, 2025

Failing Brake Actuator Assembly. This is known issue by Toyota and they issued a brief warranty repair program, but have since stopped and refuse to fix the issue or provide assistance.

NHTSA ID

11623731

Incident

Aug 3, 2024

After an Interstate highway drive and when then discovering my tire had been punctured by a screw or other object, but with still enough air in the tire to drive to a tire repair facility, I drove to have the puncture repaired. On repairing the puncture of the 185/65R15 tire, the repairman observed a portion of the tire’s steel belt to be visible on the inside of the tire. An immediate replacement of the tire was recommended, but this facility did not have an identical tire to provide. The facility emailed me a picture of the protruding steel belt. This writer has twice reported the matter to the tire’s manufacturer, but still no response since the first report on 09/24/2024. No party other than the tire repair facility has inspected the tire. This writer has recognized no noticeable effect of the defect, but the repair facility stated it could cause a blowout at any time.

NHTSA ID

11617019

Incident

Sep 23, 2024

The drivers seat belt receptacle spit out a spring and plastic part and it cannot buckle anymore.

NHTSA ID

11615569

Incident

Sep 18, 2024

2007 Toyota Prius Brake Actuator needs replaced. ABS, Parking Brake, VSC light came on 2 weeks ago when driving down a highway.

NHTSA ID

11610960

Incident

Aug 5, 2024

There is a known, (by Toyota), issue with the ABS brake actuator in many Prius generations including the 2nd generation Prius that I own. My mechanic said it would cost @$3000 to fix. This as I said is and has been a known issue with these cars that affects the ABS braking and puts myself, my family and any one on the road near me in danger. Toyota was quietly replacing these under an unadvertised, extended warranty program. Mine is out of this so called warranty period but if this was a known issue and was corrected at no cost due to the fact Toyota knew there was an issue why was there never a recall on the affected models all with this same problem? I feel that this dangerous problem should be corrected by Toyota at no cost to the owners of their dangerous affected vehicles.

NHTSA ID

11609836

Incident

Aug 1, 2024

Hatch release has melted, see NHTSA ID’s for example: 10511408, 10533059, 10504366, 10496197, 10448470, etc.

NHTSA ID

11600977

Incident

Jan 1, 2010

Failing hybrid water pump at around 110,000 miles. This part was part of a recall in 2012 but my VIN is not included for the same issue.

NHTSA ID

11586567

Incident

Apr 13, 2024

This complaint is about the problematic brake actuator for a Toyota Prius Hybrid. I started to hear frequent whirring noises from the front part of the vehicle a few month ago. Additionally, whenever my foot is on the brake, a mechanic sound appears. Recently, the whirring noise is becoming more frequent, on a approximately every 10-15 sec frequency. I took the car to the dealership last Friday, and the mechanics stated the issues being associated with the brake actuator. The dealership also stated that if repairs or replacement was recommended after diagnosis, the cost would be on the order of $2,000 to $3,000. I contacted my regular mechanic shop, and found out that they do not perform brake actuator repairs on a hybrid. This issue left me with limited choice for solution because it seems to be specialized and is expensive to fix, and most importantly, this issue could lead to a safety hazard for my future transportation.

NHTSA ID

11581639

Incident

Apr 5, 2024

I CANT SEE THE ROAD. Who is in charge of allowing these new bright LED headlights? They make it very hard to see where I’m driving when they’re eye level with my car!! So all I see is a bunch of LED lights coming straight at me, which is very unacceptable because now I can’t see the road. Making it a very obvious safety concern which is weird when I thought the government is supposed to be preventing stuff like this from happening. What the heck

NHTSA ID

11571556

Incident

Feb 12, 2024

I keep replacing P1116 and it keeps coming back also I was driving up a hill when I lost power and the car wouldn't accelerate. It would turn on and go into gear but not go anywhere. I know it says my vin doesn't have recalls but why am I experiencing them

NHTSA ID

11566087

Incident

Dec 15, 2023

The lights spontaneously turned off while driving on a cloudy night on an unlit section of interstate. While slowing the car down, it went onto gravel, semi-circled around and flipped over onto the lower median. No air bag deployed. No protection from shoulder seat belt. Head hit steering wheel, and I briefly lost consciousness. Tests showed skull and cervical fractures. The car was "totaled." I was planning a move. Now I consider myself to be lucky to be alive. I am rewriting because of previous a NHTSA computer malfunction changing a serious injury to "NO" injury on the questionnaire.

NHTSA ID

11554493

Incident

Oct 12, 2023

Both headlights failed, one earlier, then the second, on a cloudy night on an unlit, deserted rural stretch of interstate highway. Driver started slowing down from 60 mph, looking for a place to pull over. An accident resulted--only the defective car was involved. No airbag was deployed. The driver was injured. (Full recovery--months.) The car was totaled.

NHTSA ID

11550528

Incident

Oct 12, 2023

Combination meter often does not turn on when turning the car on. This means you cannot see a speedometer, any warning lights, fuel tank levels, or mileage. Also the trunk gets locked and is unable to open. Sometimes the car will not turn off. This has been happening on and off for over a year but has gotten increasingly worse. There are no warning signs. This can happen any time you turn on the car but might not always happen. It can also prevent you from turning off the car. When searching online, it seems this is a common problem with high mileage Priuses between 2005-2009 and so Toyota extended a warranty on it but did not tell all of the owners, most likely to get out of a recall.

NHTSA ID

11547630

Incident

Oct 1, 2023

Brake Actuator system (ABS) needs to be replaced with only 133K miles on my 2007 prius. I heard a sound and had a Toyota service center check for any issues. They told me it was the ABS system that needed to be replaced at a cost of $5K. The repair costs are greater than the car value. Toyota knows about this year, make, and model issue. I contacted Toyota Corporate about this this week and learned there was an extended warranty for this specific issue on my car. They refuse to honor the extended ABS system warranty even though I'm under 150K miles per the warranty. They told me a letter was sent to me about replacing it at no cost in 2017. I never received the letter nor did the Toyota service center I used at the time tell me about the issue. Additional Info: I am not driving the car since the dash lights have come on - red triangle, check engine, VSC and (!) symbol - with a circle inside the (). Noise checked at Toyota dealer service center and confirmed it's the brake actuator system No inspection by the manufacturer, police, insurance rep, or others The sound came first when pressing the brake pedal and then the lights came on after taking to the service center

NHTSA ID

11542716

Incident

May 16, 2023

catalytic converter is easily accessible and there should be a recall to have a safety operation and stop all these cars from being sold in the market because there is a rise in many thefts of the catalytic converter due to it being very easily accusable without any guard in place to prevent thieves from getting to it to remove and sell for parts. Spray paint can be cleaned off and vin numbers can be sanded down. simply trying that will not work. i was unaware that it was stolen off of the vehicle until i drove it a little ways to where the vehicle was then burning and i could smell it catching on fire

NHTSA ID

11536412

Incident

Aug 3, 2023

When the 12-volt battery in this car dies, there is NO warning light to indicate the battery is dead or is running low. The driver is given no warning or indication prior to the car being disabled. Once the battery dies, the vehicle immediately decelerates, there is no acceleration, the braking system becomes mostly disabled, and the power steering is not functional. The car becomes disabled, while being driven, without warning. When this event happens, there is a high pitched screaching alarm, and the majority of the dash lights turn on. None of which indicate there is an issue with the 12-volt battery. The large red triangle light with the exclamation mark comes on, as well the lights indicating that there is a problem with the brakes. Additional dash lights also turn on during this dangerous event. The rear view monitor screen states that there is an issue with the transmission. The reality that a minor 12- volt battery is responsible for disabling a vehicle is extremely dangerous, especially since it happens when the car is being driven. This is a serious issue. Toyota must include an indicator light that warns the driver the battery is low prior to the car being being disabled. Please investigate this matter, as it seems to be a common problem, based on online research. My safety was in jeopardy due to the fact that I was driving the car on a main road, with moderate traffic, and lost control of the car as it became disabled. To get my car off of the road required the assistance of several good Samaritans who used their bodies to block traffic in order to get the car out of the flow of oncoming traffic. Fourteen days later, after the battery was replaced, and the car serviced/inspected, I drove the car 10 to 15 miles, wherein the car did the same thing. Per the dealership, the issue was not the 12- bolt battery. Thank you for your time and consideration. Kindly, Cynthia Becker 623-209-4290 [email protected]

NHTSA ID

11532894

Incident

Jul 1, 2023

The contact owns a 2007 Toyota Prius. The contact stated that while at a stop light, she attempted to drive however, the vehicle failed to exceed 25 MPH. The HC battery, ECU, and check engine warning lights were illuminated. The vehicle was towed to an independent mechanic, who informed the contact that the vehicle displayed DTC code: P3190 (Engine Failure). The vehicle was towed to the local dealer, where it was diagnosed that the hybrid battery was severely drained, and the mechanic retrieved DTC codes: P3000 and P0A80 for the hybrid battery pack. The vehicle was not repaired. The vehicle was towed to another independent mechanic, who replaced the battery, but the failure persisted. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 160,000. The contact stated the vehicle was actually overfilled with oil at the mechanic's shop that performed the oil change, so that is what caused the issues with my vehicle.

NHTSA ID

11525645

Incident

May 30, 2023

Mileage

160,000 mi

Unknown I had just financed the vehicle 2-3 days prior.

NHTSA ID

11519356

Incident

Apr 18, 2023

The contact owns a 2007 Toyota Prius. The contact stated while driving at 60 MPH, the front windshield became foggy while driving at night. The contact stated that the defogger was operational; however, there was an extended period before the windshield was cleared. The contact stated that the vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The contact stated that a dealer informed him that the windshields were made of cheap material. The manufacturer was not made aware of the issue. The approximate failure mileage was 90,000.

NHTSA ID

11511560

Incident

Feb 13, 2023

Mileage

90,000 mi

Due to water infiltration from a poorly manufactured hatchback, water is able to get inside the "Supply Assy, Brake Control Power" module in the trunk of the second generation Prius. This part ultimately shorts out and fails causing a loss of regenerative braking and a "brake warning light". Toyota seems to be aware of the problem as a replacement module is now sold in a "water proof sheet" (see attached). Toyota has also moved this module to a different location (away from the rear wall of the Prius) in other hybrid vehicles (such as in the Camry where it has been moved forward). I wonder if the hybrid batteries in the Prius also fail due to water infiltration in the rear sections of these cars.

NHTSA ID

11510606

Incident

Jan 17, 2023

Mileage

172,000 mi

After pressing gas pedal almost all the way - it stuck for few seconds. I was able to stop by heavy braking. Has nothing to do with floor mats!

NHTSA ID

11505724

Incident

Feb 5, 2023

Toyota North America failed to notify me of the latent defect in the Headlight Operating System. I have had ongoing issues with the flickering of the lights for multiple years. I finally saved up enough money to try and fix the problem and spent $2854.34. After multiple failed attempts to get the problem fixed and having both headlights shut off simultaneously, I went to Alexandria Toyota in Virginia on October 20,2022 to get the problem diagnosed. The Automobile Status Report showed that the failed headlights were a direct result of the latent defect in the Headlight Operating System that was repaired free of charge in two separate Support Programs; one that ended in 2012, and the other in 2013. When I contacted Customer Support Service on October 24, 2022, to inquire when Toyota contacted me and where they sent the Support Program Information regarding the headlight issue, none of the three managers could tell me the date this was sent out, nor the address. I didn’t own the car in 2012, and never received the 2017 notice. If I had received this information, I would have brought my vehicle in at that time. I purchased this vehicle back in 2013 as a “Toyota Certified Vehicle” with the understanding that the 160-point quality assurance meant that this was a safe and reliable vehicle, and that any problems or latent defects were fixed. Toyota misrepresented themselves and are in contradiction with their own policy that states: “The TCUV policy prohibits the certification of any vehicle with an outstanding Safety Recall, Special Service Campaign, or Limited Service Campaign. Thus, no affected units are to be designated, sold, or delivered as a TCUV until all applicable Safety Recalls, Special Service Campaigns, and Limited Service Campaigns have been completed on that vehicle.”

NHTSA ID

11494903

Incident

Oct 11, 2022