2003 Toyota RAV4 Problems

VEHICLE STARTED TO BEGIN TAKEOFF REALLY SLOW AND HESITANT, AND THEN SHIFT REALLY HARD WITH A JERKING MOTION INTO SECOND. NOT SAFE FOR TAKING OFF WITH TRAFFIC OR CROSSING INTERSECTIONS. VERY SCARY TO OPERATE. COULD RUIN TRANSMISSION, SHAFTS, AND OTHER PARTS. QUOTE FROM DEALERSHIP TO REPLACE ECM IS AROUND 1500+. THEN TRANSMISSION AROUND 3000+. I AM CURRENTLY DEALING WITH TOYOTA BACK AND FORTH ON GETTING REPAIR APPROVED. PARTS ARE AVAILABLE. ALL NECESSARY CALLS HAVE BEEN DONE UP THE CHAIN OF COMMAND. THEY ARE NOT WARRANTING THIS CLAIM AT THIS TIME. *KB

MY HUSBAND WAS DRIVING TO THE GROCERY STORE WHEN HE HEARD A GRINDING NOISE. SOON AFTER, THE CHECK ENGINE LIGHT WENT ON. HE IMMEDIATELY TOOK OUR VEHICLE TO THE LOCAL TOYOTA DEALER. WE SOON DISCOVERED OUR 2003 TOYOTA RAV 4 HAS A DEFECTIVE ECM AND THE TRANSMISSION HAS BEEN SEVERELY DAMAGED DUE TO THE ECM. IT COSTS OVER $5,000 DOLLARS TO REPLACE THE ECM AND THE TRANSMISSION. WE ARE UNABLE TO DRIVE THE VEHICLE BECAUSE WE FEEL IT IS DANGEROUS FOR OURSELVES AND OTHERS. *TR

The contact owns a 2003 Toyota Rav4. The contact stated while driving approximately 30 MPH and at various speeds, the transmission slipped out of the intended gear. The contact stated that after depressing the accelerator pedal, the engine would rev before the transmission would jolt into gear. The contact stated that the check engine warning was illuminated. The contact had driven the vehicle to an independent mechanic, where it was diagnosed and determined that the Electronic Control Module needed to be replaced. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 103,000.

The vehicle is very delayed shifting and will slow down without pushing the breaks

The vehicle is very delayed shifting and will slow down without pushing the breaks

THIS CAR HAS BEEN MAINTAINED AND PRESERVED AND ONLY 84000 MILES ON IT. AND THE CAR WONT SHIFT. IT JOLTS ME OR REVS EXTREMELY HIGH AND ALSO ALMOST CAUSED ME AN ACCIDENT AS IT ALMOST SHUT DOWN ON POWER WHILE MAKING A LEFT TURN IN INTERSECTION. THE CHECK ENGINE LIGHT COMES ON AND OFF. IT'S ONLY WHILE GOING FROM 2ND TO 3RD OR SHIFTING DOWN FROM 2 TO 1ST. I HAD MY MECHANIC LOOK AT IT AND HE SAID IT'S A COMMON ISSUE WITH THE ECU TO TAKE IT TO DEALERSHIP TO REPLACE FOR FREE AND THEY WANT TO CHARGE ME 150 JUST TO EXAMINE IT.

HARSH SHIFTING, JUMPING FROM GEAR-TO-GEAR, SLUGGISH ACCELERATION AND TRANSMISSION/ELECTRONIC CONTROL MODULE FAILURE. CALLED TOYOTA REGARDING THE EXTENDED WARRENTY. THEY REFUSED TO HONOR THE EXTENDED WARRANTY DESPITE NOT PROVIDING NOTICE TO THE CORRECT ADDRESS.

I WAS DRIVING MY 2003 TOYOTA RAV4 AND ATTEMPTED TO MERGE INTO ANOTHER LANE WHEN I EXPERIENCED A VERY HARD SHIFT FROM THE TRANSMISSION CAUSING THE VEHICLE TO STALL WITH A REVING ENGINE NOISE AND AVOIDED BEING REAR ENDED BY A TRUCK. I PURCHASED MY RAV4 BRAND NEW IN 2003 TO ACCOMODATE MY DISABILITY NEEDS AND ONLY HAVE 82,000 MILES.I CHECKED WITH MY MECHANIC TODAY AND HE LOOKED UP THE TOYOTA RECALL ON THESE RAV4 TRANSMISSION FAILURES AND NOT ONCE DID TOYOTA INFORM ME ABOUT THE RECALL. HOW IS DISABLED INDIVIDUAL ON FIXED INCOME TO AFFORD $3000.00 FOR A TRANSMISSION ON A WELL MAINTAINED TOYOTA WITH ONLY 82,000 MILES. I WISH TOYOTA WOULD SHOW SOME EMPATHY TO ACCOMMODATE AN INDIVIDUAL WHOSE SOLE PURPOSE OF A BRAND NEW RAV4 WOULD FULFILL HIS DAILY PHYSICAL CHALLENGES IN LIFE AND NOW LEFT WITH A TOYOTA WITH 82,000 MILES IN NEED OF A TRANSMISSION. THIS RAV4 IS NO LONGER SAFE TO BE DRIVEN GIVEN ITS NATURE OF SAFETY CONCERNS.

The vehicle is very delayed shifting and will slow down without pushing the breaks

ECM FAILED. ORIGINAL OWNER, VEHICLE HAS 50,991 MI. ON IT . 16 YEARS OLD. TOYOTA AWARE OF PROBLEM-- EXTENDED WARRANTY TO 10 YRS./150000. MI. CALLED TOYOTA CUSTOMER. SERVICE, STATED THAT I'M OUT OF LUCK. ORIGINAL PART CLEARLY DEFECTIVE. CONSIDERATION SHOULD BE EXTENDED BECAUSE OF EXTREMELY LOW MILEAGE. COST WILL BE $2000.00 OR MORE. VEHICLE WAS MOVING WHEN EXPERIENCED UNCONTROLLED SHIFTING IN TRANSMISSION. CLEARLY A SAFETY ISSUE.

MY WIFE HAD AN ACCIDENT ON THE HIGHWAY OCT /16/2018 A CHEVY VAN SEVERELY CRASH INTO THE REAR OF MY 2003 RAV4 ,AND NONE OF THE AIRBAGS DEPLOYED .SHOULDN'T THE AIRBAGS HAVE DEPLOYED?WHAT SHOULD I DO?

TAKATA RECALL

TL* THE CONTACT OWNS A 2003 TOYOTA RAV4. THE CONTACT STATED THAT THE SEAT SHOULDER STRAP STARTED TO SHRED AND PROGRESSIVELY WORSENED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

SINCE LAST SUMMER OF 2015, MY DRIVER SIDE SEATBELT HAS BEEN FRAYING. THE FRAY IS OVER A FOOT LONG AND A 1/2" INCH OF SEATBELT IS FRAYED. I WILL ATTEMPT TO SEND PICS ALONG WITH THIS FORM. IT IS A HABIT WITH ME TO ALWAYS WEAR MY SEATBELT, AND OF ALL THE OTHER VEHICLES I HAVE OWN THIS IS THE FIRST TIME I'VE HAD A PROBLEM LIKE THIS. I DO HOPE THAT EVEN THOUGH THIS MAY BE AN UNUSUAL ISSUE, I TRUST YOU WILL CONSIDER THIS A SERIOUS PROBLEM AND ONE THAT SHOULD BE DEALT WITH PROMPTLY, FOR IT DOES CAUSE ME TO HAVE SAFETY CONCERNS EACH TIME I DRIVE WITH THIS FRAYED SEATBELT ON. I THANK YOU FOR YOUR IMMEDIATE ATTENTION ON THIS MATTER. SAFETY IS TOP PRIORITY WITH ME, AS I AM SURE IT IS WITH YOU AS WELL. AGAIN, THANK YOU FOR YOUR TIME AND PROMPT ATTENTION. FYI: IF MY 2 PICTURES JUST SO HAPPEN TO NOT BE WITH THIS FORM, PLEASE CONTACT ME BY E-MAIL AND I WILL TRY TO SENT THEM TO YOU AGAIN. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ON THE SUBJECT DATE I WAS PULLING INTO A PARKING SPOT, WITH CARS ON BOTH SIDES OF ME. THERE WAS A CURB AND AN ISLAND, WITH A TREE IN IT, IN FRONT OF ME. MY FOOT WAS ON THE BRAKE; I BROUGHT THE CAR TO A STOP AND WAS ABOUT TO PUT IT INTO PARK WHEN THE CAR UNEXPECTEDLY ACCELERATED, JUMPED THE CURB AND HIT THE TREE. THERE WERE NO INJURIES TO THE PASSENGERS BUT THERE WAS EXTENSIVE DAMAGE TO MY CAR. I HAVE FILED A CLAIM WITH THE TOYOTA COMPANY HOLDING THEM RESPONSIBLE FOR THIS UNEXPECTED ACCELERATION BASED ON PREVIOUS INCIDENTS WITH THIS SAME YEAR AND MODEL CAR. I AM SEEKING, AT THE VERY LEAST, REPAIR OF MY CAR. BASED ON THE PREVIOUS HISTORY OF THIS PARTICULAR MAKE, MODEL AND YEAR CAR, I FEEL THAT IT IS IMPORTANT TO BRING THIS MATTER TO THE ATTENTION OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION. I WOULD APPRECIATE ANY ASSISTANCE WHICH THE NHTSA CAN GIVE ME REGARDING HOW TO PROCEED WITH THIS MATTER. THE VEHICLE IS PRESENTLY BEING EXAMINED BY REPRESENTATIVES OF THE TOYOTA COMPANY. THANK YOU IN ADVANCE FOR ANY ASSISTANCE AND ADVICE WHICH YOU CAN GIVE ME IN THIS MATTER. *TR

TL* THE CONTACT OWNS A 2003 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE MADE A LOUD NOISE AND THE CAME TO A SUDDEN HALT. THE CONTACT MENTIONED THAT AFTER INSPECTING THE VEHICLE HE NOTICED THAT THE K-FRAME AND THE CONTROL ARM WAS FRACTURED DUE TO CORROSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE K-FRAME AND CONTROL ARM NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 97,000.

2003 RAV 4 85,401 MILES. THE TRANSMISSION BEGAN TO MISS SHIFT, ENGINE WOULD SPEED UP AND THERE WOULD BE A LOSS OF POWER. FROM A STOPPED POSITION THE ENGINE WOULD REV AND NOT SHIFT INTO GEAR. TOYOTA TECH ADVISES THAT THE VEHICLE REQUIRES NEW COMPUTER AND TRANSMISSION , A $6,000 EXPENSE. MIND YOU THAT THIS VEHICLE IS 13 YEARS OLD BUT HAS ONLY 85,000 ORIGINAL MILES AND HAS BEEN MAINTAINED. TOYOTA ADVISES NO WARRANTY EFFECT FOR THE VEHICLE. THE VEHICLE WAS BEING DRIVEN ON A MAIN HIGHWAY ( SUNRISE HIGHWAY LONG ISLAND) WHEN MALFUNCTION OCCURRED.

WHILE DRIVING MY VEHICLES RPMS CUT OUT AND THE THROTTLE WOULD NOT RESPOND IT STARTED TO SLOW DOWN AND THEN DIED IN THE MIDDLE OF THE HWY IN LAWTON OKLAHOMA. IT TOOK ME 2 AND A HALF HOURS TO GET THE VEHICLE HOME IN RYAN OKLAHOMA BECAUSE I HAD TO CONSTANTLY PUT THE VEHICLE IN NEUTRAL ALL WHILE COASTING AND LET IT DIE THEN TURN IT OFF AND TRY SEVERAL TIMES TO GET THE VEHICLE TO STAY STARTED AND EVEN THEN IT WOULD ONLY REVIEW TO 2000 RPMS AND DIE. I HAD TO GUIDE IT TO THE SIDE OF THE HWY SEVERAL TIMES AND LET IT SET FOR 20 TO 30 MINUTES BEFORE IT WOULD DRIVE AT AROUND 60 MPH FOR ONLY 2 TO 3 MINUTES. I WAS ALMOST HIT SEVERAL TIMES BECAUSE OF HOW THE THROTTLE WOULD NOT RESPOND WHILE THE RPMS CUT OUT AND THE VEHICLE WOULD NOT GET UP AND GO.

THIS SUN VISOR DRIVERS SIDE WILL NOT STAY UP IN THE CLOSED POSITION, THERE IS NO ADJUSTMENT WHICH CAN BE MADE TO FIX IT. ACCORDING TO TOYOTA DEALER IN NEWARK DE A NEW VISOR IS NEEDED. I UNDERSTAND FROM THE DEALER THIS IS A VERY FREQUENT AND COMMON PROBLEM, WITH MANY MODEL YEARS.' *TR

THE SUN VISOR DROPS SUDDENLY CAUSING MOMENTARY LOSS OF VISUAL CONTACT WITH THE ROAD AHEAD. *TR

I BOUGHT A USED 2003 TOYOTA RAV4 IN 2006. SHORTLY AFTER I PURCHASED THE VEHICLE I NOTICED IT DID NOT STOP VERY EASILY WHEN I WAS DRIVING ON EVEN MILDLY SLIPPER ROADS. IT ALSO MAKES A HORRIFIC CHATTERING NOISE WHEN I DEPRESS THE BRAKES (ONLY WITH SLIPPERY CONDITIONS). I CONTACTED THE TOYOTA DEALERSHIP BACK IN 2006 OR 2007 WHERE I PURCHASED THE VEHICLE AND WAS TOLD THIS WAS NORMAL AND THAT WAS HOW THE BRAKES WERE DESIGNED. THIS BRAKING ISSUE HAS CONTINUED. I HAVE EVEN CHECKED IN TO BUYING NEW TIRES (LAST FALL AND AGAIN THIS WINTER) AND THE MECHANIC SAID MY TIRES WERE FINE. I HAVE SORT OF LEARNED TO LIVE WITH THIS BRAKING ISSUE BY MAKING SURE WHENEVER THERE IS EVEN A SMALL AMOUNT OF SNOW THAT I SLOW DOWN BY DOWNSHIFTING TO 2ND OR 1ST RATHER THAN USING THE BRAKES. *TR

TL*THE CONTACT 2003 TOYOTA RAV4. THE CONTACT STATED THAT THERE WAS AN EXCESSIVE AMOUNT OF RUST AND CRACKS ON THE ROTORS OF THE FRONT LEFT AND RIGHT BRAKES. A LOCAL MECHANIC REPLACED THE LEFT AND RIGHT FRONT ROTORS. THE CONTACT CONFIRMED THE FAILURE WITH AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 64,000. UPDATED 01/12/10 *BF THE FRONT ROTORS HAD SEPARATED AT THE HUBS. UPDATED 01/15/10.*JB

I WAS AT A STOP SIGN NO GAS, TURNED DOWN HILL IN SNOW CAR ACCELERATED GOING STRAIGHT INTO DOWNED TREE. MY VEHICLE IS NOT ON THE RECALL LIST AND HAS HAD STICKING ACCELERATOR, REAR END CLUNKING NOISE AND POWER STEERING HAS MADE IT WHERE I AM AFRAID TO DRIVE VEHICLE. MY SERVICE ANIMAL HIT THE WINDSHIELD THAT SHATTERED WHEN VEHICLE ACCELERATED AND HAD TO SLAM ON BRAKES AT ANOTHER TIME. I'VE HAD OTHER NEAR MISSES AND TWO LEFT OF CENTER TICKETS WITH POWER STEERING ISSUES. I HAVE TAKEN INTO TOYOTA FOR STEERING AND CHECK ENGINE LIGHT AND THEY WILL NOT EVEN WRITE SERVICE TICKET. THEY FILLED POWER STEERING FLUID SAID NO PROBLEM. THEY KEEP RESETTING CHECK ENGINE LIGHT STATING ITS GAS CAP. THIS CAR IS A LEMON, TRANSMISSION PROBLEMS, ELECTRICAL SYSTEM, COMPUTER. THIS IS THE FIRST NEW VEHICLE I EVER BOUGHT AND WISH I WOULD HAVE STUCK WITH USED. *TR

TL*THE CONTACT OWNS A 2003 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN TO DRIFT UNCONTROLLABLY TOWARD THE RIGHT. AS AN ATTEMPT TO GAIN CONTROL OF THE VEHICLE, THE CONTACT DEPRESSED THE BRAKE PEDAL AND TURNED THE STEERING COLUMN. AS A RESULT, HE CRASHED INTO A TRAFFIC DIVIDING WALL. UPON FURTHER INSPECTION, HE NOTICED THAT THE TIE ROD FAILED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN AUTHORIZED REPAIR SHOP AND THE TECHNICIAN CONCLUDED THAT THE TIE ROD FRACTURED AND CAUSED THE FAILURE. THE VEHICLE WAS COMPLETELY DESTROYED. THE MANUFACTURER DID NOT ASSIST. THE FAILURE AND CURRENT MILEAGES WERE 40,000.

DT: WHILE DRIVING 60 MPH ON THE DRY HIGHWAY THERE WERE FUNNY NOISES COMING FROM FRONT OF THE VEHICLE. LEFT FRONT DRIVERS SIDE TIRE BLEW OUT. CONSUMER PULLED TO THE SIDE OF THE ROAD. THE SIDEWALL BLEW OUT AT 16,000 MILES, THERE W 40,000 MILES ON THE TIRES. THERE WERE NO PREVIOUS PROBLEMS WITH THESE TIRES. CONSUMER HAD TO CHANGE TIRES. DID NOT REPORT TO THE DEALER, BUT DID REPORT TO DUNLOP MANUFACTURER. DUNLOP SAID THERE WAS NOTHING THEY COULD DO BECAUSE IT WAS A SIDEWALL BLOWOUT AND THERE WAS NO WARRANTY. DUNLOP, ST20, GRANTREC 215/70/R16, DOT# EUYN2V94002. *JB

HAD JUST GOT ON THE FREEWAY A COUPLE OF MILES AGO, WAS GOING ABOUT 70 MILES AND HOUR AND HAD THE REAR DRIVER'S SIDE TIRE BLOWOUT IN TWO LOCATIONS ALONG THE SIDEWALL. THE TIRE IS A BRIDGESTONE DUELER H/T 687 (IT WASN'T LISTED AS A MODEL IN THE MENU).

2003 TOYOTA RAV4. CONSUMER REQUESTS RAMIFICATION TO UNSUCCESSFUL ATTEMPTS TO FIX THE MANUFACTURER'S DEFECT IN WORKMANSHIP *TGW THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED. PRIOR TO THE ENGINE LIGHT ILLUMINATING, THE CONSUMER NOTICED THE VEHICLE WOULD STALL AS SHE APPLIED THE ACCELERATOR PEDAL AFTER A RED LIGHT AND IT WOULD SURGE WITH FORCE ONCE IT ACCELERATED. THE CONSUMER WAS CHARGED $664.87 FOR A SENSOR AND V-RIPPED BELT. ON MARCH 24, 2010, THE CHECK ENGINE LIGHT ILLUMINATED AGAIN. UPON RESEARCHING ON THE INTERNET, THE CONSUMER DISCOVERED A TSB FOR THE PCM AND ECM. THE CONSUMER ALSO COMPLAINED OF A SQUEAKING NOISE COMING FROM THE FRONT OF THE VEHICLE AT THE SLIGHTEST ROAD BUMP AND HEARING A THUMP WHEN TURNING THE WHEELS TO THE FAR RIGHT. THE CONSUMER STATED THE DEALER NEVER MENTIONED THE TSB'S REGARDING THE ECM/PCM. *JB

IN THE LAST WEEK AFTER SOME HEAVY RAINS IN SAN DIEGO, CA, I NOTICED THAT THE FRONT FLOOR BOARDS ON BOTH SIDES OF MY 2003 RAV 4 WERE VERY WET. THERE WASN'T ANY WATER ON THE GROUND, THE SEATS NOR WERE THE WINDOWS OR MOON ROOF LEFT OPEN. WHEN THE CAR WAS GOING AROUND A CURVE, THERE WAS A SWOOSHING SOUND OF RUNNING WATER SOMEWHERE UNDER THE DASHBOARD (IT SOUNDED LIKE). I PURCHASED THE VEHICLE IN NOV 2002 BRAND NEW WITH AN EXTENDED WARRANTY. I CURRENTLY HAVE 52,000 MILES ON THE CAR. I HAVE NOT HAD ANY PREVIOUS PROBLEMS. I CALLED SEVERAL TOYOTA CAR DEALERSHIPS ABOUT WHAT IT COULD POSSIBLY BE AND NO ONE HAS EVER SEEN THIS. I HAVE NEVER EXPERIENCED THIS WITH ANY CAR WHETHER OLD OR NEW SINCE 1966 NOR HAVE I HEARD OF ANYONE HAVING A PROBLEM LIKE THIS. I TOOK MY CAR TO THE DEALERSHIP WHERE IT WAS PURCHASED AND TOLD THAT THIS WAS NOT COVERED BY WARRANTY. I STATED THIS WAS NOT A NORMAL PROBLEM OF WEAR AND TEAR, OTHERWISE MECHANICS WOULD BE VERY FAMILIAR WITH THIS AND BE ABLE TO DIAGNOSE IT WITHOUT DIFFICULTY. I WAS TOLD THAT MY CARPETING WAS TOTALLY RUINED (ITS MOLDY) AND ALL OF IT HAS TO BE REPLACED. I AM ASTHMATIC AND VERY ALLERGIC TO MOLD, THEREFORE ITS A HEALTH HAZARD. SINCE THIS WAS NOT CAUSED BY MY NEGLIGENCE, NOR IS IT A PART THAT IS EXPECTED TO WEAR WITH NORMAL USE IF EVER, I DO NOT FEEL THAT I SHOULD HAVE TO PAY HUNDREDS OF DOLLARS FOR PARTS AND LABOR, EVEN MORE SO THAT THE MECHANICS ARE HAVING A DIFFICULT TIME FINDING THE SOURCE. THIS PART OR PARTS ARE DEFECTIVE. THE DEALERSHIP STATED THAT THEY WILL TRY TO SPEAK WITH THE FACTORY TO GET SOME ASSISTANCE BUT AT THIS POINT ITS UNKNOWN. THERE HAS BEEN PROPER MAINTENANCE ON THE CAR AS REQUIRED AND THE CAR HAS NOT BEEN IN ANY ACCIDENTS.*AK