Owner-reported complaints naming the powertrain system, filed with NHTSA
Data refreshed
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials. Every record below is an owner-reported complaint about the 2012 Toyota RAV4 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 19 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
While at the end of a car wash with the car in neutral, the car accelerated by itself. It reached 60 mph for over a half mile, and was unresponsive to steering and brakes. The left front wheel was severely damaged. Fortunately, there were no accidents.
No accident but dealer mechanic says I need a new transmission as torque converter is the problem. . Car has 107500 miles and has had routine maintenance. I have since learned that there were dealer service bulletins on this issue and some owners got repairs. My vehicle, a 2012 RAV4, was not included in the bulletin. I read many situations like mine on the RAV4world website and other social media. Toyota needs to be held accountable for the thousands in repair costs owners are experiencing for a design flaw. The safety issue is the transmission could fail prematurely.
The contact owns a 2012 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the check engine, traction control, and 4WD drive warning lights illuminated. The contact stated that the failure had been reoccurring for approximately two months. The dealer was contacted and made aware of the failure and a service appointment was scheduled. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 125,000.
BOTH FRONT DRIVE AXLES EXHIBITED SIGNS OF SEVERE CORROSION DAMAGE LEADING TO COMPLETE LOSS OF LUBRICANT AND HAD TO BE REPLACED AT 34,056 MILES. THE VEHICLE IS GARAGED AND NOT SUBJECT TO ANY UNUSUAL OPERATING CONDITIONS. SYMPTOMS INCLUDED SEVERE CRACKING AND POPPING NOISES ON TURNS.
3 WEEKS AFTER THE 50,000 MILE SERVICE, ON OCTOBER 22 2019, I WAS DRIVING 35 MPH ON SOQUEL AVENUE, WHEN THE CAR BECAME UNRESPONSIVE, I LOST ALL POWER AND CONTROL OF THE VEHICLE, AND "CHECK EV SYSTEM" CAME ONTO THE INSTRUMENT CLUSTER. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD INTO A BUS STOP, TURNED THE CAR OFF, AND HAD THE CAR TOWED INTO THE DEALERSHIP. THE DEALERSHIP WAS UNABLE TO REPLICATE THE SYMPTOM AND INFORMED ME THAT IT WAS DUE TO THE 12V BATTERY. THEY REPLACED IT AND ASSURED ME THE ISSUE WOULD NOT HAPPEN AGAIN. ON NOV 11, 2019, THE ISSUE HAPPENED AGAIN WHILE I WAS ON THE HIGHWAY THIS TIME. I HAD THE CAR TOWED IN AGAIN TO TOYOTA, WHO INFORMED ME THAT "SOME RAV4 EVS HAVE BEEN IN THE SHOP FOR MONTHS, UNABLE TO BE DIAGNOSED". I RESEARCHED THE SYMPTOM ONLINE AND FOUND THAT IT RELATED TO A 2015 RECALL THAT RELATED TO THE ELECTRIC TRACTION MOTOR. TOYOTA'S DESCRIPTION OF THE F01 RECALL: IN THE INVOLVED RAV4 EV'S, COMPONENTS IN THE ELECTRIC VEHICLE TRACTION MOTOR ASSEMBLY, WHICH IS PART OF THE PROPULSION SYSTEM, MAY CAUSE THE VEHICLE TO SHIFT TO 'NEUTRAL' DUE TO A SOFTWARE ISSUE. THIS CONDITION WILL ALSO TRIGGER A 'CHECK EV SYSTEM' WARNING MESSAGE ON THE INSTRUMENT PANEL AND TURN ON A MALFUNCTION INDICATOR LAMP. IF THE VEHICLE SHIFTS TO 'NEUTRAL', THIS WILL RESULT IN A COMPLETE LOSS OF DRIVE POWER, WHICH CAN INCREASE THE RISK OF A CRASH. I INFORMED THE DEALERSHIP THAT MY SYMPTOMS MATCHED UP WITH RECALL EXACTLY, AND THEN WAS TOLD THAT IT HAD NOTHING TO DO WITH THIS AS THIS RECALL HAD BEEN PERFORMED ON APRIL 18 2016 WHEN I HAD MY CAR IN. UPON FURTHER QUESTIONING, I WAS ALSO TOLD THAT SOME OF THE RAV4 EVS HAD HAD THEIR MOTORS REPLACED AS PART OF THIS RECALL, IN ADDITION TO THE SOFTWARE CHANGE, BUT MINE HAD NOT. TOYOTA FAILED TO RECOGNIZE THIS FLAW NOT ONCE BUT TWICE AND I AM SEEKING COMPENSATION FOR FAILURE TO PROPERLY RECOGNIZE AND ADDRESS A KNOWN ISSUE.
I TOOK MY VEHICLE IN FOR SERVICE DUE TO AN ENGINE KNOCK. AFTER 90 MINUTES TO TROUBLESHOOT I WAS TOLD THAT THERE WAS A MAJOR PROBLEM AND THAT MY VEHICLE WAS NOT SAFE TO DRIVE. ENGINE MOUNT WAS BROKEN, NEEDED REAR DIFFERENTIAL REPLACED. MECHANIC HAD NEVER SEEN ANYTHING LIKE THIS.
I COULD NOT START MY VEHICLE ON 7/26/2018. I CALLED ROAD SIDE ASSISTANCE AND GOT A JUMP START FROM A POWER DEVICE. I WAS DRIVING TOWARDS TOYOTA SERVICE. SUDDENLY MY VEHICLE STOPPED ON THE MIDDLE OF THE ROAD. IT WAS COMPLETELY DISABLED: NO POWER STIRRING, NOT EVEN ALARM SIGNAL WORKING. IF THIS HAPPENED ON A HIGHWAY, MORE LIKELY, I WOULD NOT BE ALIVE TODAY. SAME DRIVER WHO WOULD HIT ME FROM BEHIND, BECAUSE DISABLED VEHICAL STOPED IN A MOMENT. I AM SURE, NOBODY MUST DRIVE TOYOTA RAV4 2012. IF BATTERY IS NOT FUNCTIONING, THERE MUST BE INDICATION ON THE DASHBOARD BEFORE THE VEHICLE GET DISABLED, BUT THERE WAS NOTHING TO TELL ME THAT VEHICLE IS NOT DRIVABLE. FOR REFERENCE : A) BATTERY. TRUE STAR BATTERY. WARANTY 2 YEARS. DIED IN 10 MONTHS. B) THE INCIDENT FILED IN TOYOTA AS #1808151393. NO RESOLUTION. C) SERVICE. FRED HAAS TOYOTA. 22435 SH 249, HOUSTON, TX 77070. C) ATTACHED: TOYOTA OWNER'S MANUAL MALFANCTIONED BATTERY INDICATOR.
TL* THE CONTACT OWNS A 2012 TOYOTA RAV4. WHEN THE IGNITION WAS TURNED TO THE ON POSITION WHILE THE VEHICLE WAS PARKED ON AN INCLINE, THE VEHICLE MOVED BACKWARDS WHEN IT WAS SHIFTED INTO DRIVE. WHEN THE VEHICLE WAS PARKED ON A DECLINE, THE IGNITION WAS TURNED TO THE ON POSITION AND THE VEHICLE MOVED FORWARD WHEN SHIFTED INTO REVERSE. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 7.
I GOT OUT OF MY CAR AND FORGOT TO PUT IT IN PARK. BECAUSE THE CAR HAS KEYLESS START, I WAS ABLE TO LEAVE THE CAR WITHOUT TAKING A KEY OUT. THE CAR STARTED TO ROLL BACK AND BECAUSE I LIVE AT THE TOP OF A HILL, IT BEGAN TO PICK UP SPEED. MY NEIGHBOR LIVES AT THE BOTTOM OF MY DRIVEWAY AND THE CAR WAS HEADING STRAIGHT TO THEIR HOUSE. LUKILY, THE CAR HIT A TREE WHICH STOPPED IT FROM HITTING THEIR HOUSE AND POTENTIALLY KILLING SOMEONE. THE ADJUSTER JUST TOLD ME MY CAR IS TOTALED DUE TO THE SPEED AT WHICH IT HIT THE TREE. HOWEVER, HE ALSO INDICATED THAT THE SPEED AT WHICH THE CAR WAS TRAVELLING WHEN IT HIT THE TREE, IT MAY HAVE HIT THE NEIGHBOR'S HOUSE AND CONTINUED THROUGH THE OTHER SIDE. THIS IS A SIGNIFICANT SAFETY FLAW OF WHICH NO ONE I SPEAK TO ABOUT IT IS AWARE. THEY ACTUALLY TEST IT WHICH THEIR OWN CAR AND NOTICE THE SAME ISSUE. IN MY OPINION, THERE SHOULD BE A MODIFICATION TO THIS FEATURE TO PREVENT THIS ISSUE. ESPECIALLY IS THERE ARE KIDS NEAR THE CAR.
THIS PROBLEM HAS TO DO WITH THE RAV4 GEAR SHIFTER STICKING AND/OR DEFORMED. THE PROBLEM IS ADDRESSED FOR YEARS 2013-2015 IN TOYOTA TSB 0145-14; HOWEVER, THE PROBLEM ALSO EXISTS IN THE 2012 MODEL. THE 2012 RAV4 CAN HAVE A STICKING OR DEFORMED GEAR SHIFTER. THIS COULD BE CAUSED BY COFFEE HAVING BEEN SPILLED INTO THE AREA. *TR
2012 TOYOTA RAV-4. CONSUMER STATED CAR WAS ON AN INCLINE AND ROLLED BACKWARDS AND HIT ANOTHER VEHICLE. *TA
ENGINE, IN IDLE AND IN GEAR, SUDDENLY SURGED. IT PROPELLED THE CAR FORWARD IN DRIVEWAY AND STRUCK A CAR ABOUT 1 FOOT-18 INCHES IN FRONT OF IT, DAMAGING FRONT BUMPER OF OUR CAR AND REAR BUMPER OF OTHER CAR. DAMAGE TO OUR CAR WAS QUOTED AT $878 AND SECOND CAR (OUR GRANDDAUGHTER'S) WAS LESS. REPORTED TO TOYOTA. THEY SENT ANALYST TO CHECK "BLACK BOX" AND REPORTED TO ME ACCELERATOR PEDAL AND BRAKES WERE OK. NOT CAR'S FAULT. I HAVE EXPERIENCED THIS SURGE MANY TIMES SINCE LEASING THE CAR 30 MONTHS AGO BUT NO ACCIDENTS. EACH TIME I REPORTED IT TO DEALER. SERVICE MAN SAID HE FOUND NOTHING WRONG. *TR
ON SEPTEMBER 6, 2014 AT 4:20PM WHILE PULLING FORWARD INTO A PARKING SPACE THE CAR HAD AN UNINTENDED ACCELERATION. THIS IS THE THIRD TIME WITH THE EXACT SAME CIRCUMSTANCES. I PULLED FORWARD INTO A PARKING SPACE AND STOPPED. I PLACED THE CAR INTO REVERSE WITH MY FOOT ON THE BRAKE TO RE-ADJUST THE POSITION OF THE VEHICLE IN THE SPACE. BACKED OUT WITHOUT APPLYING FOOT TO ACCELERATOR. I APPLIED THE BRAKED WHEN CAR WAS OUT OF THE SPACE. WITH FOOT ON BRAKE THEN SHIFTED INTO DRIVE AND THE CAR IMMEDIATELY ACCELERATED TO 4,000 RPMS. WITH MY FOOT FIRMLY ON THE BRAKE THE CAR CONTINUED AT 4,000 RPMS FOR THREE SECONDS THEN DROPPED THE RPMS TO 1100. THE WEATHER WAS CLEAR, 84 DEGREES, 77% HUMIDITY, DRY PAVEMENT, NO ALL WEATHER FLOOR MATS. THE CAR HAD RECENTLY HAD AN ECU PROGRAMMING UPDATE AT 17,000 MILES, WHEN AT TOYOTA FOR AN OIL CHANGE. THE PROBLEM STARTED IMMEDIATELY AFTER THE PROGRAMMING UPDATE. I HAVE HAD THE VEHICLE BACK TWICE AND TOYOTA CAN NOT FIND THE ISSUE. *TR
SINCE JANUARY 13, I HAVE HAD MY BATTERY DIE ON ME 4 TIMES (INCLUDING THE FIRST TIME) - TWICE IN JANUARY AND THE OTHERS A FEW MONTHS IN BETWEEN. IT NEVER SAT FOR MORE THAN A FEW DAYS. BRAND NEW CAR END OF NOVEMBER 2012, SO IT WAS ONLY A YEAR OLD. I THINK THERE MAY BE SOME DISCREPANCY BETWEEN THE BATTERY AND WHERE YOU CAN PLUG IN YOUR IPOD FOR MUSIC... THAT'S THE ONLY THING THAT WAS 'LEFT ON'/PLUGGED IN (I CHECKED EVERY TIME). THE TOYOTA GUY SAID THAT SHOULDN'T BE ISSUE, BUT NOTHING ELSE MAKES SENSE. I EVEN WENT TO A BATTERY SPECIALIST GUY AND HE SAID SOMETHING WAS JUST SLOWLY DRAINING AND A GOOD CHARGE OVERNIGHT WOULD DO THE TRICK. *TR
CAR CAN BE TURNED OFF WHILE CAR IS IN DRIVE. WHEN FOOT IS TAKEN OFF BRAKE THE CAR CAN ROLL AS IF IN NEUTRAL. *TT
TL-THE CONTACT OWNS A 2012 RAV4 TOYOTA. THE CONTACT STATED WHILE SHE WAS PULLING INTO A PARKING SPACE THE ACCELERATION PEDAL STUCK TO THE FLOOR OF THE VEHICLE. THE VEHICLE RAN UP ON A SIDEWALK. THE VEHICLE WAS TOWED TO A TOYOTA DEALER. THE MECHANIC HAD NOT DIAGNOSE OR REPAIRED THE FAILURE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 23,302.LJ
AFTER OWNING MY NEW 2012 RAV 4 FOR ONLY 3 DAYS, I VISITED A FRIEND'S HOUSE AND ATTEMPTED TO PARK MY CAR ON A SLIGHTLY SLOPED DRIVEWAY. I GOT OUT OF MY CAR AFTER TURNING OFF THE PUSH BUTTON START BUT NEGLECTED TO PUT THE CAR IN PARK. AS I WAS GETTING OUT OF THE CAR, SOMEONE SHOUTED, "YOUR CAR IS ROLLING - STEP ON THE BRAKE!". BY THE TIME I WAS ABLE TO REENTER THE CAR, IT HAD ALREADY ROLLED INTO ANOTHER VEHICLE IN FRONT OF IT. MY RAV 4 WAS DAMAGED, AS WAS THE VW PASSAT WAGON IT RAN INTO. THE DAMAGE TO MY BRAND NEW CAR IS ESTIMATED TO BE $1000. THE DAMAGE ESTIMATE TO THE OTHER CAR IS NOT KNOW YET BUT AT LEAST IN THAT VICINITY. LUCKILY, NO ONE WAS IN BETWEEN THE 2 CARS. THIS IS OBVIOUSLY A HUGE SAFETY CONCERN. *TR
I PARKED MY CAR IN RESIDENTIAL NEIGHBORHOOD AND PROCEEDED TO CROSS STREET WITH MY CAR PARKED BEHIND ME. THANKFULLY A MAN FACING CAR YELLED "YOUR CAR!" MY NEW CAR WAS ROLLING DOWN THE STREET BACKWARDS, GAINING SPEED DOWN THE INCLINE, HEADED FOR CURB, SIDEWALK AND HUGE TREE. I CHASED THE CAR DOWN THE STREET, GOT DOOR OPEN, JUMPED INSIDE VEHICLE AS IT WAS MOVING AND SLAMMED ON BRAKE, INJURING MY BACK AND SHOULDER IN THE PROCESS. THE PUSH-BUTTON START ALLOWED CAR TO "FREE-WHEEL" OUT OF CONTROL WHEN TURNED OFF, LEFT IN DRIVE, AND KEY LEFT IN CAR. I AM IN AND OUT OF CAR MANY TIMES A DAY. NO OTHER CAR I HAVE EVER OWNED WILL ALLOW ME, WITHOUT WARNING, TO LEAVE CAR IF LEFT IN "DRIVE". I WAS NOT INFORMED BY TOYOTA THAT PUSH-BUTTON IGNITION WOULD ALLOW MY CAR TO BECOME A POTENTIAL WEAPON, FREE WHEELING, IF LEFT IN DRIVE AND UNATTENDED. I WOULD LIKE THIS SITUATION TO BE REMEDIED TO SAVE LIVES AND PROPERTY DAMAGE. EVEN AFTER GOING THROUGH THIS FRIGHTENING EXPERIENCE, I CANNOT BE SURE IT WON'T HAPPEN AGAIN WITHOUT AN EFFECTIVE WARNING SYSTEM. *TR
MY 2012 HAS DONE THIS VIRTUALLY FROM DAY 1. WHEN BRAKING, THERE IS A SUDDEN ACCELERATION FOR 1/4 TO 1/2 SECOND AT THE TIME THE TRANSMISSION DOWNSHIFTS. I ALSO NOTICE IT WHILE DRIVING AT HIGH SPEEDS AND BRAKING. IT IS MORE DANGEROUS AT SLOWER SPEEDS ESPECIALLY WHEN BRAKING AT A LIGHT WITH SOMEONE IN FRONT OF YOU. IT FEELS LIKE YOU ARE PRESSING BOTH THE BRAKE AND ACCELERATOR AT THE SAME TIME. IT DOES NOT DO THIS ALL THE TIME. MAYBE ONCE OR TWICE A DAY. I THINK IT HAS TO DO WITH HOW HARD YOU BRAKE AND WHAT SPEED YOU ARE GOING. IT IS MOST NOTICEABLE JUST BEFORE YOU COME TO A STOP. IT ALWAYS HAPPENS JUST AS THE TRANSMISSION AUTOMATICALLY DOWNSHIFTS AND MOST NOTICEABLE WHEN IT DOWNSHIFTS TO SECOND OR FIRST. I NOTICE IT WHEN BRAKING SAY FROM 65 TO 55 MPH AS WELL, BUT THE SUDDEN ACCELERATION AT THAT SPEED HAS NO OR MINIMAL AFFECT AND IS NOT THAT NOTICEABLE. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .