2001 Toyota Sequoia Engine Problems

The contact owns a 2001 Toyota Sequoia. The contact stated while driving at various speeds, he became aware of a cranking sound and the vehicle suddenly started jerking and shaking. An unknown warning light was illuminated. The contact stated that the vehicle was repaired, and the front wheel speed sensor was replaced; however, the failure persisted. The contact stated the failure had gotten worse over time. The contact also stated that while searching online, he became aware that the failure was a common failure with similar vehicles. The vehicle was not diagnosed or repaired by an independent mechanic or local dealer. The manufacturer was not made aware of the failure. The failure mileage was 181,000.

NHTSA ID

11594461

Incident

Dec 22, 2022

Mileage

181,000 mi

THE VSC TRAC, VSC OFF, BRAKE AND ABS LIGHTS CAME ON AND ARE STAY ON UNTIL THE ENGINE IS SHUT DOWN. SOMETIMES THE LIGHTS COME ON AS SOON AS STARTUP. SOMETIMES WHEN IDLING. SUSPENSION IS VERY STIFF, AND STEERING SEEMS AFFECTED AS WELL AS ENGINE SEEMS TO LUG WHEN DRIVING AND THE LIGHTS COME ON.

NHTSA ID

10873319

Incident

Jun 7, 2016

Mileage

10 mi

TL* THE CONTACT OWNS A 2001 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY AND THAT THE VEHICLE WENT INTO A LIMP MODE. THE CONTACT MENTIONED THAT EACH TIME THE FAILURE OCCURRED, THE VEHICLE WAS EXTREMELY SLOW TO ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V148000 (TIRES). FOR YEARS, THE DEALER WAS UNABLE TO EXPLAIN WHY THE RECALL REPAIR WAS NOT COMPLETED. THE CONTACT WAS ALSO NOT ABLE TO DETERMINE WHEN THAT RECALL WOULD BE PERFORMED. THE APPROXIMATE FAILURE MILEAGE WAS 69,000.

NHTSA ID

10746761

Incident

Apr 24, 2015

Mileage

69,000 mi

AFTER COMING BACK FROM TRIP, ME AND MY FAMILY WERE HEADING HOME (WE WERE ABOUT 2 MILES FROM HOME), AND UPON COMING TO A RED LIGHT, I STEPPED THE BRAKE PEDAL ON MY 2001 TOYOTA SEQUOIA, AND THE CAR CAME TO A COMPLETE STOP; BUT WHEN THE GREEN LIGHT TRAFFIC CAME ON, AND AS SOON AS I LET GO OF THE BRAKE PEDAL, AND ABOUT TO PRESS THE GAS PEDAL, THE CAR JUST STALLED ( ALSO WITH BATTERY LIGHT ON INDICATION LIT, CHECK ENGINE ON, ABS LIT, VSC TRAC LIT, VSC OFF LIT, BRAKE LIGHT INDICATION LIT, ABS LIGHT). SO, FIRST THING I DID IS TURN OFF THE ENGINE , PUT THE CAR IN THE PARK GEAR ( AT THE SAME TIME MY FOOT IS ON THE BRAKE PEDAL), BUT AS SOON AS I TURN ON THE ENGINE, PUT THE CAR IN DRIVE AND LET GO OF THE BRAKE PEDAL, THE CAR STALLED AGAIN. NEXT THING I DID IS LET 2 PEOPLE PUSH THE CAR WHILE IN NEUTRAL TO PUT THE CAR IN A SAFE PLACE WHERE THERE IS NO TRAFFIC, UPON THEM PUSHING THE CAR, THEY LEFT, AND THE CAR WAS STILL RUNNING EVEN NO ONE PUSHING IT, AND CAME THE SCARIEST 20 SECONDS OF MY LIFE, CAR MADE A LOUD ANNOYING GRINDING SOUND, CAR STILL MOVING, EVEN WITH EMERGENCY BRAKE ON, MY FOOT ON THE BRAKE, KEY REMOVED FROM IGNITION, CAR PLACED IN PARK, IN OTHER WORDS I HAD NO CONTROL OF THE CAR. AFTER 20 SECONDS, THE CAR CAME TO A COMPLETE STOP, AND WE GOT OUT OF THE CAR SCARED AND SHAKING, I THOUGHT WE WERE GOING TO DIE THAT DAY, BUT THANK GOD THE CAR STOPPED, OR MAYBE MY KIDS ANGELS HELPED AVOIDED AN ACCIDENT. ALSO GOOD THING THERE WAS NO HEAVY INCOMING TRAFFIC, THERE WAS 1 OR 2 CARS ONLY IN THE WAY THAT STAYED OUT OF OUR WAY. I NEED HELP, TOYOTA HAS TO RECALL AND FIX IT BECAUSE IS A SAFETY ISSUE AND ALSO IT IS THE RIGHT THING TO DO, IF NOT I WILL BE REPORTING THESE TO THE BETTER BUSINESS BUREAU AND THE LOCAL STATE CONSUMER AGENCY. *TR

NHTSA ID

10546466

Incident

Jul 27, 2013

Mileage

110,000 mi

BROUGHT IN CAR TO HAVE MUFFLER CHECKED OUT AND MY MECHANIC CALLED ME BACK AFTER PUTTING CAR ON THE LIFT. THERE WERE RUST PERFORATIONS THE SIZE OF A FOOTBALL AS WELL AS OPENINGS ALONG THE WHOLE FRAME. THE MECHANIC TOLD ME IT WAS UNSAFE TO DRIVE AND THAT THIS WAS NOT NORMAL WEAR FOR THIS VEHICLE. HE WAS CONCERNED THAT THE DRIVE TRAIN WOULD FALL THROUGH IF WE WENT OVER A BIG ENOUGH BUMP AND CAUSE AN ACCIDENT. THE RUST WAS ABNORMAL AND HE SAID THAT IT LOOKED LIKE IT WAS RUSTING FROM THE INSIDE OUT OF THE FRAME. I CALLED TOYOTA TO FILE A CLAIM AND THEY HAD ME BRING IT TO THE LOCAL TOYOTA DEALER. THEY REFUSED TO SEND OUT A REGIONAL REP TO LOOK AT IT SAYING IT WAS NOT UNDER A RECALL OF ANY KIND. NOW MY CAR IS UNSAFE AND WORTHLESS. THE TOYOTA CORP. CUSTOMER SERVICE TOLD ME TO SELL IT FOR PARTS.... REALLY??? THEY DID NOTHING AND OFFERED NO ANSWERS. PLEASE RESEARCH THIS PROBLEM AND GET SOMETHING DONE ABOUT IT. DOES SOMEONE HAVE TO DIE TO GET THE ATTENTION? YOU BUY A TOYOTA FOR ITS LONGEVITY AND QUALITY. I WILL NEVER BUY A TOYOTA AGAIN. *TR

NHTSA ID

10466662

Incident

Jul 29, 2011

Mileage

190,000 mi

TL* THE CONTACT OWNS A 2001 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE REAR FRAME AND EXHAUST WERE COVERED WITH RUST, WHICH CAUSED THE VEHICLE TO FAIL STATE INSPECTION. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND THE CONTACT WAS ADVISED THAT THE VEHICLE WAS NOT SAFE TO DRIVE. THE MANUFACTURER STATED THERE WERE NO RELATED RECALLS TO THE FAILURE AND STATED THAT THE ISSUE WAS NOT A MANUFACTURING ISSUE. THE MANUFACTURER PROVIDED THE CONTACT WITH CASE NUMBER: 1207170084 AND OFFERED NO ADDITIONAL ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 151,783.

NHTSA ID

10465949

Incident

Jul 17, 2012

Mileage

151,783 mi

TL* THE CONTACT OWNS A 2001 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VSC WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. AS A RESULT, THE VEHICLE VIBRATED, THE STEERING PULLED TO THE RIGHT, AND THE VEHICLE DECELERATED FOR APPROXIMATELY FIFTEEN TO TWENTY SECONDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS ADVISED TO REPLACE THE YAW SENSOR, STEERING ANGLE SENSOR AND SKID SENSOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10410211

Incident

Jun 6, 2011

Mileage

150,000 mi

TL*THE CONTACT OWNS A 2001 TOYOTA SEQUOIA. WHILE DRIVING APPROXIMATELY 5 MPH THE CONTACT HEARD A TICKING NOISE IN THE ENGINE. THE CONTACT STATED THAT THE FAILURE HAD BEEN ON GOING SINCE 2002 AND IT OCCURRED DAILY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO ADVISED HER THAT IT WAS JUST A NOISY LIFTER AND NOTHING TO BE CONCERNED ABOUT;HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN TO SEVERAL DEALERS AND MECHANICS WHO WERE UNABLE TO DIAGNOSE THE FAILURE. DURING STATE INSPECTION SHE WAS ADVISED THAT THE MANIFOLD CASKET WAS WARPED AND THAT CARBON MONOXIDE WAS ENTERING THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AGAIN WHO STATED THAT THE MANIFOLD CASKET NEEDED TO BE REPLACED FOR $2,300. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000. THE APPROXIMATE CURRENT MILEAGE WAS 100,000.

NHTSA ID

10390265

Incident

May 15, 2002

Mileage

25,000 mi

TL*THE CONTACT OWNS A 2001 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE ECU (ENGINE CONTROL UNIT) FAILED. THE TRACTION, SKID CONTROL, BRAKE, AND ENGINE LIGHTS WERE ALL ILLUMINATED ON THE INSTRUMENT PANEL. HE EXPERIENCED NO VEHICLE PERFORMANCE ISSUES, BUT WAS ALERTED TO THE FAILURE BECAUSE OF THE LIGHTS. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE ENGINE COMPUTER FAILED AND NEEDED TO BE REPLACED AT THE COST OF $2,400. THE MANUFACTURER COULD NOT ASSIST. THE CURRENT MILEAGE WAS APPROXIMATELY 110,000 AND FAILURE MILEAGE WAS APPROXIMATELY 105,000.

NHTSA ID

10267881

Incident

Dec 16, 2008

Mileage

105,000 mi

BOTH EXHAUST MANIFOLDS HAD TO BE REPLACED AS THEY HAD DEVELOPED LEAKS. *TR

NHTSA ID

10219376

Incident

Feb 27, 2008

Mileage

80,027 mi

SUDDEN LOSS OF POWER DURING ACCELERATION OF TOYOTA 2001 VEHICLE ON THREE OCCASIONS. *TR

NHTSA ID

10218280

Incident

Jul 8, 2007

Mileage

85,000 mi

MY 2001 TOYOTA SEQUOIA HAD AN ISSUE WITH "CHECK ENGINE" LIGHT AT APPROXIMATELY 77,000 MILES. IT PULLED THE P0155 CODE THAT INDICATED FAILURE OF OXYGEN SENSOR. TOYOTA HAD AT LEAST TWO TECHNICAL SERVICE BULLETINS ON THE ISSUE SHOWING THIS PROBLEM AS WIDELY KNOWN. WHAT IS MORE, ON TUNDRA VEHICLES (THAT HAVE THE SAME ENGINE)TOYOTA RECOGNIZED THE ISSUE BY EXTENDING THE WARRANTY ON SENSORS AND ON THAT SPECIFIC CODE UP TO 90000 MILES. THE REPAIRS COST WAS ALMOST $340, PULLING THE CODE (5 MIN) AND REPLACING THE SENSOR (15 MIN) WAS CHARGED AT 2 HRS OF LABOR. TOYOTA CUSTOMER SERVICE REFUSED TO COVER REPAIRS. CUSTOMER SERVICE CASE 2007-07250397. *TR

NHTSA ID

10197455

Incident

Jul 25, 2007

Mileage

77,088 mi

2001 TOYOTA SEQUOIA. WHEN I SHIFTED FROM REVERSE TO DRIVE THE ENGINE ROARED TO A FULLY RACING ENGINE AND ACCELERATED FORWARD. HARD BRAKING COULD NOT SLOW THE VEHICLE AND IT HIT THE BACK OF A 2004 HONDA MINI-VAN THAT WAS PARKED, DOING EXTENSIVE DAMAGE BUT CAUSING NO INJURIES. *JB

NHTSA ID

10175272

Incident

Dec 5, 2006

Mileage

102,000 mi

MY VEHICLE IS A 2001 TOYOTA SEQUOIA WITH 39000 MILES AND THE AIR CONDITIONING COMPRESSOR FAILED. I BROUGHT TO THE TOYOTA DEALER AND THE COMPRESSOR IS A DEALER ONLY ITEM. COST OF REPAIR IS $3140!!!! NOW I HAVE A $50,000 TRUCK WITH NO AIR.THERE IS A NTSB OUT ON THE TRUCK THAT SHOULD BE A RECALL. THE COMPRESSOR HAS TO BE DEFECTIVE.

NHTSA ID

10124999

Incident

Jun 6, 2005

Mileage

39,749 mi

THE FRONT BRAKING SYSTEM ON 2001 SEQUOIA WAS REPLACED AND UPGRADED. *MR THE BRAKE JOBS WERE PERFORMED AT THE FOLLOWING MILEAGES: 15K, 25K, 30K, 55K, AND 74K MILES. THE LEFT WHEEL RATTLED OVER THE ROUGH ROAD, THE REAR LEFT STRUT MADE A NOISE WHEN GOING OVER BUMPS DUE TO A BROKEN SHOCK, AND THE ENGINE LIGHT HAD COME ON. *SC *JB

NHTSA ID

10091535

Incident

Aug 1, 2004

Mileage

15,000 mi

BOUGHT NOVEMBER 4TH 2000. NEW TIRES AT 20000. SMELLED EXAHUST WHEN VENTS ARE IN RECYLCE MODE. HAVE A DAMAGED EXAHUST MANIFOLD AT 55,000. DEALER HAS SATED THAT NONE OF THESE ARE UNDER WARRANTY. I HAVE HEARD OF OTHER PEOPLE HAVING SAME PROBLEMS. I BUY TOYOTAS FOR RELIABLITY AND SERVICE. I FEEL THAT I HAVE NOT HAD THE SERVICE NOR THE RELIABILITY EXPECTED. IT WOULD BE A GOOD SIGN OF COMMITTMENT IF TOTYOTA DOES HONOR A SOLUTION TO THESE TWO PROBLEMS, EXAHUST MANIFOLD/EXAHUST ENTERING CABIN. *AK

NHTSA ID

10088297

Incident

Jun 1, 2001

WHILE DRIVING AT HIGH SPEEDS EXHAUST FUMES ENTERED INTO THE CAB OF THE VEHICLE. *AK

NHTSA ID

10067240

WE HAVE A TOYOTA SEQUOIA, THE PROBLEMS ARE THE 4 WHEEL DRIVE IS NOT OPERATING ALL THE TIME. IT DOES NOT ENGAGE SOMETIMES AND DOES NOT STAY IN 4 WHEEL DRIVE. ONE EXAMPLE IS MY WIFE HAD SIX FRIENDS IN THE VEHICLE THE 4 WHEEL DRIVE DID NOT STAY ENGAGED AND THE VEHICLE SKID CONTROL MADE THE ENGINE LOOSE POWER SO SHE SLID BACKWARDS DOWN A HILL. NO ONE WOULD RIDE IN OUR 4WHEEL DRIVE AGAIN. THE VEHICLE SKID CONTROL MAKES THE ENGINE LOOSE POWER WHILE IN TRAFFIC. THERE IS ALSO A HESITATION IN THE ENGINE WHEN ACCELERATING FROM A COMPLETE STOP. ANOTHER PROBLEM IS THE BRAKING SYSTEM IS NOT ADEQUATE FOR THE VEHICLE. THE ENTIRE FRONT BRAKES HAD TO BE REPLACED. THE VEHICLE HAS BEEN IN FOR THE SAME REPAIRS AT LEAST 10 TIMES AND IS STILL NOT WORKING THE WAY IT SHOULD. WE HAVE ALL THE DOCUMENTATION FOR SERVICE ON OUR SEQUOIA. WE HAVE DONE INTERNET RESEARCH THROUGH NHTSA AND HAVE FOUND THE SAME PROBLEM WITH OTHER TOYOTA SEQUOIA'S. THERE WAS ALSO A PROBLEM WITH THE AIR CONDITIONER HAVING A BAD ODER FROM BACTERIA GROWING, THE EXHAUST MANIFOLD WAS LOOSE AND THE POWER WINDOW MOTORS MADE A LOUD NOISE. WE HAVE FILED A COMPLAINT ON ALL THE SAME PROBLEMS WITH NHTSA, COMSUMER AFFAIRS OF CALIFORNIA AND YOU. WE WANT TO PURSUE THE LEMON LAW AND GET OUR MONEY BACK. WE ARE CURRENTLY WORKING WITH TOYOTA ARBRITRATION BUT ARE GETTING NOWHERE. WE HAVE HAD TOYOTA'S PREVIOUSLY AND HAD NO PROBLEMS WITH THEM. THIS VEHICLE IS A LEMON.

NHTSA ID

10069885

Incident

Jan 15, 2003

NAR 02/28/2003 MR A STRONG SMELL IS COMING FROM THE EXHAUST WHEN ACCELERATING. *CB

NHTSA ID

10014750

Incident

Feb 1, 2003

Mileage

24,000 mi

AFTER MEETING WITH DISTRICT PARTS AND SERVICE OPERATIONS MANAGER STEVE CARLSON ON 9/23/02. I''VE COME TO THE CONCLUSION THAT TOYOTA WILL NOT FIX THE PROBLEM I HAVE WITH THE SMELL COMING FROM MY 2001 SEQUOIA. FIRST OF ALL, I HAD TO CALL THE DEALERSHIP AT 10:30 IN MORNING TO MAKE SURE THAT THE MANAGER WAS GOING TO BE THERE. SECOND IS THAT I GOT THE RUN AROUND ABOUT I SHOULD TRY A ''FOR FUN AND GIGGLES'' BY NOT RUNNING MY RECYCLING MODE WHEN DRIVING WITH THE A/C ON. THIRD IS THAT WHEN THE FRONT WINDOWS ARE OPEN I''M STILL GETTING THE WORST SMELL OF EXHAUST COMING FROM THE REAR. I UNDERSTAND HIS POINT ABOUT THE BALANCE OF AIR WITH OPENING AND CLOSING OF BAFFLES IN THE REAR AND FRONT OF THE VEHICLE. I WANT TO MAKE A NOTE THAT THE VENTING OF THIS VEHICLE WITHOUT THE RECYCLING ON IS THE WORST I''VE HAD IN ALL THE VEHICLES I''VE OWNED. THE IDEA OF ASKING ME TO USE THE FRONT VENTS INSTEAD OF RECYCLING IS A CATCH 22. WHERE IF I KEEP THE RECYCLING ON AND SMELL THE EXHAUST SMELL WITH IT''S 0% EMISSIONS IN MY VEHICLE COMPARED TO OPENING THE FRONT VENT AND SMELLING THE CAR IN FRONT OF ME WITH WHO KNOWS WHAT. FOURTH, I HAVE TO GET ENOUGH PEOPLE TO COMPLAIN ABOUT THIS PROBLEM BEFORE TOYOTA WILL DO ANYTHING TO FIX THIS DESIGN FAULT

NHTSA ID

10002986

Incident

Sep 23, 2002

Mileage

24,000 mi

WE HAVE A TOYOTA SEQUOIA, THE PROBLEMS ARE THE 4 WHEEL DRIVE IS NOT OPERATING ALL THE TIME. IT DOES NOT ENGAGE, WHEN IT DOES SOMETIMES IT DOES NOT STAY IN 4 WHEEL DRIVE. ONE EXAMPLE IS WHEN MY WIFE HAD SIX FRIENDS IN THE VEHICLE THE 4 WHEEL DRIVE DID NOT STAY ENGAGED AND THE VEHICLE SKID CONTROL MADE THE ENGINE LOOSE POWER SO SHE SLID BACKWARDS DOWN A HILL. NO ONE WOULD RIDE IN OUR 4 WHEEL DRIVE AGAIN. THE VEHICLE SKID CONTROL ACTIVATES AT RADOM ON DRY PAVEMENT. THE SKID CONTROL MAKES THE ENGINE LOOSE POWER WHILE IN TRAFFIC. THERE IS ALSO A HESITATION IN THE ENGINE WHEN ACCELERATING FROM A COMPLETE STOP. ANOTHER PROBLEM IS THE BRAKING SYSTEM IS ANOT ADEQUATE FOR THE VEHICLE. THE ENTIRE FRONT BRAKES HAD TO BE REPLACED. THE VEHICLE HAS BEEN IN FOR THE SAME REAIRS AT LEAST FIVE TIMES AND IS STILL NOT WORKING THE WAY IT SHOULD. WE HAVE ALL THE DOCUMENTATION FOR SERVICE ON OUR SEQUOIA. WE HAVE DONE INTERNET RESEARCH THROUGH THE NHTSA AND HAVE FOUND THE SAME PROBLEM WITH OTHER TOYOTA SEQUOIA'S.

NHTSA ID

10002756

Incident

Jan 28, 2002

Mileage

18,582 mi