2012 Toyota Sienna Tires & wheels Problems

The contact owns a 2012 Toyota Sienna equipped with Michelin Tires, Tire Line: Cross Climate 2, Tire Size: 235/60/R17, DOT Number: (N/A). The contact stated sidewalls on all four tires were expanding, causing the tires to bubble and bulge outwardly. The dealer was not contacted. The contact informed the tire shop where tires were purchased of the failures, and two tires were replaced. The contact was unsure what two tires were replaced. The manufacturer was made aware of the failure. The vehicle failure mileage was approximately 152,000 and the tire failure mileage was approximately 1,000. The VIN was not available.

NHTSA ID

11657784

Incident

Apr 30, 2024

Mileage

152,000 mi

10-01-2022 new tire blew out at I-10 , Columbus TX78934 4 new tires installed at 07-07-2022; YOKOHAMA YK-CTX; 235/60 R17 Invoice total cost $1085.76

NHTSA ID

11502539

Incident

Oct 1, 2022

Costco installed 4 tires on my 2012 Toyota Sienna on 11/10/2021. The tire had 80,000 mile warranty. At the time of Tire installation, the mileage on my vehicle was 253,405. I did my tire rotations every 5000 mile at Suburban Toyota in Farmington Hills. I took the vehicle for tire rotation at 283,618 miles and the dealership refused to rotate the tires because the tread was below 3/32 seconds. I thought that this was a mistake and went again to rotate the tires at 288,789 miles. I went to Costco on the same day and told Costco representative at the counter [XXX] that the tire needs to replaced under warranty. I informed him that I drove only 30,000 mile on the tires. He checked all my mileage papers when I did the tire rotations. He went inside and talked to [XXX] (Tire section manager) and told me that the tire need to be under 2/32 seconds for Michelin Warranty to work. I asked him to arrange a tire rotation and scheduled the tire rotation on 12/20/2022. I took the vehicle to Costco on 12/20/2022. The mechanic called me after 30 minutes and informed me that the tire tread is under 2/32 second and cannot be rotated. I talked to [XXX] about it and he went to talk to [XXX]. He told me that the mechanic is going to rotate the tires and I can come back after one month to check the tires again. I informed [XXX] that he, Costco, and Michelin are playing with the safety of my family. He told me that Costco is not concerned about the safety of my family. If I am concerned about the safety of my family, I should change the tires without the warranty. I believe that Costco and Michelin are installing 30,000 mile tires as 80,000 mile warranty tires. I drive most of my driving on the freeway and on cruise control. So there should not be any issue with my driving. I got tires from Discount Tire Company before and had no issue like this. I request NHSTB to investigate the issue and warn people of this issue before people die. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11499482

Incident

Dec 20, 2022

TL* THE CONTACT OWNS A 2012 TOYOTA SIENNA EQUIPPED WITH FOUR NEW COOPER CS3 TIRES, SIZE: 235/55R18 (NA). THE CONTACT STATED THAT THE TIRE PRESSURE INDICATOR ILLUMINATED, BUT THE TIRES DID NOT APPEAR LOW ON AIR. THE CONTACT NOTICED THAT THE TIRES WOBBLED WHILE DRIVING DOWN A HILL. THE CONTACT TOOK THE VEHICLE TO LAKELAND TOYOTA (2925 MALL HILL DR, LAKELAND, FL 33810, (863) 688-5451) WHERE THE TIRE PRESSURE INDICATOR WAS CLEARED; HOWEVER, IT ILLUMINATED AGAIN SHORTLY AFTER THE REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 95,000. THE TIRE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11191801

Incident

Mar 11, 2019

Mileage

95,000 mi

THE TIERS WEAR OUT TO QUICKLY AROUND 20K MILES

NHTSA ID

11128292

Incident

Sep 8, 2018

Mileage

74,000 mi

FIRESTONE PRIMEWELL VALERA TOURING II DOT #Y9HRCLTX2015... TIRE LOSING AIR. THE TIRE HAS SMALL CRACKS ON THE SIDEWALL AND IS SLOWLY LEAKING AIR. THE MANUFACTURER HAS ISSUED RECALLS. THEY CITE POTENTIAL TIRE FAILURE ASSOCIATED WITH THIS DEFECT. ALSO NOTICING CRACKS ON TWO OTHER TIRES... DOT #Y9HRCLTX2115 AND DOT #Y9HRCLTX1415. OTHER PRIMEWELL VALERA TOURING II TIRES ARE ALSO INCLUDED IN THE RECALL. DETAILS AT HTTP://RECALL.PRIMEWELL-US-COM/

NHTSA ID

11013562

Incident

Aug 7, 2017

Mileage

91,110 mi

I AM COMPLAINING ABOUT THE MICHELIN PRIMACY MXV4 TIRES. THE TIRES HAVE A 60,000 MILE WARRANTY AND I HAVE ONLY GOTTEN 20,200 MILES OUT OF THEM. THE TREAD WEAR IS A 5/6 GAUGE. I WILL HAVE TO PURCHASE THREE NEW TIRES VERY SOON, BEFORE THE TIRES START BALDING, IN ORDER TO CORRECT THERE FAILURE. I STARTED OUT WITH FOUR OF THEM, BUT NOW I AM DOWN TO THREE. ONE OF THEM HAD A SCREW FOUND IN IT, SO I REPLACED IT WITH A NEW FIRESTONE TIRE. *TR

NHTSA ID

10639654

Incident

Aug 1, 2014

Mileage

20,283 mi

2012 TOYOTA SIENNA HAD TWO FRONT-WHEEL BLOWOUTS IN LESS THAN ONE YEAR. TIRES HAD LESS THAN 25,000 MILES IN BOTH INSTANCES. *TR

NHTSA ID

10596526

Incident

Jun 5, 2014

Mileage

43,000 mi