2003 Toyota Tacoma Owner Complaints

I took my 2003 Toyota Tacoma and for a tire alignment and was told by an employee of the tire shop that my rack and pinion needed to be replaced and lower ball joints. I checked the VIN number and it said I have zero recalls, but there is a general recall on this make a model that I have what do I do? I also have the steering has a lot of play whenever I go for a bump in the road like the tires catch the road so I kind of swerve a little bit and I feel that it’s very unsafe to me and other drivers.

NHTSA ID

11719764

Incident

Feb 21, 2026

Invoice no. XXX Frame recall. I have a receipt stating…”J# 20TOZFRAM,;CS FRAM Inspection TECY(S):351 Warrenty inspected Frame, Frame failed, perforation, Replaced Frame at Dealer”. Except they did not replace the frame, I have a receipt stating they replaced the “ spare tire rack assembly. Now, my frame is so rusted it will not pass inspection next September. It has been welded already, at the tune of $2500.00. This truck has 122,000 miles. I want the truck fixed. I’ve been in touch with the BBB and the attorney general, and others. The attorney general suggested I get a lawyer. This is a a gross deception from the Orleans Dealer in [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11708851

Incident

Jun 1, 2010

While driving at both high speeds (highway) and local road speed limits, Toyota Tacoma's rear passenger side frame split completely in half. While performing maneuvers such as right turns, vehicle wobbled and I, driver, lost temporary control of vehicle. Upon further inspection, rear driver side frame also contains stress fractures which are symmetric to the rear passenger side of truck. Potential for accident has increased exponentially. Pictures provided. Brought evidence of clear safety hazard to local Metro Detroit dealership at 773 S Rochester Rd Unit B, Rochester Hills, MI 48307 on 04NOV25, and called Toyota Corporate on 05NOV25. Toyota Corporate neglected my concerns about safety hazard and potential harm to myself and family. Safety recall needs to be issued immediately. This issue stems from a well known recall from Toyota of Toyota Tacoma's, 1996-2004, which contained an OEM defect of excessive corrasion to the frames, causing premature failure of the frames due to excessive rust build up which impacts frame integrity and increases probability of failures such as observed in my case.

NHTSA ID

11697609

Incident

Nov 3, 2025

Prior to July, 2010, I received a letter from Toyota stating my Tacoma Frame was recalled. I wouldn’t have known otherwise. I set up an appointment with the Orleans Toyota dealer and set up an appointment. They gave me a loaner and had my truck for two weeks. I thought my frame had been replaced. All this time went by and now my frame is dangerously rusted. Last year I spent $2500 getting it spot welded. This year the mechanic says he may not be able to pass it next time. This provoked me to research all my bills for the truck. What I found was unbelievable to me. I never looked at my billing receipt from Orleans Toyota, but believed the frame was done. Not the case. They replaced the 83341 Spare Tire Carrier 5092 Wpt. Part=04002-11204. My Tacoma has 122,000 on it now. I’m [XXX]. I cannot afford a new car payment . From what I understand there are 100s of people with the same problem of seriously rusted frames. I need your help. Thank youL [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11686339

Incident

Jun 18, 2010

What component or system failed or malfunctioned, and is it available for inspection upon request? While driving over railroad tracks, the lower ball joint separated from its socket, which caused the CV axle shaft to break apart and led to the separation of the upper ball joint. As a result, the front driver's side tire folded under the fender, causing the truck to abruptly veer off the road and into the right shoulder All parts are available for inspection How was your safety or the safety of others put at risk? When the failure occurred, I was driving over a series of railroad tracks when the truck suddenly veered off the road onto the shoulder. This abrupt veering and stopping put my safety—and the safety of others—at risk, as the drivers behind me had to react suddenly to avoid a collision. Has the problem been reproduced or confirmed by a dealer or independent service center? The truck was serviced in 2006 in response to the recall, having the lower ball joints replaced, however the replacement parts may have failed Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No

NHTSA ID

11659677

Incident

May 6, 2025

The contact owns a 2003 Toyota Tacoma. The contact stated that while the vehicle was parked, the contact noticed that the rear subframe of the vehicle was corroded and the subframe had detached from the vehicle. The vehicle was towed to the residence. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 260,000.

NHTSA ID

11644198

Incident

Feb 21, 2025

Mileage

260,000 mi

The contact owns a 2003 Toyota Tacoma. The contact stated that while the vehicle was parked, the contact became aware that the rear sub frame on the driver's and passenger's side were corroded. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 345,000.

NHTSA ID

11623181

Incident

Nov 1, 2024

Mileage

345,000 mi

The frame rusted through and there are holes in the frame The frame broke while my wife was driving home from work. Had to get it towed to the house No No No, no symptoms

NHTSA ID

11621638

Incident

Oct 12, 2024

I was getting on the freeway when my truck either got hit by someone or it sped up without me pressing the gas causing me to spin and catch the bushes on the side of the on-ramp where I rolled and slammed my front end continuing to roll 3 times. I broke my back due to the airbag failure to deploy

NHTSA ID

11597779

Incident

Nov 15, 2023

I was getting on the freeway and was hit by another driver (who fled the scene and didn’t get caught) and my truck spun around 180 before catching bushes and rolling three times smashing my front end and almost collapsing my roof and my airbags failed to deploy as well as my seatbelt tensioner not tightening resulting in me breaking my back in three spots. I was going approximately 35-45 mph and the first roll from the top of the embankment dropped about 15 which is where the front end got smashed due to being front heavy and this is where I broke my back before continuing to roll

NHTSA ID

11596799

Incident

Nov 15, 2023

Hello I Just wanted to check if my vehicle was ever in a crash. 2/29/24 VIN. [XXX] 03 Toyota Tacoma 2WD 4 cyl. EMail is [XXX] Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11574200

Incident

Jan 1, 2004

This truck was sprayed for frame rust at Kern Toyota Winchester, Va 10/07/2010 a problem Toyota was very aware of and tried to put a band-aid on a known issue that would rust out and not pass inspection or worse yet cause a terrible accident or cause harm to driver/passengers or other drivers. We have had another vehicle in the family by Toyota that they replaced the entire frame and now they state that is not true. However, we had a rental for over a month while they did replace entire frame for same issue. Now our above truck that is in wonderful shape nothing else wrong but frame that is rusted did not pass inspection requiring parts that need welded. So we have a good truck that only thing wrong is the issue Toyota knew they used faulty equipment/parts for.

NHTSA ID

11553236

Incident

Sep 7, 2023

The contact owns a 2003 Toyota Tacoma. The contact stated while driving at an undisclosed speed, the front driver’s side wheel detached from the vehicle. The contact was able to navigate the vehicle to safety. The vehicle was towed to an independent mechanic where it was diagnosed that the front driver’s side ball joint had failed and needed to be replaced. The contact was informed that the VIN was included in NHTSA Campaign Number: 05V225000 (Suspension). The vehicle was towed to the dealer where the vehicle remained and was diagnosed that the rear frame was rusted and needed to be replaced. The dealer informed the contact that the vehicle was included in an unknown warranty extension; however, the vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 310,000.

NHTSA ID

11544553

Incident

Jun 14, 2022

Mileage

310,000 mi

The DARCARS Toyota dealership in Rckville, MD has refused to repair an outstanding safety recall issue for my 2003 Toyota PreRunner truck. I had received a recall notice from Toyota for my 2003 Toyota PreRunner. On July 21, 2023, I arrived for my 7:30 a.m. appt at DARCARS to get the spare tire lift carrier repaired. Although it was still within the eligible recall period, a very annoyed service manager told me that DARCARS would not repair it. Although I had made the appt 1+ weeks earlier, he told me no repair parts had been ordered in preparation for repairing the hazard. After I insisted the safety recall issue created a dangerous hazard for me and other drivers since the spare tire located underneath the truck might fall down onto the roadway while driving, he became angry and said the spare tire lift carriage must first be inspected (a 5-10 min inspection) to determine if corrosion on the lift was present. Since I had expected the dangerous part was going to be replaced, I agreed to the inspection. A Toyota service rep drove the truck to the service bays for an inspection. Although my appt was scheduled as the first day of the day, I waited over an hour with no response from the manager or the service rep. During this hour wait, I asked on at two occasions if the inspection was completed and was told "No" with no details provided. I finally walked outside to the back of the DARCARS dealership and discovered my truck had been sitting in a parking lot. No no one had bothered to inspect it. Due to the attitude of the DARCARS service manager, service rep, lack of communication, and the failure to have ordered any parts to repair the safety hazard, it became obvious that DARCARS had no intention of correcting the safety hazard. They intended to stall and make receiving the recall repairs as difficult as possible -- and requiring a second service visit. (Afterward, a non-Toyota mechanic performed a inspection and confirmed the lift carrier are severely corroded.)

NHTSA ID

11538920

Incident

Jul 21, 2023

We bought the truck used from a dealer about 10 -12 years ago. We've always taken good care of it, and kept it in a garage. It always passed inspection with no problems, and there is nothing wrong with the truck, except at the last inspection about 2 weeks ago the mechanic said the frame has completed rusted through and the truck is not safe to drive. We can't get it fixed. I called Toyota and they said since it was no longer under warranty, too bad. They did "open a case" for us and I'm supposed to hear back from them next week, but I don't have much hope that they will do anything. The truck only has about 90,000 miles on it, despite being 20 years old. It is in good shape in every other way.

NHTSA ID

11533658

Incident

Jul 7, 2023

I was driving home on March 10 2023 well out of no where my Toyota Tacoma something on the front end suspension broke it looks to me the recal that Toyota fixed before I even got the truck well sent me into 3 trees head on 55mph no airbag deployed I didn't have a chance to try and stop the vehicle I thought I was going to die I know the road I was on isn't the best shape I need help

NHTSA ID

11521264

Incident

Mar 10, 2023

The contact owned a 2003 Toyota Tacoma. The contact stated that while driving up the driveway at 5 MPH and turning into the garage, the accelerator pedal was depressed but went down to the floorboard and became stuck. The contact lost control of the vehicle, and the vehicle crashed into the fence gate and the corner of the neighbor's residence. The air bags did not deploy. There was no injury sustained. There was no police report filed. The vehicle was towed to a salvage yard, where it was totaled. The contact related the failure to NHTSA Campaign Number: 09V388000 (Vehicle Speed Control). The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 230,000.

NHTSA ID

11520665

Incident

Apr 27, 2023

Mileage

230,000 mi

The contact owns a 2003 Toyota Tacoma. The contact received notification of the NHTSA Campaign Number: 12V542000 (Tires) and the vehicle was taken to the dealer for the recall repair; however, the dealer declined to perform the recall repair due to rust on the subframe, and the spare tire carrier needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the issue and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 236,000.

NHTSA ID

11495276

Incident

Nov 29, 2022

Mileage

236,000 mi

frame. We did have the frame checked a few times since we were made aware of the issue with rusted frames. Terrible noise. Technician says frame is being held to cap by two inches of rusted frame on both side just above rear wheel. Our repair person says of there was a recall, he can fix it. It thought there was a recall. He said otherwise the truck looks perfect. We are original owers. have kept truck in perfect condition. This is our second toyota truck and fourth toyota car. I can't imagine you would not authorize/pay for frame replacement, new/used. we are crushed. please advise if you can authorize/pay for repair/replacement. Our repair person advised we should not drive for fear of truck splitting in half.

NHTSA ID

11480018

Incident

Aug 3, 2022

The contact owns a 2003 Toyota Tacoma. The contact stated that the entire subframe of the vehicle was rusted due to severe corrosion. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who confirmed the subframe corrosion. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 200,000. The VIN was not available. The contact stated that there was an opportunity to have the frame of the vehicle coated but that make the corrosion worse. The contact feels as though the vehicle is unsafe to drive.

NHTSA ID

11474053

Incident

Oct 12, 2021

Mileage

200,000 mi

The local dealership Cloninger Ford /Toyota told me that I need to replace the airbag ECU and Pretensioner on drivers side. The cost estimate was $1,500.00. I have seen that Toyota has given recalls on other models for this defect. I have a 2003 Toyota Tacoma. I am submitting this complaint with hopes for my case to be considered. The airbag light cam on on my truck 2 months ago and Cloninger Toyota replaced the front seat belt assy. and erased dics. This cured the problem (light on) for a few weeks. Please consider this issue for recall further than you have at this point.

NHTSA ID

11468987

Incident

Apr 1, 2022

Truck crashed into rocks on shoulder and rolled over. Driver side Windshield and roof crushed. Air bag did not deploy. Sheriff took a report of crash.HI213530034 Greenspot road. Highland , CA. Vehicle is in possession of coparts authorized by USAA insurance

NHTSA ID

11445196

Incident

Dec 18, 2021

While driving, on the highway, the rear shock absorber support mount came loose, allowing the truck bed to come loose from the frame/chassis. Fortunately only the passenger side came loose, keeping the truck's bed attached to the rear of the truck I later found that this particular model has a problem with Frame rot which generated a Toyota bulletin. I bought the truck from Toyota, as a used truck in 2011, but received no notifications of this potentially hazardous vehicle. If the bed had come loose at highway speed, any vehicle following the 2003 Toyota Tacoma truck would have been severely damaged or potentially resulted in the death of the people in the cars following behind me and the truck. There was a Toyota bulletin issued previously which was not disclosed to me at the time of purchase. The vehicle has been in Toyota shops regularly for inspections, maintenance and other repairs but the shop never mentioned anything about a "rusty" frame. Upon further research, I have found multiple Toyota Tacoma owners with similar issues with the frame. I believe Toyota knowingly manufactured and sold a defective product with serious potential safety issues. This vehicle either should be banned from the road for the safety of all drivers.

NHTSA ID

11420490

Incident

Jun 6, 2021

The contact owns a 2003 Toyota Tacoma. The contact stated while changing the oil, he noticed that the undercarriage of the vehicle was rusted which resulted in the sub-frame being compromised. The vehicle was diagnosed but not repaired. The manufacturer was informed of failure of the failure but offered no assistance. The failure mileage was approximately 140,000.

NHTSA ID

11420436

Incident

May 10, 2021

Mileage

140,000 mi

TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN THE GARAGE, RODENTS ATE THE FUEL LINE CAUSING A FUEL LEAK. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO HALEY TOYOTA OF ROANOKE (1530 COURTLAND RD NE, ROANOKE, VA 24012) WHERE IT WAS DIAGNOSED WITH THE FUEL LINE NEEDING TO BE REPLACED. THE VEHICLE HAD BEEN REPAIRED TWICE HOWEVER, THE ISSUE RECURRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

11407284

Incident

Apr 7, 2021

Mileage

75,000 mi